IllustrationAS I STARTED UP FROM A STOP AT A LIGHT I FELT A CLUNKING IN THE FRONT END. I STARTED TO INCREASE SPEED AND ATTEMPTED TO MAKE A SUDDEN TURN TO AVOID AN OBSTACLE IN THE ROAD. THE FRONT END FROZE UP.
2005 Land Rover Range Rover
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Range Rover years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
30–25K
825–50K
650–75K
375–100K
6100–150K
3150K+
29 reports with mileage · 6 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports1 fire reports1 injury reports
Power Train complaints
21 reportsMY DIFFERENTIAL IS LEAKING & I THINK IT HAS CAUSE MY TRANSMISSION TO FALSE.. I BELIEVE THIS HAS HAPPEN WHILE IN MOTION ON THE STREET IN NEWYORK ... I PURCHASED THE RANGE ROVER FROM LAND ROVER OF VIRGINIA IN 2008.
2005 RANGE ROVER HAS A LEAK IN THE FRONT DIFFERENTIAL. ALTHOUGH THE FRONT DIFFERENTIAL SHOULD LAST FOR THE LIFE OF THE VEHICLE, THE MECHANIC INDICATED THAT THIS WOULD LEAD TO PREMATURE MECHANICAL FAILURE OF THE UNIT AND POTENTIAL LIFE SAFETY ISSUE IF IT FAILS WHILE DRIVING.
WHILE DRIVING DOWN CITY STREET AT 30 MPH, A LOUD HUMMING SOUND COMES FROM FRONT OF VEHICLE. IMMEDIATELY BROUGHT TRUCK TO MECHANIC AND MECHANIC THEN STATED AFTER INSPECTION THAT HE HAS SEEN THIS PROBLEM ON RANGE ROVERS BEFORE AND THAT IT SHOULD BE COVERED UNDER SAFETY RECALL. NHTSA CAMPAIGN ID NUMBER: 08V635000. *TR
TL* THE CONTACT OWNS A 2005 LAND ROVER RANGE ROVER. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, A HUMMING SOUND WAS HEARD FROM THE FRONT END OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS STATED THAT THE DIFFERENTIAL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NO…
Read full complaint
TL* THE CONTACT OWNS A 2005 LAND ROVER RANGE ROVER. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, A HUMMING SOUND WAS HEARD FROM THE FRONT END OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS STATED THAT THE DIFFERENTIAL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.
FRONT DIFFERENTIAL FAILURE ON A 2005 LAND ROVER, RANGE ROVER HSE. THERE WAS A LOUD NOISE FROM THE RIGHT SIDE OF THE CAR, AND FORWARD MOVEMENT OF THE VEHICLE WAS HAMPERED AS WELL AS MY STEERING. I WAS FORTUNATE THAT I WASN'T NEAR ANOTHER VEHICLE AND I WAS ABLE TO FORCE THE CAR TO THE SIDE OF THE ROAD. THIS IS VERY DANGEROUS AN…
Read full complaint
FRONT DIFFERENTIAL FAILURE ON A 2005 LAND ROVER, RANGE ROVER HSE. THERE WAS A LOUD NOISE FROM THE RIGHT SIDE OF THE CAR, AND FORWARD MOVEMENT OF THE VEHICLE WAS HAMPERED AS WELL AS MY STEERING. I WAS FORTUNATE THAT I WASN'T NEAR ANOTHER VEHICLE AND I WAS ABLE TO FORCE THE CAR TO THE SIDE OF THE ROAD. THIS IS VERY DANGEROUS AND APPARENTLY A COMMON FAILURE WITH THIS VEHICLE. THE MECHANIC SAYS THE CV JOINT MUST BE REPLACED BUT THAT A FLAW IN THE DESIGN CAUSES THIS FREQUENTLY WITH THIS VEHICLE. *TR
