2023 Mazda CX-30

The contact owns a 2023 Mazda CX-30. The contact stated that while operating the vehicle, the vehicle experienced erroneous Lane Assist and Brake Assist failures, causing the vehicle to drive into the wrong lane. The vehicle experienced acceleration and braking assist failures. Occasionally, the vehicle failed to immediately start. The vehicle was serviced by the dealer on several occasions, and the battery was replaced. Additionally, the transmission and transmission pin failures persisted. The manufacturer was notified of the failure. The failure mileage was 45,000.

I am the original owner of a 2023 Mazda CX-30 AWD (VIN: [XXX]), purchased new on XXX from Mazda of Clearwater, [XXX]. This vehicle has experienced four separate warranty failure events involving critical safety systems within approximately 32 months and 44,530 miles of ownership. In June 2026, at approximately 44,500 miles, my 2023 Mazda CX-30 AWD exhibited sudden RPM lock and inability to shift, with delayed and jerky acceleration. Dashboard warning lights activated including transmission malfunction indicators. DTCs P0756 (Shift Solenoid B Stuck Off) and P0780 (Shift Malfunction) were set. The vehicle was taken to an authorized Mazda dealership. The dealer confirmed the concern and contacted Mazda's regional tech specialist. The valve body was replaced first per Mazda's direction; however, the vehicle continued to exhibit rough and delayed shifting on test drive. Mazda then directed the dealer to replace the full transmission assembly. The repair required 35 days at the dealership. This failure did not occur in isolation. The same vehicle had previously required warranty replacement of brake components (disc, caliper, pads) at approximately 26,400 miles due to a driveability concern, and battery and drive belt tensioner replacement at approximately 29,100 miles. An independent service record five months prior to the transmission failure confirmed transmission fluid was at correct level, ruling out neglect. The pattern of cascading safety-system failures — braking, electrical, and transmission — within 32 months on a low-mileage vehicle suggests a potential systemic manufacturing defect. The RPM lock and inability to shift at highway speeds represents a direct safety hazard to the driver and other motorists. All repairs were confirmed and performed by an authorized Mazda dealer under factory warranty. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2023 Mazda. The contact stated that the vehicle was braking randomly while driving. There was an unknown malfunction code that flashed quickly. The steering was stiff and failed to turn. The steering wheel adjusted and guided the vehicle into the wrong lane. The RPM was sporadically reeving. The RPM increased, and the vehicle stalled without acceleration. There was smoke emerging from the hood. There was oil leaking. The vehicle failed to turn off and on. The fuel gauge and infotainment center were not working properly. The contact stated that while leaving the local dealer, the vehicle stalled. The battery was replaced. The vehicle was towed to another unknown local dealer who determined the battery needed to be replaced. The vehicle was replaced, but the failure recurred. The dealer determined that there was an oil leak and needed to replace the transmission, serpentine belt, and battery. The dealer informed me additional testing was needed. The vehicle was not repaired. The manufacturer was contacted regarding a buyback, but no assistance was provided. The failure mileage was approximately 37,000.

Unexpected Automatic Emergency Braking Activation at Highway Speeds in Cold Temperatures. Description: I am reporting a safety issue with a 2023 Mazda CX-30 involving the collision avoidance / automatic emergency braking system. While driving at highway speeds, the system activates a forward collision warning (audible alert and dashboard indicator), followed almost immediately by automatic braking, even when there are no vehicles, obstacles, or pedestrians ahead. Conditions When Issue Occurs: * Ambient temperature: below ~40°F (4°C) * Road conditions: cold, often icy or snowy * Speed: highway speeds 45-75 * Environment: clear roadway, no visible hazards * visibility : clear System Behavior: * Audible warning and visual alert activate * Automatic braking occurs approximately 0.5–1 second after the warning * No obstacle is present to justify intervention Safety Risk: This presents a serious safety hazard because: * Sudden braking at highway speeds creates a high risk of rear-end collision * The warning-to-brake interval is extremely short, leaving little time for driver override. * Occurs in low-traction conditions, increasing risk of loss of control. * The event is unexpected and not predictable by the driver. Frequency: * Occurred multiple times under similar cold-weather conditions. * Appears repeatable based on temperature range. Attempts to Resolve: * Sensors/camera appear clean and unobstructed. * No prior collision damage to the vehicle. * Issue persists despite normal operation otherwise. * Similar reports observed from other owners in online discussions. This is not a one time occurrence, in the section below, i noted the last event but this is a daily occurrence in temperatures below 42F.

