Electrical System. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Forward Collision Avoidance. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Seats. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports0 fire reports0 injury reports

Seats complaints

3 reports

Clear category filter

Mileage unknown · May 4, 2026

Electrical SystemSeats

The second row seat is moving or reclining while I’m driving. The car seat motor has a sound while it reclines.

NHTSA ODI #11735438

Mileage unknown · Nov 16, 2025

Seats

The 2nd row seats are malfunctioning, sliding up and folding while the car is moving. The button at the top of the seat seems to be getting stuck. There is a whole forum about this issue, with years of reports but never seems to be a recall - this is a SERIOUS safety issue: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM O…

Read full complaint

NHTSA ODI #11699708

Mileage unknown · Oct 11, 2025

Seats

Read full complaint

I was sold on [XXX] this vehicle with an active recall. I was later told by the dealer, BeauTownsend Ford, that only they could fix this recall and no other dealer could touch the car until they fixed it. When an unrelated repair was needed I took it to my local dealer. They could not find record of the sale being registered with the Company, Lincoln, and therefore could not start the repair or assist in completing the safety recalls. When contacting BeauTownsend Ford, where the vehicle was purchased, they said my only option was to bring the car back to them. I asked about why the sale had not been registered and did not get an answer. I have reached out multiple time through email and phone and am not getting any response in my request for them to register the sale. The dealership this vehicle was purchased from: BeauTownsend Ford 1020 W National Road Vandalia OH 45377 I believe these actions are an effort to cover up a stop sale that they knowingly proceeded with. I have both repairs and safety recalls that I have attempted to have completed but am unable to unless I bring my vehicle to them since I am unable to get them to register this sale. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI #11692643

Official recalls

26V470000 · Seats:front Assembly:power Adjust

Jul 21, 2026

Ford Motor Company (Ford) is recalling certain 2025-2027 Explorer and Lincoln Aviator vehicles. An unoccupied driver's seat may recline unintentionally during certain scenarios, such as remote unlock or remote start.

Consequence & remedy

Consequence: Unexpected movement of the driver’s seat back may trap a second-row occupant, increasing the risk of injury.

Remedy: Dealers will disable the driver seat module (DSM) feature until parts are available. Once available, the motor will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 3, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S53.

26V451000 · Seats:mid/rear Assembly

Jul 14, 2026

Ford Motor Company (Ford) is recalling certain 2020-2027 Aviator and 2020-2026 Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, tipping, or sliding unexpectedly.

Consequence & remedy

Consequence: A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing the risk of injury.

Remedy: Dealers will inspect and replace the bezel around the switch as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters explaining the safety risk were mailed August 19, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Lincoln Aviator owner notification letters were mailed August 21, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S52. This recall expands Recall 25V393. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.

26V165000 · Back Over Prevention:software; Electrical System:adas

Mar 18, 2026

Ford Motor Company (Ford) is recalling certain 2022-2025 Lincoln Navigator, 2024-2025 Lincoln Nautilus, 2025 Lincoln Aviator and Explorer vehicles. The Image Processing Module A (IPMA) may experience multiple unexpected resets, resulting in loss of the rearview camera image and advanced driver assistance (ADAS) features, including pre-collision assist, lane-keeping assist, and blind-spot monitoring.

Consequence & remedy

Consequence: Loss of the rearview camera image and certain driver assistance features, can reduce the driver’s ability to detect hazards, increasing the risk of a crash.

Remedy: The Image Processing Module A software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. This is a Phased campaign. Phase 1 will include 2025 Aviator, 2025 Explorer, 2025 Nautilus notified owners on 4/13/2026. Phase 2 will include 2025 Navigator will notify owners on or about 4/20/2026. Phase 3 will include 2022-2024 Navigator will notify owners on or about 6/8/2026. Phase 4 will include 2024 Nautilus will notify owners on or about 6/22/2026. Owner notification letters were mailed April 13, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S21. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 25, 2026.

