IllustrationWHEN I FILL THE TANK WITS GAS(NOT TOPPED OFF) WHEN I DRIVE IT HOM PARK IT IN GARAGE IT SMELL OF A STRONG GAS ORDER. AFRESH DRIVIBG A LITTLE ( TO USE GAS) IT GOES AWAY, HAPPENS EACH TIME I FILL.
2005 Mercedes Benz E320
Owner reports · Recalls · Investigations
More warning signs than most E320 years
Owner complaints for the 2005 Mercedes Benz E320 are substantially higher than the model-year median of 42.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all E320 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
170–25K
1825–50K
4050–75K
3475–100K
59100–150K
21150K+
189 reports with mileage · 42 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 81 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports4 fire reports11 injury reports
What owners actually said
231 reportsTL* THE CONTACT OWNS A 2005 MERCEDES-BENZ E320. WHILE THE VEHICLE WAS STATIONARY, DIESEL FUEL LEAKED ONTO THE GROUND. THE CONTACT NOTICED AN ODOR OF FUEL INSIDE THE VEHICLE, WHICH CAUSED HEADACHES FOR THE OCCUPANTS. MERCEDES-BENZ IN DAYTONA BEACH, FLORIDA WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTU…
Read full complaint
TL* THE CONTACT OWNS A 2005 MERCEDES-BENZ E320. WHILE THE VEHICLE WAS STATIONARY, DIESEL FUEL LEAKED ONTO THE GROUND. THE CONTACT NOTICED AN ODOR OF FUEL INSIDE THE VEHICLE, WHICH CAUSED HEADACHES FOR THE OCCUPANTS. MERCEDES-BENZ IN DAYTONA BEACH, FLORIDA WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 129,000.
WAS DRIVING IN MY 2005 E320 W211, LAST WEEK 500 AM IN THE MORNING SOUTHBOUND TOWARDS FREEWAY ABOUT 45 MPH HAD PERFECT BRAKES THEN RED WARNING ON DASH NO BRAKES HAD COMPLETE BRAKE FAILURE WENT THROUGH THE RED LIGHT ROLLED TO A STOP!GOOD THING IT WAS EARLY IN THE MORNING.. 2ND COMPLAINT I CALLED MERCEDES DEALER WHERE I BOUGHT THE …
Read full complaint
WAS DRIVING IN MY 2005 E320 W211, LAST WEEK 500 AM IN THE MORNING SOUTHBOUND TOWARDS FREEWAY ABOUT 45 MPH HAD PERFECT BRAKES THEN RED WARNING ON DASH NO BRAKES HAD COMPLETE BRAKE FAILURE WENT THROUGH THE RED LIGHT ROLLED TO A STOP!GOOD THING IT WAS EARLY IN THE MORNING.. 2ND COMPLAINT I CALLED MERCEDES DEALER WHERE I BOUGHT THE CAR JUST GOT BRUSH OFF AS USUAL. WELL ANOTHER W211 WITH SBC PUMP FAILURE!HOW MANY DOES THIS MAKE! GOOD THING NOT DOING 80 ON FREEWAY WITH KIDS IN THE CAR!!!!!!! ANYWAY MY STARTECH MECHANIC WARNED ME ABOUT THIS WHEN I CALLED MY DEALER IN 2013 STILL UNDER EXTEDED GOODWILL WARRANTY THAT NOBODY KNEW ABOUT. I CALLED AND ASKED ABOUT RECALL, I WAS TOLD: "NOTHING WRONG WITH THAT MODEL CAR NO RECAL"L AND NOW!!!NEVER GOT A LETTER EXPLAINING THE BRAKES COULD GO OUT ANYTIME WITHOUT WARNING OR PHONE CALL, ABOUT THIS DEFECTIVE BRAKE PUMP DRIVING AROUND IN POTENTIAL DEATH MACHINE!!!! JUST REALLY DISSAPOINTED IN MY DEALERSHIP. I CALLED THEM AGAIN TELLING THEM SBC PUMP WENT NO GOODWILL GOODHEART CHANGE OF DEFECTIVE PUMP AND NOW COST ME 2000.00 TO FIX A DEFECTIVE SBC PUMP THAT SHOULD HAD BEEN CHANGED BEFORE I BOUGHT THE CAR, OR CORRECTED ME WHEN I CALLED THEY SHOULD HAVE TOLD ME THERE IS A EXTENDED WARRANTY I WOULD HAVE BROUGHT IT IN THEN! VERY FRUSTRATED WITH MERCEDES BENZ DEALER WHERE I BOUGHT MY CAR HOPE THIS BECOMES A NATIONAL RECALL BEFORE SOMETHING REALLY BAD HAPPENS, MOST PEOPLE 2ND OWNERS ARE PROBABLY HAVE NO IDEA.
