NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
88 reportsClear category filterMileage unknown · Dec 4, 2009
Engine And Engine CoolingFire
TL*THE CONTACT OWNS A 2003 LAND ROVER FREELANDER. THE CONTACT WAS DRIVING AT AN UNKNOWN SPEED RATE ON NORMAL ROAD CONDITIONS. THERE WAS A STRONG ODOR OF COOLANT INSIDE OF THE VEHICLE. SUDDENLY, SMOKED EXPELLED FROM UNDERNEATH THE HOOD. THE DRIVER PULLED OVER TO THE SIDE OF THE ROAD AND INSPECTED THE VEHICLE. THERE WAS A COO…
Read full complaint
TL*THE CONTACT OWNS A 2003 LAND ROVER FREELANDER. THE CONTACT WAS DRIVING AT AN UNKNOWN SPEED RATE ON NORMAL ROAD CONDITIONS. THERE WAS A STRONG ODOR OF COOLANT INSIDE OF THE VEHICLE. SUDDENLY, SMOKED EXPELLED FROM UNDERNEATH THE HOOD. THE DRIVER PULLED OVER TO THE SIDE OF THE ROAD AND INSPECTED THE VEHICLE. THERE WAS A COOLANT LEAKAGE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR INSPECTION. THE TECHNICIAN REPLACED THE THERMOSTAT. THE IDENTICAL FAILURES OCCURRED ON THIRTY SEPARATE OCCASIONS. THE COMPONENTS REPLACED OVER A PERIOD OF TIME CONSIST OF THE HEAD GASKET AND REPLACEMENT OF THE ENGINE THREE SEPARATE OCCASIONS. THE FAILURES CONTINUED AFTER THE REPAIRS PERFORMED ON THE VEHICLE. THERE WERE NO RESOLUTIONS. THE VEHICLE HAS NOT BEEN REPAIRED AT THIS TIME. THE CONTACT HAD CONCERN OF THE SAFETY RISK INVOLVED. THE FAILURE MILEAGE WAS UNAVAILABLE. THE CURRENT MILEAGE WAS 105,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10294464
75,000 miles · Nov 25, 2009
Engine And Engine Cooling
WHEN I PURCHASE MY CAR JAN 2009 IT HAD ROUGHLY 56,000 MILES ON IT. I DID NOTICE THAT WHEN I STARTED IT IN THE MORNING IT HAD A FUNNY SOUND. I TRIED TO BRING BACK TO THE DEALERSHIP SEVERAL TIMES TO HAVE IT LOOKED AT, EITHER NO ONE WAS THERE TO HELP ME OR THE NOISE WAS GONE SINCE THE CAR WAS WARM. I NOTICE SOME SMOKE A WEEK AGO …
Read full complaint
WHEN I PURCHASE MY CAR JAN 2009 IT HAD ROUGHLY 56,000 MILES ON IT. I DID NOTICE THAT WHEN I STARTED IT IN THE MORNING IT HAD A FUNNY SOUND. I TRIED TO BRING BACK TO THE DEALERSHIP SEVERAL TIMES TO HAVE IT LOOKED AT, EITHER NO ONE WAS THERE TO HELP ME OR THE NOISE WAS GONE SINCE THE CAR WAS WARM. I NOTICE SOME SMOKE A WEEK AGO AND FILLED THE ANTIFREEZE FLUID BACK TO MAX LINE, THEN I NOTICE THE ANTIFREEZE WAS DOWN PAST THE MIN LINE AGAIN, WITH NO ANTIFREEZE ON THE GROUND??? TOOK IT IN THE SHOP AND HE GAVE A LIST OF THIS WRONG, INTAKE MANIFOLD VALVES ALWAYS OPEN, BANK 1 & 2 LEAN, HE REPLACE MY "T" CONNECTOR, JUST TO NAME SOME.. OH YEAH AND NOISE COMING FROM THREE DIFFERENT PLACES.. VALVE TRAN, WATER PUMP/TIMING BELT AND THE ALTERNATOR. NO HE TOLD ME IT WILL COST THOUSAND OF DOLLARS TO FIX IT. *TR
NHTSA ODI #10293618
93,000 miles · Nov 17, 2009
Engine And Engine Cooling
COOLANT HAS BEEN LEAKING INTO THE ENGINE EVER SINCE I PURCHASED ABOUT 18 MONTHS AGO. LANDROVER FINALLY ACKNOWLEDGE THE PROBLEM BUT NOW THERE IS NOT ENOUGH FUNDS ON MY EXTENDED WARRANTY TO COVER A NEW ENGINE. FOR THE PAST 18 MONTHS MY VEHICLE HAS BEEN AT THE DEALERSHIP AT LEAST HALF THE TIME. IT JUST SEEMS LIKE A BIG COVER UP.…
Read full complaint
