IllustrationTL* THE CONTACT OWNED A 1991 MAZDA PROTEGE. WHILE DRIVING VARIOUS SPEEDS, SMOKE APPEARED UNDER THE HOOD. THERE WERE NO FLAMES VISIBLE AND NO INJURIES. THE VEHICLE WAS DESTROYED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V674000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS UNKNOWN.
1991 Mazda Protege
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1991 Mazda Protege do not stand out strongly from the model-year median of 66.
About this comparison →How this year compares
Owner complaints by model year
Compare all Protege years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 51 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Seat Belts. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports2 fire reports7 injury reports
What owners actually said
51 reportsTL* THE CONTACT OWNS A 1991 MAZDA PROTEGE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH DURING RAIN WEATHER CONDITIONS, THE VEHICLE WENT OVER A POTHOLE CAUSING THE CONTACT TO LOSE CONTROL OF THE VEHICLE AND STOPPING ON THE SHOULDER OF THE ROAD. THE CONTACT THEN ATTEMPTED TO DRIVE AND THE VEHICLE SPUN CRASHING TH…
Read full complaint
TL* THE CONTACT OWNS A 1991 MAZDA PROTEGE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH DURING RAIN WEATHER CONDITIONS, THE VEHICLE WENT OVER A POTHOLE CAUSING THE CONTACT TO LOSE CONTROL OF THE VEHICLE AND STOPPING ON THE SHOULDER OF THE ROAD. THE CONTACT THEN ATTEMPTED TO DRIVE AND THE VEHICLE SPUN CRASHING THE FRONT OF THE VEHICLE INTO A TREE. THE SEAT BELT DETACHED AND THE CONTACT WAS RELEASED FROM THE REAR WINDOW. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS TOWED AND DEEMED DESTROYED. THE CONTACT RECEIVED KNEE, HEAD, AND BACK INJURIES WHICH REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. UPDATED 03/15/16*LJ *TR
REAR STRUT TOWERS RUST RIGHT THROUGH. *TR
THE AUTOMATIC SHOULDER BELT WOULD RETRACT SLOWER AND SLOWER UNTIL IT FINALLY STOPPED RETRACTING. THE CONSEQUENCES WERE: ON APRIL 18, 2005 I WAS GIVEN A FIX-IT TICKET FOR NOT WEARING MY SHOULDER HARNESS.*AK THE AUTOMATIC HARNESS NO LONGER FULLY RETRACTS, SO IT IS USELESS.
THE SEAT BELT CORD ON MY 1991 MAZDA PROTEGE HAS BECOME INOPERABLE AND THEREFORE I HAVE NO TOP SEAT BELT ON MY CARS DRIVER SIDE. *AK
WHILE DRIVING, THE VEHICLE'S HOOD DETACHED RESULTING IN THE HOOD HITTING THE WINDSHIELD.*MR *CB *JB
DRIVER SIDE SEAT BELT WILL NOT RETURN TO THE RETACTOR, LEAVING THE OCCUPANT UNRESTRAINED. DEALER NOTIFED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
TRANSMITION LOCKED UP GOING 65 MPH. *AK
TRUNK LID WAS IN THE UP POSITION AND TRUNK CAME DOWN AND HIT CONSUMER'S DAUGHTER ON HEAD. *AK CONSUMER STATES NOTHING TO KEEP THE TRUNK LID IN UPRIGHT POSITION. A SLIGHT WIND OR ELEVATION COULD BLOW THE OPEN LID DOWN AND MAY CAUSE SERIOUS INJURY. *YH
SEAT BELT SEAT BELT WARNING LIGHT AND BEEP GO ON AND OFF INTERMITTENTLY WHILE DRIVING DUE TO AN ELECTRICAL CONNECTOR WEARING THROUGH IN THE DRIVERS SHOULDER BELT RETRACTOR LOCATED IN THE CENTER CONSOLE. REPLACED SEVERAL TIMES UNDER WARRANTY. PART IS NEARLY $300. SEVERAL PEOPLE I KNOW WITH THIS MODEL AND YEAR HAVE THE SAME PROBLE…
Read full complaint
SEAT BELT SEAT BELT WARNING LIGHT AND BEEP GO ON AND OFF INTERMITTENTLY WHILE DRIVING DUE TO AN ELECTRICAL CONNECTOR WEARING THROUGH IN THE DRIVERS SHOULDER BELT RETRACTOR LOCATED IN THE CENTER CONSOLE. REPLACED SEVERAL TIMES UNDER WARRANTY. PART IS NEARLY $300. SEVERAL PEOPLE I KNOW WITH THIS MODEL AND YEAR HAVE THE SAME PROBLEM.*AK
Official recalls
115V674000 · Electrical System:ignition:switch
Oct 19, 2015
Mazda North American Operations (Mazda) is recalling certain model year 1989-1998 MPV, 1990-1995 323, 1990-1998 Protege, 1992-1993 MX-3, 1993-1995 929, 1993-1997 MX-6, and 1993-1998 626 vehicles. In the affected vehicles, grease applied to the contact points inside the ignition switch may become conductive and overheat.
Consequence & remedy
Consequence: If the ignition switch overheats there would be an increased risk of a fire.
Remedy: Mazda will notify owners, and dealers will replace the ignition switch, free of charge. The recall began on December 17, 2015. Owners may contact Mazda Customer Experience Center at 1-800-222-5500, option#6. Mazda's number for this recall is 8715J.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA94039 · Auto Restraint System Fail
Opened Nov 30, 1994 · Closed Nov 26, 1997
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
PE94059 · Auto Restraint System Fail
Opened Jul 28, 1994 · Closed Nov 30, 1994
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available