RANGE ROVER 2005 HSE DRIVESHAFT WENT OUT. *TR
INTERSTATE TRIP I-10 REMOTE AREA SOUTH OF MOBILE, ALABAMA. LOST ABILITY TO ACCELERATE AND WAS ONLY ABLE TO ROLL THE VEHICLE OFF THE SIDE OF THE INTERSTATE IN HEAVY TRAFFIC. UNABLE TO MOVE VEHICLE FROM ROAD SHOULDER WITHOUT TOWING. FRONT DIFFERENTIAL FAILURE THAT REQUIRED TOWING AND REPLACEMENT OF DIFFERENTIAL. OCCURRED AT A…
Read full complaint
INTERSTATE TRIP I-10 REMOTE AREA SOUTH OF MOBILE, ALABAMA. LOST ABILITY TO ACCELERATE AND WAS ONLY ABLE TO ROLL THE VEHICLE OFF THE SIDE OF THE INTERSTATE IN HEAVY TRAFFIC. UNABLE TO MOVE VEHICLE FROM ROAD SHOULDER WITHOUT TOWING. FRONT DIFFERENTIAL FAILURE THAT REQUIRED TOWING AND REPLACEMENT OF DIFFERENTIAL. OCCURRED AT APPROX. 20000 MILES ON NEW RANGE ROVER. *TR
I AM THE OWNER OF A 2005 RANGE ROVER. I PURCHASED THE VEHICLE USED IN 2006 WITH 60,000 MILE'S ON IT. IN JUNE 2007, THE FRONT DIFFERENTIAL BROKE WHILE IN THE MIDDLE OF TWO BUSY INTERSECTIONS. TRAFFIC WAS HALTED UNTIL SOME MEN PUSHED MY CAR TO THE SIDE OF THE ROAD. THERE WAS NO WARNING LEADING UP TO THIS BREAKDOWN. IN FACT, TH…
Read full complaint
I AM THE OWNER OF A 2005 RANGE ROVER. I PURCHASED THE VEHICLE USED IN 2006 WITH 60,000 MILE'S ON IT. IN JUNE 2007, THE FRONT DIFFERENTIAL BROKE WHILE IN THE MIDDLE OF TWO BUSY INTERSECTIONS. TRAFFIC WAS HALTED UNTIL SOME MEN PUSHED MY CAR TO THE SIDE OF THE ROAD. THERE WAS NO WARNING LEADING UP TO THIS BREAKDOWN. IN FACT, THE CAR WAS JUST AT THE DEALERSHIP FOR THE 75,000 MILE CHECKUP. NOT TO MENTION RANGE ROVER CHARGED ME $3,000.00 FOR THIS REPAIR.. THE MOST RECENT FRONT DIFFERENTIAL BREAKDOWN WAS MORE SERIOUS SINCE IT OCCURRED ON THE EXPRESSWAY IN THE MIDDLE OF NOWHERE. WHILE TRAVELING TO BIRMINGHAM AL. FROM ATLANTA GA. AT A SPEED OF 70 MILES PER/HR THE CAR MADE A SUDDEN GRINDING NOISE AND STOP ACCELERATING. ONCE I REALIZED WGAT WAS GOING ON I STARTED GETTING TO THE SIDE OF THE ROAD. IT WAS SCARY BECAUSE PART OF THE TRUCK WAS STILL IN THE FREEWAY LANE AND TRUCKS AND CARS WERE AVOIDING HITTING US. MY TEENAGE SON HAD TO PUSH THE CAR OFF THE FREEWAY. AFTER THIS BEING THE SECOND TIME IN PERIL I AM NOW AFRAID TO DRIVE THIS VEHICLE THAT I OWE A CONSIDERABLE AMOUNT OF MONEY ON. THIS LAST INCIDENT OCCURRED ON MARCH 07, 2008. THE PART WAS STILL UNDER WARRANTY SINCE IT HAD ONLY BEEN 9 MONTHS AND LESS THAN 8,000 MILES SINCE THE LAST FRONT DIFFERENTIAL WAS REPLACED. OH BY THE WAY , THE CAR IS STILL AT THE DEALERSHIP IN BIRMINGHAM AL. THEY DIDN'T HAVE THE PARTS AND THE PARTS HAVEN'T ARRIVED YET. I HOPE SOMETHING CAN BE DONE TO HELP ME, AND OTHERS IN MY POSITION. *TR
