MY AIRBAGS SELF DEPLOYED WHILE I WAS DRIVING. I HAD JUST LEFT WORK AND DRIVING NORTHBOUND ON THE WEST SAM HOUSTON TOLLWAY APPROACHING THE TOLL STATION AT HIGHWAY SPEEDS. THERE WAS AN INCREDIBLY LOUD EXPLOSION AND AND HARD PERCUSSION AS THE AIRBAGS SELF DEPLOYED WHILE I WAS DRIVING. I THOUGHT I HAD BEEN PUNCHED OR SHOT IN THE …
Read full complaint
MY AIRBAGS SELF DEPLOYED WHILE I WAS DRIVING. I HAD JUST LEFT WORK AND DRIVING NORTHBOUND ON THE WEST SAM HOUSTON TOLLWAY APPROACHING THE TOLL STATION AT HIGHWAY SPEEDS. THERE WAS AN INCREDIBLY LOUD EXPLOSION AND AND HARD PERCUSSION AS THE AIRBAGS SELF DEPLOYED WHILE I WAS DRIVING. I THOUGHT I HAD BEEN PUNCHED OR SHOT IN THE GUT. THE PASSENGER SIDE CURTAIN DROPPED DOWN AND THE RIGHT REAR PASSENGER SIDE DOOR BAG DEPLOYED. THE SEATBELT AROUND MY WAIST AND SHOULDER TIGHTENED. FORTUNATELY, I KEPT IT TOGETHER AND DROVE DIRECTLY TO THE DEALERSHIP. I HAD NOT HIT ANYTHING, RUN OVER A POTHOLE, SWERVED OR OTHERWISE MAKE ANY SUDDEN DIRECTION CHANGE. I WAS IMMEDIATELY CALLED BY AN OPERATOR ON THE MERCEDES EMERGENCY SYSTEM WITHIN THE CAR. SO MERCEDES IS AWARE OF THE INCIDENT AT THE TIME IT HAPPENED. SHE ASKED IF I NEEDED AN AMBULANCE OR POLICE. I TOLD HER THAT THE AIRBAGS HAD DEPLOYED ON THEIR OWN AND THAT I WAS PHYSICALLY OK. ADDITIONALLY, I DROVE IMMEDIATELY TO STAR MOTOR DEALERSHIP WHERE THEY LOOKED AT MY VEHICLE LESS THAN 20 MINUTES AFTER IT OCCURRED. THE SERVICE ADVISER AND SOME OF THE TECHNICIANS QUICKLY LOOKED AT THE VEHICLE (IT WAS NEAR CLOSING TIME). THEY SAID THEY COULD NOT READ THE CODES OTHER THAN THE SRS FAULT. I WAS ADVISED THAT IT WOULD LIKELY BE CHEAPER TO FIX AT A BODY SHOP THAN AT THE DEALER. I LATER FOUND THAT THE DRIVER SIDE REAR SEATBELT HAD ALSO DEPLOYED AND WAS TIGHTENED.
NHTSA ODI #11021798
125,000 miles · Apr 12, 2016
Air BagsCrashInjury
I WAS INVOLVED IN AN ACCIDENT SAT. APRIL 9, 2016. I STRUCK ANOTHER VEHICLE THAT WAS STOPPED DEAD STILL IN THE ROAD. MY AIR BAGS DID NOT DEPLOY . I WAS TRAVELING AT A SPEED OVER 30 MILES AN HOUR BUT LESS THAN 45 MPH AND THE IMPACT WAS DEAD ON, NO GLANCING BLOW. THE ACCIDENT HAPPENED ON A STATE HIGHWAY ABOUT 10 P.M.
