← New search

2006 Lexus Rx Hybrid

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

About this comparison →

When problems were reported

Mileage at the reported incident

138 reports with mileage · 16 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes, Hydraulic. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

15 crash reports0 fire reports5 injury reports

Structure complaints

16 reports
Clear category filter
80,128 miles · Feb 26, 2018
StructureUnknown Or Other

THE VEHICLE DASH HAS DEVELOPED PREMATURE CRACKS, AND IS SHINING AND STICKY. LEXUS CLAIMS THIS IS ONLY A COSMETIC ISSUE HOWEVER THE DASH IS AN INTEGRAL PART OF THE VEHICLE AND WITH THE DASH DETERIORATING THE FOAM PADDING IS HARDING CREATING A SAFETY ISSUE IN EVENT OF CRASH. LEXUS HAS ADMITTED TO THE ISSUE HOWEVER HAS ONLY OFFE…

Read full complaint

THE VEHICLE DASH HAS DEVELOPED PREMATURE CRACKS, AND IS SHINING AND STICKY. LEXUS CLAIMS THIS IS ONLY A COSMETIC ISSUE HOWEVER THE DASH IS AN INTEGRAL PART OF THE VEHICLE AND WITH THE DASH DETERIORATING THE FOAM PADDING IS HARDING CREATING A SAFETY ISSUE IN EVENT OF CRASH. LEXUS HAS ADMITTED TO THE ISSUE HOWEVER HAS ONLY OFFER REPAIRS TO A LIMITED ARBITRUARY NUMBER OF OWNERS WHILE ARBITRUARILY EXCLUDING OTHER OWNERS. THERE SHOULD BE A MANATORY RECALL ON THIS ISSUE AS IS A SAFETY ISSUE.

NHTSA ODI #11075015

100,000 miles · Jan 10, 2018
Structure

DASHBOARD HAS DEVELOPED CRACKS IN 2017 AND AM TOLD THERE WAS A RECALL. CONTACTED LEXUS AND WAS TOLD THAT THE RECALL HAS ENDED. I NEVER RECEIVED NOTIFICATION OF RECALL. LEXUS IS REFUSING TO HONOR THE RECALL.

NHTSA ODI #11061579

Mileage unknown · Feb 29, 2016
Electrical SystemElectronic Stability Control (esc)StructureCrash

ALL SERVICE LIGHTS ARE ON, ABS VSC, AND INFO DISPLAY STATES SOME SORT OF VSC MALFUNCTION.

NHTSA ODI #10838905

75,000 miles · Jul 29, 2014
Structure

MULTIPLE CRACKS AND MELTING DASHBOARD. THE DASH IS VERY STICKY AND IS FALLING OFF IN PIECES. I'M CONCERNED IF THE AIRBAGS EVER DEPLOY THIS DEFECTIVE DASH WILL BECOME AN IED! *JS

NHTSA ODI #10617401

148,000 miles · Jun 6, 2014
Structure

TL* THE CONTACT OWNS A 2006 LEXUS RX400H (HYBRID). THE CONTACT STATED THAT THE PASSENGER SIDE DASHBOARD EXHIBITED VERTICAL CRACKS NEAR THE AIR BAG HOUSING AREA. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE …

Read full complaint

TL* THE CONTACT OWNS A 2006 LEXUS RX400H (HYBRID). THE CONTACT STATED THAT THE PASSENGER SIDE DASHBOARD EXHIBITED VERTICAL CRACKS NEAR THE AIR BAG HOUSING AREA. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 148,000.