Additional source detail variants (2)

Back Over Prevention:software

Consequence: Loss of the rearview camera image and certain driver assistance features, can reduce the driver’s ability to detect hazards, increasing the risk of a crash.

Remedy: The Image Processing Module A software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. This is a Phased campaign. Phase 1 will include 2025 Aviator, 2025 Explorer, 2025 Nautilus notified owners on 4/13/2026. Phase 2 will include 2025 Navigator will notify owners on or about 4/20/2026. Phase 3 will include 2022-2024 Navigator will notify owners on or about 6/8/2026. Phase 4 will include 2024 Nautilus will notify owners on or about 6/22/2026. Owner notification letters were mailed April 13, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S21. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 25, 2026.

Electrical System:adas

Consequence: Loss of the rearview camera image and certain driver assistance features, can reduce the driver’s ability to detect hazards, increasing the risk of a crash.

26V159000 · Seat Belts

Mar 17, 2026

Ford Motor Company (Ford) is recalling certain 2020-2026 Explorer and Lincoln Aviator vehicles. The seat belt anchor bolts at the second-row outer seating positions may be improperly secured.

Consequence & remedy

Consequence: A loose seat belt buckle may not properly restrain an occupant during a crash, increasing the risk of injury.

Remedy: Dealers will inspect the second-row outer seat belt lower anchor bolts and replace or repair them as necessary, free of charge. Owner notification letters were mailed March 30, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C18. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 19, 2026.

25V730000 · Visibility:windshield

Oct 24, 2025

Ford Motor Company (Ford) is recalling certain 2025-2026 Lincoln Corsair, Lincoln Aviator, and Explorer vehicles. The windshield glass may have visible air bubbles, which can obscure the driver's visibility. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 205, "Glazing Materials."

Consequence & remedy

Consequence: Reduced visibility while driving can increase the risk of a crash.

Remedy: Dealers will inspect and replace the windshield as necessary, free of charge. Owner notification letters were mailed November 6, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C60. Vehicle Identification Numbers (VINs) involved in this recall become searchable on NHTSA.gov beginning October 27, 2025.

25V687000 · Trailer Hitches

Oct 10, 2025

Ford Motor Company (Ford) is recalling certain 2024-2026 Explorer and 2024-2026 Lincoln Aviator vehicles. The trailer hitch assembly bolts may be loose.

Consequence & remedy

Consequence: While towing a trailer, loose trailer hitch bolts can cause a loss of vehicle handling and control, or cause the trailer to detach. Either of these conditions can increase the risk of a crash.

Remedy: Dealers will inspect and tighten the trailer hitch bolts, or replace them as necessary, free of charge. Owner notification letters were mailed October 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA3. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

25V543000 · Exterior Lighting:tail Lights

Aug 22, 2025

Ford Motor Company (Ford) is recalling certain 2025 Explorer and Aviator vehicles. When towing a trailer, the tail lights on the trailer may fail to illuminate due to an improperly manufactured body control module. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."

Consequence & remedy

Consequence: Trailer tail lights that do not illuminate as intended can reduce visibility to other drivers, increasing the risk of a crash.

Remedy: Dealers will replace the body control module C on vehicles with less than 9,000 miles. For vehicles over 9,000 miles, dealers will perform a functional check on the body control module C and replace it as necessary. Repairs will be performed free of charge. Aviator 2025 owner notification letters were mailed October 13, 2025. Explorer 2025 owner letters were mailed November 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C42.

25V484000 · Visibility:power Window Devices And Controls

Jul 25, 2025

Ford Motor Company (Ford) is recalling certain 2025 Lincoln Aviator vehicles. When closing the windows with the global closing feature, the side rear windows may exert excessive force when encountering an object, before they automatically reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 118, "Power-Operated Window Systems."

Consequence & remedy

Consequence: A closing window that does not reverse direction as expected can pinch a passenger before retracting, increasing the risk of injury.

Remedy: Dealers will update the Body Control Module (BCM) software, free of charge. Owner notification letters were mailed October 7, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C33.

