IllustrationThe rear passenger side inside door handle will not open the door. This is an unacceptable safety hazard.
2004 Mercedes Benz E320
Owner reports · Recalls · Investigations
More warning signs than most E320 years
Owner complaints for the 2004 Mercedes Benz E320 are substantially higher than the model-year median of 42.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all E320 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
80–25K
1525–50K
3150–75K
3275–100K
64100–150K
18150K+
168 reports with mileage · 35 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 79 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports1 fire reports4 injury reports
What owners actually said
203 reportsOctober 26, 2022 my 2004 Mercedes model E320 W211 VIN # [XXX] dash pop out warning " Brake Wearing visit workshop" October 27, 2022 I had the brake pads and wear sensors both replaced and test drive verified car running normal for 30 minutes then dash pop out RED warning "Brake malfunction stop vehicle" plus transmission shifte…
Read full complaint
October 26, 2022 my 2004 Mercedes model E320 W211 VIN # [XXX] dash pop out warning " Brake Wearing visit workshop" October 27, 2022 I had the brake pads and wear sensors both replaced and test drive verified car running normal for 30 minutes then dash pop out RED warning "Brake malfunction stop vehicle" plus transmission shifter stick to parking port can not be shift to other position, so can not drive and car being forced to stop on the road, I managed to press the lock off so can shift out of parking but there has no brake function when driving, I called MB USA and being advised that my car qualified to 25 years extended warranty for SBC hydraulic pump repair, 2005070007 2005110001 but when I tow my car to Mercedes dealer they said it only repair the Recall: 2020040011 - Sliding Roof Bonding - Phase 2, but the SBC Hydraulic pump may be at additional service charges, Please help investigate why Mercedes USA said it is under 25 years extended warranty while dealer said it might not qualify? car can not drive because of the SBC hydraulic pump problem and defected the driving safety? Best Regards/[XXX] email: [XXX] tel: [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Total brake failure Had to cross the over to the other side of the road to turn around. Was almost hit by an oncoming big rig truck . I've looked it up and this is a common occurrence on these vehicles,! They have a SBC unit that has caused numerous incidents exactly like mine . Someone could easily be killed because of this def…
Read full complaint
Total brake failure Had to cross the over to the other side of the road to turn around. Was almost hit by an oncoming big rig truck . I've looked it up and this is a common occurrence on these vehicles,! They have a SBC unit that has caused numerous incidents exactly like mine . Someone could easily be killed because of this defect. I've read that they extended the warranty for 25 years . But I haven't been notified. They notified me about a recall of the sun roof but not this!!
My car seat belts not fastened and car door warning devices stop working. I took it to the Mercedes service department and told and showed them the safety system was not warning me when my door was not properly closed or when I removed the seat belt while driving. They told me that they needed to replace my instrument cluster in…
Read full complaint
My car seat belts not fastened and car door warning devices stop working. I took it to the Mercedes service department and told and showed them the safety system was not warning me when my door was not properly closed or when I removed the seat belt while driving. They told me that they needed to replace my instrument cluster in order to fix the issue. They charged me almost $2300.00 to change the panel. When I went to pick the vehicle up. And I drove off and took my seat belt off to see if the repair was done and no warning light came on. I than while driving through a parking lot open my door and no warning happened. Now the dealership is telling me that their is nothing they can do to address this dangerous safety issue and that I have no recourse to get what I paid for. Because Mercedes Benz Corp will not allow them to code the new instrument cluster. I was driving one day and did not realize the door was ajar until I hit a bump and heard the rattling. I have spoken with other Mercedes Benz owners of my model and found they've had this problem, but it is just too expensive to repair. I have been dealing with this now since December of 2021 and now no one from the dealership is returning any calls or offered a answer to this issue. I have spoken with the Service Director last on February 7 2022. And he has not reached out to me since.
Extreme Gas Odor after filling gas tank and during time of driving.
The vehicle will flood after being exposed to rain which has caused all sorts of electrical issues. I have read online where several others have filed lawsuits regarding E class Mercedes for similar issues. The car’s interior will take on water and since there’s several electrical components running along the floor board of the …
Read full complaint
The vehicle will flood after being exposed to rain which has caused all sorts of electrical issues. I have read online where several others have filed lawsuits regarding E class Mercedes for similar issues. The car’s interior will take on water and since there’s several electrical components running along the floor board of the car they will become damaged and cause the car’s computers and electrical system to go crazy. I picked up my car from having the oil changed at a local service shop a few days after it was repaired and I was driving back home after the service pick up and the car completely lost power. I got out of the car and opened the trunk in which I had to do so by using the key inside of the key fob. When I opened the trunk, I noticed that there was a little bit of water in the trunk which led me to open the back door and to my surprise there was standing water behind the driver seat. I checked the driver floor and it was soaked as well. I had the car towed back to the shop where I had the oil changed and the owner did not have the available equipment to test the car. I dried the car out over the next several days and drove to a local Mercedes dealership where they told me to do a full diagnostic on the car it would cost upwards of $19k. Are you kidding me? Now I know from reading others stories that this isn’t an unknown issue. So, what do I do now…file an insurance claim? I guess that would be the next step but they’ll turn around and get the money right back out of me by raising my policy rates. This is terrible. My car is a 2004 E320 with just under 65k miles on it.
