2003 Mazda Mpv

THE PROBLEM IS WITH A FAULTY 2003 MAZDA MPV PCV HOSE. ORIGINAL MAZDA RECALL NUMBER 2204H WAS CONDUCTED TO REPLACE THE ORIGINAL FAULTY PCV HOSE. (NOTE: WHEN PCV HOSE COLLAPSED, IT CAUSED A VACUUM LEAK THAT AFFECTED MY BRAKE SYSTEM AND CAUSED PROBLEMS WHILE IN TRAFFIC, PROBLEM INTENSITY WAS BETWEEN MINOR AND MAJOR) I HAD MY PCV HOSE REPLACED IN 2004 UNDER THE RECALL, BUT THE REPLACEMENT HOSE ALSO COLLAPSED. I'VE NEVER HEARD OF A PCV HOSE COLLAPSING. I'VE HEARD OF THEM BECOMING DRY/BRITTLE SINCE IT'S A RUBBER HOSE, BUT I'VE NEVER HEARD OF A PCV HOSE COLLAPSING UNTIL THE MAZDA RECALL. THERE IS SOME VACUUM ON THE HOSE, BUT IT'S NOT VERY STRONG, I DON'T THINK IT'S STRONG ENOUGH TO CAUSE A COLLAPSE. IN MY OPINION, THERE NEEDS TO BE A SECOND RECALL TO REPLACE THE NOW COLLAPSING REPLACEMENT HOSES. I CONTACTED MAZDA CORPORATION AT 11:30 A.M. ON 7 MAY 09, THEIR RESPONSE WAS THAT THEY DID NOT KEEP RECORDS ON EXPECTED LIFE SPAN OR REPETITIVE PROBLEMS WITH PARTS AND THAT SINCE I HAD PUT A LOT OF MILES ON THE VAN AND IT WAS 5 YEARS OLD, AND SINCE THEY DID THE RECALL WORK, IT WAS NOW MY RESPONSIBILITY TO REPLACE THE FAULTY REPLACEMENT HOSE. IT'S DIFFICULT FOR ME TO BELIEVE THE MANUFACTURER WOULD NOT KEEP RECORDS ON FAULTY, RECALLED PARTS, ESPECIALLY FOR UNUSUAL PROBLEMS. MAZDA'S CASE FILE FOR MY COMPLAINT TO THEM IS 123531180. *TR

I HAVE HAD TO REPLACE FIVE OF THE SIX COILS ON MY 2003 MAZDA MPV OVER 3 YEARS. THEY FAIL FREQUENTLY AND CAUSE THE ENGINE TO MISS OR STALL EVEN WHILE MOVING. VERY DANGEROUS IN HEAVY TRAFFIC. I SEE THIS IS A COMMON PROBLEM WITH MAZDA MPV 2002 - 2006. VERY EXPENSIVE TO REPLACE THE BACK COILS - SEVERAL HUNDRED DOLLARS. THE FRONT ONES ARE EASY TO REPLACE. *TR

TL*THE CONTACT OWNS A 2003 MAZDA MPV. THE CONTACT STATED THAT THE ENGINE FAILED FOUR TIMES. THE VEHICLE HAD TO BE TOWED EACH TIME. THE DEALER INSTALLED ANOTHER ENGINE IN THE VEHICLE. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT CONTINUED TO ILLUMINATE AND THE COIL IGNITION HAD TO BE REPLACED TWICE. THE DEALER INSTALLED NEW SPARK PLUGS IN THE VEHICLE ON MARCH 13, 2007; HOWEVER, THEY FAILED A YEAR LATER AND HAD TO BE REPLACED. THE DEALER ALSO INSTALLED A WIRING HARNESS. THE BATTERY WAS DYING, THERE WAS A COOLANT LEAK, AND THE RADIATOR CORE, CATALYTIC CONVERTER, MANIFOLD STUDS, AND PCM ALL FAILED AND NEEDED TO BE REPLACED. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS APPROXIMATELY 48,000 AND FAILURE MILEAGE WAS 36,000.

2003 MPV'S CHECK ENGINE LIGHT CAME ON SHORTLY AFTER GETTING ON THE INTERSTATE. VAN HAD A "STUTTERING" FEEL. EVEN THOUGH THE VAN WAS 5 WEEKS OUT OF WARRANTY BY TIME, NOT MILEAGE (39901 MILES) I TOOK IT TO THE DEALERSHIP HOPING FOR A GOODWILL FIX. THEY SAID IT WAS THE EGR VALVE. I HAVE NEVER SEEN AN EGR VALVE TO OUT SO EARLY. DEALERSHIP DID COVER THE PART AND CHARGED ME $180 IN LABOR TO REPLACE THE VALVE THAT WAS ONLY A TWO BOLT REMOVAL AND EXTREMELY EASY TO GET TO. MAZDA SHOULD HAVE COVERED THIS FULLY. I WAS EXPECTING THIS TO BE THE FAMOUS COIL PROBLEM. *TR

AT SPEEDS OF 25 - 35 MILES PER HOUR, OUR 2003 MAZDA MPV LX STALLED FOR NO APPARENT REASON IN TRAFFIC. ALL CONTROL OF THE VEHICLE WAS LOST WHEN IT STALLED, LUCKILY, WE WERE TRAVELING AT SPEEDS AND IN A LANE THAT NO ACCIDENT OCCURRED, HOWEVER, IT WAS EXTREMELY DANGEROUS. WE HAD THE VEHICLE SERVICED AT A DEALER LOCAL TO WHERE WE WERE VACATIONING. THE DEALERSHIP, HOLMAN MAZDA IN EGG HARBOR TOWNSHIP, NJ, REPLACED AN AIR BYPASS VALVE, WHICH THEY STATED WAS THE REASON FOR STALLING AT APPROXIMATELY 2500 RPM. WHEN ASKED IF THIS WAS A NORMAL FAILURE, THE DEALER DID NOT BELIEVE SO. *NM