PLEASE NOTE, I HAVE NOT HAD AN ISSUE YET, BUT OTHER PEOPLE I KNOW HAVE. THE REAR SUSPENSION INNER TOE LINK HAS BEEN KNOWN TO FAIL ON THE 05 + 06 LOTUS ELISE. I HAVE SEEN FAILURES OF THIS PART SHEARING APART ON VEHICLES WITH AS LOW AS 5000 MILES. A CATASTROPHIC FAILURE OF THIS PART CAUSES THE CAR TO BECOME UNCONTROLLABLE AND…
Read full complaint
PLEASE NOTE, I HAVE NOT HAD AN ISSUE YET, BUT OTHER PEOPLE I KNOW HAVE. THE REAR SUSPENSION INNER TOE LINK HAS BEEN KNOWN TO FAIL ON THE 05 + 06 LOTUS ELISE. I HAVE SEEN FAILURES OF THIS PART SHEARING APART ON VEHICLES WITH AS LOW AS 5000 MILES. A CATASTROPHIC FAILURE OF THIS PART CAUSES THE CAR TO BECOME UNCONTROLLABLE AND UNDRIVEABLE. IT IS A SERIOUS SITUATION WHERE SOMEONE COULD BE INJURED OR KILLED. LUCKILY NO ONE HAS OF YET. HERE IS AN INTERNET LINK THAT DESCRIBES THE ISSUE IN A LITTLE BETTER DETAIL, AND SHOWS WHAT HAPPENS TO THE TOE LINK. HTTP://WWW.ELISETALK.COM/FORUMS/SHOWPOST.PHP?P=392088&POSTCOUNT=34 HERE IS ALSO ANOTHER PICTURE OF A DIFFERENT FAILURE OF THIS PIECE. HTTP://WWW.1017.ORG/TEMP/TOELINK.JPG I UNDERSTAND THAT LOTUS SPORT HAS A FIX FOR THIS ISSUE, INCLUDING BETTER JOINTS, AND A SUSPENSION BRACE. I WOULD URGE THE NHTSA TO PRESSURE LOTUS INTO DOING A RETROFIT FOR EXISTING CARS, AND IMPROVE THE DESIGN GOING FORWARD. FOR SOME INFO ON THAT BRACE, HERE IS ONE INTERNET DISCUSSION. HTTP://WWW.ELISETALK.COM/FORUMS/SHOWPOST.PHP?P=179555&POSTCOUNT=1 THANKS FOR YOUR TIME. *JB
LOTUS IS RECALLING CERTAIN MODEL YEAR 2005-2007 ELISE AND EXIGE VEHICLES MANUFACTURED FROM JUNE 1, 2004, THROUGH NOVEMBER 30, 2006. THE OIL COOLER LINE MAY BECOME DETACHED FROM ITS FITTING.
Consequence & remedy
Consequence: A DETACHED OIL LINE COULD SPRAY OIL ON A TIRE, INCREASING THE RISK OF A CRASH, OR IT COULD SPRAY OIL THROUGHOUT THE ENGINE COMPARTMENT INCREASING THE RISK OF A FIRE.
Remedy: LOTUS WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE VEHICLES AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE DECEMBER 19, 2011. OWNERS MAY CONTACT LOTUS AT 1-800-245-6887.
Additional source detail variants (2)
Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings
LOTUS IS RECALLING CERTAIN MODEL YEAR 2005-2007 ELISE AND EXIGE VEHICLES MANUFACTURED FROM JUNE 1, 2004, THROUGH NOVEMBER 30, 2006. THE OIL COOLER LINE MAY BECOME DETACHED FROM ITS FITTING.
Consequence: A DETACHED OIL LINE COULD SPRAY OIL ON A TIRE, INCREASING THE RISK OF A CRASH, OR IT COULD SPRAY OIL THROUGHOUT THE ENGINE COMPARTMENT INCREASING THE RISK OF A FIRE.
Remedy: LOTUS WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE VEHICLES AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE DECEMBER 19, 2011. OWNERS MAY CONTACT LOTUS AT 1-800-245-6887.
Engine And Engine Cooling
LOTUS IS RECALLING CERTAIN MODEL YEAR 2005-2007 ELISE AND EXIGE VEHICLES MANUFACTURED FROM JUNE 1, 2004, THROUGH NOVEMBER 30, 2006. THE OIL COOLER LINE MAY BECOME DETACHED FROM ITS FITTING.
Consequence: A DETACHED OIL LINE COULD SPRAY OIL ON A TIRE, INCREASING THE RISK OF A CRASH, OR IT COULD SPRAY OIL THROUGHOUT THE ENGINE COMPARTMENT INCREASING THE RISK OF A FIRE.
Remedy: LOTUS WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE VEHICLES AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE DECEMBER 19, 2011. OWNERS MAY CONTACT LOTUS AT 1-800-245-6887.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE11022 · Engine Oil Cooler Line Detachment
Opened Jul 18, 2011 · Closed Nov 3, 2011
Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings
On October 14, 2011, Lotus Cars USA Inc. notified the Office of Defects Investigation (ODI) that it will conduct a safety recall (11V-510) to address concerns with engine oil cooler lines detaching from its crimped fitting on MY 2005-2006 Lotus Elise vehicles.In its 573 report to ODI, Lotus indicated that they have identified instances where the oil cooler lines would detach from their fittings.Lotus attributes this condition to a majority of single supplier affected parts built from June 2004 to November 2006.Lotus states that the cause of the failure is an inadequate process by which the hose is crimped into its fitting by the supplier.In October 2006 the supplier implemented an improved crimping process.Reports indicated that this condition can occur while driving or while the vehicle is stationary with the engine running.In cases where the failure occurred while driving, oil would be expelled under pressure and could come into contact with the tires and or brake friction surfaces, potentially causing a loss of braking or vehicle control. One crash and one vehicle fire were also reported with no injuries.Additionally Lotus indicated that the same condition can occur in MY 2005-2006 Exige vehicles as well. These vehicles are also included in the recall.The action taken by Lotus is sufficient to resolve the issues raised by this investigation.This investigation is therefore closed.