I GOT A MESSAGE ON MY DASHBOARD TO VISIT CAR SHOP FOR BRAKES. THINKING THAT I NEEDED TO REPLACE BRAKES, I DROVE IT FOR A COUPLE OF WEEKS ( I HARDLY DRIVE) AND TOOK IT IN. ONLY TO FIND OUT IT WAS THE HYDRAULIC PUMP THAT WENT OUT AND COULD LEAVE ME WITHOUT ANY BRAKES AT ANY SECOND!! I HAD TO LEAVE IT THERE FOR 4 DAYS AND PAID 15…
Read full complaint
I GOT A MESSAGE ON MY DASHBOARD TO VISIT CAR SHOP FOR BRAKES. THINKING THAT I NEEDED TO REPLACE BRAKES, I DROVE IT FOR A COUPLE OF WEEKS ( I HARDLY DRIVE) AND TOOK IT IN. ONLY TO FIND OUT IT WAS THE HYDRAULIC PUMP THAT WENT OUT AND COULD LEAVE ME WITHOUT ANY BRAKES AT ANY SECOND!! I HAD TO LEAVE IT THERE FOR 4 DAYS AND PAID 1544.
THE CAR IS BEING HACKED INTO BY MULTIPLE INDIVIDUALS ACROSS TRIPLE CITIES. THE HACKERS ARE ABLE TO LOCK AND UNLOCK THE DOORS, SHIFT GEARS, TURN ON THE CHECK ENGINE LIGHT, CONTROL THE RADIO AND CD PLAYER, OPEN THE HOOD TO STEAL OIL AND CONTROL THE COMPLETE FUNCTIONALITY OF THE CAR. INCLUDING TURNING ON THE CABIN LIGHTS, BLACKING …
Read full complaint
THE CAR IS BEING HACKED INTO BY MULTIPLE INDIVIDUALS ACROSS TRIPLE CITIES. THE HACKERS ARE ABLE TO LOCK AND UNLOCK THE DOORS, SHIFT GEARS, TURN ON THE CHECK ENGINE LIGHT, CONTROL THE RADIO AND CD PLAYER, OPEN THE HOOD TO STEAL OIL AND CONTROL THE COMPLETE FUNCTIONALITY OF THE CAR. INCLUDING TURNING ON THE CABIN LIGHTS, BLACKING OUT THE ODOMETER ALONG WITH THE FUEL GAUGE, AND SHUTTING THE CAR OFF WHEN DESIRED THIS INCLUDES IN THE MIDDLE OF THE STREET. BECAUSE THEY CAN UNLOCK THE DOORS AND ROLL DOWN THE WINDOWS THEY HAVE ACCESS TO THE HOOD AND GAS DOOR. THIS ALLOWED THEM TO BREAK THE RADIATOR, DAMAGE THE CATALYTIC CONVERTER, AND STEAL GAS. ALSO SINCE THE HACKERS HAVE ACCESS THEY HAVE DESTROYED THE DRIVERS SEAT, CRACK THE WOOD ON THE STEERING WHEEL AND DOOR TRIM, REMOVED THE RIGHT AND LEFT FRONT DOORS, AND DESTROYED THE CENTER ARM REST. THE RF FIELD IS CONTROLLED BY THEM, AND LOUD CRACKING SOUNDS ARE REMOTELY INTRODUCED WHEN THE CAR IS STATIONARY AND KEY REMOVED. THE TELE- AID IS ALSO ACTIVITIES REMOTELY ON OCCASION AS WELL. THE FBI HAS BEEN NOTIFIED NUMEROUS TIMES TO NO AVAIL ALONG WITH THE CAR MAKER WHO TOLD ME NOT TO CONTACT THEM AGAIN. THREE DEALERSHIPS CHECKED OUT THE CAR AND NONE KNEW HOW TO DEAL WITH THE ISSUE. MERCEDES BENZ IN GERMANY WAS NOTIFIED BY EMAI AND SAID MERCEDES USA HAS MY INFORMATION I'M THEIR LEGAL DEPARTMENT. THIS WAS OVER 2 YEARS AGO WITH NO CONTACT FROM THEM REGARDING THIS ISSUE. ALL ATTEMPTS TO REACH THEM BY PHONE VIA CUSTOMER SERVICE HAS FAILED. MULTIPLE POLICE REPORTS HAVE BEEN MADE WITH SEVERAL POLICE DEPARTMENTS.
