IllustrationBATTERY LIGHT CAME ON SO IT WAS CHARGED THEN RECONNECTED, EVERYTHING GOOD, TURN KEY TO ON POSITION EVERYTHING GOOD, TURN KEY TO START AND BANG! LOUD BANG AND WHITE SMOKE EVERYWHERE, ENGINE CONTINUED TO SMOKE FOR SEVERAL MINUTES AFTER EXPLOSION, HOLE IN FRONT OF ENGINE
2005 Mercedes Benz E320
Owner reports · Recalls · Investigations
More warning signs than most E320 years
Owner complaints for the 2005 Mercedes Benz E320 are substantially higher than the model-year median of 42.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all E320 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
170–25K
1825–50K
4050–75K
3475–100K
59100–150K
21150K+
189 reports with mileage · 42 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 81 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports4 fire reports11 injury reports
Electrical System complaints
16 reportsTHE CAR IS BEING HACKED INTO BY MULTIPLE INDIVIDUALS ACROSS TRIPLE CITIES. THE HACKERS ARE ABLE TO LOCK AND UNLOCK THE DOORS, SHIFT GEARS, TURN ON THE CHECK ENGINE LIGHT, CONTROL THE RADIO AND CD PLAYER, OPEN THE HOOD TO STEAL OIL AND CONTROL THE COMPLETE FUNCTIONALITY OF THE CAR. INCLUDING TURNING ON THE CABIN LIGHTS, BLACKING …
Read full complaint
THE CAR IS BEING HACKED INTO BY MULTIPLE INDIVIDUALS ACROSS TRIPLE CITIES. THE HACKERS ARE ABLE TO LOCK AND UNLOCK THE DOORS, SHIFT GEARS, TURN ON THE CHECK ENGINE LIGHT, CONTROL THE RADIO AND CD PLAYER, OPEN THE HOOD TO STEAL OIL AND CONTROL THE COMPLETE FUNCTIONALITY OF THE CAR. INCLUDING TURNING ON THE CABIN LIGHTS, BLACKING OUT THE ODOMETER ALONG WITH THE FUEL GAUGE, AND SHUTTING THE CAR OFF WHEN DESIRED THIS INCLUDES IN THE MIDDLE OF THE STREET. BECAUSE THEY CAN UNLOCK THE DOORS AND ROLL DOWN THE WINDOWS THEY HAVE ACCESS TO THE HOOD AND GAS DOOR. THIS ALLOWED THEM TO BREAK THE RADIATOR, DAMAGE THE CATALYTIC CONVERTER, AND STEAL GAS. ALSO SINCE THE HACKERS HAVE ACCESS THEY HAVE DESTROYED THE DRIVERS SEAT, CRACK THE WOOD ON THE STEERING WHEEL AND DOOR TRIM, REMOVED THE RIGHT AND LEFT FRONT DOORS, AND DESTROYED THE CENTER ARM REST. THE RF FIELD IS CONTROLLED BY THEM, AND LOUD CRACKING SOUNDS ARE REMOTELY INTRODUCED WHEN THE CAR IS STATIONARY AND KEY REMOVED. THE TELE- AID IS ALSO ACTIVITIES REMOTELY ON OCCASION AS WELL. THE FBI HAS BEEN NOTIFIED NUMEROUS TIMES TO NO AVAIL ALONG WITH THE CAR MAKER WHO TOLD ME NOT TO CONTACT THEM AGAIN. THREE DEALERSHIPS CHECKED OUT THE CAR AND NONE KNEW HOW TO DEAL WITH THE ISSUE. MERCEDES BENZ IN GERMANY WAS NOTIFIED BY EMAI AND SAID MERCEDES USA HAS MY INFORMATION I'M THEIR LEGAL DEPARTMENT. THIS WAS OVER 2 YEARS AGO WITH NO CONTACT FROM THEM REGARDING THIS ISSUE. ALL ATTEMPTS TO REACH THEM BY PHONE VIA CUSTOMER SERVICE HAS FAILED. MULTIPLE POLICE REPORTS HAVE BEEN MADE WITH SEVERAL POLICE DEPARTMENTS.