NHTSA ODI #10596574

144,693 miles · Jun 6, 2014
StructureVehicle Speed ControlCrash

WHILE SLOWLY PULLING INTO A PARKING SPACE IN A PARKING STRUCTURE, THE CAR SUDDENLY ACCELERATED AND CRASHED INTO THE CEMENT BLOCK WALL IN FRONT OF ME. SINCE THE DISTANCE FROM HALF-WAY INTO THE PARKING SPACE TO THE WALL WAS SMALL (PROBABLY THREE TO FOUR FEET), I HAD NO TIME TO SLAM ON THE BRAKES BEFORE IMPACT. THE CAR WAS TOWED …

Read full complaint

WHILE SLOWLY PULLING INTO A PARKING SPACE IN A PARKING STRUCTURE, THE CAR SUDDENLY ACCELERATED AND CRASHED INTO THE CEMENT BLOCK WALL IN FRONT OF ME. SINCE THE DISTANCE FROM HALF-WAY INTO THE PARKING SPACE TO THE WALL WAS SMALL (PROBABLY THREE TO FOUR FEET), I HAD NO TIME TO SLAM ON THE BRAKES BEFORE IMPACT. THE CAR WAS TOWED TO A LEXUS DEALER. I WAS IMMEDIATELY REFERRED TO THEIR LEGAL DEPARTMENT WHO HANDLED ALL TRANSACTIONS AFTER THAT. AN INDEPENDENT EVALUATOR INSPECTED THE CAR, RETRIEVED THE CRASH DATA RETRIEVAL RECORDER AND ISSUED A REPORT. THE CDR INDICATED THAT THE ACCELERATOR AND THE BRAKES WERE NOT PUSHED UNTIL AFTER THE CRASH, AND THAT THE SPEED IN THE FEW SECONDS BEFORE THE CRASH WENT FROM 3.7 TO 60.9 MPH. LEXUS REFUSED TO ADMIT THERE WAS A PROBLEM, STATING ONLY THAT THE BRAKES, ACCELERATOR AND FLOOR MATS SEEMED TO BE IN GOOD WORKING ORDER. I REFUSED TO DRIVE THE CAR AGAIN OR HAVE ONLY THE BODY FIXED AND SOLD TO AN UNSUSPECTING THIRD PARTY. IT WAS EVENTUALLY DECLARED A TOTAL LOSS BY OUR INSURANCE COMPANY. THERE WAS NO HELP OR ADMISSION OF A PROBLEM FROM LEXUS, EXCEPT TO TRY TO CHARGE US FOR CAR STORAGE AT THE DEALERSHIP DURING THE PROCESS. *TR

NHTSA ODI #10596551

90,000 miles · May 4, 2014
Fuel/propulsion SystemPower TrainStructure

HAVING ENJOYED OWNING A LEXUS RX300, I MADE A HUGE "INVESTMENT" AND PURCHASED THE 2006 RX400H. IN APRIL OF 2014, THE VEHICLE WOULD NOT START DUE TO A FAILURE OF THE HYBRID SYSTEM. I ATTEMPTED TO JUMP START THE VEHICLE AS SUGGESTED BY THE LEXUS DEALER. UPON FURTHER INVESTIGATION I DISCOVERED THE CARPET INSIDE THE CABIN AREA WA…

