Electrical SystemFuel/propulsion SystemVehicle Speed Control
Fuel gauge says zero miles to empty and will not take any gas more than a few gallons before kicking pump off. Gauge shows it's over heating but if you turn ignition off and turn right back on it resets and is fine. Codes come back saying nothing about fuel or cooling, but only something about speed control in the hub. Sounds li…
Read full complaint
Fuel gauge says zero miles to empty and will not take any gas more than a few gallons before kicking pump off. Gauge shows it's over heating but if you turn ignition off and turn right back on it resets and is fine. Codes come back saying nothing about fuel or cooling, but only something about speed control in the hub. Sounds like an electrical issue but no where to be found.
NHTSA ODI #11482715
68,000 miles · Jul 6, 2017
Fuel/propulsion SystemService BrakesFire
TL* THE CONTACT OWNS A 2006 LINCOLN NAVIGATOR. WHILE THE VEHICLE WAS STOPPED, THE CONTACT SMELLED BURNING RUBBER AND PLASTIC. THE CONTACT NOTICED SMOKE AND FLAMES EMERGING FROM BOTH THE FRONT DRIVER AND PASSENGER SIDES. THE FIRE DEPARTMENT WAS NOT CALLED AND THE CONTACT EXTINGUISHED THE FIRE. A POLICE REPORT WAS NOT FILED AND TH…
Read full complaint
TL* THE CONTACT OWNS A 2006 LINCOLN NAVIGATOR. WHILE THE VEHICLE WAS STOPPED, THE CONTACT SMELLED BURNING RUBBER AND PLASTIC. THE CONTACT NOTICED SMOKE AND FLAMES EMERGING FROM BOTH THE FRONT DRIVER AND PASSENGER SIDES. THE FIRE DEPARTMENT WAS NOT CALLED AND THE CONTACT EXTINGUISHED THE FIRE. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO BAYWAY LINCOLN (12333 GULF FWY, HOUSTON, TX 77034) WHERE IT WAS DIAGNOSED THAT THE FUEL AND BRAKE LINES HAD OVERHEATED AND CAUGHT FIRE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 68,000.
NHTSA ODI #11003307
Mileage unknown · Oct 20, 2016
Fuel/propulsion System
LINCOLN NAVIGATOR VEHICLES EQUIPPED WITH 5.4L ENGINES. THE FUEL RAIL CROSS-OVER HOSE MAY CONTAIN WEAK AREAS. AS A RESULT, THE HOSE MAY CRACK, WHICH COULD CAUSE A FUEL ODOR AND/OR FUEL LEAK
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH AN INCORRECTLY MANUFACTURED AUTOMATIC TRANSMISSION PARKING PAWL GUIDE PLATE.
Consequence & remedy
Consequence: THIS COULD CAUSE THE PARKING LOCK SYSTEM NOT TO ENGAGE, AFTER THE TRANSMISSION IS PLACED IN THE PARK ("P") POSITION. IF THE VEHICLE WAS PARKED ON AN INCLINE, AND THE PARKING BRAKE WAS NOT ENGAGED, THIS COULD RESULT IN A VEHICLE ROLLAWAY CONDITION.
Remedy: DEALERS WILL REPAIR AND REPLACE THE AUTOMATIC TRANSMISSION GUIDE PLATE. THE RECALL BEGAN ON NOVEMBER 18, 2005. OWNERS MAY CONTACT LINCOLN AT 1-800-248-0186.
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
Consequence & remedy
Consequence: AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Remedy: DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.
ON CERTAIN SPORT UTILITY VEHICLES, THE FRONT AND REAR TIRES ON THE DRIVER'S SIDE OF AFFECTED VEHICLES MAY HAVE BEEN DAMAGED AT THE CENTER TREAD DURING PRODUCTION.
Consequence & remedy
Consequence: OVER TIME, THE DAMAGE MAY BE SUFFICIENT TO ALLOW BELT CORROSION ULTIMATELY LEADING TO A TREAD SEPARATION, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT ALL FOUR TIRES (TO ENSURE INSPECTION OF THE LEFT HAND SIDE TIRES THAT MAY HAVE BEEN ROTATED TO THE OTHER SIDE OF THE VEHICLE) FOR TIRE TREAD DAMAGE AND, IF NECESSARY, REPLACE THE DAMAGED TIRE. THE RECALL BEGAN ON JULY 13, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2006 Lincoln Navigator Problems, Complaints & Recalls | Skip That Year
Illustration