Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 15 of 58 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports1 fire reports1 injury reports
What owners actually said
58 reports
Mileage unknown · Oct 17, 2025
Engine
Cracked cylinder head causing oil leak and possible coolant leak. This is a known issue with this year and model. Mazda is trying to suggest the issue is only for the turbo engine, but the non-turbo engine is also defective, per countless reports online. I have a video from the service technician from the mazda dealership, but i…
Read full complaint
Cracked cylinder head causing oil leak and possible coolant leak. This is a known issue with this year and model. Mazda is trying to suggest the issue is only for the turbo engine, but the non-turbo engine is also defective, per countless reports online. I have a video from the service technician from the mazda dealership, but it is too big to upload.
NHTSA ODI #11694210
Mileage unknown · Sep 18, 2025
Power Train
Was driving then car suddenly shut down and all panel lights turned on. The car would not start after an hour it started but was Perkins when driving. Mechanics were unable to diagnose the issue.
NHTSA ODI #11688263
Mileage unknown · May 27, 2025
Service Brakes
Premature caliper failure on front and rear. Ruined rotors at 40k miles, confirmed caliper failure by two service shops. Grinding/squeaking sounds intermittently been happening for since 30,000 miles
NHTSA ODI #11663276
75,000 miles · May 14, 2025
Fuel System, Gasoline
The contact owns a 2018 Mazda Mazda6. The contact stated upon taken the vehicle to the dealer for an oil change, the dealer notified the contact of a fuel leak. The dealer diagnosed the vehicle and informed the contact that the top of the fuel tank and bolts connected to the fuel pump were significantly rusted, causing the fuel …
Read full complaint
The contact owns a 2018 Mazda Mazda6. The contact stated upon taken the vehicle to the dealer for an oil change, the dealer notified the contact of a fuel leak. The dealer diagnosed the vehicle and informed the contact that the top of the fuel tank and bolts connected to the fuel pump were significantly rusted, causing the fuel leak. The dealer determined that the fuel tank and the fuel pump needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure and informed the contact that no assistance would be provided because the contact had already authorized the dealer to repair the vehicle. The failure mileage was approximately 75,000.
NHTSA ODI #11660947
Mileage unknown · May 9, 2025
Engine
Bought used with 47k miles. Two weeks later, took it to my mechanic for an inspection, they found a massive oil leak on the back of the motor. Took it back to the dealership and they diagnosed it as a cracked cylinder head, for which there is a known TSB and warranty extension. Unfortunately, the warranty extension only covers a…
Read full complaint
Bought used with 47k miles. Two weeks later, took it to my mechanic for an inspection, they found a massive oil leak on the back of the motor. Took it back to the dealership and they diagnosed it as a cracked cylinder head, for which there is a known TSB and warranty extension. Unfortunately, the warranty extension only covers a coolant leak from the cracked cylinder head, not an oil leak. Thankfully, the dealership took care of me but had they not, I was looking at a $7k+ repair on a car I had owned for 2 weeks. In the TSB, Mazda acknowledges that there were both design and manufacturing flaws for the affected model years. In acknowledging the issue, they should have issued a recall for affected vehicles, not a simple warranty extension
NHTSA ODI #11659983
Mileage unknown · Mar 6, 2025
Service Brakes
I am having my brake pads changed at a local mechanic and when changing the pads, the mechanic was unable to change them because the rotors and calipers were rusted and the brake pistons stuck. The previous recall only considered Mazda 6 up to 2013 but my 2018 has had the same problem.
NHTSA ODI #11646848
Mileage unknown · Jan 17, 2025
Unknown Or Other
Software error/loss of engine power. No warning of this before it happens. The car completely loses power, and stalls or stops in the middle of me driving. This has happened on the freeway and risked my life as well as my husbands, and children. This same issue has been a previous recall and fixed in 2019 for my car, and now it …
Read full complaint
Software error/loss of engine power. No warning of this before it happens. The car completely loses power, and stalls or stops in the middle of me driving. This has happened on the freeway and risked my life as well as my husbands, and children. This same issue has been a previous recall and fixed in 2019 for my car, and now it is happening again.
NHTSA ODI #11636672
Mileage unknown · Jan 8, 2025
EngineUnknown Or Other
Coolant leaks at the cylinder head around the exhaust manifold causing my car to over heat. Also when my thermostat is set to the exact temperature for both sides my driver side blows cold and the passenger side blows hot
NHTSA ODI #11634788
Mileage unknown · Jan 4, 2025
Engine
Driving in traffic and the engine temperature warning appeared on dash. Dealer has confirmed there is a large coolant leak from the cylinder head. Mazda released a technical service bulletin regarding the issue affecting Mazda6, cx-5 and cx-9, but I will have to pay for a head gasket replacement.
NHTSA ODI #11634029
Mileage unknown · Nov 26, 2024
Engine
Cracked cylinder head near the exhaust manifold. Created a large oil leak. Oil on the exhaust is a fire hazard. After one quart of oil loss a low oil level light comes on. This is a reported problem. One version of the engine I have has a Mazda TSB and an extended warranty. TSB 01-0022/23 A local repair shop has diagn…
Read full complaint
Cracked cylinder head near the exhaust manifold. Created a large oil leak. Oil on the exhaust is a fire hazard. After one quart of oil loss a low oil level light comes on. This is a reported problem. One version of the engine I have has a Mazda TSB and an extended warranty. TSB 01-0022/23 A local repair shop has diagnosed the problem.
Mazda North American Operations (Mazda) is recalling certain 2018 Mazda3, Mazda6, 2019 CX-3, 2018-2019 MX-5, CX-5, CX-9, and 2019-2020 Mazda2 vehicles. The impeller inside the low-pressure fuel pump may crack and deform, potentially causing the fuel pump to fail.
Consequence & remedy
Consequence: Fuel pump failure may cause an engine stall, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pumps, free of charge. Owner notification letters were mailed July 18, 2022. Owners may contact Mazda customer service at 1-800-222-5500 Option 4. Mazda's number for this recall is 5321K.
Mazda North American Operations (Mazda) is recalling certain 2018-2019 CX-5, Mazda6, and 2019 Mazda3 vehicles. A software error in the powertrain control module (PCM) may cause the engine to stall.
Consequence & remedy
Consequence: An unexpected stall increases the risk of a crash.
Remedy: Mazda will notify owners, and dealers will reprogram the PCM software, free of charge. The recall began August 20, 2019. Owners may contact Mazda customer service at 1-800-222-5500, option 4. Mazda's number for this recall is 3719F.
Additional source detail variants (2)
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Mazda North American Operations (Mazda) is recalling certain 2018-2019 CX-5, Mazda6, and 2019 Mazda3 vehicles. A software error in the powertrain control module (PCM) may cause the engine to stall.
Consequence: An unexpected stall increases the risk of a crash.
Remedy: Mazda will notify owners, and dealers will reprogram the PCM software, free of charge. The recall began August 20, 2019. Owners may contact Mazda customer service at 1-800-222-5500, option 4. Mazda's number for this recall is 3719F.
Engine
Mazda North American Operations (Mazda) is recalling certain 2018-2019 CX-5, Mazda6, and 2019 Mazda3 vehicles. A software error in the powertrain control module (PCM) may cause the engine to stall.
Consequence: An unexpected stall increases the risk of a crash.
Remedy: Mazda will notify owners, and dealers will reprogram the PCM software, free of charge. The recall began August 20, 2019. Owners may contact Mazda customer service at 1-800-222-5500, option 4. Mazda's number for this recall is 3719F.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2018 Mazda MAZDA6 Problems, Complaints & Recalls | Skip That Year
Illustration