THE FAILURE WHICH OCCURRED TWICE WAS THAT MY FRONT DIFFERENTIAL AND FRONT DRIVE SHAFT FAILED (FIRST TIME 48,000 MILES AND SECOND 68,000 MILES). WHAT WAS DONE TO CORRECT THE FAILURE WAS APPARENTLY ALL PARTS WERE CHANGED. CAR DOES NOT MOVE. OLD PARTS ARE AVAILABLE. DEALER WANTS TO CHARGE TWICE AS MUCH AS A PRIVATE MECHANIC WANTS…
Read full complaint
THE FAILURE WHICH OCCURRED TWICE WAS THAT MY FRONT DIFFERENTIAL AND FRONT DRIVE SHAFT FAILED (FIRST TIME 48,000 MILES AND SECOND 68,000 MILES). WHAT WAS DONE TO CORRECT THE FAILURE WAS APPARENTLY ALL PARTS WERE CHANGED. CAR DOES NOT MOVE. OLD PARTS ARE AVAILABLE. DEALER WANTS TO CHARGE TWICE AS MUCH AS A PRIVATE MECHANIC WANTS TO CHARGE. VEHICLE IS NOT OUTSIDE THE WARRANTY AND DEALER WILL NOT REPLACE PARTS FOR FREE. DEALER DOES NOT ACKNOWLEDGE HIGH RATE OF FRONT DIFFERENTIAL FAILURE. *TR
Official recalls
108V635000 · Power Train:driveline:driveshaft
Dec 3, 2008
LAND ROVER IS RECALLING 19,168 MY 2003-2005 RANGE ROVER VEHICLES. THE FRONT DIFFERENTIAL COUPLING SLEEVE AND THE PROPELLER SHAFT MAY BE MISALIGNED, RESULTING IN SPLINE WEAR OVER A PERIOD OF TIME. AS THE WEAR BETWEEN THE PROPELLER SHAFT AND THE DIFFERENTIAL SPLINE COUPLING PROGRESSES, NOISE AND VIBRATION ARE EXPECTED.
Consequence & remedy
Consequence: CONTINUED VEHICLE OPERATION CAN EVENTUALLY RESULT IN THE SPLINES SHEARING AND A LOSS OF DRIVE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A REVISED DESIGN OF THE PROPELLER SHAFT, THE FLANGE KIT AND HEAT SHIELD KIT. THE RECALL BEGAN ON JANUARY 6, 2009. OWNERS MAY CONTACT LAND ROVER AT 1-800- 637-6837.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA07012 · Front Diff. / Propeller Shaft Failure
Opened Aug 14, 2007 · Closed Dec 10, 2008
Status: closed (inferred from source dates) · Power Train:axle Assembly; Power Train:axle Assembly:axle Shaft; Power Train:driveline; Power Train:driveline:differential Unit; Power Train:driveline:driveshaft
SUMMARY:IN A LETTER DATED DECEMBER 2, 2008, FORD MOTOR COMPANY (FORD) NOTIFIED NHTSA THAT LAND ROVER IS CONDUCTING A SAFETY RECALL OF MODEL YEAR (MY) 2003 THROUGH 2005 RANGE ROVER VEHICLES BUILT AT THE SOLIHULL (UK) ASSEMBLY PLANT FROM JANUARY 3, 2002 THROUGH FEBRUARY 22, 2005, TO REPLACE THE FRONT DRIVESHAFT JOINT (NHTSA RECALL NO. 08V-635, LAND ROVER RECALL NO. P041). THE FRONT DIFFERENTIAL COUPLING SLEEVE AND THE PROPELLER SHAFT MAY BE MISALIGNED RESULTING IN SPLINE WEAR OVER TIME, WHICH MAY EVENTUALLY RESULT IN THE SPLINES SHEARING.THE DEFECT CONDITION CAN RESULT IN A LOSS OF PROPULSION AND SUBSEQUENT VEHICLE DISABLEMENT IN THE ROADWAY OR ON THE SHOULDER OF THE ROADWAY. FURTHERMORE, THE DEFECT CONDITION CAN ALSO CAUSE LOSS OF