IllustrationWITH LESS THAN 90K MILES, THE HYDRAULIC BRAKE PUMP WENT OUT. MBUSA KNEW ABOUT ISSUES WITH THE PART AND EXTENDED ITS WARRANT UNTIL 12/24/2014 BUT DID NOT NOTIFY AFFECTED VEHICLE OWNERS.
2005 Mercedes Benz E320
Owner reports · Recalls · Investigations
More warning signs than most E320 years
Owner complaints for the 2005 Mercedes Benz E320 are substantially higher than the model-year median of 42.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all E320 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
170–25K
1825–50K
4050–75K
3475–100K
59100–150K
21150K+
189 reports with mileage · 42 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 81 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports4 fire reports11 injury reports
Service Brakes complaints
43 reportsOUR CAR'S BRAKES HAVE BEEN MAINTAINED BECAUSE STOPPING IS AN ESSENTIAL FUNCTION. E.G. PADS AND ROTORS AS NEEDED PLUS FLUID FLUSH PERIODICALLY. NOW WE'VE LEARNED WE MAY BE AT RISK OF CAREENING OUT OF CONTROL WITH NO BRAKES - PERHAPS INTO ONCOMING TRAFFIC OR PEDESTRIANS - JUST BECAUSE THE MERCEDES' SBC (SENSOTRONIC BRAKE CONTROL) …
Read full complaint
OUR CAR'S BRAKES HAVE BEEN MAINTAINED BECAUSE STOPPING IS AN ESSENTIAL FUNCTION. E.G. PADS AND ROTORS AS NEEDED PLUS FLUID FLUSH PERIODICALLY. NOW WE'VE LEARNED WE MAY BE AT RISK OF CAREENING OUT OF CONTROL WITH NO BRAKES - PERHAPS INTO ONCOMING TRAFFIC OR PEDESTRIANS - JUST BECAUSE THE MERCEDES' SBC (SENSOTRONIC BRAKE CONTROL) SOFTWARE PREDETERMINES WHEN THE BRAKES HAVE REACHED END OF SERVICE AND DISABLES THEM. WORSE, IT MAY DO THIS WITHOUT WARNING! SINCE THE WARRANTY ON THE SBC WAS EXTENDED FROM 4-YR/50K MILES TO 10 YEARS/UNLIMITED, AND CONSIDERING THE LIFE OF THESE CARS IS SIGNIFICANTLY MORE THAN 10 YEARS, SHOULDN'T THE REPLACEMENT WARRANTY BE EXTENDED FURTHER, TO PERHAPS 15 OR 20 YEARS? OR BETTER STILL, SHOULDN'T THEY BE RETROFITTED WITH NON-ELETROHYDRAULIC BRAKES . . . LIKE MODELS PRIOR TO AND SUBSEQUENT TO MERCEDES' SBC EXPERIMENT? MOREOVER, WHEN THESE CARS ARE SOLD, IS THE PUBLIC ON THE HOOK FOR THE LIABILITY OF A CAR SOLD WITH DEFECTIVE BRAKES? E.G. ONE, WHICH HAS BRAKES CAPABLE OF BEING DISABLED BY MERCEDES' SOFTWARE? PLEASE HELP!
WHILE DRIVING TO WORK THE VEHICLE DISPLAYED SEVERAL WARNINGS OF PROBLEMS WITH SBC, ABS, ESP. THE BRAKES THEN REQUIRED A GREAT DEAL OF PRESSURE TO EFFECTIVELY STOP THE VEHICLE AND THE VEHICLE BECAME MUCH HARDER TO STEER.AFTER PULLING OFF THE HIGHWAY AND PLACING THE TRANSMISSION IN PARK, I WAS UNABLE TO GET THE TRANSMISSION OUT O…
Read full complaint
WHILE DRIVING TO WORK THE VEHICLE DISPLAYED SEVERAL WARNINGS OF PROBLEMS WITH SBC, ABS, ESP. THE BRAKES THEN REQUIRED A GREAT DEAL OF PRESSURE TO EFFECTIVELY STOP THE VEHICLE AND THE VEHICLE BECAME MUCH HARDER TO STEER.AFTER PULLING OFF THE HIGHWAY AND PLACING THE TRANSMISSION IN PARK, I WAS UNABLE TO GET THE TRANSMISSION OUT OF PARK.THE VEHICLE WAS TAKEN TO MY MECHANIC WHERE THEY DIAGNOSED A PROBLEM WITH THE SBC,AND ESP MODULES. I HAVE DISCOVERED THAT THIS IS A COMMON OCCURRENCE WITH MERCEDES BENZ VEHICLES WITH THIS BRAKING SYSTEM, SO MUCH SO THAT THE DISCONTINUED USING IT. THIS CREATES AN EXTREMELY DANGEROUS SITUATION FOR THE DRIVERS OF THESE VEHICLES AND MERCEDES SHOULD EITHER REPAIR ALL EFFECTED VEHICLES OR REMOVE THEM FROM THE ROAD.
