IllustrationSRS LIGHT ILLUMINATED 1. 05/11/06-REPLACED L/F PRETENSIONER 2. 08/07/06-REPLACED ALTERNATOR 3. 10/26/07-REPLACED L/F PRETENSIONER 4. 01/29/08-REPLACED L/F PRETENSIONER. *TR
2003 Land Rover Freelander
Owner reports · Recalls · Investigations
More warning signs than most Freelander years
Owner complaints for the 2003 Land Rover Freelander are substantially higher than the model-year median of 42.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Freelander years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
140–25K
2725–50K
4150–75K
3075–100K
9100–150K
2150K+
123 reports with mileage · 17 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 88 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports6 fire reports0 injury reports
What owners actually said
140 reportsI OWN A 03' FREELANDER WITH ONLY 34,000 MILES ON IT. AT THIS STAGE IN A VEHICLE'S LIFE, THERE SHOULD BE VERY LITTLE MECHANICAL PROBLEMS. IT HAS NOT BEEN THE CASE FOR ME. I HAVE HAD THIS CAR FOR 1 AND 1/2 YEARS AND PROBLEMS BEGAN OCCURRING 1 YEAR AFTER OWNERSHIP. THERE IS THE SMELL OF BURNT ANTIFREEZE INSIDE THE CAR AND A…
Read full complaint
I OWN A 03' FREELANDER WITH ONLY 34,000 MILES ON IT. AT THIS STAGE IN A VEHICLE'S LIFE, THERE SHOULD BE VERY LITTLE MECHANICAL PROBLEMS. IT HAS NOT BEEN THE CASE FOR ME. I HAVE HAD THIS CAR FOR 1 AND 1/2 YEARS AND PROBLEMS BEGAN OCCURRING 1 YEAR AFTER OWNERSHIP. THERE IS THE SMELL OF BURNT ANTIFREEZE INSIDE THE CAR AND AN EVEN STRONGER SMELL OUTSIDE THE CAR ONCE THE ENGINE IS TURNED OFF. THE SMELL IS TOXIC AND I'M AFRAID THAT THE FUMES COULD EASILY IMPACT SOMEONE'S DRIVING ABILITY IF NOT HAVE THE DRIVER GO UNCONSCIOUS AFTER A LONG ROAD TRIP. I HAVE READ ABOUT THIS PROBLEM EXISTING ON MANY OTHER FREELANDER VEHICLES ON BLOGS AND CUSTOMER REVIEWS. SOMETHING OUGHT TO BE DONE. ALSO, FOR THE PAST FEW DAYS, I'VE BEEN HEARING A CLICKING NOISE COMING FROM MY ENGINE. I IMMEDIATELY TOOK MY CAR TO A REPAIR SHOP TO GET CHECKED OUT. THE OWNER OF THE SHOP OPERATED ON MY VEHICLE AND DISCOVERED THE ENGINE MANIFOLD NEEDED TO BE REPLACED ($970 PART + $240 SERVICE). HE CONTACTED THE LR PARTS DEALER AND THE DEALER NOTIFIED HIM THAT THIS IS A CONSTANT OCCURRENCE. IN FACT, DEALER SAID THAT HE HAD RECEIVED 4 OTHER PHONE CALLS THE SAME DAY FOR THE SAME EXACT PART. THIS IS RIDICULOUS. LR NEEDS TO TAKE PROACTIVE STEPS IN RESOLVING THESE PROBLEMS. THIS IS A FREQUENT OCCURRENCE AND IMPLIES THAT THERE WERE PROBLEMS WITH THE MANUFACTURING OF THESE VEHICLES. AS OF RIGHT NOW, THESE FRIVOLOUS REPAIRS ARE COSTING FREELANDER OWNERS LOTS OF MONEY, AND IN THE FUTURE, AS THESE CARS BECOME A BIT OLDER, THEY WILL COST PEOPLE LIVES. I URGE YOU TO PLEASE TAKE CORRECTIVE ACTION AND HELP IN ORCHESTRATING A RECALL ON THIS PART. THANK YOU, ROBERT GLEYZER *TR
TOTAL TRANSMISSION FAILURE IN 2002 LANDROVER FREELANDER (PURCHASED IN FEBRUARY 2003) AT 56K. TWO FAULTY VIS MOTORS FOUND, BLOWN LEFT SPEAKER CONE, FAILED FUEL SENDER, FAULTY HEATER FAN, BROKEN WINDOW DRIVE BRACKET. TOTAL REPAIR COST $6000. NO HELP FROM DEALER, NO HELP FROM LANDROVER. CAR FINALLY UNLOADED IN PART EXCHANGE FOR $1,…
Read full complaint
TOTAL TRANSMISSION FAILURE IN 2002 LANDROVER FREELANDER (PURCHASED IN FEBRUARY 2003) AT 56K. TWO FAULTY VIS MOTORS FOUND, BLOWN LEFT SPEAKER CONE, FAILED FUEL SENDER, FAULTY HEATER FAN, BROKEN WINDOW DRIVE BRACKET. TOTAL REPAIR COST $6000. NO HELP FROM DEALER, NO HELP FROM LANDROVER. CAR FINALLY UNLOADED IN PART EXCHANGE FOR $1,250 JUST TO GET RID OF IT AFTER READING OTHER POSTS ON THIS SITE. *TR