THERE IS A HIGH LEVEL OF RF BEING EMITTED INSIDE THE CABIN OF THE CAR. THE LEVEL IS SO HIGH IT PUSHES PULSED RF WAVES AGAINST AN ALUMINUM EMERGENCY BLANKET THAT WAS SET UP TO IDENTIFY WHICH DIRECTION IT WAS COMING FROM. THIS METHOD SHOWED IT IS COMING FROM MULTIPLE DIRECTION WITHIN THE CABIN. THIS IS WITH THE ENGINE OFF AND WIND…
Read full complaint
THERE IS A HIGH LEVEL OF RF BEING EMITTED INSIDE THE CABIN OF THE CAR. THE LEVEL IS SO HIGH IT PUSHES PULSED RF WAVES AGAINST AN ALUMINUM EMERGENCY BLANKET THAT WAS SET UP TO IDENTIFY WHICH DIRECTION IT WAS COMING FROM. THIS METHOD SHOWED IT IS COMING FROM MULTIPLE DIRECTION WITHIN THE CABIN. THIS IS WITH THE ENGINE OFF AND WINDOWS ROLLED UP. ALSO LF L LEAVE THE CAR AND COME BACK WITHIN LESS THAN A MINUTE THE CLIMATE INSIDE WILL KNOCK ME OUT, OR MAKE ME VERY SLEEPY. I HAVE TO IMMEDIATELY GET OUT OF THE CAR AND WALK 50 TO 70 FEET AWAY FROM IT TO STOP THIS FROM HAPPENING IF L CATCH IT IN TIME. MOST OF THE TIME L DO NOT AND SOMEONE IS USING THIS DEFECT TO STEAL ITEMS FROM THE CAR, DESTROY THE INTERIOR AD ALONG WITH A HOST OF ILLEGAL ACTIVITY WHILE L AM PASSED OUT INSIDE.BECAUSE THIS DANGEROUS ACTIVITY HAPPENS 90 PERCENT OF THE TIME THE RF MAY BE REMOTELY CONTROLLED. ALSO L HAVE ALMOST BEEN KNOCKED OUT WHILE DRIVING ON SEVERAL DIFFERENT OCCASIONS. THANKS TO JESUS CHRIST L WAS ABLE TO PULL THE CAR OVER AND RECOVER. IN ADDITION THE RF WILL ISOLATE AND FREEZE DIFFERENT BODY PARTS INDIVIDUALLY SIMILAR TO THE THERAPEUTIC PROCEDURE OF COOL SCULPTING. MULTIPLE POLICE REPORTS HAVE BEEN MADE AND THE DEALERSHIP NOTIFIED. THE CAR MARKER WAS NOTIFIED BY PHONE BUT REFUSE TO HELP.
HEADLIGHT AND ENGINE WIRING DETERIORATING BEYOND REPAIR! DANGEROUS AND MAY CAUSE SUDDEN CRASH OR FIRE.,.
TL* THE CONTACT OWNS A 2005 MERCEDES-BENZ E320. WHILE THE VEHICLE WAS STATIONARY, IT WAS HACKED INTO ELECTRONICALLY. THE BRAKES, AIR BAGS, RADIO, AND ALL OTHER ELECTRICAL FUNCTIONS WERE ABLE TO BE CONTROLLED, INCLUDING THE VEHICLE'S SOFTWARE. THE MANUFACTURER AND DEALER WERE UNABLE TO ASSIST. THE FAILURE MILEAGE WAS 181,514.
TL* THE CONTACT OWNS A 2005 MERCEDES-BENZ E320. THE BRAKES FAILED TO RESPOND WHEN THE BRAKE PEDAL WAS DEPRESSED AND THE BATTERY WARNING INDICATOR FLASHED ON THE INSTRUMENT PANEL. THE MANUFACTURER INDICATED THAT THE STATUTE TO RECEIVE AN EXTENDED SERVICE CAMPAIGN EXPIRED; THEREFORE, THEY REFUSED TO REPAIR THE VEHICLE. THE VIN WAS…
Read full complaint
TL* THE CONTACT OWNS A 2005 MERCEDES-BENZ E320. THE BRAKES FAILED TO RESPOND WHEN THE BRAKE PEDAL WAS DEPRESSED AND THE BATTERY WARNING INDICATOR FLASHED ON THE INSTRUMENT PANEL. THE MANUFACTURER INDICATED THAT THE STATUTE TO RECEIVE AN EXTENDED SERVICE CAMPAIGN EXPIRED; THEREFORE, THEY REFUSED TO REPAIR THE VEHICLE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V133000 (SERVICE BRAKES, HYDRAULIC). THE APPROXIMATE FAILURE MILEAGE WAS 145,000.
