THERE IS A SULFUR SMELL COMING FROM THE ENGINE INTO THE PASSENGER COMPARTMENT, DEALER SAID ITS THE ETHANOL GAS THAT IS CAUSING THE PROBLEM AND THAT IT IS SEASONAL; DEALER SAID TO TRY OTHER GAS; DEALER HAS SAID THEY HAVE RECEIVED OTHER COMPLAINTS OF THIS SAME SMELL AND THAT AT LEAST ONE (PREGNANT) OWNER CANNOT DRIVE HER CAR WITHO…
Read full complaint
THERE IS A SULFUR SMELL COMING FROM THE ENGINE INTO THE PASSENGER COMPARTMENT, DEALER SAID ITS THE ETHANOL GAS THAT IS CAUSING THE PROBLEM AND THAT IT IS SEASONAL; DEALER SAID TO TRY OTHER GAS; DEALER HAS SAID THEY HAVE RECEIVED OTHER COMPLAINTS OF THIS SAME SMELL AND THAT AT LEAST ONE (PREGNANT) OWNER CANNOT DRIVE HER CAR WITHOUT BECOMING SICK. *LA
NHTSA ODI #10047073
57 miles · Nov 12, 2003
Engine And Engine CoolingPower Train
WHILE DRIVING AT ANY SPEED, THE GEARS IN THE VEHICLE SEEM TO BE SLIPPING. THE GEARS DIDN'T CHANGE AT THE PROPER INTERVALS. THERE WERE TIMES WHEN THE CONSUMER WOULD BE AT A STOP LIGHT AND THE VEHICLE WOULD LURCH FORWARD , AS IF STRUCK FROM BEHIND. THE CHECK ENGINE LIGHT CAME ON AND STAYED ON. THE VEHICLE WAS TAKEN TO THE DEAL…
Read full complaint
WHILE DRIVING AT ANY SPEED, THE GEARS IN THE VEHICLE SEEM TO BE SLIPPING. THE GEARS DIDN'T CHANGE AT THE PROPER INTERVALS. THERE WERE TIMES WHEN THE CONSUMER WOULD BE AT A STOP LIGHT AND THE VEHICLE WOULD LURCH FORWARD , AS IF STRUCK FROM BEHIND. THE CHECK ENGINE LIGHT CAME ON AND STAYED ON. THE VEHICLE WAS TAKEN TO THE DEALER, WHO REPROGRAMMED THE PCM MODULE IN THE TRANSMISSION. THE REPROGRAMMING DID NOT STOP THE ENGINE FROM SLIPPING, BUT IT DID CAUSE THE CHECK ENGINE LIGHT TO GO OUT. THE VEHICLE HAS BEEN IN THE SHOP FOR THE ENGINE SLIPPING THREE TIMES, AND THE PROBLEM STILL PERSISTS. THE MANUFACTURER HAS BEEN INFORMED OF THE PROBLEM. *PH
NHTSA ODI #10047846
Mileage unknown · Apr 7, 2003
Engine And Engine Cooling
THERE IS A SULFUR SMELL COMING FROM THE ENGINE EXHAUST, DEALER SAID TO TRY DIFFERENT GAS, AND IT SHOULD GO AWAY, I HAVE TRIED SEVERAL BRANDS OF GAS AND THE SMELL IS STILL THERE. *JB
THE TIRE INFLATION PRESSURE INDICATED ON THE VEHICLE CERTIFICATION LABEL IS NOT CORRECT. THE LABELS SHOW THE MAXIMUM TIRE PRESSURE AS 240 KPA/32 PSI WHEN IT SHOULD BE SHOWN AS 240 KPA/35 PSI. AS A RESULT OF THIS ERROR, THE LOAD RATIOS FOR THE 205/65R15 94H AND THE 215/60R16 95H TIRES EXCEED THE LEVELS PERMITTED BY FMVSS 120.