(1) 2003 LAND ROVER FREELANDER WAS RUNNING ROUGH SUDDENLY. IT THEN STALLED WHILE IN TRAFFIC AND WOULD NOT RESTART. AFTER 3 HOURS OF WAITING FOR FLATBED TRUCK FROM AAA ROAD SERVICE, VEHICLE WAS TRANSPORTED TO LOCAL LAND ROVER DEALER. (2) A FAILED FUEL PUMP WAS DISCOVERED. (3) IT WAS REPLACED WITH A NEW ONE. VEHICLE WAS OUT OF W…
Read full complaint
(1) 2003 LAND ROVER FREELANDER WAS RUNNING ROUGH SUDDENLY. IT THEN STALLED WHILE IN TRAFFIC AND WOULD NOT RESTART. AFTER 3 HOURS OF WAITING FOR FLATBED TRUCK FROM AAA ROAD SERVICE, VEHICLE WAS TRANSPORTED TO LOCAL LAND ROVER DEALER. (2) A FAILED FUEL PUMP WAS DISCOVERED. (3) IT WAS REPLACED WITH A NEW ONE. VEHICLE WAS OUT OF WARRANTY AND THEREFORE VERY COSTLY FOR ORIGINAL OWNER. *TR
I WAS DRIVING AT APPROX 55 MPH WHEN THE ENGINE SUDDENLY STALLED WITHOUT WARNING WHILE DRIVING. MANAGED TO PULL OFF THE ROAD AND THE ENGINE WOULD NOT START. HAD MY 2003 FREELANDER TOWED TO THE LOCAL GARAGE WHERE I WAS INFORMED THAT THE FUEL PUMP HAD FAILED AND HAD TO BE REPLACED. THE WARRANTY IS NO LONGER IN EFFECT (48 MONTH / 50…
Read full complaint
I WAS DRIVING AT APPROX 55 MPH WHEN THE ENGINE SUDDENLY STALLED WITHOUT WARNING WHILE DRIVING. MANAGED TO PULL OFF THE ROAD AND THE ENGINE WOULD NOT START. HAD MY 2003 FREELANDER TOWED TO THE LOCAL GARAGE WHERE I WAS INFORMED THAT THE FUEL PUMP HAD FAILED AND HAD TO BE REPLACED. THE WARRANTY IS NO LONGER IN EFFECT (48 MONTH / 50,000 MILE). *TR
CAR JUST STARTED RUNNING HOT I DID NOT SEE ANY LEAKS LANDROVER DEALER STATED THAT IT WAS THE THERMOSTAT. KEEP OVERHEATING. HAS BEEN IN SHOP SINCE OCTOBER 2007 BUT HAS BEEN IN THE GARAGE SINCE MARCH 2007. *TR
OWN A 2003 LAND ROVER FREELANDER SE, VEHICLE LOOSES COOLANT INTO ENGINE THEN OVER HEATS. HAD HEAD GASKETS REPLACED AT A COST OF $1,700.00. VEHICLE STILL LEAKING COOLANT INTO ENGINE. I DID SOME INVESTIGATION INTO THIS MATTER FOUND A CHAT ROOM ON EDMUNDS.COM IT SEEMS IT IS A COMMON PROBLEM WITH THIS VEHICLE, THE CAUSE OF THE COOLA…
Read full complaint
OWN A 2003 LAND ROVER FREELANDER SE, VEHICLE LOOSES COOLANT INTO ENGINE THEN OVER HEATS. HAD HEAD GASKETS REPLACED AT A COST OF $1,700.00. VEHICLE STILL LEAKING COOLANT INTO ENGINE. I DID SOME INVESTIGATION INTO THIS MATTER FOUND A CHAT ROOM ON EDMUNDS.COM IT SEEMS IT IS A COMMON PROBLEM WITH THIS VEHICLE, THE CAUSE OF THE COOLANT LEAK IS A POOR DESIGN OF THE ENGINE. IT SEEMS THAT THE CYLINDER SLEEVE SHIFTS INSIDE THE ENGINE AND THE COOLANT BURNS INTERNALLY. LAND ROVER IS WELL AWARE OF THIS ISSUE BUT DOES NOT WANT TO REPLACE ENGINE. *TR
2003 LAND ROVER FREELANDER CAR WAS RUNNING BUT SPUTTERED THEN ENGINE STOPPED. FUEL PUMP FAILED. 43,000 TOTAL MILES. 3 MONTHS PAST WARRANTY PERIOD END. EXHIBITED IMPENDING FAILURE SIGNS (HARD STARTING) BUT HAD NOT QUIT AND WAS NOT DIAGNOSED AS A FUEL PUMP PROBLEM ON PREVIOUS DEALERSHIP VISITS. CAR WOULD NOT START AFTERWARDS. F…
Read full complaint
2003 LAND ROVER FREELANDER CAR WAS RUNNING BUT SPUTTERED THEN ENGINE STOPPED. FUEL PUMP FAILED. 43,000 TOTAL MILES. 3 MONTHS PAST WARRANTY PERIOD END. EXHIBITED IMPENDING FAILURE SIGNS (HARD STARTING) BUT HAD NOT QUIT AND WAS NOT DIAGNOSED AS A FUEL PUMP PROBLEM ON PREVIOUS DEALERSHIP VISITS. CAR WOULD NOT START AFTERWARDS. FUEL PUMP REPLACED BY LR DEALER. CAR RUNS NORMALLY NOW. *TR
