IllustrationHanger for Diesel Particulate Filter cracked and cracked the DPF as well. Causing some exhaust to vent to cabin compartment. If one was to believe social media there are THOUSANDS of these and Mercedes chooses to look the other way. All the while charging more than $4,000 to repair. Dealer has confirmed. No engine lights.
2014 Mercedes Benz Sprinter 2500
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sprinter 2500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 11 of 22 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports1 fire reports0 injury reports
Engine complaints
3 reportsMY SPRINTER WENT INTO LIMP MODE. WOULD NOT GO OVER 10 MILES PER HOUR. HAD IT TOWED TO A MERCEDES BENZ DEALER. REPLACED UPSTREAM AND DOWNSTREAM SENSORS. THE UPSTREAM NOX SENSOR WAS MALFUNCTIONING. I RECIEVED A LETTER FOR A RECALL WITH THIS PROBLEM. MERCEDES BENZ DOES NOT RECOGNIZE THIS REPAIR AS A FIX. PLEASE ADVISED [XXX] IN…
Read full complaint
MY SPRINTER WENT INTO LIMP MODE. WOULD NOT GO OVER 10 MILES PER HOUR. HAD IT TOWED TO A MERCEDES BENZ DEALER. REPLACED UPSTREAM AND DOWNSTREAM SENSORS. THE UPSTREAM NOX SENSOR WAS MALFUNCTIONING. I RECIEVED A LETTER FOR A RECALL WITH THIS PROBLEM. MERCEDES BENZ DOES NOT RECOGNIZE THIS REPAIR AS A FIX. PLEASE ADVISED [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
CAR HAS BEEN DRIVING NORMALLY FOR SEVERAL MIN AT HIGHWAY SPEEDS. WHILE STOPPED AT STOPLIGHT OR WHILE DRIVING SLOWLY THROUGH A PARKING LOT THE VEHICLE WILL STALL AND SHUT OFF. THE VEHICLE DOES RESTART WHEN TURNED TO OFF POSITION AND RESTARTED. NO CHECK ENGINE LIGHTS ILLUMINATE AFTERWARD AND VEHICLE DRIVES NORMALLY AFTER RESTARTIN…
Read full complaint
CAR HAS BEEN DRIVING NORMALLY FOR SEVERAL MIN AT HIGHWAY SPEEDS. WHILE STOPPED AT STOPLIGHT OR WHILE DRIVING SLOWLY THROUGH A PARKING LOT THE VEHICLE WILL STALL AND SHUT OFF. THE VEHICLE DOES RESTART WHEN TURNED TO OFF POSITION AND RESTARTED. NO CHECK ENGINE LIGHTS ILLUMINATE AFTERWARD AND VEHICLE DRIVES NORMALLY AFTER RESTARTING. HAS OCCURRED APPROX 10X OVER PAST FEW MONTHS. CONCERNING BECAUSE NOW IT IS OCCURRING WHILE THE VEHICLE IS IN MOTION AND RESULTS IN LOSS OF POWER, POWER STEERING AND ITS UNSAFE. CAR IS NEW AND STILL COVERED UNDER WARRANTY. NO RECALLS LISTED FOR VEHICLE. THIS ENGINE IS NEW FOR THIS MODEL YEAR. NO PREVIOUS SIGNIFICANT REPAIRS OR ACCIDENTS. *TR
Official recalls
114V764000 · Engine And Engine Cooling:engine:diesel
Dec 1, 2014
Mercedes-Benz USA, LLC - DBA Sprinter (Mercedes) is recalling certain model year 2014-2015 Sprinter 2500, and Sprinter 3500 vehicles manufactured February 28, 2014, to November 21, 2014. In the affected vehicles, oil may leak from around the chain tensioner gasket area.
Consequence & remedy
Consequence: Leaking oil may drip onto a hot engine surface, increasing the risk of a fire. Additionally, the leaking oil may be a road hazard for other vehicles, increasing the risk of a crash.
Remedy: Mercedes will notify owners, and dealers will replace the chain tensioner gasket, free of charge. The recall began on December 19, 2014. Owners may contact Mercedes customer service at 1-877-762-8267. Mercedes' number for this recall is 2014120003.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.