Our 2022 Corsair Hybrid has been at Haldeman Ford in Kutztown, PA since October 29th. We will not drive it to our house because it is unsafe at any speed. The engine in this car has suddenly failed at least seven or eight times while being driven. At least three of these failures occurred when being driven by different Halde…
Read full complaint
Our 2022 Corsair Hybrid has been at Haldeman Ford in Kutztown, PA since October 29th. We will not drive it to our house because it is unsafe at any speed. The engine in this car has suddenly failed at least seven or eight times while being driven. At least three of these failures occurred when being driven by different Haldeman Ford technicians. They saw nothing that would explain the engine’s sudden catastrophic failure. The technicians cannot find out what is wrong with the vehicle and agree that the vehicle is dangerous to drive. Prior recall for engine failure stated that the car was not to be driven but also not to be plugged in because there was risk of fire. That recall is proof that the car was a lemon from the day it left the factory. It has been gently driven and has less than 16,000 miles. If the Corsair were to be said to be “repaired” at this point it would then require us to then act as crash test dummies with no guarantee that the engine would not stop suddenly - resulting in catastrophic injury or death. I could not ethically sell this car going forward. NOTE: On November 20, 2025 the NHTSA issued Manufacturer Recall Number 25SC4 - NHTSA Recall Number 25V789. This recall is for a manufacturing defect in the high voltage battery cells to cause an internal short circuit. This recall cites lost of motive power with increased risks in both crash and fire issues. This car has had several recalls in the past as well also dealing with fire and safety problems from the factory.
Ford Motor Company (Ford) is recalling certain 2020-2024 Ford Escape and 2021-2024 Lincoln Corsair plug-in hybrid vehicles. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.
Consequence & remedy
Consequence: Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.
Remedy: Dealers will update the battery energy control module (BECM) and hybrid powertrain control module (HPCM), free of charge. Owners are advised to only use "Auto EV" mode and will be instructed by mail to limit the maximum charge of the battery until the remedy has been completed. Owner notification letters were mailed September 4, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SC4. Vehicles in this recall were previously recalled under 24V954 and will need to have the new remedy performed. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on November 18, 2025.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2022 Lincoln Corsair Phev Problems, Complaints & Recalls | Skip That Year
Illustration