ENGINE COOLANT DISAPPEARING INTO COMBUSTION CHAMBER(S), ENGINE OVERHEATING, DUE TO ENGINE SLEEVE. REQUIRES REPLACEMENT ENGINE, EITHER NEW OR REMANUFACTURED. *TR PROBLEM: THERE ARE NO REPLACEMENT ENGINES, ANYWHERE. VEHICLE HAS BEEN IN THE LR DEALERSHIP SINCE 9/27/07. FIRST ESTIMATE WAS REPAIR BY 10/5. THEN IT BECAME 10/2…
Read full complaint
ENGINE COOLANT DISAPPEARING INTO COMBUSTION CHAMBER(S), ENGINE OVERHEATING, DUE TO ENGINE SLEEVE. REQUIRES REPLACEMENT ENGINE, EITHER NEW OR REMANUFACTURED. *TR PROBLEM: THERE ARE NO REPLACEMENT ENGINES, ANYWHERE. VEHICLE HAS BEEN IN THE LR DEALERSHIP SINCE 9/27/07. FIRST ESTIMATE WAS REPAIR BY 10/5. THEN IT BECAME 10/22. NOW I'M TOLD IT MIGHT BE MONTHS BEFORE A REPLACEMENT ENGINE IS AVAILABLE. THIS IS AN INTOLERABLE SITUATION WHICH LAND ROVER PRETENDS DOES NOT EXIST. IT IS AFFECTING OWNERS OF THIS MODEL ALL OVER THE COUNTRY AND CANADA, WHICH IS PART OF THE REASON THE ENGINES ARE IN SHORT SUPPLY. THE OTHER PART IS BECAUSE LAND ROVER MADE A HUGE MISTAKE BY SELLING THE ENGINE TO A CHINESE MFG. COMPANY AND NOW CAN'T MEET DEMANDS FOR REPLACING WHAT IS REALLY A POOR DESIGN WITH A NEW POORLY DESIGNED ENGINE. IN MY OPINION, LAND ROVER SHOULD BE BUYING THESE FAILED VEHICLES BACK IF THEY CAN'T BE REPAIRED. THESE ARE NOT OLD VEHICLES, AND THE OWNERS HAVE BEEN ABANDONED BY LAND ROVER.
ENGINE BEGAN OVERHEATING, TOOK IT TO DEALER. DEALER REPLACED HOSES AND CHECKED SEALS, ETC.. PROBLEM CONTINUED. NOW IT IS IN THE DEALERS SHOP BECAUSE IT BEGAN SPEWING SMOKE AND LOST POWER ON THE HIGHWAY. IT APPEARS TO BE END OF THE ENGINE PROBLEM. *TR
Official recalls
507V041000 · Exterior Lighting:brake Lights:switch
Feb 9, 2007
ON CERTAIN SPORT UTILITY VEHICLES, THE BRAKE LIGHTS MAY REMAIN ILLUMINATED EVEN WHEN THE BRAKE PEDAL IS NOT DEPRESSED. HILL DESCENT CONTROL (HDC), TRACTION CONTROL (TC) AND CRUISE CONTROL WARNING LIGHTS MAY ALSO BE ILLUMINATED.
Consequence & remedy
Consequence: FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSPECT THE BRAKE LAMP OPERATION AND WHERE REQUIRED, ADJUST AND/OR REPLACE THE BRAKE LIGHT SWITCHES WITH NEW SWITCHES OF THE SAME DESIGN UNTIL A NEWLY DESIGNED BRAKE LAMP SWITCH IS AVAILABLE IN MAY 2007. OWNERS WILL THEN BE RE-NOTIFIED TO BRING THEIR VEHICLES IN FOR THE NEW BRAKE LIGHT SWITCH. AN INTERIM LETTER FOR THE INITIAL INSPECTION WAS MAILED ON MARCH 26, 2007. THE SECOND LETTER FOR REPLACEMENT OF THE SWITCHES WAS MAILED BEGINNING JULY 30, 2007. OWNERS MAY CONTACT LAND ROVER AT 1-80-637-6837.
05V300000 · Latches/locks/linkages:doors:latch
Jun 28, 2005
ON CERTAIN FIVE DOOR SPORT UTILITY VEHICLES, IT IS POSSIBLE TO OPERATE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR WHEN THE CHILD SAFETY LEVER IS IN THE "ON" POSITION.
Consequence & remedy
Consequence: THE OCCUPANT MAY OPEN THE DOOR INADVERTENTLY WHILE THE VEHICLE IS IN MOTION AND FALL OUT INTO THE TRAFFIC, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSPECT AND REPLACE THE LATCH ASSEMBLY. THE RECALL BEGAN ON SEPTEMBER 8, 2005. OWNERS SHOULD CONTACT LAND ROVER AT 1-800-637-6837.
04V489000 · Structure:frame And Members
Oct 7, 2004
ON CERTAIN SPORT UTILITY VEHICLES, AN INCORRECT WELD NUT WAS INSTALLED. LACK OF THIS BOLT COULD EVENTUALLY CAUSE THE SUBFRAME TO CRACK OR BECOME DEFORMED.
