SHOULDER BRACKET MANUFACTURING DEFECT, ALL YEARS, PROBABLY LR4 AS WELL AS EOROPEAN AND INTERNATIONAL MODELS DISCOVERY 3 AND 4, RANGE ROVER SPORT CASTING SPLITS AND CRACKS AT MULTIPLE POINTS AROUND BOLT HOLE OVER TIME. 4 OF 4 UNITS I INSPECTED WITH SIMILARR FAILURE. THERE WAS NO INCIDENT, FRAYED SEATBELT, ORDERED USED REPLACEM…
Read full complaint
SHOULDER BRACKET MANUFACTURING DEFECT, ALL YEARS, PROBABLY LR4 AS WELL AS EOROPEAN AND INTERNATIONAL MODELS DISCOVERY 3 AND 4, RANGE ROVER SPORT CASTING SPLITS AND CRACKS AT MULTIPLE POINTS AROUND BOLT HOLE OVER TIME. 4 OF 4 UNITS I INSPECTED WITH SIMILARR FAILURE. THERE WAS NO INCIDENT, FRAYED SEATBELT, ORDERED USED REPLACEMENT, THEY WERE AS BAD AS THE ONE ON THE VEHICLE, ALL WERE CRACKED. NO ACCIDENT WITH THE VEHICLE. FACTORY ORIGINAL AND ONE ADDITIONAL UNIT AVAILABLE FOR INSPECTION.
NHTSA ODI #11105191
171,000 miles · Feb 24, 2017
Seat Belts
DRIVER AND PASSENGER SEATBELT SHOULDER ANCHORS HAVE NUMEROUS CRACKS IN THEM. I DISCOVERED THIS WHILE REMOVING INTERNAL BODY PANELS TO DIAGNOSE RAIN WATER LEAKS/INGRESS.
LAND ROVER IS RECALLING 37,142 MY 2005-2006 LR3 AND RANGE ROVER SPORT VEHICLES. RELATIVE MOTION BETWEEN THE STEERING WHEEL HUB AND/OR THE STEERING COLUMN COWL WITH THE CLOCKSPRING, WHICH INCLUDES THE DRIVER SIDE AIR BAG CIRCUITRY, COULD RESULT IN FRACTURING OF THE AIR BAG WIRING CONNECTION. IF AN AIR BAG WIRE FRACTURES, THE SRS WARNING LIGHT WILL ILLUMINATE ON THE INSTRUMENT CLUSTER. THE SRS WARNING LIGHT INDICATES TO THE DRIVER THAT THERE IS A CONCERN WITH THE SRS SYSTEM IN THE VEHICLE AND THAT IMMEDIATE REPAIR IS NECESSARY.
Consequence & remedy
Consequence: IF THE SRS WARNING LIGHT IS IGNORED AND A VEHICLE CRASH OF SUFFICIENT SEVERITY TO COMMAND DEPLOYMENT OF THE DRIVER'S AIR BAG OCCURS, THE AIR BAG MODULE MAY NOT DEPLOY IN THE INTENDED MANNER. THE CONDITION MAY RESULT IN THE DEPLOYMENT OF ONLY ONE STAGE OF THE DUAL STAGE DRIVER'S AIR BAG OR THE AIR BAG MAY NOT DEPLOY AT ALL INCREASING THE RISK OF SERIOUS INJURIES TO THE DRIVER.
Remedy: DEALERS WILL INSERT 1MM SPACERS BETWEEN THE LOWER LEFT HAND SIDE OF THE COLUMN SWITCH MOUNTING POINT AND THE COLUMN LOCK TO IMPROVE THE ALIGNMENT OF THE COLUMN SWITCH. TWO FOAM PADS WILL ALSO BE FITTED TO THE TOP OF THE STEERING COLUMN SWITCH GEAR TO PROVIDE ASSURED CLEARANCE BETWEEN THE COWL AND THE CLOCKSPRING FACE. THE RECALL BEGAN ON JULY 30, 2008. OWNERS MAY CONTACT LAND ROVER AT 1-800-637-6837.
SOME SPORT UTILITY VEHICLES MAY HAVE FUEL TANKS THAT CONTAIN AN INTERNAL BREATHER PIPE THAT WAS NOT MADE TO SPECIFICATION. THIS COULD RESULT IN EXCESSIVE SWELLING AND CRACKING OF A GROMMET AND SUBSEQUENT DETACHMENT OF THE BREATHER PIPE FROM A CONNECTOR TUBE. WHEN THE FUEL LEVEL IN THE TANK IS ABOVE THE LEVEL OF THE DETACHED JOINT, FUEL MAY THEN ENTER THE BREATHER PIPE AND EXCESS FUEL MAY BE DISCHARGED ONTO THE GROUND.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANKS. THE RECALL BEGAN ON MARCH 12, 2007. OWNERS MAY CONTACT LAND ROVER AT 1-800-637-6837.
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, 'THEFT PROTECTION.' WHEN THE IGNITION IS SWITCHED OFF, AFTER A PERIOD OF TIME, IT IS POSSIBLE TO REMOVE THE IGNITION KEY WHEN THE TRANSMISSION SHIFT LEVER IS NOT IN PARK.
Consequence & remedy
Consequence: THIS CONDITION INCREASES THE RISK OF A CRASH RESULTING FROM THE UNINTENDED MOVEMENT OF PARKED VEHICLES.
Remedy: DEALERS WILL REPROGRAM THE DRIVELINE CONTROL TRANSFER BOX ELECTRONIC CONTROL UNIT (ECU) WITH REVISED SOFTWARE. THE RECALL BEGAN ON JUNE 30, 2006. OWNERS MAY CONTACT LAND ROVER AT 1-201-818-8500.
SOME SPORT UTILITY VEHICLES MAY HAVE FUEL TANKS THAT CONTAIN AN INTERNAL BREATHER PIPE THAT WAS NOT MADE TO SPECIFICATION. THIS COULD RESULT IN EXCESSIVE SWELLING AND CRACKING OF A GROMMET AND SUBSEQUENT DETACHMENT OF THE BREATHER PIPE FROM A CONNECTOR TUBE. WHEN THE FUEL LEVEL IN THE TANK IS ABOVE THE LEVEL OF THE DETACHED JOINT, FUEL MAY THEN ENTER THE BREATHER PIPE.
Consequence & remedy
Consequence: THE DRIVER MAY NOTICE FUEL ODOR, DRIVABILITY CONCERNS SUCH AS HESITATION, MISFIRE, STALLING, ROUGH RUNNING, OR DIFFICULTY IN STARTING AND THE 'CHECK ENGINE' LIGHT MAY BE ILLUMINATED. IF THE AMOUNT OF FUEL FLOWING INTO THE BREATHER PIPE REACHES THE VAPOR CANISTER AND EXCEEDS ITS CAPACITY, THE EXCESS FUEL MAY BE DISCHARGED ONTO THE GROUND. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANKS. THE RECALL BEGAN ON OCTOBER 24, 2005. OWNERS MAY CONTACT LAND ROVER AT 1-800-637-6837.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2005 Land Rover LR3 Problems, Complaints & Recalls | Skip That Year
Illustration