THE TRANSMISSION LOCK FUNCTION WHEN THE VEHICLE IS SHIFTED INTO THE PARK POSITION.THE LOSS OF THE TRANSMISSION LOCK FUNCTION CAN CAUSE A VEHICLE ROLLAWAY CONDITION IF THE EMERGENCY BRAKE IS NOT APPLIED AND THE VEHICLE IS UNATTENDED BY THE DRIVER. IN JULY 2008, LAND ROVER INITIATED A SERVICE ACTION (Q041) INSTRUCTING DEALERS TO INSTALL A REDESIGNED FRONT PROPELLER SHAFT, FRONT DIFFERENTIAL COUPLING AND HEAT SHIELD KIT TO ADDRESS THE MISALIGNMENT AND SUBSEQUENT SPLINE WEAR.THIS IS THE SAME REPAIR PROCEDURE THAT WILL BE USED IN SAFETY RECALL 08V-635.APPROXIMATELY 48 PERCENT OF THE SUBJECT VEHICLES (18,000) HAVE HAD THE REMEDY PERFORMED UNDER SERVICE ACTION Q041 AS OF DECEMBER 2, 2008. ODI BELIEVES THAT SUDDEN LOSS OF MOTIVE POWER WITHOUT WARNING AND FAILURE OF THE TRANSMISSION LOCK FUNCTION ARE SAFETY CONSEQUENCES THAT, PARTICULARLY IN THE CONTEXT OF THE HIGH FAILURE RATE OF THE SUBJECT COMPONENTS, REPRESENT AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY AS STATED IN A RECALL REQUEST LETTER SENT TO FORD AND LAND ROVER ON NOVEMBER 6, 2008.LAND ROVER DOES NOT AGREE, BUT IS CHANGING ITS CUSTOMER SATISFACTION PROGRAM TO A SAFETY RECALL AS ODI REQUESTED. LAND ROVER NOTED THAT IT WAS AWARE OF ONE ALLEGED ACCIDENT; HOWEVER, IT WAS UNAWARE OF ANY INJURY OR VEHICLE DAMAGE ASSOCIATED WITH THE ALLEGED ACCIDENT.LAND ROVER'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION. THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (5)
Power Train:axle Assembly:axle Shaft
SUMMARY:IN A LETTER DATED DECEMBER 2, 2008, FORD MOTOR COMPANY (FORD) NOTIFIED NHTSA THAT LAND ROVER IS CONDUCTING A SAFETY RECALL OF MODEL YEAR (MY) 2003 THROUGH 2005 RANGE ROVER VEHICLES BUILT AT THE SOLIHULL (UK) ASSEMBLY PLANT FROM JANUARY 3, 2002 THROUGH FEBRUARY 22, 2005, TO REPLACE THE FRONT DRIVESHAFT JOINT (NHTSA RECALL NO. 08V-635, LAND ROVER RECALL NO. P041). THE FRONT DIFFERENTIAL COUPLING SLEEVE AND THE PROPELLER SHAFT MAY BE MISALIGNED RESULTING IN SPLINE WEAR OVER TIME, WHICH MAY EVENTUALLY RESULT IN THE SPLINES SHEARING.THE DEFECT CONDITION CAN RESULT IN A LOSS OF PROPULSION AND SUBSEQUENT VEHICLE DISABLEMENT IN THE ROADWAY OR ON THE SHOULDER OF THE ROADWAY. FURTHERMORE, THE DEFECT CONDITION CAN ALSO CAUSE LOSS OF THE TRANSMISSION LOCK FUNCTION WHEN THE VEHICLE IS SHIFTED INTO THE PARK POSITION.THE LOSS OF THE TRANSMISSION LOCK FUNCTION CAN CAUSE A VEHICLE ROLLAWAY CONDITION IF THE EMERGENCY BRAKE IS NOT APPLIED AND THE VEHICLE IS UNATTENDED BY THE DRIVER. IN JULY 2008, LAND ROVER INITIATED A SERVICE ACTION (Q041) INSTRUCTING DEALERS TO INSTALL A REDESIGNED FRONT PROPELLER SHAFT, FRONT DIFFERENTIAL COUPLING AND HEAT SHIELD KIT TO ADDRESS THE MISALIGNMENT AND SUBSEQUENT