I RECEIVED THE RED DASH WARNING AT THE SAME TIME AS THE COMPLETE BRAKING FAILURE (NOT BEFORE) AND THERE WAS MAYBE 2% BRAKING CAPABILITY REMAINING (USELESS HYDRAULIC FAIL SAFE). THAT'S WITH THE PEDAL ON THE FIREWALL AT 5 MPH. EVEN WITH FORCE ENOUGH TO PUSH THE PEDAL INTO THE FIREWALL IT WAS STILL A GRADUAL SLOW DOWN. THIS WAS AT …
Read full complaint
I RECEIVED THE RED DASH WARNING AT THE SAME TIME AS THE COMPLETE BRAKING FAILURE (NOT BEFORE) AND THERE WAS MAYBE 2% BRAKING CAPABILITY REMAINING (USELESS HYDRAULIC FAIL SAFE). THAT'S WITH THE PEDAL ON THE FIREWALL AT 5 MPH. EVEN WITH FORCE ENOUGH TO PUSH THE PEDAL INTO THE FIREWALL IT WAS STILL A GRADUAL SLOW DOWN. THIS WAS AT AROUND 5 MPH! NOW IMAGINE COMING OFF A STEEP OFF RAMP FROM 70MPH THAT ENDS ABRUPTLY AND PERPENDICULAR TO A BUSY INTERSECTION WHEN THIS HAPPENS... NOT GOOD. AFTER SITTING IN THE CAR OFF FOR A FEW MINUTES I DECIDED TO START THE CAR UP AGAIN, THE MESSAGE WAS GONE AND FULL BRAKING PRESSURE RESTORED. TALK ABOUT A GAME OF RUSSIAN ROULETTE, I HAVE NO IDEA WHEN THIS TIME BOMB IS SET TO GO OFF AGAIN. THIS IS NOT EVEN REMOTELY ACCEPTABLE AND IS INCREDIBLY DANGEROUS. MERCEDES KNEW THIS AND MOVED BACK TO A STANDARD BRAKING SYSTEM IN 2006 LEAVING VERY LITTLE ASSISTANCE TO THOSE WITH THE SBC MODULES INSTALLED. THESE SHOULD BE REPLACED BY DEALERS AT THEIR EXPENSE INDEFINITELY. IT WAS A TERRIBLE MISTAKE AND THEY ADMIT IT, NOW IT'S TIME TO TAKE RESPONSIBILITY FOR THOSE WITH MALFUNCTIONING UNITS AND SAVE SOME LIVES. CHECK MERCEDES SERVICE BULLETIN S142.46-P-0012A FOR MORE INFORMATION. *TR
THIS VEHICLE IS EQUIPPED WITH SENSOTRONIC BRAKE CONTROL THAT HAS A SERVICE THRESHOLD. WHEN THIS THRESHOLD IS REACHED, THE VEHICLE'S BRAKE SYSTEM DEFAULTS TO NON POWER ASSISTED HYDRAULIC MODE TO THE FRONT WHEELS ONLY. THIS OCCURS WITHOUT ANY PRIOR WARNING AND RESULTS IN GREATLY INCREASED STOPPING DISTANCES ALONG WITH MUCH LONGER …
Read full complaint
THIS VEHICLE IS EQUIPPED WITH SENSOTRONIC BRAKE CONTROL THAT HAS A SERVICE THRESHOLD. WHEN THIS THRESHOLD IS REACHED, THE VEHICLE'S BRAKE SYSTEM DEFAULTS TO NON POWER ASSISTED HYDRAULIC MODE TO THE FRONT WHEELS ONLY. THIS OCCURS WITHOUT ANY PRIOR WARNING AND RESULTS IN GREATLY INCREASED STOPPING DISTANCES ALONG WITH MUCH LONGER TIME INTERVAL FOR VEHICLE SPEED REDUCTION DUE TO LOSS OF BRAKE EFFECTIVENESS. MERCEDES (HEREINAFTER REFERRED TO AS MBUSA FOR MERCEDES BENZ USA) SERVICE BULLETIN S142.46-P-0012A ADDRESSES THIS ISSUE. MERCEDES DISCONTINUED INSTALLING THIS TYPE BRAKE SYSTEM ON NEW PRODUCTION VEHICLES AT THE END OF MY 06. SUGGESTED CURE - MBUSA SHOULD ISSUE A MANDATORY RECALL TO INTERROGATE THESE VEHICLES WITH STAR DAS TO DETERMINE HOW CLOSE TO THE SERVICE THRESHOLD (I.E. BRAKE FAILURE) THE SBC UNIT IS. IF MBUSA IS UNABLE TO ASSURE THE VEHICLE OWNER THAT (DUE TO THE DESIGN OF THE SYSTEM) THE VEHICLE'S BRAKES WILL NOT DEFAULT TO BASIC HYDRAULIC MODE FOR FRONT WHEELS ONLY WITHOUT PRIOR NOTICE OF IMMINENT FAILURE, MBUSA SHOULD RETROFIT & REPLACE THE NECESSARY BRAKE SYSTEM COMPONENTS TO INSURE VEHICLE SAFETY AT THE EXPENSE OF MBUSA. THIS IS A MAJOR LIFE-SAFETY ISSUE THAT NEEDS TO BE IMMEDIATELY ADDRESSED. A MAJOR REDUCTION OF EFFICIENCY IN A VEHICLE BRAKING SYSTEM OCCURRING WITHOUT PRIOR WARNING CAN CAUSE PROPERTY LOSS, PERSONAL INJURY AND DEATH, ESPECIALLY AT INTERSTATE HIGHWAY SPEEDS. *TR