BOUGHT USED ONE OWNER CAR W/88,500 MILES IN JULY 2015. AFTER DRIVING ONLY 200 MILES CHECK ENGINE LIGHT CAME ON, ENGINE WOULD TURN OVER BUT NOT START, IT WAS TOWED TO REPAIR SHOP. CODES READ CRANKSHAFT SENSOR, GENERATOR. MECHANIC REPLACED CRANKSHAFT SENSOR AND REPAIRED WIRE TO IT. DID NOT REPLACE ALTERNATOR. CALLED AND ADVIS…
Read full complaint
BOUGHT USED ONE OWNER CAR W/88,500 MILES IN JULY 2015. AFTER DRIVING ONLY 200 MILES CHECK ENGINE LIGHT CAME ON, ENGINE WOULD TURN OVER BUT NOT START, IT WAS TOWED TO REPAIR SHOP. CODES READ CRANKSHAFT SENSOR, GENERATOR. MECHANIC REPLACED CRANKSHAFT SENSOR AND REPAIRED WIRE TO IT. DID NOT REPLACE ALTERNATOR. CALLED AND ADVISED CAR WAS READY FOR PICKUP. PICKED UP CAR AND DROVE LESS THAN 2 MILES AND CHECK ENGINE LIGHT CAME ON AGAIN. TOOK BACK TO MECHANIC WHO REMOVED CODES. DROVE ANOTHER 5 MILES AND CHECK ENGINE LIGHT CAME ON AGAIN. HE DIDN'T ANSWER PHONE, DROVE HOME IN LIMP MODE WHERE IT SAT FOR OVER A MONTH WHEN ANOTHER MECHANIC WAS WILLING TO TACKLE JOB. HE PUT ON NEW ALTERNATOR AND DRIVE BELT. CRANKSHAFT SENSOR WAS BAD AGAIN AND HE REPLACED IT. CAR WOULD NOT START. TOWED TO MB IN FRANKLIN, TN WHO SAID ECM/ ECU MODULE BAD. REPLACED IT AND THEN SAID BATTERIES BAD, AND ALTERNATOR BAD. THEY REPLACED BATTERIES BUT LOCAL MECHANIC TOLD THEM ALTERNATOR WAS WORKING FINE WHEN IT WAS PUT IN CAR. CAR TOWED BACK TO LOCAL MECHANIC WHO CHECKED AND SAID ALTERNATOR WAS INDEED BAD NOW AND HE REPLACED IT WITH ONE HE CHECKED OUT AGAIN BEFORE INSTALLING. NOW THE ALTERNATOR WAS NOT BEING ALLOWED TO CHARGE THE SYSTEM AND IS BEING TOWED BACK TO MB IN FRANKLIN, TN. AFTER SEARCHING THE INTERNET I FOUND THAT MB HAS BEEN INSTALLING DEFECTIVE WIRING HARNESSES IN THEIR CARS SINCE THE 1990'S AND THEY KNOW IT BUT WILL ONLY REPLACE THE DEFECTIVE HARNESS TO THOSE TO YELL THE LOUDEST BECAUSE THERE ARE SUPPOSEDLY MILLIONS ON CARS ON THE ROAD JUST WAITING TO SHORT OUT EXPENSIVE PARTS AND CAUSE OWNERS COSTLY REPAIRS. I AM YELLING AT THE TOP OF MY VOICE FOR YOU TO GO AFTER THEM WITH A VENGEANCE AND MAKE THEM DO THE REPAIRS. I HAVE SPENT OVER $4000. ALREADY ON THIS CAR WHICH SHOULD HAVE BEEN FIXED BY THEM AT THEIR EXPENSE. THE COVERING ON THE WIRES GETS BRITTLE AND SHORTS OUT VARIOUS..
TL* THE CONTACT OWNS A 2005 MERCEDES BENZ E320. THE CONTACT STATED THAT THE FUEL GAUGE AND THE SPEEDOMETER GAUGE DISPLAYED INACCURATE READINGS ON THE INSTRUMENT PANEL. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V303000 (ELECTRICAL SYSTEM). THE DEALER DID NOT RECODE THE SCN, BUT RATHER EMPTIED THE FUEL TANK AND REPL…
Read full complaint
TL* THE CONTACT OWNS A 2005 MERCEDES BENZ E320. THE CONTACT STATED THAT THE FUEL GAUGE AND THE SPEEDOMETER GAUGE DISPLAYED INACCURATE READINGS ON THE INSTRUMENT PANEL. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V303000 (ELECTRICAL SYSTEM). THE DEALER DID NOT RECODE THE SCN, BUT RATHER EMPTIED THE FUEL TANK AND REPLACED THE FUEL AND THE FUEL LEVER SENSOR. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS ALSO NOT INCLUDED IN NHTSA ACTION NUMBER: EA13003 (FUEL SYSTEM, GASOLINE). THE CONTACT REPORTED THE SAFETY CONCERN WITH THE AIR BAG SENSOR, WHICH WAS NOT INCLUDED IN PE: 10017 (AIR BAGS AND ELECTRICAL SYSTEM). THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER MORE THAN TWICE, BUT THE FAILURES PERSIST. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 68,000.