SPLINE WEAR.THIS IS THE SAME REPAIR PROCEDURE THAT WILL BE USED IN SAFETY RECALL 08V-635.APPROXIMATELY 48 PERCENT OF THE SUBJECT VEHICLES (18,000) HAVE HAD THE REMEDY PERFORMED UNDER SERVICE ACTION Q041 AS OF DECEMBER 2, 2008. ODI BELIEVES THAT SUDDEN LOSS OF MOTIVE POWER WITHOUT WARNING AND FAILURE OF THE TRANSMISSION LOCK FUNCTION ARE SAFETY CONSEQUENCES THAT, PARTICULARLY IN THE CONTEXT OF THE HIGH FAILURE RATE OF THE SUBJECT COMPONENTS, REPRESENT AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY AS STATED IN A RECALL REQUEST LETTER SENT TO FORD AND LAND ROVER ON NOVEMBER 6, 2008.LAND ROVER DOES NOT AGREE, BUT IS CHANGING ITS CUSTOMER SATISFACTION PROGRAM TO A SAFETY RECALL AS ODI REQUESTED. LAND ROVER NOTED THAT IT WAS AWARE OF ONE ALLEGED ACCIDENT; HOWEVER, IT WAS UNAWARE OF ANY INJURY OR VEHICLE DAMAGE ASSOCIATED WITH THE ALLEGED ACCIDENT.LAND ROVER'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION. THIS ENGINEERING ANALYSIS IS CLOSED.
Power Train:axle Assembly
SUMMARY:IN A LETTER DATED DECEMBER 2, 2008, FORD MOTOR COMPANY (FORD) NOTIFIED NHTSA THAT LAND ROVER IS CONDUCTING A SAFETY RECALL OF MODEL YEAR (MY) 2003 THROUGH 2005 RANGE ROVER VEHICLES BUILT AT THE SOLIHULL (UK) ASSEMBLY PLANT FROM JANUARY 3, 2002 THROUGH FEBRUARY 22, 2005, TO REPLACE THE FRONT DRIVESHAFT JOINT (NHTSA RECALL NO. 08V-635, LAND ROVER RECALL NO. P041). THE FRONT DIFFERENTIAL COUPLING SLEEVE AND THE PROPELLER SHAFT MAY BE MISALIGNED RESULTING IN SPLINE WEAR OVER TIME, WHICH MAY EVENTUALLY RESULT IN THE SPLINES SHEARING.THE DEFECT CONDITION CAN RESULT IN A LOSS OF PROPULSION AND SUBSEQUENT VEHICLE DISABLEMENT IN THE ROADWAY OR ON THE SHOULDER OF THE ROADWAY. FURTHERMORE, THE DEFECT CONDITION CAN ALSO CAUSE LOSS OF THE TRANSMISSION LOCK FUNCTION WHEN THE VEHICLE IS SHIFTED INTO THE PARK POSITION.THE LOSS OF THE TRANSMISSION LOCK FUNCTION CAN CAUSE A VEHICLE ROLLAWAY CONDITION IF THE EMERGENCY BRAKE IS NOT APPLIED AND THE VEHICLE IS UNATTENDED BY THE DRIVER. IN JULY 2008, LAND ROVER INITIATED A SERVICE ACTION (Q041) INSTRUCTING DEALERS TO INSTALL A REDESIGNED FRONT PROPELLER SHAFT, FRONT DIFFERENTIAL COUPLING AND HEAT SHIELD KIT TO ADDRESS THE MISALIGNMENT AND SUBSEQUENT SPLINE WEAR.THIS IS THE SAME REPAIR PROCEDURE THAT WILL BE USED IN SAFETY RECALL 08V-635.APPROXIMATELY 48 PERCENT OF THE SUBJECT VEHICLES (18,000) HAVE HAD THE REMEDY PERFORMED UNDER SERVICE ACTION Q041 AS OF DECEMBER 2, 2008. ODI BELIEVES THAT SUDDEN LOSS OF MOTIVE POWER WITHOUT WARNING AND FAILURE OF THE TRANSMISSION LOCK FUNCTION ARE SAFETY CONSEQUENCES THAT, PARTICULARLY IN THE CONTEXT OF THE HIGH FAILURE RATE OF THE SUBJECT COMPONENTS, REPRESENT AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY