The contact owns a 2022 Lincoln Corsair. The contact stated while refueling the vehicle, there was fuel dripping out of the filler neck onto the ground. The contact stated that the failure had occurred two times. The vehicle was taken to the dealer where it was diagnosed with a failed fuel tank filler pipe. The contact was infor…
Read full complaint
The contact owns a 2022 Lincoln Corsair. The contact stated while refueling the vehicle, there was fuel dripping out of the filler neck onto the ground. The contact stated that the failure had occurred two times. The vehicle was taken to the dealer where it was diagnosed with a failed fuel tank filler pipe. The contact was informed that the fuel tank filler pipe needed to be replaced. The vehicle was repaired. The manufacturer was not made aware of the failure. The contact was informed that the repair was not covered under Technical Service Bulletin: 22-2176. The failure mileage was approximately 3,800.
Ford Motor Company (Ford) is recalling certain 2020-2024 Ford Escape and 2021-2024 Lincoln Corsair plug-in hybrid vehicles. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.
Consequence & remedy
Consequence: Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.
Remedy: Dealers will update the battery energy control module (BECM) and hybrid powertrain control module (HPCM), free of charge. Owners are advised to only use "Auto EV" mode and will be instructed by mail to limit the maximum charge of the battery until the remedy has been completed. Owner notification letters were mailed September 4, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SC4. Vehicles in this recall were previously recalled under 24V954 and will need to have the new remedy performed. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on November 18, 2025.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2022 Lincoln Corsair Phev Problems, Complaints & Recalls | Skip That Year
Illustration