While driving down the road a vehicle in front of me braked to stop for a bus loading kids, as I stepped on the brakes nothing happened and the vehicle surged forward. After the accident I viewed the vehicles onboard system status and it had logged several errors including errors to the activsense driver assist control. I used the vehicle’s emergency assist button and contacted 911, and reported the incident to ride share and contact my spouse. Police report lists the wrong time and vehicle but does have the correct vin number

While attempting a left-hand turn, the steering wheel suddenly became stiff and unresponsive, as if the mechanical gear had bound. This sudden resistance made it impossible to complete the turn, causing the vehicle to strike a curb at low speed. A post-accident inspection at Lee Johnson Mazda (RO# 649854) confirmed extensive damage, including a bent inner tie rod, a damaged front wheel bearing/hub assembly, and wheel/tire damage totaling over $6,500. The dealership stated no electronic fault codes were present in the computer, but the physical behavior matches the 'sticky steering' symptoms currently under federal investigation for other Mazda models (Recall 24V022 / RQ26002). I believe a mechanical failure in the steering gear caused the collision.

My 2023 Mazda CX-30, which is currently under full manufacturer warranty, was brought to the dealer on October 10, 2025, specifically to address a safety defect involving white chemical particulates blowing through the HVAC vents. The dealership confirmed the failure of the "evaporative coating", which resulted in unidentified chemical byproduct being discharged directly into the passenger cabin.The vehicle remained out of service for 103 days due to this manufacturing defect. Upon receiving the Repair order (RO# 77004584) today, January 20, 2026, I discovered a significant safety concern that violates standard warranty repair protocols: the technician admitted to receiving two separate heater unit boxes that were damaged during shipping and subsequently 'transferred all salvageable items "from one damaged unit to the other to make one complete unit". As a consumer with a vehicle under warranty, I am entitled to a repair using new, undamaged factory parts. I am extremely concerned about the structural and functional integrity of a "reconstructed" HVAC system assembled from damaged components. Furthermore, despite the confirmed chemical emission, no professional decontamination of the interior was performed. The manufactures is now using financial threats of storage and rental car fees to force me to accept this substandard, "cannibalized" repair.

One day after oil and filter change, engine LOW OIL LEVEL light illuminated on dash. Engine oil dipstick displays full oil level; no signs on oil leaks under the vehicle. Appears to be failed oil level sensor. Upon restarting the vehicle, LOW OIL LEVEL light is turned off. Intermittently returns after some time of driving. Have not observed light turning itself off without shutting down the vehicle.

While coasting slowly through a parking lot at approximately 5-8mph I tapped the brake to slow further while making a tight turn and to safely pass a vehicle also turning towards me. This caused the car to lurch and accelerate as though my foot was on the gas pedal, but it wasn't. I had to step hard on the brake to bring it under control.

While driving at approximately 20 mph on a residential road during slushy conditions, the side curtain airbags deployed without warning. There was no collision, no impact, and no indication of a rollover or crash. A police officer arrived and completed a report, which noted no crash had occurred. The airbag deployment caused damage throughout the vehicle, and the car has since been declared a total loss by the insurance company. The manufacturer initially delayed responding for over two weeks. When they did respond, they claimed the airbags deployed properly based on “connected data” indicating a possible rollover. However, they refused to provide any proof of this data, any Event Data Recorder (EDR) data, or any technical explanation of what triggered the deployment. No warning lights or messages were displayed before the deployment. The local dealership that had the vehicle inspected the physical damage but did not confirm a rollover or any significant structural event. Mazda has refused to release their investigation data and instead closed the case without transparency. This deployment caused significant damage and created safety and financial risk. I am concerned that this incident may reflect a larger issue in airbag deployment logic that other owners may also face.