THE EMERGENCY BRAKE LINES ARE CROSSED AHEAD OF THE REAR DRIVERS TIRE. THERE IS A LOT OF PRESSURE ON THESE LINES AND THEY ARE RUBBING TOGETHER CAUSING A GREAT DEAL OF WEAR. I HAVE NOTICED THE SAME PROBLEM ON OTHER MAZDA B SERIES AND FORD RANGER PICKUPS. I HAVE PLACED A PIECE OF RUBBER BETWEEN THE LINES TO PREVENT FURTHER DAMAG…
Read full complaint
THE EMERGENCY BRAKE LINES ARE CROSSED AHEAD OF THE REAR DRIVERS TIRE. THERE IS A LOT OF PRESSURE ON THESE LINES AND THEY ARE RUBBING TOGETHER CAUSING A GREAT DEAL OF WEAR. I HAVE NOTICED THE SAME PROBLEM ON OTHER MAZDA B SERIES AND FORD RANGER PICKUPS. I HAVE PLACED A PIECE OF RUBBER BETWEEN THE LINES TO PREVENT FURTHER DAMAGE. I BELIEVE THAT THE EMERGENCY LINES ON THE MAZDA AND FORD RANGER PICKUPS SHOULD BE RECALLED BEFORE THEY FAIL AND CAUSE INJURIES.
ON CERTAIN TRUCKS EQUIPPED WITH A SPEED CONTROL SYSTEM, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. AN INTERIM NOTICE WAS SENT TO OWNERS ON SEPTEMBER 7, 2007, DIRECTING THEM TO HAVE THE SPEED DEACTIVATION CONTROL SWITCH DISCONNECTED TEMPORARILY. A SECOND NOTIFICATION LETTER TO OWNERS WAS IN FEBRUARY 2008 ADVISING THEM TO RETURN TO DEALERS FOR INSTALLATION OF THE REPAIR PART. OWNERS OF AFFECTED VEHICLES WHO DID NOT RECEIVE A PHASE 2 NOTICE AND HAVE NOT HAD THE RECALL COMPLETED WILL BE NOTIFIED BEGINNING AUGUST 6, 2008. OWNERS MAY CONTACT MAZDA AT 1-800-222-5500.
VEHICLE DESCRIPTION: CERTAIN 1998-1998 MAZDA B-SERIES TRUCKS (B2500, B3000 AND B4000) EQUIPPED WITH CRUISE CONTROL AND BUILT FROM JANUARY 1998 THROUGH MARCH 4, 1999. A CRUISE CONTROL CABLE CAN INTERFERE WITH THE SPEED CONTROL SERVO PULLEY AND NOT ALLOW THE THROTTLE TO RETURN TO IDLE WHEN DISENGAGING THE CRUISE CONTROL.
Consequence & remedy
Consequence: IF THE CRUISE CONTROL IS USED AND THIS CONDITION IS PRESENT, A STUCK THROTTLE COULD RESULT, WHICH COULD POTENTIALLY RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CRUISE CONTROL CABLES. AT THE PRESENT TIME, THE REPLACEMENT CABLES ARE NOT AVAILABLE. CUSTOMERS ARE BEING ADVISED NOT TO USE THE CRUISE CONTROL SYSTEM UNTIL A REPLACEMENT CAN BE MADE.
VEHICLE DESCRIPTION: LIGHT DUTY 4X2 AND 4X4 PICKUP TRUCKS EQUIPPED WITH 4.0L ENGINES. THE FLEXIBLE SECTION OF THE CHASSIS MOUNTED FUEL LINE THAT CONNECTS TO THE ENGINE WAS ROUTED TOO CLOSE TO THE EXHAUST MANIFOLD. THE LINE COULD CONTACT THE MANIFOLD.
Consequence & remedy
Consequence: THIS COULD POTENTIALLY RESULT IN DAMAGE TO THE FUEL LINE, OR IN SOME CASES, CAUSE A FUEL LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL CLIP TO HOLD THE FUEL LINE IN THE INTENDED DESIGN POSITION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1998 Mazda B-SERIES Truck Problems, Complaints & Recalls | Skip That Year
Illustration