THE FRAME, SUSPENSION, AND BRAKE LINES RUSTED THROUGH PREMATURELY. THE BRAKE LINES WERE REPLACED ALL AROUND BEFORE 75,000 MILES. BEFORE 80,000 MILES THE TRUCK HAS BEEN DECLARED NON-REPAIRABLE AS THE FRAME AND SUSPENSION HAVE RUSTED THROUGH AT INSPECTION. TRUCK WAS LIGHTLY USED SINCE 2001 AND HAD NOT HIT 80,000. MILES BUT BECAME …
Read full complaint
THE FRAME, SUSPENSION, AND BRAKE LINES RUSTED THROUGH PREMATURELY. THE BRAKE LINES WERE REPLACED ALL AROUND BEFORE 75,000 MILES. BEFORE 80,000 MILES THE TRUCK HAS BEEN DECLARED NON-REPAIRABLE AS THE FRAME AND SUSPENSION HAVE RUSTED THROUGH AT INSPECTION. TRUCK WAS LIGHTLY USED SINCE 2001 AND HAD NOT HIT 80,000. MILES BUT BECAME UNSAFE TO OPERATE DUE TO RUST.
NHTSA ODI #11098059
144,000 miles · Dec 13, 2012
StructureSuspension
DISCOVERED THE RIGHT REAR SPRING HANGER HAD RUSTED OFF THE FRAME OF THE TRUCK. FURTHER INSPECTION HAS FOUND THE FRAME IS SO BADLY RUSTED THAT REPAIR OF THE SPRING HANGER IS NOT POSSIBLE DUE TO THE OVERALL CONDITION OF THE FRAME. SIMPLY PUT, THE FRAME HAS ROTTED AND PIECES FALL OF AS YOU DRIVE. THERE IS NO MORE FRAME LEFT TO RE-A…
Read full complaint
DISCOVERED THE RIGHT REAR SPRING HANGER HAD RUSTED OFF THE FRAME OF THE TRUCK. FURTHER INSPECTION HAS FOUND THE FRAME IS SO BADLY RUSTED THAT REPAIR OF THE SPRING HANGER IS NOT POSSIBLE DUE TO THE OVERALL CONDITION OF THE FRAME. SIMPLY PUT, THE FRAME HAS ROTTED AND PIECES FALL OF AS YOU DRIVE. THERE IS NO MORE FRAME LEFT TO RE-ATTACH THE REAR SPRING TO. SEVERE PREMATURE RUST. THE REST OF THE VEHICLE METAL IS IN GOOD CONDITION. *TR
NHTSA ODI #10488687
Mileage unknown · Aug 6, 2001
Engine And Engine CoolingLatches/locks/linkagesPower Train
CONSUMER STATES THAT THE CLUTCH CATCHES TOO QUICKLY WHEN GEARS ARE SHIFTED AND THERE IS A LOUD CLUNK THAT CAN BE FELT AND HEARD THROUGHOUT THE TRUCK, CONSUMER STATES IT IS METAL HITTING METAL. VEHICLE PULLS TO THE RIGHT. MOTOR IS MISSING AND HAS NO POWER. DRIVERS DOOR FLIES OPEN AFTER GOING OVER BUMPS. DEALER REFUSED TO DO A…
Read full complaint
CONSUMER STATES THAT THE CLUTCH CATCHES TOO QUICKLY WHEN GEARS ARE SHIFTED AND THERE IS A LOUD CLUNK THAT CAN BE FELT AND HEARD THROUGHOUT THE TRUCK, CONSUMER STATES IT IS METAL HITTING METAL. VEHICLE PULLS TO THE RIGHT. MOTOR IS MISSING AND HAS NO POWER. DRIVERS DOOR FLIES OPEN AFTER GOING OVER BUMPS. DEALER REFUSED TO DO ANYTHING ABOUT ANY OF THE PROBLEMS AND IS STATING THAT EVERYTHING IS NORMAL. *SLC A SERVICE TECHNICIAN STATED THAT IT SOUNDED LIKE THE CLUTCH WAS NOT CATCHING UNTIL THE LAST MINUTE, THE JARRING WAS THE TRANSMISSION AFTER SHIFTING AND DECELERATING OUT OF ADJUSTMENT. *SLC