Read full complaint

HAVING ENJOYED OWNING A LEXUS RX300, I MADE A HUGE "INVESTMENT" AND PURCHASED THE 2006 RX400H. IN APRIL OF 2014, THE VEHICLE WOULD NOT START DUE TO A FAILURE OF THE HYBRID SYSTEM. I ATTEMPTED TO JUMP START THE VEHICLE AS SUGGESTED BY THE LEXUS DEALER. UPON FURTHER INVESTIGATION I DISCOVERED THE CARPET INSIDE THE CABIN AREA WAS SOAKING WET! THE CAR HAD BEEN OUTSIDE IN THE RAIN WITH THE WINDOWS, SUNROOF AND DOORS CLOSED. ALSO, I TAKE THE CAR TO AN AUTOMATIC CAR WASH ON A REGULAR BASIS. WHILE LOADING THE CAR ON TO THE JERR-DAN TOW TRUCK, A LARGE AMOUNT OF WATER POURED OUT OF THE REAR TRUNK AREA. THE TOW TRUCK OPERATOR WAS AMAZED AT THE AMOUNT OF WATER THAT WAS POURING ONTO THE DRIVEWAY. THE VEHICLE WAS TAKEN TO THE LEXUS DEALER. AFTER SEVERAL DAYS, A LEAK IN THE REAR HATCH AREA WAS FOUND TO BE THE SOURCE OF THE WATER. THERE APPARENTLY IS A METAL SEAM WHERE THE WELDS DO NOT HOLD UP OR WERE NOT WELDED PROPERLY. WATER COLLECTED IN THE HYBRID BATTERY AREA CAUSING OVER $7000 DAMAGE. OF COURSE, LUCKILY FOR LEXUS, THE VEHICLE WARRANTY HAD EXPIRED. THE ONLY RECOURSE I HAD WAS TO MAKE A CLAIM TO MY INSURANCE, WHICH ONLY COVERED THE DAMAGES BUT NOT THE CAUSE. MY OUT OF POCKET EXPENSES ARE APPROXIMATELY $3000. WATER LEAKING FROM THE OUTSIDE INTO THE CABIN OF A VEHICLE, ESPECIALLY ONE OF THIS PRICE, IS UNACCEPTABLE. AND TO HAVE WATER COLLECT INTO THE "HEART" OF THE VEHICLE AND RENDER THE VEHICLE INOPERABLE IS FRIGHTENING. I COULD HAVE BEEN ON AN ISOLATED ROAD OR A BUSY HIGHWAY AND THE VEHICLE COULD HAVE SUDDENLY QUIT. LEXUS KNEW ABOUT THIS POTENTIAL PROBLEM BUT DID NOT ADVISE THEIR CUSTOMERS TO WATCH FOR ANY SIGNS OF MOISTURE. THE REPAIR TO THE POPPED SEAM COULD HAVE BEEN DONE BY ANY BODY SHOP OR, I'M TOLD, THE USE OF A GOOD QUALITY SILICONE. THERE IS A TECHNICAL SERVICE BULLETIN FROM 3/10/2009 THAT SPECIFICALLY ADDRESSES THIS PROBLEM: TSB-L-SB0019-09 REV 1. *TR

NHTSA ODI #10586442

82,000 miles · May 1, 2014
Structure

THE VEHICLE DEVELOPED CRACKS IN THE PASSENGER SIDE OF THE DASHBOARD. WE WERE TOLD THIS COULD BE A SAFETY RISK RELATED TO FUNCTION OF THE AIRBAG. LEXUS OFFERED TO PROVIDE A NEW DASHBOARD IF WE PAID THE LABOR CHARGE OF $800. EVENTUALLY THE DEALER SPLIT THE LABOR CHARGE WITH US AND WE REPLACED THE DASHBOARD. *TR

NHTSA ODI #10586038

104,000 miles · Apr 14, 2014
Power TrainStructure

THE CAR IS A HYBRID. IT WOULD NOT START (THE READY LIGHT WOULD NOT COME ON), THEREFORE IT WAS INOPERABLE. FORTUNATELY, THE CAR WAS PARKED AND DID NOT DIE WHILE DRIVING. IF IT WOULD HAVE DIED WHILE DRIVING, MANY DANGEROUS POSSIBILITIES COULD HAVE INCURRED. AFTER HAVING IT TOWED TO A LEXUS DEALER IN COLUMBUS, THE SOURCE OF…