Consequence & remedy
Consequence: A CRACKED OR DEFORMED SUBFRAME COULD POTENTIALLY LEAD TO INSTABILITY OF THE VEHICLE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE VEHICLE TO SEE IF THE SUBFRAME FIXING IS CORRECTLY FITTED AND CLAMPED UP. IF NECESSARY, THE SUBFRAME WILL BE REPLACED WITH A NEW ONE THAT HAS CORRECT WELD NUTS. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE. OWNERS SHOULD CONTACT LAND ROVER AT 1-800-637-6837.
04V347000 · Structure:body:roof And Pillars
Jul 12, 2004
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT MARGINALLY ABOVE THE PERMITTED 1000 HEAD IMPACT CRITERIA. AT THE LEFT AND RIGHT HAND A-PILLAR TRIM AREA.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL REPLACE THE A-PILLAR TRIM WITH A REVISED COMPONENT THAT ENABLES THE VEHICLE TO FULLY MEET THE REQUIREMENTS OF FMVSS 201. THE RECALL BEGAN ON DECEMBER 6, 2005. OWNERS SHOULD CONTACT LAND ROVER AT 1-800-637-6837.
04V207000 · Latches/locks/linkages:doors:latch
May 5, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE CHILD DOOR LOCK ON THE LEFT HAND REAR DOOR CAN BECOME DISENGAGED.
Consequence & remedy
Consequence: THIS COULD LEAD TO A CHILD BEING ABLE TO OPEN A REAR DOOR WHILE THE VEHICLE IS IN MOTION, INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL REPLACE THE LEFT HAND REAR LATCH. THE RECALL BEGAN DECEMBER 4, 2004. OWNERS SHOULD CONTACT LAND ROVER AT 1-800-637-6837.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA07018 · Fuel Pump Failure - Stall
Opened Dec 7, 2007 · Closed Dec 22, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
SUBJECT COMPONENT FAILURES FOUND THAT CAN OCCUR AT ANY SPEED AND GENERALLY RESULT IN A NO RESTART CONDITION.THESE ARE GENERALLY CONSIDERED TO BE FACTORS THAT INCREASE THE POTENTIAL SEVERITY OF STALLING INCIDENTS.HOWEVER, THESE INCIDENTS HAVE OCCURRED AT RELATIVELY LOW RATES IN THE SUBJECT VEHICLE POPULATION WHEN COMPARED WITH PRIOR INVESTIGATIONS INVOLVING SIMILAR CATEGORIES OF ENGINE STALL CONSEQUENCES.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR MORE INFORMATION ABOUT THIS INVESTIGATION.
PE07036 · Fuel Pump Failure
Opened Jul 17, 2007 · Closed Dec 10, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE07-036 ON JULY 17, 2007, BASED ON THREE CONSUMER COMPLAINTS ALLEGING INCIDENTS OF SUDDEN ENGINE STALL WHILE DRIVING DUE TO FUEL PUMP FAILURE IN MODEL YEAR (MY) 2003 LAND ROVER FREELANDER VEHICLES.IN EACH INCIDENT THE VEHICLE COULD NOT BE RESTARTED AND HAD TO BE TOWED FOR REPAIRS. IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, FORD PROVIDED OWNER COMPLAINT INFORMATION, FIELD REPORTS AND WARRANTY CLAIM DATA FOR APPROXIMATELY 9,985 SUBJECT VEHICLES SOLD IN THE UNITED STATES.THE BASE WARRANTY FOR THE SUBJECT VEHICLES IS 48 MONTHS OR 50,000 MILES, WHICHEVER OCCURS FIRST.FORD CATEGORIZED THE DATA BY ENGINE STALLS THAT OCCURRED WHILE DRIVING, ENGINE STALLS WITH AN UNKNOWN DRIVING CONDITION, NO START CONDITIONS AND OTHER DRIVEABILITY CONDITIONS. ODI'S ANALYSIS SHOWED THAT THE SUBJECT VEHICLES HAVE EXPERIENCED A 6.7% FUEL PUMP WARRANTY CLAIM RATE FOR ALL CONDITIONS AFTER APPROXIMATELY 4 TO 5 YEARS OF SERVICE, INCLUDING 1.4% CATEGORIZED AS A STALL WHILE DRIVING EVENT AND 2.1% CATEGORIZED AS A STALL WITH AN UNKNOWN DRIVING CONDITION.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-018) TO FURTHER ASSESS THE FREQUENCY AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Additional source detail variants (2)