THERE IS A HIGH LEVEL OF RF BEING EMITTED INSIDE THE CABIN OF THE CAR. THE LEVEL IS SO HIGH IT PUSHES PULSED RF WAVES AGAINST AN ALUMINUM EMERGENCY BLANKET THAT WAS SET UP TO IDENTIFY WHICH DIRECTION IT WAS COMING FROM. THIS METHOD SHOWED IT IS COMING FROM MULTIPLE DIRECTION WITHIN THE CABIN. THIS IS WITH THE ENGINE OFF AND WIND…
Read full complaint
THERE IS A HIGH LEVEL OF RF BEING EMITTED INSIDE THE CABIN OF THE CAR. THE LEVEL IS SO HIGH IT PUSHES PULSED RF WAVES AGAINST AN ALUMINUM EMERGENCY BLANKET THAT WAS SET UP TO IDENTIFY WHICH DIRECTION IT WAS COMING FROM. THIS METHOD SHOWED IT IS COMING FROM MULTIPLE DIRECTION WITHIN THE CABIN. THIS IS WITH THE ENGINE OFF AND WINDOWS ROLLED UP. ALSO LF L LEAVE THE CAR AND COME BACK WITHIN LESS THAN A MINUTE THE CLIMATE INSIDE WILL KNOCK ME OUT, OR MAKE ME VERY SLEEPY. I HAVE TO IMMEDIATELY GET OUT OF THE CAR AND WALK 50 TO 70 FEET AWAY FROM IT TO STOP THIS FROM HAPPENING IF L CATCH IT IN TIME. MOST OF THE TIME L DO NOT AND SOMEONE IS USING THIS DEFECT TO STEAL ITEMS FROM THE CAR, DESTROY THE INTERIOR AD ALONG WITH A HOST OF ILLEGAL ACTIVITY WHILE L AM PASSED OUT INSIDE.BECAUSE THIS DANGEROUS ACTIVITY HAPPENS 90 PERCENT OF THE TIME THE RF MAY BE REMOTELY CONTROLLED. ALSO L HAVE ALMOST BEEN KNOCKED OUT WHILE DRIVING ON SEVERAL DIFFERENT OCCASIONS. THANKS TO JESUS CHRIST L WAS ABLE TO PULL THE CAR OVER AND RECOVER. IN ADDITION THE RF WILL ISOLATE AND FREEZE DIFFERENT BODY PARTS INDIVIDUALLY SIMILAR TO THE THERAPEUTIC PROCEDURE OF COOL SCULPTING. MULTIPLE POLICE REPORTS HAVE BEEN MADE AND THE DEALERSHIP NOTIFIED. THE CAR MARKER WAS NOTIFIED BY PHONE BUT REFUSE TO HELP.