MAZDA IS RECALLING MODEL YEAR 1995 THROUGH 1997 AND MODEL YEAR 2001 THROUGH 2003 TRUCKS EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS) AND/OR ANTI-LOCK BRAKE SYSTEM (ABS) AND MANUFACTURED ON OR BEFORE DECEMBER 5, 2002. A COMPONENT OF THE CRUISE CONTROL DEACTIVATION SWITCH MAY DETERIORATE OVER TIME AND DEVELOP A LEAK. THIS OCCURRENCE COULD CAUSE THE SWITCH TO OVERHEAT, SMOKE OR BURN WHICH COULD RESULT IN AN UNDER HOOD FIRE.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: MAZDA WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A UNIVERSAL FUSED JUMPER HARNESS ON THE CRUISE CONTROL DEACTIVATION SWITCH FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 11, 2009. OWNERS MAY CONTACT MAZDA AT 1-800-222-5500 OPTION #6.
ON CERTAIN TRUCKS EQUIPPED WITH A SPEED CONTROL SYSTEM, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. AN INTERIM NOTICE WAS SENT TO OWNERS ON SEPTEMBER 7, 2007, DIRECTING THEM TO HAVE THE SPEED DEACTIVATION CONTROL SWITCH DISCONNECTED TEMPORARILY. A SECOND NOTIFICATION LETTER TO OWNERS WAS IN FEBRUARY 2008 ADVISING THEM TO RETURN TO DEALERS FOR INSTALLATION OF THE REPAIR PART. OWNERS OF AFFECTED VEHICLES WHO DID NOT RECEIVE A PHASE 2 NOTICE AND HAVE NOT HAD THE RECALL COMPLETED WILL BE NOTIFIED BEGINNING AUGUST 6, 2008. OWNERS MAY CONTACT MAZDA AT 1-800-222-5500.
VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS EQUIPPED WITH SEAT BELTS SUPPLIED BY TRW. IT IS POSSIBLE THAT THE DRIVER'S AND/OR FRONT PASSENGER'S OUTBOARD SEAT BELT BUCKLE MAY NOT FULLY LATCH. FORD CROWN VICTORIA BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01 MERCURY GRAND MARQUIS BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01. LINCOLN TOWN CARS BUILT AT WIXOM ASSEMBLY PLANT FROM 3/27/00 - 5/30/01. LINCOLN NAVIGATORS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01. FORD WINDSTARS BUILT AT OAKVILLE ASSEMBLY PLANT FROM 3/23/00 - 5/30/01. FORD RANGERS BUILT AT TWIN CITIES PLANT FROM 3/28/00 - 5/30/01, AND ALSO AT THE EDISON PLANT FROM 3/13/00 - 5/25/01. FORD F-150 TRUCK BUILT AT NORFOLK PLANT FROM 4/18/00 - 5/25/00; AT ONTARIO PLANT FROM 5/10/00 - 5/28/01; AT KANSAS CITY PLANT FROM 9/11/99 - 5/25/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/9/01. FORD SUPER DUTY F-250, F-350, F-450, AND F-550 TRUCKS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 5/27/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/19/01. FORD EXCURSIONS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 10/2/00. FORD EXPEDITIONS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE OCCUPANT PROTECTION, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL INSPECT THE FRONT OUTBOARD SEAT BELT BUCKLES AND IF THE BUCKLE FAILS THE INSPECTION PROCESS, IT WILL BE REPLACED. OWNER NOTIFICATION BEGAN AUGUST 15, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MAZDA AT 1-800-222-5500.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2001 Mazda B-SERIES Truck Problems, Complaints & Recalls | Skip That Year
Illustration