Fuel System, Gasoline:delivery:fuel Pump
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE07-036 ON JULY 17, 2007, BASED ON THREE CONSUMER COMPLAINTS ALLEGING INCIDENTS OF SUDDEN ENGINE STALL WHILE DRIVING DUE TO FUEL PUMP FAILURE IN MODEL YEAR (MY) 2003 LAND ROVER FREELANDER VEHICLES.IN EACH INCIDENT THE VEHICLE COULD NOT BE RESTARTED AND HAD TO BE TOWED FOR REPAIRS. IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, FORD PROVIDED OWNER COMPLAINT INFORMATION, FIELD REPORTS AND WARRANTY CLAIM DATA FOR APPROXIMATELY 9,985 SUBJECT VEHICLES SOLD IN THE UNITED STATES.THE BASE WARRANTY FOR THE SUBJECT VEHICLES IS 48 MONTHS OR 50,000 MILES, WHICHEVER OCCURS FIRST.FORD CATEGORIZED THE DATA BY ENGINE STALLS THAT OCCURRED WHILE DRIVING, ENGINE STALLS WITH AN UNKNOWN DRIVING CONDITION, NO START CONDITIONS AND OTHER DRIVEABILITY CONDITIONS. ODI'S ANALYSIS SHOWED THAT THE SUBJECT VEHICLES HAVE EXPERIENCED A 6.7% FUEL PUMP WARRANTY CLAIM RATE FOR ALL CONDITIONS AFTER APPROXIMATELY 4 TO 5 YEARS OF SERVICE, INCLUDING 1.4% CATEGORIZED AS A STALL WHILE DRIVING EVENT AND 2.1% CATEGORIZED AS A STALL WITH AN UNKNOWN DRIVING CONDITION.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-018) TO FURTHER ASSESS THE FREQUENCY AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Fuel System, Gasoline:delivery
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE07-036 ON JULY 17, 2007, BASED ON THREE CONSUMER COMPLAINTS ALLEGING INCIDENTS OF SUDDEN ENGINE STALL WHILE DRIVING DUE TO FUEL PUMP FAILURE IN MODEL YEAR (MY) 2003 LAND ROVER FREELANDER VEHICLES.IN EACH INCIDENT THE VEHICLE COULD NOT BE RESTARTED AND HAD TO BE TOWED FOR REPAIRS. IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, FORD PROVIDED OWNER COMPLAINT INFORMATION, FIELD REPORTS AND WARRANTY CLAIM DATA FOR APPROXIMATELY 9,985 SUBJECT VEHICLES SOLD IN THE UNITED STATES.THE BASE WARRANTY FOR THE SUBJECT VEHICLES IS 48 MONTHS OR 50,000 MILES, WHICHEVER OCCURS FIRST.FORD CATEGORIZED THE DATA BY ENGINE STALLS THAT OCCURRED WHILE DRIVING, ENGINE STALLS WITH AN UNKNOWN DRIVING CONDITION, NO START CONDITIONS AND OTHER DRIVEABILITY CONDITIONS. ODI'S ANALYSIS SHOWED THAT THE SUBJECT VEHICLES HAVE EXPERIENCED A 6.7% FUEL PUMP WARRANTY CLAIM RATE FOR ALL CONDITIONS AFTER APPROXIMATELY 4 TO 5 YEARS OF SERVICE, INCLUDING 1.4% CATEGORIZED AS A STALL WHILE DRIVING EVENT AND 2.1% CATEGORIZED AS A STALL WITH AN UNKNOWN DRIVING CONDITION.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-018) TO FURTHER ASSESS THE FREQUENCY AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
EA05016 · Brake Light Switch Failure
Opened Oct 14, 2005 · Closed Feb 22, 2007
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
ON JUNE 16, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE05-034) TO INVESTIGATE ALLEGED STOP LAMP (BRAKE) SWITCH FAILURES IN CERTAIN MODEL YEAR (MY) 2004 LAND ROVER DISCOVERY SERIES II VEHICLES.ON OCTOBER 14, 2005, THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS AND THE SCOPE EXPANDED TO INCLUDE CERTAIN MY 2002 THROUGH 2005 FREELANDER VEHICLES THAT USE A SUBSTANTIALLY SIMILAR SELF-ADJUSTING STOP LAMP SWITCH FURNISHED BY THE SAME SUPPLIER, METHODE ELECTRONICS MALTA, LTD. (METHODE).IN SEPTEMBER 2003, METHODE MOVED THE PRODUCTION OF AN INTERNAL SWITCH COMPONENT, KNOWN AS THE SLIDER MECHANISM, FROM A VALIDATED PLASTIC INJECTION-MOLDING TOOL (?CAVITY 1?) TO ANOTHER TOOL (?CAVITY 