DRIVER IS EXPERIENCING A HEAVY ODOR OF GASOLINE AFTER FILL UP. VEHICLE IS NOT OVERFILLED/TOPPED OFF. VEHICLE WAS SITTING INSIDE GARAGE WHEN OWNER NOTICED A HEAVY FUEL ODOR AND NOTIFIED FIRE DEPARTMENT TO INVESTIGATE. PER RECOMMENDATIONS OF FIRE DEPARTMENT, KEEP VEHICLE OUT OF GARAGE UNTIL ISSUE COULD BE INSPECTED BY A QUALIFI…
Read full complaint
DRIVER IS EXPERIENCING A HEAVY ODOR OF GASOLINE AFTER FILL UP. VEHICLE IS NOT OVERFILLED/TOPPED OFF. VEHICLE WAS SITTING INSIDE GARAGE WHEN OWNER NOTICED A HEAVY FUEL ODOR AND NOTIFIED FIRE DEPARTMENT TO INVESTIGATE. PER RECOMMENDATIONS OF FIRE DEPARTMENT, KEEP VEHICLE OUT OF GARAGE UNTIL ISSUE COULD BE INSPECTED BY A QUALIFIED MECHANIC. MECHANIC INSPECTED FUEL SYSTEM AND FOUND FUEL LEAK UNDER REAR SEATS NEAR FUEL PUMP/SENDING UNIT. MERCEDES BENZ REFUSES REPAIR ISSUE SAYING IT IS NOT A SAFETY ISSUE. GASOLINE FUMES/VAPORS ARE ESPECIALLY HEAVY INSIDE A SINGLE CAR GARAGE, AND IF A IGNITION SOURCE IS INTRODUCED IT COULD BECOME FATAL.
I FILLED THE GAS TANK FULL AND ON PULLING IN THE GARAGE COULD SMELL A STRONG SMELL OF GASOLINE... WENT TO GET MY OIL CHANGE THE NEXT DAY AND THE GENTLEMAN MENTIONED HE COULD SMELL GAS COMING FROM MY CAR AT VALVOLINE OIL CHANGE.... VERY STRONG SMELL IN THE INTERIOR OF THE CAR AS WELL AS WHEN WALKING AROUND THE OUTSIDE OF THE CAR …
Read full complaint
I FILLED THE GAS TANK FULL AND ON PULLING IN THE GARAGE COULD SMELL A STRONG SMELL OF GASOLINE... WENT TO GET MY OIL CHANGE THE NEXT DAY AND THE GENTLEMAN MENTIONED HE COULD SMELL GAS COMING FROM MY CAR AT VALVOLINE OIL CHANGE.... VERY STRONG SMELL IN THE INTERIOR OF THE CAR AS WELL AS WHEN WALKING AROUND THE OUTSIDE OF THE CAR YOU COULD SMELL A STRONG SMELL OF GAS... THE GENTLEMAN FROM VALVOLINE LOOKED UNDER THE CAR AND SAID THERE'S SOME TYPE OF COVER THAT GOES UNDERNEATH THE GAS TANK ITSELF AND PUT HIS FINGER INTO IT AND COULD TOUCH GASOLINE ON HIS HAND... I JUST WENT ONTO THE INTERNET AND READ MANY MANY COMPLAINTS OF THE SAME THING WITH THIS TYPE OF CAR LAWSUITS HAVE BEEN FILED... IN THOSE COMPLAINTS THE PEOPLE THAT BROUGHT THEIR CAR TO DEALERSHIP SAID THAT IT WAS VERY EXPENSIVE TO REMEDY AND THAT THERE SHOULD HAVE BEEN A RECALL... AFTER DRIVING A LITTLE BIT AND REDUCING THE AMOUNT OF GASOLINE IN THE TANK THE SMELL HAS SUBSIDED SOMEWHAT... THOSE COMPLAINTS ALSO MENTION THAT IT CAN BE VERY DANGEROUS WITH THIS TYPE OF LEAK
ON 12/16/2020 WHILE DRIVING THE BRAKES ON MY VEHICLE FAILED. A RED WARNING TRIANGLE APPEARED ON THE VEHICLE MESSAGE BOARD STATING THE CARS BRAKING ABILITY WAS SEVERELY REDUCED AND TO STOP DRIVING IMMEDIATELY. I WAS ABLE TO DRIFT TO THE SIDE OF THE ROAD WITHOUT INCIDENT AND HAD THE VEHICLE TOWED TO MY MECHANIC. THE MECHANIC C…
Read full complaint