THERE WAS A MESSAGE THAT THE BRAKES NEEDED ATTENTION. I COULD FEEL SOMETHING INSIDE THE BRAKES. I TOOK IT AND THEY REPLACED MY BRAKES, BUT THE ISSUE KEPT HAPPENING. THEN ONE DAY, WHILE GOING 55 MILES AN HOUR, THE BRAKES WOULD NOT FULLY OPERATE. THE WHOLE DASH WENT RED AND IT CAME TO A SLOW STOP. LUCKILY NO ONE WAS IMMEDIATEL…
Read full complaint
THERE WAS A MESSAGE THAT THE BRAKES NEEDED ATTENTION. I COULD FEEL SOMETHING INSIDE THE BRAKES. I TOOK IT AND THEY REPLACED MY BRAKES, BUT THE ISSUE KEPT HAPPENING. THEN ONE DAY, WHILE GOING 55 MILES AN HOUR, THE BRAKES WOULD NOT FULLY OPERATE. THE WHOLE DASH WENT RED AND IT CAME TO A SLOW STOP. LUCKILY NO ONE WAS IMMEDIATELY IN FRONT OF ME. WE CALLED THE DEALERSHIP AND THEY SAID THEY HAD A 10 YEAR RECALL OF THE SBC UNIT BUT I DON'T SEE THE RECALL ANYWHERE. THIS IS A SERIOUS ISSUE! *TR
THE WELL KNOWN BRAKE SAFETY ISSUE OF NUMEROUS MB CARS, ALSO CALLED THE SBC SYSTEM, IS CYCLING WAY TO OFTEN AND FEAR ITS PAST IS PREDETERMINED "LIFE CYCLES". FOR SOME REASON MB PUTS A # OF ACTUATIONS ON THE SYSTEM BEFORE IS QUITS OR MUST BE REPLACED. MB HAS INSTRUCTED DEALERS TO NOT REPLACE THE SYSTEM UNLESS A PARTICULAR CODE …
Read full complaint
THE WELL KNOWN BRAKE SAFETY ISSUE OF NUMEROUS MB CARS, ALSO CALLED THE SBC SYSTEM, IS CYCLING WAY TO OFTEN AND FEAR ITS PAST IS PREDETERMINED "LIFE CYCLES". FOR SOME REASON MB PUTS A # OF ACTUATIONS ON THE SYSTEM BEFORE IS QUITS OR MUST BE REPLACED. MB HAS INSTRUCTED DEALERS TO NOT REPLACE THE SYSTEM UNLESS A PARTICULAR CODE SHOWS UP UNDER A DIAGNOSTIC READ. PROBLEM IS THAT FROM THE DEALER OWN SERVICE TECHS.....'FAILING PUMPS DON'T ALWAYS THROW A CODE THAT WILL BE STORED IN THE COMPUTER, OR THERE IS A RESET FACILITY BUILT INTO THE COMPUTER SELF DIAGNOSTIC SYSTEM THAT IS TO RESET A CODE FOR ISSUES WITH THE SBC SYSTEM WHEN CAR IS CYCLED OFF THEN RESTARTED.' MB REFUSES TO FIX SUCH SAFETY ISSUE IF REPAIR IS NEEDED BEYOND THEIR 10 YEAR WARRANTY PERIOD. FOR SECONDARY OWNERS THE REPAIRS THAT ARE NEEDED FOR THE SAFETY OF OCCUPANTS OF THE CAR AND ALL THOSE AROUND THEM PRESENTS AN ISSUE. THIS IS SUCH A SAFETY ISSUE THAT MB QUICKLY STOPPED PRODUCING VEHICLES WITH THE NEW BRAKING SYSTEM EVEN AFTER THEY HAD TOUTED THIS AS BEING THE NEXT BREAK THROUGH IN BRAKING FOR ALL THEIR VEHICLE LINE. THEY KNOW IT IS A SAFETY ISSUE WHICH IS WHY THEY MOVED AWAY FROM PRODUCING IT FURTHER. THE PROBLEM IS THEY ARE NOT BEING HELD RESPONSIBLE FOR REPLACING ALL 'SBC' BRAKING SYSTEMS WHICH HAVE AN INHERENT DEFECT FOR FAILURES. A NON SAFETY ISSUE I CAN UNDERSTAND A WARRANTY RECALL EXPIRATION, BUT NOT FOR SOMETHING LIKE THIS. *TR