2?) THAT HAD NOT BEEN USED BEFORE TO PRODUCE PARTS FOR LAND ROVER.SLIDERS FROM CAVITY 2 MAY BE CHARACTERIZED BY POOR FILL, LACK OF DEFINITION IN THE SLIDER TEETH AND DIMENSIONAL INSTABILITY.CONSEQUENTLY, THE SLIDER MAY BE UNABLE TO RESTRAIN IMPROPER MOVEMENT OF THE PLUNGER DURING NORMAL BRAKE PEDAL OPERATION.THIS MAY CAUSE THE SWITCH TO FALL OUT OF ADJUSTMENT, THUS SIGNIFICANTLY REDUCING THE EFFORT REQUIRED TO ENERGIZE THE SWITCH AND ILLUMINATE THE STOP LAMPS.?CAVITY 2? SWITCHES WERE INSTALLED IN APPROXIMATELY 8,763 DISCOVERY SUBJECT VEHICLES BUILT FROM DECEMBER 2003 THROUGH MAY 2004 AND APPROXIMATELY 3,915 FREELANDER SUBJECT VEHICLES BUILT FROM OCTOBER 2003 THROUGH MAY 2004.ADDITIONALLY, STOP LAMP SWITCHES IN CERTAIN MY 2002 THROUGH 2005 FREELANDER SUBJECT VEHICLES MAY SLIP OUT OF ADJUSTMENT AS A RESULT OF SWITCH DAMAGE DUE TO AN INCORRECT SETTING PROCEDURE DURING VEHICLE MANUFACTURE OR AS A RESULT OF SWITCH MOUNTING BRACKET FLEX.ANALYSIS OF ALL AVAILABLE DATA INDICATES THE PREDOMINANT FAILURE MODE IS CONSTANT STOP LAMP ILLUMINATION.OTHER REPORTED CONSEQUENCES OF STOP LAMP SWITCH MALADJUSTMENT INCLUDE INOPERATIVE AUTOMATIC TRANSMISSION GEAR SELECTOR/BRAKE PEDAL SHIFT INTERLOCK, INOPERATIVE SPEED (CRUISE) CONTROL, AND TELLTALE ILLUMINATION AS DESCRIBED IN TECHNICAL SERVICE BULLETIN (TSB) NO. LT206-001 DATED OCTOBER 28, 2004 ISSUED BY THE MANUFACTURER TO LAND ROVER DEALERS IN THE UNITED KINGDOM (UK).TO DATE, ODI IS AWARE OF 77 NON-DUPLICATIVE COMPLAINTS THAT ALLEGE STOP LAMP SWITCH FAILURE ON THE SUBJECT VEHICLES (10 COMPLAINTS ON MY 2004 DISCOVERY, 45 ON MY 2002 FREELANDER, 19 ON MY 2003 FREELANDER, AND 3 ON MY 2004 FREELANDER VEHICLES).ADDITIONALLY, 4,595 DISCOVERY AND 13,370 FREELANDER SUBJECT VEHICLES HAVE EXPERIENCED ONE OR MORE WARRANTY CLAIMS TO REPLACE THE STOP LAMP SWITCH.OF THE 5,170 WARRANTY CLAIMS PAID TO REPLACE STOP LAMP SWITCHES ON DISCOVERY SUBJECT VEHICLES, APPROXIMATELY 31% OCCURRED BEFORE THE VEHICLE WAS SOLD NEW AND APPROXIMATELY 88% OCCURRED WITHIN THE FIRST 12 MONTHS OF VEHICLE SERVICE.THE WARRANTY TREND ON DISCOVERY SUBJECT VEHICLES IS IN DECLINE WITH 3,545 CLAIMS PAID IN CALENDAR YEAR (CY) 2004, 1,303 CLAIMS PAID IN CY 2005, AND 322 CLAIMS PAID IN CY 2006 THROUGH SEPTEMBER 28, 2006 (WHICH IS WHEN ODI LAST RECEIVED UPDATED WARRANTY CLAIMS DATA FROM LAND ROVER), AND IT APPEARS THAT THE ALLEGED DEFECT ON DISCOVER SUBJECT VEHICLES HAS BEEN REMEDIED THROUGH WARRANTY REPAIRS.HOWEVER, ODI ANALYSIS OF THE MANUFACTURER?S WARRANTY AND COMPLAINT RECORDS INDICATES THE FAILURE TREND ON CERTAIN FREELANDER SUBJECT VEHICLES IS ONGOING.BY LETTER DATED FEBRUARY 2, 2007, LAND ROVER HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 07V-041) TO REPLACE DEFECTIVE STOP LAMP SWITCHES IN APPROXIMATELY 33,247 MY 2002 THROUGH 2005 FREELANDER VEHICLES BUILT AT THE SOLIHULL, UK ASSEMBLY PLANT FROM SEPTEMBER 5, 2001 THROUGH MAY 19, 2005. ALTHOUGH ODI HAS CONCERN
Additional source detail variants (2)
Exterior Lighting:brake Lights