Read full complaint

THE CAR IS A HYBRID. IT WOULD NOT START (THE READY LIGHT WOULD NOT COME ON), THEREFORE IT WAS INOPERABLE. FORTUNATELY, THE CAR WAS PARKED AND DID NOT DIE WHILE DRIVING. IF IT WOULD HAVE DIED WHILE DRIVING, MANY DANGEROUS POSSIBILITIES COULD HAVE INCURRED. AFTER HAVING IT TOWED TO A LEXUS DEALER IN COLUMBUS, THE SOURCE OF THE PROBLEM WAS DIAGNOSED AS WATER IN THE HYBRID BATTERY AREA. AFTER LENGTHY DISCUSSION WITH LEXUS SERVICE PERSONNEL, THEY CONCLUDED THAT "WELDS" NEAR THE HATCH HINGES HAD COME APART, WHICH ALLOWED WATER TO SEEP INTO THE INTERIOR OF THE CAR TO THE HYBRID ELECTRONIC CONTROLS. LEXUS SERVICE HAD EXPERIENCE THESE PROBLEMS BEFORE, AND HAD GUESSED AT A VARIETY OF REASONS (SUCH AS EXCESSIVE OPENING AND CLOSING OF THE HATCH, WIND CATCHING THE HATCH WHILE IT WAS OPEN, AND OTHER LAME REASONS). THERE IS NO TICKER ON THE HATCH TO COUNT HOW MANY TIMES IT WAS OPENED NOR WHAT THERE ANY GUST OF WIND THAT WOULD HAVE CAUSE THE WELDS, TWO WELDS, TO BREAK ALLOWING WATER TO SEEP INTO THE CAR. MY CONCLUSION IS THAT SINCE THE PROBLEM HAS OCCURRED BEFORE, THAT THERE IS EITHER A MANUFACTURING ISSUE, AN ENGINEERING ISSUE, OR BOTH. I AM NEITHER AN EXPERT IN THESE AREAS, BUT DO HAVE SOME COMMON SENSE. LEXUS CORPORATE OR THE DEALER WOULD NOT CONFESS TO THE WRONGDOING AND THEREFORE I HAD TO SHELL OUT OVER $1600 IN REPAIRS. THEY WANTED ANOTHER $1100 TO RE-WELD THE 3 INCH GAP ON BOTH SIDES WITH PAINTING INCLUDED. DUE TO THE EXPENSE, I HAD TO OPT FOR USING SILICONE TO SEAL THE GAPS AND AM FORCED TO DRIVE THE CAR IN DRY WEATHER. *JS

NHTSA ODI #10579631

45,000 miles · Aug 11, 2013
Structure

THE BLACK PLASTIC FINISH TRIM ON THE DRIVER SIDE REAR TRIANGULAR WINDOW BLEW OFF ON THE FREEWAY AT 65 MILES PER HOUR. APPARENTLY THIS IS A VERY COMMON OCCURRENCE, SINCE NOW THAT I AM AWARE OF IT...I HAVE NOTICED THAT OTHER LEXUS SUV'S OF THE SAME OR SIMILAR MODELS HAVE THAT PIECE MISSING! I SAW 3 OTHERS JUST YESTERDAY! I AM TH…

Read full complaint

THE BLACK PLASTIC FINISH TRIM ON THE DRIVER SIDE REAR TRIANGULAR WINDOW BLEW OFF ON THE FREEWAY AT 65 MILES PER HOUR. APPARENTLY THIS IS A VERY COMMON OCCURRENCE, SINCE NOW THAT I AM AWARE OF IT...I HAVE NOTICED THAT OTHER LEXUS SUV'S OF THE SAME OR SIMILAR MODELS HAVE THAT PIECE MISSING! I SAW 3 OTHERS JUST YESTERDAY! I AM THINKING THAT WHATEVER IS SUPPOSE TO HOLD THAT PIECE ON IS NOT SUFFICIENT TO DO SO! *TR

NHTSA ODI #10534748

Official recalls

5

13V396000 · Hybrid Propulsion System: Inverter

Sep 4, 2013

Toyota is recalling certain model year 2006-2010 Highlander hybrid vehicles manufactured February 16, 2005, through July 29, 2010; and model year 2006-2008 Lexus RX400h vehicles manufactured February 23, 2005, through December 2, 2008. The Intelligent Power Module (IPM) inside the inverter module may contain transistors that have higher operating temperatures than the solder can support and the transistors may be heat damaged by the solder. If this occurs, various warning lamps, including the malfunction indicator lamp, slip indicator light, brake system warning light, and master warning light, will be illuminated on the instrument panel.

Consequence & remedy

Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. It is possible that the hybrid system will shut down while the vehicle is being driven, causing the vehicle to stall unexpectedly, increasing the risk of a crash.

Remedy: Toyota will notify owners, and dealers will replace the IPM free of charge. Owners may contact Toyota at 1-800-331-4331. Vehicles that had their IPM replaced under recall 11V-342 are not affected by this campaign.

11V539000 · Engine And Engine Cooling

Nov 9, 2011

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.

Consequence & remedy

Consequence: IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.

Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

11V342000 · Electrical System

Jun 29, 2011

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006-2007 HIGHLANDER HYBRID AND LEXUS RX400H PASSENGER CARS MANUFACTURED FROM FEBRUARY 16, 2005, THROUGH AUGUST 30, 2006. A MODULE INSIDE THE INVERTER MODULE MAY CONTAIN INADEQUATELY SOLDERED TRANSISTORS THAT DURING HIGH-LOAD DRIVING, MAY BE DAMAGED BY HEAT CAUSED BY THE LARGE CURRENT. IF THIS OCCURS, VARIOUS WARNING LAMPS, INCLUDING THE MALFUNCTION INDICATOR LAMP, SLIP INDICATOR LIGHT, BRAKE SYSTEM WARNING LIGHT, AND MASTER WARNING LIGHT, WILL BE ILLUMINATED ON THE INSTRUMENT PANEL.

Consequence & remedy

Consequence: THE VEHICLE MAY ENTER A FAIL-SAFE/LIMP-HOME MODE THAT LIMITS THE DRIVABILITY OF THE VEHICLE. IT IS POSSIBLE THAT THE HYBRID SYSTEM WILL SHUT DOWN WHILE THE VEHICLE IS BEING DRIVEN, CAUSING THE VEHICLE TO STALL UNEXPECTEDLY, INCREASING THE RISK OF A CRASH.

Remedy: TOYOTA/LEXUS MAILED AN INTERIM OWNER NOTIFICATION ON JULY 19, 2011 TO ADVISE OWNERS OF THIS RECALL AND THE FACT THAT THEY WILL RECEIVE A FUTURE NOTICE WHEN PARTS BECOME AVAILABLE TO COMPLETE REPAIRS. TOYOTA DEALERS WILL INSPECT THE HYBRID INVERTER PRODUCTION NUMBER TO DETERMINE WHETHER THE INVERTER CONTAINS SUSPECT TRANSISTORS AND REPLACE THE MODULE FREE OF CHARGE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

11V112000 · Vehicle Speed Control:accelerator Pedal

Feb 24, 2011

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.

Consequence & remedy

Consequence: IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

06V253000 · Vehicle Speed Control:accelerator Pedal

Jul 13, 2006

ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD.

Consequence & remedy

Consequence: THIS CONDITION MAY INTERFERE WITH THE ACCELERATOR PEDAL RETURNING TO THE IDLE POSITION INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE TWO FLOOR CARPET COVER RETAINING CLIPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 24, 2006, AND SHOULD BE COMPLETED BY EARLY SEPTEMBER 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

PE11005 · Hybrid Inverter Failure - Vehicle Stall

Opened Feb 15, 2011 · Closed Jul 20, 2011

Status: closed (inferred from source dates) · Hybrid Propulsion System: Inverter

In a June 29, 2011 letter to NHTSA, Toyota submitted a Defect Information Report regarding a safety recall of certain Toyota Highlander Hybrid and Lexus RX400h vehicles to address a defect condition with the hybrid inverter assembly (NHTSA Recall No. 11V-342).Toyota's letter identified a defect related to inadequately soldered transistors on the Intelligent Power Module (IPM) of some of the subject vehicles that could result in sudden loss of power while driving.Toyota's remedy procedure instructs dealers to inspect the hybrid inverter production number to determine if the inverter contains suspect transistors.If so, the dealer will replace the IPM.The recall covers approximately 45,528 model year (MY) 2006 and 2007 Toyota Highlander Hybrid vehicles manufactured from February 16, 2005 through August 29, 2006 and approximately 36,745 MY 2006 and 2007 Lexus RX400h vehicles manufactured from February 23, 2005 through August 30, 2006.This Preliminary Evaluation is closed.

RQ10003 · Unintended And Uncontrolled Acceleration

Opened Feb 16, 2010 · Closed Mar 1, 2011

Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Additional source detail variants (6)

Electrical System:software

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Electrical System:software

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Electrical System:software

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Vehicle Speed Control:accelerator Pedal

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Vehicle Speed Control:accelerator Pedal

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Vehicle Speed Control:accelerator Pedal

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.