2002 Mazda MX-5 Miata

ONE OF TWO LATCHES FOR THE CONVERTIBLE SOFT TOP CAME UNFASTENED WHILE DRIVING CAUSING ONE SIDE OF THE TOP TO LIFT UPWARDS WITH GREAT VIOLENCE AND A VERY LOUD NOISE. NO ACCIDENT THIS TIME BUT IT WILL HAPPEN- E.G. SWERVING OUT OF LANE AND INTO ANOTHER VEHICLE, PEDESTRIAN, TREE, ETC. DUE TO 1) THE VIOLENCE AND NOISE AND/OR 2) THE DRIVER *ATTEMPTING* (ITS IMPOSSIBLE!) TO RE-LATCH AND RE-LOCK THE TOP. THE CAUSE OF THE FAILURE IS A VERY POOR DESIGN OF THE LATCH/LOCK AND THE LOCKS LEVER BEING MADE OF POT METAL. BOTH FACTORS COMBINE IN A SYNERGISTIC MANNER WHICH CAUSE VERY RAPID LOCK WEAR AND ABRUPT FAILURE. THERE SHOULD BE A RECALL DUE TO RISK AND THE NUMBER OF NHTSA COMPLAINTS ON THIS DESIGN DEFECT- INCLUDING ONE WHERE BOTH LATCHES FAILED AND THE TOP BLEW OFF! DEFECTIVE PART NUMBERS ARE NA01R1310_ AND NA01R1320_.

TL*THE CONTACT OWNS A 2002 MAZDA MIATA. THE CONTACT STATED THAT THE CONVERTIBLE TOP LATCH DOES NOT LATCH PROPERLY AND CAUSED THE CONVERTIBLE TOP TO DETACH WHILE DRIVING. THE CONTACT HAS TAKEN THE VEHICLE TO THE DEALER WHO STATED THAT THE CONVERTIBLE TOP LATCH NEEDED TO BE REPLACED. THE CONTACT STATED THAT WAS A DESIGN DEFECT THAT THE MANUFACTURER WAS AWARE OF AND THAT WARRANTS A RECALL. THE CONTACT STATED THAT WAS IS A SAFETY ISSUE. THE FAILURE MILEAGE WAS 10,000. UPDATED 01/11/2011*LJ

CONVERTIBLE TOP LATCHES DO NOT STAY LATCHED. MAZDA IS AWARE OF THE PROBLEM AND HAS ISSUED A TSB (09-009/03) TELLING THE TECH TO REPLACE THE LATCHES AND STRIKERS WITH A REVISED DESIGN. MAZDA REFUSES TO REPLACE THE UNITS FREE OF CHARGE EVEN THOUGH IT IS OBVIOUSLY A MANUFACTURING DEFECT. TOPS FLYING OPEN ON THE HIGHWAY ARE A MAJOR SAFETY ISSUE AND SHOULD NOT BE FIXED AT THE CUSTOMERS EXPENSE, ESPECIALLY ON A CAR WITH ONLY 28000 MILES. THE CAR HAS ALWAYS BEEN DEALER MAINTAINED AND IS ACTUALLY IN BETTER CONDITION THAN WHEN I BOUGHT IT OFF THE SHOWROOM. MAZDA REFUSES TO REPLACE IT UNDER THE ORIGINAL WARRANTY, OR EVEN THE EXTENDED FACTORY WARRANTY. *TR