STEERING WHEEL CONTINUED TURNING LEFT, UNASSISTED, INSTEAD OF RETURNING TO TDC WHEN GRIP PRESSURE ON THE STEERING WHEEL IS RELAXED. EXAMINATION DETERMINED CORROSION HAD CREATED A HOLE IN THE LEFT REAR CORNER COWEL PANEL IN SPIT OF RUST UNDERCOATING. ADDITIONAL RUST COVERED AN AREA OF THE UNDERBODY. ADVISE THAT THE REASON THE …
Read full complaint
STEERING WHEEL CONTINUED TURNING LEFT, UNASSISTED, INSTEAD OF RETURNING TO TDC WHEN GRIP PRESSURE ON THE STEERING WHEEL IS RELAXED. EXAMINATION DETERMINED CORROSION HAD CREATED A HOLE IN THE LEFT REAR CORNER COWEL PANEL IN SPIT OF RUST UNDERCOATING. ADDITIONAL RUST COVERED AN AREA OF THE UNDERBODY. ADVISE THAT THE REASON THE LOSS OF STEERING CONTROL WAS ATTRIBUTED TO THE CORROSION DAMAGED LEFT REAR CORNER COWELL PANEL CAUSING THE ENGINE TO LURCH TO THE LEFT WHEN MAKING A 90 DEGREE LEFT TURN.
NHTSA ODI #9002935
Mileage unknown · Jun 20, 2001
SteeringCrash
WHEN MAKING A LEFT TURN STEERING WHEEL LOCKED UP AND COULD NOT BE MANEUVERED TO THE LEFT, CAUSING A COLLISION. PLEASE GIVE ANY FURTHER DETAILS. *AK
NHTSA ODI #890747
Mileage unknown · Nov 21, 2000
Steering
FAILURE OF POWER STEERING HOSE WHICH COULD CAUSE POWER STEERING FLUID TO FLOW ONTO EXHAUST PIPE. CONSUMER WAS AWARE OF TSB ISSUED BY MANUFACTURER, AND A CLASS ACTION LAW SUIT ISSUED FOR THE SAME DEFECT.*AK
NHTSA ODI #875340
Mileage unknown · Feb 19, 2000
Engine And Engine CoolingPower TrainSteering
SHORTLY AFTER COMPLETE TRANSMISSION, MOTOR MOUNTS, AND POWER STEERING REPLACED,THE ENGINE HEAD GASKETS FAILED, ONCE AGAIN CONTRBUTING TO A POTENTIAL ACCIDENT. WHILE RTURNING HOME FROM BABTSITTING MY GRANDDAUGHTER I WAS ALARMED BY DRIVERS GOING THE OPPOSITE WAY BEEPING AT ME. ONE FINALLY ROLLED DOWN HIS WINDOW AND YELLED THAT I …
Read full complaint
SHORTLY AFTER COMPLETE TRANSMISSION, MOTOR MOUNTS, AND POWER STEERING REPLACED,THE ENGINE HEAD GASKETS FAILED, ONCE AGAIN CONTRBUTING TO A POTENTIAL ACCIDENT. WHILE RTURNING HOME FROM BABTSITTING MY GRANDDAUGHTER I WAS ALARMED BY DRIVERS GOING THE OPPOSITE WAY BEEPING AT ME. ONE FINALLY ROLLED DOWN HIS WINDOW AND YELLED THAT I WAS SMOKING SO BADLY I WAS BLOCKING EVERYONES VIEW. I LOOKED BACK TO SEE A DENSE CLOUD OF STEAM COVERING BOTH LANES OF TRAFFIC BEHIND ME. CARS WERE AT A STANDSTILL UNTIL THE STEAM DISSIPATED. I PULLED OVER AND SHUT DOWN. WATER WAS POURING OUT OF ONE OF THE DUAL EXHAUST PIPES. A MOTORIST STOPPED AND OFFERED A LIFT BUT I WAS ONLY A FEW BLOCKS FROM HOME. HE WENT ON TO TELL ME HIS SISTER HAD THE SAME THING HAPPEN TO HER WINDSTAR MINIVAN ON A TRIP TO MAINE AND THE CAR WAS ONLY 45 THOUSAND MILES OLD. HE SAID IT WAS DEFINITELY MY HEAD GASKET, WHICH TURNED OUT TO BE CORRECT. HE ALSO SAID THAT THE FORD 3.8 LITER ENGINE IS A DEFECTIVE DISASTER ESPECIALLY WHEN USED WITH FRONT WHEEL DRIVE. WITH RESPECT TO THE UNDERDASH ELECTRICAL PROBLEM IT WAS A DISTRACTING WARNING CHIME AND OIL PRESSURE INDICATOR WHICH WOULD BEEP WITHOUT PROPER CAUSE ON AN INTERMITTANT BASIS. OIL PRESSURE WAS INDEED OKAY AND THE SENDING UNIT WAS REPLACED TO NO AVAIL. ONLY WHEN AN ENTIRE INSTRUMENT CLUSTER WAS REPLACED DID THIS LONGSTANDING DISTRACTION GO AWAY. MY SON-IN-LAW IN OCTOBER OF '99 TOOK OUT THE ORIGINAL CLUSTER WHICH HAD THE ODOMETER READING OF 64740 ORIGINAL MILES AND REPLACED IT WITH ONE FROM AN AUTO WRECKING YARD WHICH WAS POSSIBLY FROM AN EARLIER YEAR CAR. THE REPLACEMENT MODULE READ 131200 MILES. IN FEBRUARY OF 2000 I GAVE THE CAR TO MY DAUGTER AND SON-IN-LAW. THE TITLE HAS BEEN ANOTATED WITH THE NEW ODOMETER READING AS "NOT THE ACTUAL MILEAGE". THIS FAULTY CHIME / GAUGE IS ALSO A COMMON DEFECT IN THESE CARS I AM TOLD. IT CAN BE A DANGEROUS THING WHEN IT OCCURS WITHOUT WARNING (NO PUN INTENDED) .