AS STATED IN A RECALL REQUEST LETTER SENT TO FORD AND LAND ROVER ON NOVEMBER 6, 2008.LAND ROVER DOES NOT AGREE, BUT IS CHANGING ITS CUSTOMER SATISFACTION PROGRAM TO A SAFETY RECALL AS ODI REQUESTED. LAND ROVER NOTED THAT IT WAS AWARE OF ONE ALLEGED ACCIDENT; HOWEVER, IT WAS UNAWARE OF ANY INJURY OR VEHICLE DAMAGE ASSOCIATED WITH THE ALLEGED ACCIDENT.LAND ROVER'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION. THIS ENGINEERING ANALYSIS IS CLOSED.
Power Train:driveline:differential Unit
SUMMARY:IN A LETTER DATED DECEMBER 2, 2008, FORD MOTOR COMPANY (FORD) NOTIFIED NHTSA THAT LAND ROVER IS CONDUCTING A SAFETY RECALL OF MODEL YEAR (MY) 2003 THROUGH 2005 RANGE ROVER VEHICLES BUILT AT THE SOLIHULL (UK) ASSEMBLY PLANT FROM JANUARY 3, 2002 THROUGH FEBRUARY 22, 2005, TO REPLACE THE FRONT DRIVESHAFT JOINT (NHTSA RECALL NO. 08V-635, LAND ROVER RECALL NO. P041). THE FRONT DIFFERENTIAL COUPLING SLEEVE AND THE PROPELLER SHAFT MAY BE MISALIGNED RESULTING IN SPLINE WEAR OVER TIME, WHICH MAY EVENTUALLY RESULT IN THE SPLINES SHEARING.THE DEFECT CONDITION CAN RESULT IN A LOSS OF PROPULSION AND SUBSEQUENT VEHICLE DISABLEMENT IN THE ROADWAY OR ON THE SHOULDER OF THE ROADWAY. FURTHERMORE, THE DEFECT CONDITION CAN ALSO CAUSE LOSS OF THE TRANSMISSION LOCK FUNCTION WHEN THE VEHICLE IS SHIFTED INTO THE PARK POSITION.THE LOSS OF THE TRANSMISSION LOCK FUNCTION CAN CAUSE A VEHICLE ROLLAWAY CONDITION IF THE EMERGENCY BRAKE IS NOT APPLIED AND THE VEHICLE IS UNATTENDED BY THE DRIVER. IN JULY 2008, LAND ROVER INITIATED A SERVICE ACTION (Q041) INSTRUCTING DEALERS TO INSTALL A REDESIGNED FRONT PROPELLER SHAFT, FRONT DIFFERENTIAL COUPLING AND HEAT SHIELD KIT TO ADDRESS THE MISALIGNMENT AND SUBSEQUENT SPLINE WEAR.THIS IS THE SAME REPAIR PROCEDURE THAT WILL BE USED IN SAFETY RECALL 08V-635.APPROXIMATELY 48 PERCENT OF THE SUBJECT VEHICLES (18,000) HAVE HAD THE REMEDY PERFORMED UNDER SERVICE ACTION Q041 AS OF DECEMBER 2, 2008. ODI BELIEVES THAT SUDDEN LOSS OF MOTIVE POWER WITHOUT WARNING AND FAILURE OF THE TRANSMISSION LOCK FUNCTION ARE SAFETY CONSEQUENCES THAT, PARTICULARLY IN THE CONTEXT OF THE HIGH FAILURE RATE OF THE SUBJECT COMPONENTS, REPRESENT AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY AS STATED IN A RECALL REQUEST LETTER SENT TO FORD AND LAND ROVER ON NOVEMBER 6, 2008.LAND ROVER DOES NOT AGREE, BUT IS CHANGING ITS CUSTOMER SATISFACTION PROGRAM TO A SAFETY RECALL AS ODI REQUESTED. LAND ROVER NOTED THAT IT WAS AWARE OF ONE ALLEGED ACCIDENT; HOWEVER, IT WAS UNAWARE OF ANY INJURY OR VEHICLE DAMAGE ASSOCIATED WITH THE ALLEGED ACCIDENT.LAND ROVER'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION. THIS ENGINEERING ANALYSIS IS CLOSED.