ON JUNE 16, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE05-034) TO INVESTIGATE ALLEGED STOP LAMP (BRAKE) SWITCH FAILURES IN CERTAIN MODEL YEAR (MY) 2004 LAND ROVER DISCOVERY SERIES II VEHICLES.ON OCTOBER 14, 2005, THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS AND THE SCOPE EXPANDED TO INCLUDE CERTAIN MY 2002 THROUGH 2005 FREELANDER VEHICLES THAT USE A SUBSTANTIALLY SIMILAR SELF-ADJUSTING STOP LAMP SWITCH FURNISHED BY THE SAME SUPPLIER, METHODE ELECTRONICS MALTA, LTD. (METHODE).IN SEPTEMBER 2003, METHODE MOVED THE PRODUCTION OF AN INTERNAL SWITCH COMPONENT, KNOWN AS THE SLIDER MECHANISM, FROM A VALIDATED PLASTIC INJECTION-MOLDING TOOL (?CAVITY 1?) TO ANOTHER TOOL (?CAVITY 2?) THAT HAD NOT BEEN USED BEFORE TO PRODUCE PARTS FOR LAND ROVER.SLIDERS FROM CAVITY 2 MAY BE CHARACTERIZED BY POOR FILL, LACK OF DEFINITION IN THE SLIDER TEETH AND DIMENSIONAL INSTABILITY.CONSEQUENTLY, THE SLIDER MAY BE UNABLE TO RESTRAIN IMPROPER MOVEMENT OF THE PLUNGER DURING NORMAL BRAKE PEDAL OPERATION.THIS MAY CAUSE THE SWITCH TO FALL OUT OF ADJUSTMENT, THUS SIGNIFICANTLY REDUCING THE EFFORT REQUIRED TO ENERGIZE THE SWITCH AND ILLUMINATE THE STOP LAMPS.?CAVITY 2? SWITCHES WERE INSTALLED IN APPROXIMATELY 8,763 DISCOVERY SUBJECT VEHICLES BUILT FROM DECEMBER 2003 THROUGH MAY 2004 AND APPROXIMATELY 3,915 FREELANDER SUBJECT VEHICLES BUILT FROM OCTOBER 2003 THROUGH MAY 2004.ADDITIONALLY, STOP LAMP SWITCHES IN CERTAIN MY 2002 THROUGH 2005 FREELANDER SUBJECT VEHICLES MAY SLIP OUT OF ADJUSTMENT AS A RESULT OF SWITCH DAMAGE DUE TO AN INCORRECT SETTING PROCEDURE DURING VEHICLE MANUFACTURE OR AS A RESULT OF SWITCH MOUNTING BRACKET FLEX.ANALYSIS OF ALL AVAILABLE DATA INDICATES THE PREDOMINANT FAILURE MODE IS CONSTANT STOP LAMP ILLUMINATION.OTHER REPORTED CONSEQUENCES OF STOP LAMP SWITCH MALADJUSTMENT INCLUDE INOPERATIVE AUTOMATIC TRANSMISSION GEAR SELECTOR/BRAKE PEDAL SHIFT INTERLOCK, INOPERATIVE SPEED (CRUISE) CONTROL, AND TELLTALE ILLUMINATION AS DESCRIBED IN TECHNICAL SERVICE BULLETIN (TSB) NO. LT206-001 DATED OCTOBER 28, 2004 ISSUED BY THE MANUFACTURER TO LAND ROVER DEALERS IN THE UNITED KINGDOM (UK).TO DATE, ODI IS AWARE OF 77 NON-DUPLICATIVE COMPLAINTS THAT ALLEGE STOP LAMP SWITCH FAILURE ON THE SUBJECT VEHICLES (10 COMPLAINTS ON MY 2004 DISCOVERY, 45 ON MY 2002 FREELANDER, 19 ON MY 2003 FREELANDER, AND 3 ON MY 2004 FREELANDER VEHICLES).ADDITIONALLY, 4,595 DISCOVERY AND 13,370 FREELANDER SUBJECT VEHICLES HAVE EXPERIENCED ONE OR MORE WARRANTY CLAIMS TO REPLACE THE STOP LAMP SWITCH.OF THE 5,170 WARRANTY CLAIMS PAID TO REPLACE STOP LAMP SWITCHES ON DISCOVERY SUBJECT VEHICLES, APPROXIMATELY 31% OCCURRED BEFORE THE VEHICLE WAS SOLD NEW AND APPROXIMATELY 88% OCCURRED WITHIN THE FIRST 12 MONTHS OF VEHICLE SERVICE.THE WARRANTY TREND ON DISCOVERY SUBJECT VEHICLES IS IN DECLINE WITH 3,545 CLAIMS PAID IN CALENDAR YEAR (CY) 2004, 1,303 CLAIMS PAID IN CY 2005, AND 322 CLAIMS PAID IN CY 2006 THROUGH SEPTEMBER 28, 2006 (WHICH IS WHEN ODI LAST RECEIVED UPDATED WARRANTY CLAIMS DATA FROM LAND ROVER), AND IT APPEARS THAT THE ALLEGED DEFECT ON DISCOVER SUBJECT VEHICLES HAS BEEN REMEDIED THROUGH WARRANTY REPAIRS.HOWEVER, ODI ANALYSIS OF THE MANUFACTURER?S WARRANTY AND COMPLAINT RECORDS INDICATES THE FAILURE TREND ON CERTAIN FREELANDER SUBJECT VEHICLES IS ONGOING.BY LETTER DATED FEBRUARY 2, 2007, LAND ROVER HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 07V-041) TO REPLACE DEFECTIVE STOP LAMP SWITCHES IN APPROXIMATELY 33,247 MY 2002 THROUGH 2005 FREELANDER VEHICLES BUILT AT THE SOLIHULL, UK ASSEMBLY PLANT FROM SEPTEMBER 5, 2001 THROUGH MAY 19, 2005. ALTHOUGH ODI HAS CONCERN
Exterior Lighting:brake Lights:switch
