Rear upper control arm failure. A crack develops along a casting line, which then allows the upper bushing to move within the control arm. This bushing is pressed into the control arm, and is not supposed to move. Because the hub was allowed to tilt forward due to the bushing not being held firmly by the control arm, the outer…
Read full complaint
Rear upper control arm failure. A crack develops along a casting line, which then allows the upper bushing to move within the control arm. This bushing is pressed into the control arm, and is not supposed to move. Because the hub was allowed to tilt forward due to the bushing not being held firmly by the control arm, the outer CV boot was allowed to contact the lower spring perch, which then burned a hole in the CV boot, allowing all its grease to escape. This scenario can generate an excessive amount of heat and/or wear in that joint, leading to axle failure.
Lotus Cars USA, Inc. (Lotus) is recalling certain model year 2008-2011 Elise and Exige vehicles manufactured from November 2007 to July 2011, and 2011 Evora vehicles manufactured September 2010 through September 2011. The oil cooler hose may detach from its fitting.
Consequence & remedy
Consequence: A detached oil hose could spray oil on a tire, increasing the risk of a crash, or it could spray oil throughout the engine compartment, increasing the risk of a fire.
Remedy: Lotus will notify owners, and dealers will replace the oil cooler hose fittings on the Elise and Exige vehicles and will replace the oil cooler hose assemblies on the Evora vehicles, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Lotus at 1-800-245-6887. Lotus' number for this recall is 201401R (Elise/Exige), and 2014/02R (Evora). Note: This recall is an expansion of recalls 11V-510 and 13V-041.
Lotus Cars USA, Inc. is recalling certain model year 2011 Evora supercharged vehicles equipped with a manual transmission and manufactured September 2010 through September 2011. The engine oil cooler hose may chafe and rupture resulting in oil loss.
Consequence & remedy
Consequence: Engine oil may be ejected onto the road or rear wheels which could cause a reduction in vehicle control and potential engine failure, increasing the risk of a crash. Engine oil sprayed onto a heat source may also lead to a vehicle fire.
Remedy: Lotus will notify owners and dealers will repair the vehicles free of charge. The recall began on December 11, 2013. Owners may contact Lotus at 1-770-476-6564. Lotus' campaign number is 2013/03R.
Lotus is recalling certain model year 2011 Evora supercharged vehicles manufactured from February 2011 through September 2011, equipped with a three-piece oil feed pipe with a flexible hose section. This engine mounted oil feed pipe, used to supply oil to the engine cylinder head, can rupture.
Consequence & remedy
Consequence: The ruptured pipe can result in oil loss and engine damage, and oil sprayed onto hot engine components may result in a fire.
Remedy: Lotus will notify owners, and dealers will replace the oil feed pipe free of charge. The safety recall began on December 10, 2012. Owners may contact Lotus at 1-800-245-6887.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2011 Lotus Evora Problems, Complaints & Recalls | Skip That Year
Illustration