NHTSA ODI #10855019
84,042 miles · Oct 28, 2011
Air BagsService Brakes, HydraulicCrashInjury
DRIVING EAST ON US 30 IN SLOW MOVING TRAFFIC ON WET PAVEMENT (DUE TO PREVIOUS RAIN) BETWEEN TORONITO STREET AND LOUCKS MILL ROAD IN YORK, PA, I ATTEMPTED TO SLOW DOWN TO STAY WITH THE TRAFFIC AND REALIZED THE BRAKES WERE NOT WORKING, I APPLIED FULL PRESSURE EXPECTING THE ABS TO ACTIVATE AND NOTHING HAPPENED. I RAN INTO THE BACK …
Read full complaint
DRIVING EAST ON US 30 IN SLOW MOVING TRAFFIC ON WET PAVEMENT (DUE TO PREVIOUS RAIN) BETWEEN TORONITO STREET AND LOUCKS MILL ROAD IN YORK, PA, I ATTEMPTED TO SLOW DOWN TO STAY WITH THE TRAFFIC AND REALIZED THE BRAKES WERE NOT WORKING, I APPLIED FULL PRESSURE EXPECTING THE ABS TO ACTIVATE AND NOTHING HAPPENED. I RAN INTO THE BACK OF THE CAR AHEAD WHICH WENT INTO THE CAR IN FRONT OF HIM. THE IMPACT DID NOT ACTIVATE THE AIRBAGS. MY SEAT BELT HELD ME BUT I DID RECEIVE WHIP-LASH. THE INSURANCE COMPANY HAS TOTALED MY CAR. *TR THE CONSUMER RECEIVED A LETTER FROM MERCEDES BENZ STATING THE IMPACT DAMAGE WAS BELOW AIR BAG DEPLOYMENT THRESHOLDS AND THE EXAMINATION OF THE VEHICLE, REVEALED NO DEFECT IN THE BRAKING SYSTEM. UPDATED IVOQ 01/06/12. *TT
NHTSA ODI #10433501
60,000 miles · Nov 9, 2010
Air BagsSeat Belts
2006 MERCEDES E320 CDI SRS MALFUNCTION MESSAGE. SO FAR HAVE HAD TO REPLACE STEERING WHEEL WIRING HARNESS CONNECTOR, HARNESS, REEL, AND COMPUTER TO REPAIR SRS. *TR
NHTSA ODI #10365149
Mileage unknown · Jan 21, 2007
Air Bags
ON DECEMBER 28 2006 I TOOK MY 2003 MERCEDES BENZ E320 TO MERCEDES BENZ OF MANHATTAN BECAUSE THE SRS (SAFETY RESTRAINT SYSTEM) LIGHT CAME ON IN THE DASHBOARD. THE TECHNICIANS DETERMINED THAT THE SRS CONTROL UNIT WAS MALFUNCTIONING AND NEEDED TO BE REPLACED. THE SRS CONTROL UNIT IS RESPONSIBLE FOR DEPLOYING THE AIR BAGS AND TENSI…
Read full complaint
ON DECEMBER 28 2006 I TOOK MY 2003 MERCEDES BENZ E320 TO MERCEDES BENZ OF MANHATTAN BECAUSE THE SRS (SAFETY RESTRAINT SYSTEM) LIGHT CAME ON IN THE DASHBOARD. THE TECHNICIANS DETERMINED THAT THE SRS CONTROL UNIT WAS MALFUNCTIONING AND NEEDED TO BE REPLACED. THE SRS CONTROL UNIT IS RESPONSIBLE FOR DEPLOYING THE AIR BAGS AND TENSIONING THE SEAT BELTS IN CASE OF AN ACCIDENT. I PURCHASED MY CAR USED FROM A NISSAN DEALERSHIP WITH A BUMPER TO BUMPER EXTENDED WARRANTY FROM QUALITYGUARD PLUS 615-725-1000 POLICY #QSDL01651641 EXPIRES: 07-01-2007. THE WARRANTY COMPANY WAS INFORMED OF THE ABOVE, BUT REFUSED TO PAY FOR REPAIRS CLAIMING THAT THE PART WAS NOT COVERED UNDER THE WARRANTY. I ASKED THEM WHY, AND THEY JUST REPEATED, ITS NOT COVERED. I THINK I DESERVE A BETTER ANSWER THAN THAT, ESPECIALLY WHEN IT COMES TO MY PERSONAL SAFETY AND THE SAFETY OF MY FAMILY. I THINK IT SHOULD BE COVERED. YOU ASSISTANCE WITH THIS MATTER WOULD BE APPRECIATED. *NM
NHTSA ODI #10179264
14,500 miles · Nov 5, 2006
Air Bags
(1)ERROR MESSAGE ON VEHICLE TO RETURN VEHICLE TO SERVICE BECAUSE OF SRS FAILURE. (2) DEALER TOLD ME THAT THIS FAILURE RESULTS IN NON DEPLOYMENT OF AIR BAGS AND SEAT BELT TENSIONERS, AND TOLD ME IT WAS NOT SAFE TO DRIVE THE VEHICLE. (3) DEALER REPLACED 5 CABLES, 10 CABLE CONNECTORS, 1 FUSE ELEMENT AND REPROGRAMMED COMPUTER. B…
Read full complaint
(1)ERROR MESSAGE ON VEHICLE TO RETURN VEHICLE TO SERVICE BECAUSE OF SRS FAILURE. (2) DEALER TOLD ME THAT THIS FAILURE RESULTS IN NON DEPLOYMENT OF AIR BAGS AND SEAT BELT TENSIONERS, AND TOLD ME IT WAS NOT SAFE TO DRIVE THE VEHICLE. (3) DEALER REPLACED 5 CABLES, 10 CABLE CONNECTORS, 1 FUSE ELEMENT AND REPROGRAMMED COMPUTER. BY THE WAY, CONSUMER FORUMS AND BLOGS REFERENCE MANY IDENTICAL MERCEDES SYSTEM FAILURES. *NM