TL*THE CONTACT OWNS A 2005 MERCEDES BENZ E-320. THE CONTACT STATED THAT A WARNING MESSAGE ILLUMINATED ON THE INSTRUMENT PANEL STATING 'REDUCED BRAKING POWER'. THE VEHICLE WAS TAKEN TO A DEALER, WHERE THE TECHNICIAN DIAGNOSED THE SPC CONTROL UNIT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE…
Read full complaint
TL*THE CONTACT OWNS A 2005 MERCEDES BENZ E-320. THE CONTACT STATED THAT A WARNING MESSAGE ILLUMINATED ON THE INSTRUMENT PANEL STATING 'REDUCED BRAKING POWER'. THE VEHICLE WAS TAKEN TO A DEALER, WHERE THE TECHNICIAN DIAGNOSED THE SPC CONTROL UNIT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 25,070.
A LITTLE LESS THAN 2 YEARS AGO, VEHICLE'S SENSOTRONIC BRAKE CONTROL (SBC) SYSTEM FAILED. IT WAS REPLACED BY MERCEDES DEALER WITH A RE-MANUFACTURED UNIT UNDER THE TEN YEAR WARRANTY FOR THAT BRAKE SYSTEM. THAT SYSTEM IS VERY WELL KNOWN TO BREAK DOWN WITHOUT WARNING WHICH RENDERS CAR A MOVING HAZARD TO OCCUPANTS AND OTHER MOTORISTS…
Read full complaint
A LITTLE LESS THAN 2 YEARS AGO, VEHICLE'S SENSOTRONIC BRAKE CONTROL (SBC) SYSTEM FAILED. IT WAS REPLACED BY MERCEDES DEALER WITH A RE-MANUFACTURED UNIT UNDER THE TEN YEAR WARRANTY FOR THAT BRAKE SYSTEM. THAT SYSTEM IS VERY WELL KNOWN TO BREAK DOWN WITHOUT WARNING WHICH RENDERS CAR A MOVING HAZARD TO OCCUPANTS AND OTHER MOTORISTS. ON MB FORUMS, IT IS STATED BY COMMENTATORS/OWNERS THAT UNIT HAS A LIFE SPAN OF 300,000 ACTUATIONS; BRAKE PUSHES. THIS IS NOT ANYWHERE IN THE MB LITERATURE OR OWNER'S MANUAL. CAR ELECTRONICS HAVE NO METER TO MEASURE OR GAUGE THOSE ACTUATIONS, SO A CATASTROPHIC FAILURE COULD OCCUR WITHOUT ME THE DRIVER BEING PREPARED FOR IT. MERCEDES BENZ NEEDS TO WARRANTY THIS SAFETY RELATED DEFECT FOR THE LIFE OF THE CAR. *TR
I WAS SLOWING DOWN TO EXIT THE HIGHWAY AND WHEN I STEPPED ON THE BRAKES, I FELT NO PRESSURE ON THE PEDAL BRAKES. I PRESSED HARDER ON THE BRAKES AND STILL THE CAR DIDN'T SLOW UNTIL I GOT TO A SLIGHT INCLINE AT THE END OF THE RAMP. THEN A RED WARNING LIGHT ON THE DASHBOARD APPEARED READING "REDUCED BRAKE POWER". I TURNED OFF TH…
Read full complaint
I WAS SLOWING DOWN TO EXIT THE HIGHWAY AND WHEN I STEPPED ON THE BRAKES, I FELT NO PRESSURE ON THE PEDAL BRAKES. I PRESSED HARDER ON THE BRAKES AND STILL THE CAR DIDN'T SLOW UNTIL I GOT TO A SLIGHT INCLINE AT THE END OF THE RAMP. THEN A RED WARNING LIGHT ON THE DASHBOARD APPEARED READING "REDUCED BRAKE POWER". I TURNED OFF THE ENGINE AND WAITED A COUPLE OF MINUTES. I MANAGED TO GET HOME SAFELY. I CALLED A CERTIFIED MECHANIC AND HE TOLD ME TO CALL THE MERCEDES BENZ DEALER BECAUSE OF A POSSIBLE RECALL. AS PER THE MECHANIC, THIS ARE THE FAULTING CODES: C2131 - PRESSURE RESERVOIR FAULTY C249F - OPERATING TIME OF COMPONENT A7/3 (SBC LEFT HYDRAULIC UNIT) IS EXCEEDED C25D5 - HYDRAULIC FAULT MALFUNCTION IN PRESSURE SUPPLY AS OF THIS WRITING, MY BRAKES HAVE NOT BEEN REPAIRED. *TR
Official recalls
324V874000 · Visibility:sun/moon Roof Assembly
Nov 19, 2024
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2001-2011 C-Class, CLK, E-Class, and CLS vehicles. Please see the recall report for a complete list of models and model years. The glass sunroof panel may not be properly secured and can detach.