Power Train:driveline:driveshaft
SUMMARY:IN A LETTER DATED DECEMBER 2, 2008, FORD MOTOR COMPANY (FORD) NOTIFIED NHTSA THAT LAND ROVER IS CONDUCTING A SAFETY RECALL OF MODEL YEAR (MY) 2003 THROUGH 2005 RANGE ROVER VEHICLES BUILT AT THE SOLIHULL (UK) ASSEMBLY PLANT FROM JANUARY 3, 2002 THROUGH FEBRUARY 22, 2005, TO REPLACE THE FRONT DRIVESHAFT JOINT (NHTSA RECALL NO. 08V-635, LAND ROVER RECALL NO. P041). THE FRONT DIFFERENTIAL COUPLING SLEEVE AND THE PROPELLER SHAFT MAY BE MISALIGNED RESULTING IN SPLINE WEAR OVER TIME, WHICH MAY EVENTUALLY RESULT IN THE SPLINES SHEARING.THE DEFECT CONDITION CAN RESULT IN A LOSS OF PROPULSION AND SUBSEQUENT VEHICLE DISABLEMENT IN THE ROADWAY OR ON THE SHOULDER OF THE ROADWAY. FURTHERMORE, THE DEFECT CONDITION CAN ALSO CAUSE LOSS OF THE TRANSMISSION LOCK FUNCTION WHEN THE VEHICLE IS SHIFTED INTO THE PARK POSITION.THE LOSS OF THE TRANSMISSION LOCK FUNCTION CAN CAUSE A VEHICLE ROLLAWAY CONDITION IF THE EMERGENCY BRAKE IS NOT APPLIED AND THE VEHICLE IS UNATTENDED BY THE DRIVER. IN JULY 2008, LAND ROVER INITIATED A SERVICE ACTION (Q041) INSTRUCTING DEALERS TO INSTALL A REDESIGNED FRONT PROPELLER SHAFT, FRONT DIFFERENTIAL COUPLING AND HEAT SHIELD KIT TO ADDRESS THE MISALIGNMENT AND SUBSEQUENT SPLINE WEAR.THIS IS THE SAME REPAIR PROCEDURE THAT WILL BE USED IN SAFETY RECALL 08V-635.APPROXIMATELY 48 PERCENT OF THE SUBJECT VEHICLES (18,000) HAVE HAD THE REMEDY PERFORMED UNDER SERVICE ACTION Q041 AS OF DECEMBER 2, 2008. ODI BELIEVES THAT SUDDEN LOSS OF MOTIVE POWER WITHOUT WARNING AND FAILURE OF THE TRANSMISSION LOCK FUNCTION ARE SAFETY CONSEQUENCES THAT, PARTICULARLY IN THE CONTEXT OF THE HIGH FAILURE RATE OF THE SUBJECT COMPONENTS, REPRESENT AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY AS STATED IN A RECALL REQUEST LETTER SENT TO FORD AND LAND ROVER ON NOVEMBER 6, 2008.LAND ROVER DOES NOT AGREE, BUT IS CHANGING ITS CUSTOMER SATISFACTION PROGRAM TO A SAFETY RECALL AS ODI REQUESTED. LAND ROVER NOTED THAT IT WAS AWARE OF ONE ALLEGED ACCIDENT; HOWEVER, IT WAS UNAWARE OF ANY INJURY OR VEHICLE DAMAGE ASSOCIATED WITH THE ALLEGED ACCIDENT.LAND ROVER'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION. THIS ENGINEERING ANALYSIS IS CLOSED.