TL* THE CONTACT OWNS A 2005 MERCEDES BENZ E320. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, THE FUEL GAUGE DISPLAYED ERRONEOUS READINGS. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE FUEL SYSTEM HAD FAILED. THE VEHICLE WAS REPAIRED BUT THE FAILURE PERSISTED. THE VEHICLE WAS TAKEN BACK TO…
Read full complaint
TL* THE CONTACT OWNS A 2005 MERCEDES BENZ E320. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, THE FUEL GAUGE DISPLAYED ERRONEOUS READINGS. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE FUEL SYSTEM HAD FAILED. THE VEHICLE WAS REPAIRED BUT THE FAILURE PERSISTED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHO STATED THAT THE FUEL INJECTION AND FUEL GAUGE NEEDED TO BE REPLACED. IN ADDITION, THE CONTACT STATED THAT AFTER ONLY DRIVING ONE BLOCK THE SPEEDOMETER WOULD DISPLAY ONE MILE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
TL* THE CONTACT OWNS A 2005 MERCEDES BENZ E320. THE CONTACT STATED THAT THERE WAS A DAILY OCCURRENCE OF MASSIVE RFID LEAK WHICH CAUSED PAIN TO THE CONTACT. THE CONTACT MENTIONED THE ONLY WAY TO PROTECT FROM THE PAIN WAS TO COVER THE BODY WITH ALUMINUM SHIELDING OR METAL. ADDITIONALLY, THE CONTACT STATED THAT THE VEHICLE WOULD FA…
Read full complaint
TL* THE CONTACT OWNS A 2005 MERCEDES BENZ E320. THE CONTACT STATED THAT THERE WAS A DAILY OCCURRENCE OF MASSIVE RFID LEAK WHICH CAUSED PAIN TO THE CONTACT. THE CONTACT MENTIONED THE ONLY WAY TO PROTECT FROM THE PAIN WAS TO COVER THE BODY WITH ALUMINUM SHIELDING OR METAL. ADDITIONALLY, THE CONTACT STATED THAT THE VEHICLE WOULD FAIL TO START INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS UNABLE TO BE DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 24,000 AND THE CURRENT MILEAGE WAS 153,000.
Official recalls
324V874000 · Visibility:sun/moon Roof Assembly
Nov 19, 2024
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2001-2011 C-Class, CLK, E-Class, and CLS vehicles. Please see the recall report for a complete list of models and model years. The glass sunroof panel may not be properly secured and can detach.
Consequence & remedy
Consequence: A detached sunroof panel can become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the sunroof panel as necessary, free of charge. Owner notification letters were mailed January 10, 2025. Owners may contact MBUSA customer service at 1-800-367-6372. This recall is an expansion of previous NHTSA recall number 22V-954. MBUSA's number for this recall is 2024120001/2/3.
22V954000 · Visibility:sun/moon Roof Assembly
Dec 23, 2022
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2001-2011 C-Class, CLK, E-Class, and CLS vehicles. Please refer to MBUSA's recall report for specific vehicle model details. The glass sunroof panel may not be properly secured and may detach.
Consequence & remedy
Consequence: A detached sunroof panel may become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the sunroof panel as necessary free of charge. Owner notification letters were mailed February 3, 2023. Owners may contact MBUSA customer service at 1-800-367-6372. This recall expands NHTSA recall number 19V-918. MBUSA's numbers for this recall are 2023010004, 2023010005, and 2023010006.
19V918000 · Visibility:sun/moon Roof Assembly
Dec 20, 2019
Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2001-2011 vehicles. The bonding between the glass panel and the sliding roof frame may deteriorate, possibly resulting in the glass panel detaching from the vehicle. For a full list of the affected models visit: https://static.nhtsa.gov/odi/rcl/2019/RMISC-19V918-4126.pdf
Consequence & remedy
Consequence: A detached glass panel can separate from the vehicle and become a road hazard, increasing the risk of a crash.
Remedy: MBUSA will notify owners, and dealers will inspect the glass panel bonding and replace the sliding roof, as necessary, free of charge. The recall began July 10, 2020. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2020040011.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA13003 · Fuel Leakage From The Fuel Tank
Opened Mar 15, 2013 · Closed Dec 19, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Additional source detail variants (6)
Fuel System, Gasoline:delivery:fuel Pump
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
PE10017 · Driver Air Bag Circuit High Resistance
Opened May 14, 2010 · Closed Nov 24, 2010
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Electrical System; Electrical System:wiring; Electrical System:wiring:interior/under Dash
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Additional source detail variants (5)
Air Bags:frontal
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Air Bags
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Electrical System
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Electrical System:wiring:interior/under Dash
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Electrical System:wiring
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.