Consequence & remedy
Consequence: A detached sunroof panel can become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the sunroof panel as necessary, free of charge. Owner notification letters were mailed January 10, 2025. Owners may contact MBUSA customer service at 1-800-367-6372. This recall is an expansion of previous NHTSA recall number 22V-954. MBUSA's number for this recall is 2024120001/2/3.
22V954000 · Visibility:sun/moon Roof Assembly
Dec 23, 2022
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2001-2011 C-Class, CLK, E-Class, and CLS vehicles. Please refer to MBUSA's recall report for specific vehicle model details. The glass sunroof panel may not be properly secured and may detach.
Consequence & remedy
Consequence: A detached sunroof panel may become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the sunroof panel as necessary free of charge. Owner notification letters were mailed February 3, 2023. Owners may contact MBUSA customer service at 1-800-367-6372. This recall expands NHTSA recall number 19V-918. MBUSA's numbers for this recall are 2023010004, 2023010005, and 2023010006.
19V918000 · Visibility:sun/moon Roof Assembly
Dec 20, 2019
Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2001-2011 vehicles. The bonding between the glass panel and the sliding roof frame may deteriorate, possibly resulting in the glass panel detaching from the vehicle. For a full list of the affected models visit: https://static.nhtsa.gov/odi/rcl/2019/RMISC-19V918-4126.pdf
Consequence & remedy
Consequence: A detached glass panel can separate from the vehicle and become a road hazard, increasing the risk of a crash.
Remedy: MBUSA will notify owners, and dealers will inspect the glass panel bonding and replace the sliding roof, as necessary, free of charge. The recall began July 10, 2020. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2020040011.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA13003 · Fuel Leakage From The Fuel Tank
Opened Mar 15, 2013 · Closed Dec 19, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Additional source detail variants (6)
Fuel System, Gasoline:delivery:fuel Pump
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
PE10017 · Driver Air Bag Circuit High Resistance
Opened May 14, 2010 · Closed Nov 24, 2010
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Electrical System; Electrical System:wiring; Electrical System:wiring:interior/under Dash
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Additional source detail variants (5)
Air Bags:frontal
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Air Bags
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Electrical System
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Electrical System:wiring:interior/under Dash
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Electrical System:wiring
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.