ON JUNE 16, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE05-034) TO INVESTIGATE ALLEGED STOP LAMP (BRAKE) SWITCH FAILURES IN CERTAIN MODEL YEAR (MY) 2004 LAND ROVER DISCOVERY SERIES II VEHICLES.ON OCTOBER 14, 2005, THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS AND THE SCOPE EXPANDED TO INCLUDE CERTAIN MY 2002 THROUGH 2005 FREELANDER VEHICLES THAT USE A SUBSTANTIALLY SIMILAR SELF-ADJUSTING STOP LAMP SWITCH FURNISHED BY THE SAME SUPPLIER, METHODE ELECTRONICS MALTA, LTD. (METHODE).IN SEPTEMBER 2003, METHODE MOVED THE PRODUCTION OF AN INTERNAL SWITCH COMPONENT, KNOWN AS THE SLIDER MECHANISM, FROM A VALIDATED PLASTIC INJECTION-MOLDING TOOL (?CAVITY 1?) TO ANOTHER TOOL (?CAVITY 2?) THAT HAD NOT BEEN USED BEFORE TO PRODUCE PARTS FOR LAND ROVER.SLIDERS FROM CAVITY 2 MAY BE CHARACTERIZED BY POOR FILL, LACK OF DEFINITION IN THE SLIDER TEETH AND DIMENSIONAL INSTABILITY.CONSEQUENTLY, THE SLIDER MAY BE UNABLE TO RESTRAIN IMPROPER MOVEMENT OF THE PLUNGER DURING NORMAL BRAKE PEDAL OPERATION.THIS MAY CAUSE THE SWITCH TO FALL OUT OF ADJUSTMENT, THUS SIGNIFICANTLY REDUCING THE EFFORT REQUIRED TO ENERGIZE THE SWITCH AND ILLUMINATE THE STOP LAMPS.?CAVITY 2? SWITCHES WERE INSTALLED IN APPROXIMATELY 8,763 DISCOVERY SUBJECT VEHICLES BUILT FROM DECEMBER 2003 THROUGH MAY 2004 AND APPROXIMATELY 3,915 FREELANDER SUBJECT VEHICLES BUILT FROM OCTOBER 2003 THROUGH MAY 2004.ADDITIONALLY, STOP LAMP SWITCHES IN CERTAIN MY 2002 THROUGH 2005 FREELANDER SUBJECT VEHICLES MAY SLIP OUT OF ADJUSTMENT AS A RESULT OF SWITCH DAMAGE DUE TO AN INCORRECT SETTING PROCEDURE DURING VEHICLE MANUFACTURE OR AS A RESULT OF SWITCH MOUNTING BRACKET FLEX.ANALYSIS OF ALL AVAILABLE DATA INDICATES THE PREDOMINANT FAILURE MODE IS CONSTANT STOP LAMP ILLUMINATION.OTHER REPORTED CONSEQUENCES OF STOP LAMP SWITCH MALADJUSTMENT INCLUDE INOPERATIVE AUTOMATIC TRANSMISSION GEAR SELECTOR/BRAKE PEDAL SHIFT INTERLOCK, INOPERATIVE SPEED (CRUISE) CONTROL, AND TELLTALE ILLUMINATION AS DESCRIBED IN TECHNICAL SERVICE BULLETIN (TSB) NO. LT206-001 DATED OCTOBER 28, 2004 ISSUED BY THE MANUFACTURER TO LAND ROVER DEALERS IN THE UNITED KINGDOM (UK).TO DATE, ODI IS AWARE OF 77 NON-DUPLICATIVE COMPLAINTS THAT ALLEGE STOP LAMP SWITCH FAILURE ON THE SUBJECT VEHICLES (10 COMPLAINTS ON MY 2004 DISCOVERY, 45 ON MY 2002 FREELANDER, 19 ON MY 2003 FREELANDER, AND 3 ON MY 2004 FREELANDER VEHICLES).ADDITIONALLY, 4,595 DISCOVERY AND 13,370 FREELANDER SUBJECT VEHICLES HAVE EXPERIENCED ONE OR MORE WARRANTY CLAIMS TO REPLACE THE STOP LAMP SWITCH.OF THE 5,170 WARRANTY CLAIMS PAID TO REPLACE STOP LAMP SWITCHES ON DISCOVERY SUBJECT VEHICLES, APPROXIMATELY 31% OCCURRED BEFORE THE VEHICLE WAS SOLD NEW AND APPROXIMATELY 88% OCCURRED WITHIN THE FIRST 12 MONTHS OF VEHICLE SERVICE.THE WARRANTY TREND ON DISCOVERY SUBJECT VEHICLES IS IN DECLINE WITH 3,545 CLAIMS PAID IN CALENDAR YEAR (CY) 2004, 1,303 CLAIMS PAID IN CY 2005, AND 322 CLAIMS PAID IN CY 2006 THROUGH SEPTEMBER 28, 2006 (WHICH IS WHEN ODI LAST RECEIVED UPDATED WARRANTY CLAIMS DATA FROM LAND ROVER), AND IT APPEARS THAT THE ALLEGED DEFECT ON DISCOVER SUBJECT VEHICLES HAS BEEN REMEDIED THROUGH WARRANTY REPAIRS.HOWEVER, ODI ANALYSIS OF THE MANUFACTURER?S WARRANTY AND COMPLAINT RECORDS INDICATES THE FAILURE TREND ON CERTAIN FREELANDER SUBJECT VEHICLES IS ONGOING.BY LETTER DATED FEBRUARY 2, 2007, LAND ROVER HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 07V-041) TO REPLACE DEFECTIVE STOP LAMP SWITCHES IN APPROXIMATELY 33,247 MY 2002 THROUGH 2005 FREELANDER VEHICLES BUILT AT THE SOLIHULL, UK ASSEMBLY PLANT FROM SEPTEMBER 5, 2001 THROUGH MAY 19, 2005. ALTHOUGH ODI HAS CONCERN