Additional source detail variants (4)
Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings
On October 14, 2011, Lotus Cars USA Inc. notified the Office of Defects Investigation (ODI) that it will conduct a safety recall (11V-510) to address concerns with engine oil cooler lines detaching from its crimped fitting on MY 2005-2006 Lotus Elise vehicles.In its 573 report to ODI, Lotus indicated that they have identified instances where the oil cooler lines would detach from their fittings.Lotus attributes this condition to a majority of single supplier affected parts built from June 2004 to November 2006.Lotus states that the cause of the failure is an inadequate process by which the hose is crimped into its fitting by the supplier.In October 2006 the supplier implemented an improved crimping process.Reports indicated that this condition can occur while driving or while the vehicle is stationary with the engine running.In cases where the failure occurred while driving, oil would be expelled under pressure and could come into contact with the tires and or brake friction surfaces, potentially causing a loss of braking or vehicle control. One crash and one vehicle fire were also reported with no injuries.Additionally Lotus indicated that the same condition can occur in MY 2005-2006 Exige vehicles as well. These vehicles are also included in the recall.The action taken by Lotus is sufficient to resolve the issues raised by this investigation.This investigation is therefore closed.
Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings
On October 14, 2011, Lotus Cars USA Inc. notified the Office of Defects Investigation (ODI) that it will conduct a safety recall (11V-510) to address concerns with engine oil cooler lines detaching from its crimped fitting on MY 2005-2006 Lotus Elise vehicles.In its 573 report to ODI, Lotus indicated that they have identified instances where the oil cooler lines would detach from their fittings.Lotus attributes this condition to a majority of single supplier affected parts built from June 2004 to November 2006.Lotus states that the cause of the failure is an inadequate process by which the hose is crimped into its fitting by the supplier.In October 2006 the supplier implemented an improved crimping process.Reports indicated that this condition can occur while driving or while the vehicle is stationary with the engine running.In cases where the failure occurred while driving, oil would be expelled under pressure and could come into contact with the tires and or brake friction surfaces, potentially causing a loss of braking or vehicle control. One crash and one vehicle fire were also reported with no injuries.Additionally Lotus indicated that the same condition can occur in MY 2005-2006 Exige vehicles as well. These vehicles are also included in the recall.The action taken by Lotus is sufficient to resolve the issues raised by this investigation.This investigation is therefore closed.
Engine And Engine Cooling
On October 14, 2011, Lotus Cars USA Inc. notified the Office of Defects Investigation (ODI) that it will conduct a safety recall (11V-510) to address concerns with engine oil cooler lines detaching from its crimped fitting on MY 2005-2006 Lotus Elise vehicles.In its 573 report to ODI, Lotus indicated that they have identified instances where the oil cooler lines would detach from their fittings.Lotus attributes this condition to a majority of single supplier affected parts built from June 2004 to November 2006.Lotus states that the cause of the failure is an inadequate process by which the hose is crimped into its fitting by the supplier.In October 2006 the supplier implemented an improved crimping process.Reports indicated that this condition can occur while driving or while the vehicle is stationary with the engine running.In cases where the failure occurred while driving, oil would be expelled under pressure and could come into contact with the tires and or brake friction surfaces, potentially causing a loss of braking or vehicle control. One crash and one vehicle fire were also reported with no injuries.Additionally Lotus indicated that the same condition can occur in MY 2005-2006 Exige vehicles as well. These vehicles are also included in the recall.The action taken by Lotus is sufficient to resolve the issues raised by this investigation.This investigation is therefore closed.
Engine And Engine Cooling
On October 14, 2011, Lotus Cars USA Inc. notified the Office of Defects Investigation (ODI) that it will conduct a safety recall (11V-510) to address concerns with engine oil cooler lines detaching from its crimped fitting on MY 2005-2006 Lotus Elise vehicles.In its 573 report to ODI, Lotus indicated that they have identified instances where the oil cooler lines would detach from their fittings.Lotus attributes this condition to a majority of single supplier affected parts built from June 2004 to November 2006.Lotus states that the cause of the failure is an inadequate process by which the hose is crimped into its fitting by the supplier.In October 2006 the supplier implemented an improved crimping process.Reports indicated that this condition can occur while driving or while the vehicle is stationary with the engine running.In cases where the failure occurred while driving, oil would be expelled under pressure and could come into contact with the tires and or brake friction surfaces, potentially causing a loss of braking or vehicle control. One crash and one vehicle fire were also reported with no injuries.Additionally Lotus indicated that the same condition can occur in MY 2005-2006 Exige vehicles as well. These vehicles are also included in the recall.The action taken by Lotus is sufficient to resolve the issues raised by this investigation.This investigation is therefore closed.
2006 Lotus Elise Problems, Complaints & Recalls | Skip That Year
Illustration