TL* THE CONTACT OWNS A 2005 MERCEDES-BENZ E320. WHILE DECELERATING FROM 60 MPH, THE BRAKES FAILED TO ENGAGE. THE BRAKE WARNING INDICATOR ILLUMINATED PRIOR TO THE FAILURE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SENSOTRONIC BRAKE CONTROL (SBC) WAS FAULTY. THE VEHICLE WAS REPAIRED. THE DEAL…
Read full complaint
TL* THE CONTACT OWNS A 2005 MERCEDES-BENZ E320. WHILE DECELERATING FROM 60 MPH, THE BRAKES FAILED TO ENGAGE. THE BRAKE WARNING INDICATOR ILLUMINATED PRIOR TO THE FAILURE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SENSOTRONIC BRAKE CONTROL (SBC) WAS FAULTY. THE VEHICLE WAS REPAIRED. THE DEALER AND MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE DEALER INFORMATION WAS UNKNOWN. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 65,000. *TT *TR
TL* THE CONTACT OWNS A 2005 MERCEDES-BENZ E320. WHEN THE VEHICLE WAS STARTED, THE FRONT PASSENGER AIR BAG WARNING CHIME WAS AUDIBLE. THE CONTACT STATED THAT THE WARNING CHIME CONTINUED UNTIL THE SEAT BELT WAS SECURED EVEN THOUGH THERE WAS NO PASSENGER SEATED IN THE FRONT PASSENGER SEAT. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED.…
Read full complaint
TL* THE CONTACT OWNS A 2005 MERCEDES-BENZ E320. WHEN THE VEHICLE WAS STARTED, THE FRONT PASSENGER AIR BAG WARNING CHIME WAS AUDIBLE. THE CONTACT STATED THAT THE WARNING CHIME CONTINUED UNTIL THE SEAT BELT WAS SECURED EVEN THOUGH THERE WAS NO PASSENGER SEATED IN THE FRONT PASSENGER SEAT. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED. MERCEDES-BENZ OF FLORENCE (2199 DAVID H MCLEOD BLVD, FLORENCE, SC 29501, (843) 410-5188) STATED THAT THE VEHICLE NEEDED TO BE DIAGNOSED, BUT DECLINED TO DO SO. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 82,000.
IN 2015 WE STARTED TO NOTICE THE SMELL OF GASOLINE FOLLOWING FILLING THE TANK WITH GAS. THE SMELL OF GASOLINE IS SO STRONG THAT WE HAD TO OPEN OUR GARAGE DOORS TO VENT THE FUMES. NO GASOLINE WAS SPILLED DURING REFUELING. THERE IS NO VISIBLE GAS LEAK ON THE GARAGE FLOOR. THE VEHICLE IS A 2005 MERCEDES-BENZ E320 WITH ONLY 44,0…
Read full complaint
IN 2015 WE STARTED TO NOTICE THE SMELL OF GASOLINE FOLLOWING FILLING THE TANK WITH GAS. THE SMELL OF GASOLINE IS SO STRONG THAT WE HAD TO OPEN OUR GARAGE DOORS TO VENT THE FUMES. NO GASOLINE WAS SPILLED DURING REFUELING. THERE IS NO VISIBLE GAS LEAK ON THE GARAGE FLOOR. THE VEHICLE IS A 2005 MERCEDES-BENZ E320 WITH ONLY 44,000 MILES. AFTER RESEARCHING THIS PROBLEM WE DISCOVERED NUMEROUS OTHER OWNERS OF THIS MODEL MERCEDES HAVE EXPERIENCED THE SAME PROBLEM. MERCEDES HAS NO RECALL FOR THIS FUEL FUME DEFECT AND ANY REPAIR IS NOT WITHIN THE ORIGINAL WARRANTY PERIOD. NHTSA ACTION #EA13003 SUMMARY TEST & ANALYSIS BY MERCEDES-BENZ SHOWS NO RISKS OF FIRE OR PASSENGER SAFETY. THIS IS BS AS FUEL FUMES WITHIN AN ENCLOSED AREA, SUCH AS A GARAGE WHERE A NATURAL GAS HOT WATER TANK EXISTS, COULD CAUSE A FIRE. NHTSA NEEDS TO REQUIRE MERCEDES-BENZ TO RECALL THE VEHICLES AFFECTED BY THIS DEFECT.