ON 12/16/2020 WHILE DRIVING THE BRAKES ON MY VEHICLE FAILED. A RED WARNING TRIANGLE APPEARED ON THE VEHICLE MESSAGE BOARD STATING THE CARS BRAKING ABILITY WAS SEVERELY REDUCED AND TO STOP DRIVING IMMEDIATELY. I WAS ABLE TO DRIFT TO THE SIDE OF THE ROAD WITHOUT INCIDENT AND HAD THE VEHICLE TOWED TO MY MECHANIC. THE MECHANIC COULD FIND NO MECHANICAL REASON FOR THE BRAKE FAILURE. THE RED WARNING LIGHT WAS GONE AND THE BRAKES WERE FUNCTIONING NORMALLY. ONLINE RESEARCH REVEALED AN EXTENDED WARRANTY/RECALL FOR THE YEAR, MAKE AND MODEL OF THE CAR RELATED TO BRAKE FAILURE. MERCEDES WILL REPLACE THE SENSORTRONIC BRAKE CONTROL MODULE (SBC) FREE PROVIDED THE CORRECT CODES ARE EVIDENT WHEN THEY DIAGNOSE THE CAR.(SAFETY RECALL #2005110001 I BELIEVE) MY MECHANIC SAID THAT THERE ARE NO CODES SHOWING FOR THE BRAKES AND THE BRAKES ARE NOW FUNCTIONING. MY ONLINE RESEARCH HAS SHOWN THAT THIS CAN BE AN INTERMITTENT PROBLEM AND THE DEALERSHIPS ARE RELUCTANT OR WILL NOT REPLACE THE SBC IF THERE ARE NO CODES. AFTER CONTACTING MERCEDES THE CAR IS BEING TOWED TO THE DEALERSHIP AS I TYPE THIS. I AM HOPEFUL THAT MERCEDES WILL DO THE CORRECT THING AND REPLACE THEIR ADMITTEDLY FLAWED BRAKE MODULE BUT IT ISN'T LOOKING GOOD AS THEY SAID IF THE CORRECT CODES DO NOT APPEAR THEY WILL NOT REPLACE. THE INSANE IDEA THAT I AM EXPECTED TO CONTINUE TO DRIVE THE VEHICLE UNTIL THE BRAKES FAIL AGAIN IN ORDER TO GET THEM REPLACED IS UNACCEPTABLE. I'M IN A NO WIN SITUATION.
SENSOR TONIC BRAKE SYSTEM LIGHT IN INTERMITTENTLY
Official recalls
224V874000 · Visibility:sun/moon Roof Assembly
Nov 19, 2024
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2001-2011 C-Class, CLK, E-Class, and CLS vehicles. Please see the recall report for a complete list of models and model years. The glass sunroof panel may not be properly secured and can detach.
Consequence & remedy
Consequence: A detached sunroof panel can become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the sunroof panel as necessary, free of charge. Owner notification letters were mailed January 10, 2025. Owners may contact MBUSA customer service at 1-800-367-6372. This recall is an expansion of previous NHTSA recall number 22V-954. MBUSA's number for this recall is 2024120001/2/3.
19V918000 · Visibility:sun/moon Roof Assembly
Dec 20, 2019
Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2001-2011 vehicles. The bonding between the glass panel and the sliding roof frame may deteriorate, possibly resulting in the glass panel detaching from the vehicle. For a full list of the affected models visit: https://static.nhtsa.gov/odi/rcl/2019/RMISC-19V918-4126.pdf
Consequence & remedy
Consequence: A detached glass panel can separate from the vehicle and become a road hazard, increasing the risk of a crash.
Remedy: MBUSA will notify owners, and dealers will inspect the glass panel bonding and replace the sliding roof, as necessary, free of charge. The recall began July 10, 2020. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2020040011.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA13003 · Fuel Leakage From The Fuel Tank
Opened Mar 15, 2013 · Closed Dec 19, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Additional source detail variants (6)
Fuel System, Gasoline:delivery:fuel Pump
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un