NHTSA ODI #718957
Mileage unknown · Jul 30, 1999
Steering
RACK AND PINION STEERING WENT OUT, CAUSING THE FRONT TIRES TO GO IN OPPOSITE DIRECTIONS. DEALER HAS TO REPLACED RACK AND PINION STEERING. *AK
NHTSA ODI #843888
Mileage unknown · Apr 28, 1999
Steering
POWER STEERING FLUID LEAKS. THE DEALER HAS REPAIRED THE POWER STEERING PUMP AND LINES TWICE, HOWEVER, THE PROBLEM STILL EXISTS. *AK
NHTSA ODI #837203
Mileage unknown · Dec 29, 1998
Engine And Engine CoolingSteering
MOTOR MOUNTS REPLACED FOUR TIMES ,AND CURRENTLY MOTOR MOUNTS WENT OUT AGAIN, CAUSING THE VEHICLE TO SMOKE. ALSO,POWER STEERING FLUID IS LEAKING, AND VEHICLE IS JERKING. DEALER HAS REPAIRED THE VEHICLE FOUR TIMES. *AK
NHTSA ODI #832804
Mileage unknown · Dec 10, 1998
Engine And Engine CoolingEquipmentPower Train
FRONT AND REAR AIR SHOCKS AND STRUTS FAILED.
NHTSA ODI #542977
Mileage unknown · Dec 9, 1998
SteeringFire
THE CONSUMER HAS EXPERIENCED A PROBLEM WITH POWER STEERING. WHILE DRIVING HEARD A POP, POWER STEERING WENT OUT, AND VEHICLE CAUGHT ON FIRE. THE FIRE DEPARTMENT HAD TO PUT THE FIRE OUT. THE MANUFACTURER HAS YET TO BE CONTACTED. *AK
NHTSA ODI #832034
Mileage unknown · Jun 12, 1997
Electrical SystemEngine And Engine CoolingEquipment
DOOR WILL NOT OPEN FROM OUTSIDE DUE TO FAULTY HANDLE ASSEMBLY.
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Consequence & remedy
Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
FRONT DISC BRAKE ROTORS OF THE SUBJECT VEHICLES MAY EXPERIENCE SEVERE CORROSION IF OPERATED IN AREAS WHERE CALCIUM CHLORIDE AND SODIUM CHLORIDE ARE USED EXTENSIVELY.
Consequence & remedy
Consequence: SEVERELY CORRODED ROTORS MAY FRACTURE OR SEPARATE NEARTHE INNER EDGES OF THE BRAKE DISCS RESULTING IN REDUCED BRAKING EFFECTIVENESS,HIGHER THAN NORMAL PEDAL EFFORTS, LOUD GRINDING NOISES, AND MODERATE PULLS WHENTHE BRAKES ARE APPLIED. REDUCED BRAKING EFFECTIVENESS MAY INCREASE MINIMUMSTOPPING DISTANCES, POSSIBLY RESULTING IN AN ACCIDENT.
Remedy: REPLACE FRONT BRAKE ROTORS WITH FULL CAST FRONT BRAKE ROTORS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7
EA96024 · Engine Cooling Fan Fires
Opened Sep 30, 1996 · Closed Apr 15, 1997
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
PE96033 · Engine Cooling Fan Fires
Opened May 2, 1996 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.
DP95004 · Alleged Defective Tie Rods
Opened Aug 8, 1995 · Closed Aug 30, 1995
Status: closed (inferred from source dates) · Unknown Or Other
ALLEGED DEFECTIVE TIE RODS
EA94008 · Broken Tie Rods
Opened Feb 16, 1994 · Closed Feb 27, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93070 · Failure Of Wheel Studs
Opened Jul 27, 1993 · Closed Nov 22, 1993
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE93058 · Broken Tie Rods
Opened Jun 15, 1993 · Closed Feb 16, 1994
Status: closed (inferred from source dates) · Steering
There is no summary currently available
EA92040 · SUB-FRM/UNIBODY Absor.fail
Opened Nov 30, 1992 · Closed Jun 30, 1993
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
1991 Lincoln Continental Problems, Complaints & Recalls | Skip That Year
Illustration