TL* THE CONTACT OWNS A 2005 MERCEDES-BENZ E320. THE CONTACT STATED THAT WHEN THE DEALER (RBM OF ATLANTA, INC, 7640 ROSWELL RD, ATLANTA, GA 30350, (770) 390-0700) SOLD THE VEHICLE, THE CONTACT WAS NOT INFORMED THAT IT WAS INCLUDED IN A MANUFACTURER SERVICE CAMPAIGN FOR THE SBC PUMP. IN ADDITION, WHILE APPROACHING A STOP, THE VEHI…
Read full complaint
TL* THE CONTACT OWNS A 2005 MERCEDES-BENZ E320. THE CONTACT STATED THAT WHEN THE DEALER (RBM OF ATLANTA, INC, 7640 ROSWELL RD, ATLANTA, GA 30350, (770) 390-0700) SOLD THE VEHICLE, THE CONTACT WAS NOT INFORMED THAT IT WAS INCLUDED IN A MANUFACTURER SERVICE CAMPAIGN FOR THE SBC PUMP. IN ADDITION, WHILE APPROACHING A STOP, THE VEHICLE STALLED AND A RED WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS UNABLE TO BE DRIVEN. THE POLICE HAD TO ASSIST THE CONTACT WITH COASTING THE VEHICLE OFF THE ROAD DUE TO THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE DEALER (MERCEDES-BENZ OF SARASOTA, 4754 CLARK RD, SARASOTA, FL 34233, (941) 275-1293) ADVISED THAT THE VEHICLE BE TOWED FOR DIAGNOSTIC TESTING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO SERVICED THE VEHICLE. THE MANUFACTURER INDICATED THAT THE VEHICLE WAS EXCLUDED FROM THE CAMPAIGN FOR THE SBC PUMP, STATING THAT THE STATUTE HAD EXPIRED TO RECEIVE THE REPAIR; HOWEVER, THE CONTACT WAS NEVER NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Official recalls
324V874000 · Visibility:sun/moon Roof Assembly
Nov 19, 2024
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2001-2011 C-Class, CLK, E-Class, and CLS vehicles. Please see the recall report for a complete list of models and model years. The glass sunroof panel may not be properly secured and can detach.
Consequence & remedy
Consequence: A detached sunroof panel can become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the sunroof panel as necessary, free of charge. Owner notification letters were mailed January 10, 2025. Owners may contact MBUSA customer service at 1-800-367-6372. This recall is an expansion of previous NHTSA recall number 22V-954. MBUSA's number for this recall is 2024120001/2/3.
22V954000 · Visibility:sun/moon Roof Assembly
Dec 23, 2022
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2001-2011 C-Class, CLK, E-Class, and CLS vehicles. Please refer to MBUSA's recall report for specific vehicle model details. The glass sunroof panel may not be properly secured and may detach.
Consequence & remedy
Consequence: A detached sunroof panel may become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the sunroof panel as necessary free of charge. Owner notification letters were mailed February 3, 2023. Owners may contact MBUSA customer service at 1-800-367-6372. This recall expands NHTSA recall number 19V-918. MBUSA's numbers for this recall are 2023010004, 2023010005, and 2023010006.
19V918000 · Visibility:sun/moon Roof Assembly
Dec 20, 2019
Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2001-2011 vehicles. The bonding between the glass panel and the sliding roof frame may deteriorate, possibly resulting in the glass panel detaching from the vehicle. For a full list of the affected models visit: https://static.nhtsa.gov/odi/rcl/2019/RMISC-19V918-4126.pdf
Consequence & remedy
Consequence: A detached glass panel can separate from the vehicle and become a road hazard, increasing the risk of a crash.
Remedy: MBUSA will notify owners, and dealers will inspect the glass panel bonding and replace the sliding roof, as necessary, free of charge. The recall began July 10, 2020. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2020040011.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA13003 · Fuel Leakage From The Fuel Tank
Opened Mar 15, 2013 · Closed Dec 19, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Additional source detail variants (6)
Fuel System, Gasoline:delivery:fuel Pump
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
PE10017 · Driver Air Bag Circuit High Resistance
Opened May 14, 2010 · Closed Nov 24, 2010
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Electrical System; Electrical System:wiring; Electrical System:wiring:interior/under Dash
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Additional source detail variants (5)
Air Bags:frontal
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Air Bags
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Electrical System
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Electrical System:wiring:interior/under Dash
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Electrical System:wiring
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.