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2001-2011 C-Class, CLK, E-Class, and CLS vehicles. Please see the recall report for a complete list of models and model years. The glass sunroof panel may not be properly secured and can detach.
Consequence & remedy
Consequence: A detached sunroof panel can become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the sunroof panel as necessary, free of charge. Owner notification letters were mailed January 10, 2025. Owners may contact MBUSA customer service at 1-800-367-6372. This recall is an expansion of previous NHTSA recall number 22V-954. MBUSA's number for this recall is 2024120001/2/3.
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2001-2011 C-Class, CLK, E-Class, and CLS vehicles. Please refer to MBUSA's recall report for specific vehicle model details. The glass sunroof panel may not be properly secured and may detach.
Consequence & remedy
Consequence: A detached sunroof panel may become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the sunroof panel as necessary free of charge. Owner notification letters were mailed February 3, 2023. Owners may contact MBUSA customer service at 1-800-367-6372. This recall expands NHTSA recall number 19V-918. MBUSA's numbers for this recall are 2023010004, 2023010005, and 2023010006.
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2006-2007 C350, C230, C280, CLK350, E320CDI, E350 Wagon, E350, 2006 C55 AMG, CLK500, CLS500, CLS55 AMG, E500 Wagon, E500, E55 AMG, 2007 CLK550, CLS550, CLS63 AMG, E550, E63 AMG, and E63 Wagon AMG vehicles. The bonding between the glass panel and the sliding roof frame may deteriorate, possibly causing the glass panel to detach from the vehicle.
Consequence & remedy
Consequence: A detached glass panel can separate from the vehicle and become a road hazard, increasing the risk of a crash.
Remedy: MBUSA will notify owners, and dealers will inspect the glass panel bonding and replace the sliding roof, as necessary, free of charge. Owner letters were mailed May 7, 2021. Owners may contact MBUSA customer service at 1-800-367-6372. This recall is an expansion of recall number 19V-918. MBUSA's number for this recall is 2021040012.
Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2001-2011 vehicles. The bonding between the glass panel and the sliding roof frame may deteriorate, possibly resulting in the glass panel detaching from the vehicle. For a full list of the affected models visit: https://static.nhtsa.gov/odi/rcl/2019/RMISC-19V918-4126.pdf
Consequence & remedy
Consequence: A detached glass panel can separate from the vehicle and become a road hazard, increasing the risk of a crash.
Remedy: MBUSA will notify owners, and dealers will inspect the glass panel bonding and replace the sliding roof, as necessary, free of charge. The recall began July 10, 2020. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2020040011.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE10017 · Driver Air Bag Circuit High Resistance
Opened May 14, 2010 · Closed Nov 24, 2010
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Electrical System; Electrical System:wiring; Electrical System:wiring:interior/under Dash
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Additional source detail variants (5)
Air Bags:frontal
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Air Bags
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Electrical System
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Electrical System:wiring:interior/under Dash
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Electrical System:wiring
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
2006 Mercedes Benz E320 Problems, Complaints & Recalls | Skip That Year
Illustration