25V393000 · Seats:mid/rear Assembly

Jun 13, 2025

Ford Motor Company (Ford) is recalling certain 2020-2025 Aviator, and Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, folding, or sliding unexpectedly while driving.

Consequence & remedy

Consequence: A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing their risk of injury.

Remedy: Dealers will inspect the second-row seat switch, and replace the bezel around the switch as necessary, free of charge. Owner notification letters were mailed August 7, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S67.

25V407000 · Structure:body

Jun 13, 2025

Ford Motor Company (Ford) is recalling certain 2020-2025 Aviator vehicles. The rear door window bars and C-pillar trim may have insufficient adhesive bonding, which can allow the trim to detach from the vehicle.

Consequence & remedy

Consequence: Detached trim may cause a road hazard and increase the risk of a crash.

Remedy: Dealers will repair or replace C-pillar appliques and window division bars, free of charge. Owner notification letters were mailed September 29, 2025. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 25S66.

25V316000 · Structure:frame And Members

May 9, 2025

Ford Motor Company (Ford) is recalling certain 2025 Explorer and Aviator vehicles. A mounting bolt for the front subframe may have been tightened improperly.

Consequence & remedy

Consequence: A loose subframe bolt may reduce the vehicle's performance in a crash, increasing the risk of injury.

Remedy: Dealers will inspect and tighten the subframe bolts as necessary, free of charge. Owners may contact Ford Customer Service at 1-866-436-7332. Owner notification letters were mailed May 21, 2025. Ford's number for this recall is 25S43.

25V164000 · Power Train:automatic Transmission:fluid/lubricant:valves/valve Body

Mar 14, 2025

Ford Motor Company (Ford) is recalling certain 2024-2025 F-150, Bronco, 2024 Ranger, 2025 Mustang, Explorer, and Aviator vehicles. The transmission valve body may have been machined incorrectly, which can cause reverse gear failure, or unexpected forward movement in reverse or neutral gear.

Consequence & remedy

Consequence: Unexpected vehicle movement increases the risk of a crash.

Remedy: Dealers will replace the transmission main control valve body, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S19.

25V020000 · Power Train:automatic Transmission; Structure:frame And Members

Jan 17, 2025

Ford Motor Company (Ford) is recalling certain 2025 Ford Explorer and Lincoln Aviator vehicles. The transmission may be improperly secured due to loose cross member bolts.

Consequence & remedy

Consequence: An improperly secured transmission can result in a loss of drive power, increasing the risk of a crash.

Remedy: Dealers will inspect and replace the transmission cross member bolts as necessary, free of charge. If the cross member bolts are missing, dealers will replace the cross member and install new bolts, free of charge. Owner notification letters were mailed January 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S03.

Additional source detail variants (2)

Structure:frame And Members

Ford Motor Company (Ford) is recalling certain 2025 Ford Explorer and Lincoln Aviator vehicles. The transmission may be improperly secured due to loose cross member bolts.

Consequence: An improperly secured transmission can result in a loss of drive power, increasing the risk of a crash.

Remedy: Dealers will inspect and replace the transmission cross member bolts as necessary, free of charge. If the cross member bolts are missing, dealers will replace the cross member and install new bolts, free of charge. Owner notification letters were mailed January 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S03.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2025 Ford Explorer and Lincoln Aviator vehicles. The transmission may be improperly secured due to loose cross member bolts.

Consequence: An improperly secured transmission can result in a loss of drive power, increasing the risk of a crash.

24V852000 · Equipment:other:labels

Nov 8, 2024

Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Consequence & remedy

Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.

Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.

24V801000 · Back Over Prevention:software

Oct 25, 2024

Ford Motor Company (Ford) is recalling certain 2025 Explorer and Lincoln Aviator vehicles. The rearview camera image may fail when the vehicle speed reaches 10 MPH or greater. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Consequence & remedy

Consequence: The loss of the rearview camera image while in reverse can reduce the driver's rear visibility, increasing the risk of a crash.

Remedy: The accessory protocol interface module (APIM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed on March 28, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C34.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.