Consequence & remedy
Consequence: IF THE TIRE IS OPERATED IN AN UNDER-INFLATED CONDITION, THE LOAD CARRYING CAPACITY OF THE VEHICLE MAY BE COMPROMISED, INCREASING THE RISK OF A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH A CORRECTED LABEL THAT THEY CAN APPLY TO THEIR VEHICLE, OR THEY CAN HAVE A DEALER INSTALL THE LABEL, IF DESIRED. THE RECALL BEGAN ON JULY 16, 2004. OWNERS SHOULD CONTACT MAZDA AT 1-800-222-5500, OPTION #4.
CERTAIN MINIVANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." SOME OF THESE VEHICLES WERE PRODUCED WITH AIR BAG WARNING LABELS INTENDED FOR THE CANADIAN MARKET. THUS, THE LABELS CONTAIN WARNINGS IN BOTH ENGLISH AND FRENCH. AS A RESULT, THE AREA OF THE ENGLISH WARNING IS ONLY 16 SQUARE CENTIMETERS, AS OPPOSED TO THE 30 SQUARE CENTIMETERS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: Not supplied
Remedy: OWNERS WILL BE PROVIDED WITH AIR BAG CAUTION LABELS AND INSTALLATION INSTRUCTIONS WHICH WERE MAILED ON JULY 22, 2004. OWNERS SHOULD CONTACT MAZDA AT 1-800-222-5500.
ON CERTAIN MINI VANS AND PASSENGER VEHICLES, THE SOCKET HOLDER IN THE FOG LIGHTS IS INSTALLED IN THE LAMP CASING USING PRESSURE. DURING OPERATION OF THE FOG LIGHT, THE HEAT FROM THE BULB CAN EXPAND THE SOCKET HOLDER. THE EXPANSION CAN FORCE THE SOCKET HOLDER REARWARD. AFTER REPEATEDLY BEING SUBJECT TO THIS EXPANSION, IF THE FOG LIGHT IS ALSO SUBJECTED TO VIBRATION DURING VEHICLE OPERATION, THE SOCKET HOLDER WITH THE BULB HOLDER AND THE WIRING HARNESS MAY SEPARATE FROM THE FOG LIGHT CASING.
Consequence & remedy
Consequence: SHOULD THIS OCCUR, THE BULB SOCKET AND THE HARNESS CAN DROP INSIDE THE BUMPER AND POSSIBLY BUT RARELY, THE HEAT GENERATED BY THE BULB CAN CAUSE THE BUMPER TO BURN.
Remedy: DEALERS WILL INSTALL A SPRING TO PREVENT THE SOCKET HOLDER FROM SEPARATING FROM THE LAMP CASE. OWNER NOTIFICATION BEGAN ON JULY 14, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MAZDA AT 1-800-222-5500.
ON CERTAIN MINI VANS EQUIPPED WITH FRONT FOG LIGHTS,THE FOG LIGHT BULB SOCKET MAY HAVE BEEN INSTALLED IMPROPERLY.
Consequence & remedy
Consequence: IF THE VEHICLE CONTINUES TO BE USED WITH THIS CONDITION, THE BULB SOCKET AND THE WIRING HARNESS MAY SEPARATE FROM THE FOG LIGHT HOUSING IF EXPOSED TO SHOCK AND/OR VIBRATION AND DROP INSIDE THE BUMPER. SHOULD THIS OCCUR, THE OPERATION OF THE FOG LIGHT MAY THEN CAUSE THE BUMPER TO BURN.
Remedy: DEALERS WILL INSPECT THE INSTALLATION CONDITION OF THE FOG LIGHT BULB ASSEMBLY, AND REPAIR IT WHEN NECESSARY. OWNER NOTIFICATION BEGAN MARCH 31, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MAZDA AT 1-800-222-5500.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2003 Mazda Mpv Problems, Complaints & Recalls | Skip That Year
Illustration