Power Train:driveline
SUMMARY:IN A LETTER DATED DECEMBER 2, 2008, FORD MOTOR COMPANY (FORD) NOTIFIED NHTSA THAT LAND ROVER IS CONDUCTING A SAFETY RECALL OF MODEL YEAR (MY) 2003 THROUGH 2005 RANGE ROVER VEHICLES BUILT AT THE SOLIHULL (UK) ASSEMBLY PLANT FROM JANUARY 3, 2002 THROUGH FEBRUARY 22, 2005, TO REPLACE THE FRONT DRIVESHAFT JOINT (NHTSA RECALL NO. 08V-635, LAND ROVER RECALL NO. P041). THE FRONT DIFFERENTIAL COUPLING SLEEVE AND THE PROPELLER SHAFT MAY BE MISALIGNED RESULTING IN SPLINE WEAR OVER TIME, WHICH MAY EVENTUALLY RESULT IN THE SPLINES SHEARING.THE DEFECT CONDITION CAN RESULT IN A LOSS OF PROPULSION AND SUBSEQUENT VEHICLE DISABLEMENT IN THE ROADWAY OR ON THE SHOULDER OF THE ROADWAY. FURTHERMORE, THE DEFECT CONDITION CAN ALSO CAUSE LOSS OF THE TRANSMISSION LOCK FUNCTION WHEN THE VEHICLE IS SHIFTED INTO THE PARK POSITION.THE LOSS OF THE TRANSMISSION LOCK FUNCTION CAN CAUSE A VEHICLE ROLLAWAY CONDITION IF THE EMERGENCY BRAKE IS NOT APPLIED AND THE VEHICLE IS UNATTENDED BY THE DRIVER. IN JULY 2008, LAND ROVER INITIATED A SERVICE ACTION (Q041) INSTRUCTING DEALERS TO INSTALL A REDESIGNED FRONT PROPELLER SHAFT, FRONT DIFFERENTIAL COUPLING AND HEAT SHIELD KIT TO ADDRESS THE MISALIGNMENT AND SUBSEQUENT SPLINE WEAR.THIS IS THE SAME REPAIR PROCEDURE THAT WILL BE USED IN SAFETY RECALL 08V-635.APPROXIMATELY 48 PERCENT OF THE SUBJECT VEHICLES (18,000) HAVE HAD THE REMEDY PERFORMED UNDER SERVICE ACTION Q041 AS OF DECEMBER 2, 2008. ODI BELIEVES THAT SUDDEN LOSS OF MOTIVE POWER WITHOUT WARNING AND FAILURE OF THE TRANSMISSION LOCK FUNCTION ARE SAFETY CONSEQUENCES THAT, PARTICULARLY IN THE CONTEXT OF THE HIGH FAILURE RATE OF THE SUBJECT COMPONENTS, REPRESENT AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY AS STATED IN A RECALL REQUEST LETTER SENT TO FORD AND LAND ROVER ON NOVEMBER 6, 2008.LAND ROVER DOES NOT AGREE, BUT IS CHANGING ITS CUSTOMER SATISFACTION PROGRAM TO A SAFETY RECALL AS ODI REQUESTED. LAND ROVER NOTED THAT IT WAS AWARE OF ONE ALLEGED ACCIDENT; HOWEVER, IT WAS UNAWARE OF ANY INJURY OR VEHICLE DAMAGE ASSOCIATED WITH THE ALLEGED ACCIDENT.LAND ROVER'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION. THIS ENGINEERING ANALYSIS IS CLOSED.