COOLANT HAS BEEN LEAKING INTO THE ENGINE EVER SINCE I PURCHASED ABOUT 18 MONTHS AGO. LANDROVER FINALLY ACKNOWLEDGE THE PROBLEM BUT NOW THERE IS NOT ENOUGH FUNDS ON MY EXTENDED WARRANTY TO COVER A NEW ENGINE. FOR THE PAST 18 MONTHS MY VEHICLE HAS BEEN AT THE DEALERSHIP AT LEAST HALF THE TIME. IT JUST SEEMS LIKE A BIG COVER UP. *TR
NHTSA ODI #10292592
80,000 miles · Nov 4, 2009
Engine And Engine Cooling
AFTER KNOWING ABOUT THE COOLANT PROBLEMS OF THIS CAR WE TOOK CARE, HAD AN COOLANT FLUSH AND REGULARLY CONTROL THAT THERE WAS ENOUGH COOLANT. WHEN WE NOTICED THAT THE COOLANT WAS RUNNING LOW, WE TOPPED IT OFF, BUT THIS HAPPENED AGAIN AND AGAIN WITHOUT ANY OBVIOUS LEAKING. THE REPAIR FACILITY SAW SOME CRACKS IN THE COOLANT TANK …
Read full complaint
AFTER KNOWING ABOUT THE COOLANT PROBLEMS OF THIS CAR WE TOOK CARE, HAD AN COOLANT FLUSH AND REGULARLY CONTROL THAT THERE WAS ENOUGH COOLANT. WHEN WE NOTICED THAT THE COOLANT WAS RUNNING LOW, WE TOPPED IT OFF, BUT THIS HAPPENED AGAIN AND AGAIN WITHOUT ANY OBVIOUS LEAKING. THE REPAIR FACILITY SAW SOME CRACKS IN THE COOLANT TANK SO WE CHANGED IT, A FEW DAYS LATER THE CAR DID NOT WORK AT ALL AND HAND TO BE TOWED. THE WHOLE ENGINE HAD TO BE CHANGE; THE EXPLANATION WAS COOLANT WAS LEAKING AND MIXING WITH OIL. NOW, WITH THE NEW ENGINE THERE ARE AGAIN WARNING LIGHTS BLINKING AND REPAIR FACILITY TOLD US WE COULD NEED A NEW INTAKE MANIFOLD. MEANWHILE THE COOLANT WAS LOW AGAIN AND WE HAD TO CHANGE THE THERMOSTAT BECAUSE THEY FOUND A LEAKING THERE. THERE ARE SO MANY COMPLAINTS WITH THE COOLANT AND ENGINE TO FIND IN THE INTERNET AND EVEN ON THIS PAGE, SO WHEN DO THEY RECALL THE COOLANT SYSTEM AND ENGINE?? *TR
NHTSA ODI #10291010
103,000 miles · Oct 27, 2009
Engine And Engine Cooling
COOLANT LEAKS INTO THE ENGINE IN THE 2003 LAND ROVER FREELANDER. PROBLEM STARTED AT 25,000 MILES AND WAS DISMISSED BY THE LAND ROVER DEALER (FRANKEL LAND ROVER- HUNT VALLEY) WHO I BOUGHT THE CAR FROM. I BOUGHT IT BRAND NEW. EVENTUALLY AT ABOUT 60,000 MILES THEY TOLD ME I WOULD NEED A NEW ENGINE AFTER THE WARRANTY EXPIRED. I …
Read full complaint
COOLANT LEAKS INTO THE ENGINE IN THE 2003 LAND ROVER FREELANDER. PROBLEM STARTED AT 25,000 MILES AND WAS DISMISSED BY THE LAND ROVER DEALER (FRANKEL LAND ROVER- HUNT VALLEY) WHO I BOUGHT THE CAR FROM. I BOUGHT IT BRAND NEW. EVENTUALLY AT ABOUT 60,000 MILES THEY TOLD ME I WOULD NEED A NEW ENGINE AFTER THE WARRANTY EXPIRED. I CONTINUED TO FILL THE COOLANT CHAMBER DAILY AND DROVE IT UNTIL IT COMPLETELY FAILED AT 103,000 MILES WHILE I WAS DRIVING ON THE BALTIMORE BELTWAY (695) AT 60 MPH. FREELANDER K-SERIES ENGINES HAVE BEEN KNOWN TO DROP THE CYLINDER LINERS INTO THE BLOCK. BECAUSE THE LINERS ARE STEEL AND THE BLOCK IS ALLOY, THE LINERS BEING HARDER, WORK THEIR WAY INTO THE BLOCK. THIS IS DUE TO THE ENGINE BLOCK AND CYLINDER HEAD BEING COMPOSED OF DIFFERENT MATERIALS THAT EXPAND AT DIFFERENT RATES WITH HEAT GENERATED DURING RUNNING OF THE VEHICLE. THIS CAN CAUSE THE HEAD GASKET TO FAIL. THE HEAD GASKET/CYLINDER LINER DESIGN FAULT HAS NOT BEEN CLASSIFIED AS A RECALL. *TR
NHTSA ODI #10289998
107,650 miles · Sep 16, 2009
Engine And Engine CoolingFuel System, GasolineLatches/locks/linkages
THE 2003 LANDROVER FREELANDER STALLED ON 2 SEPERATE OCASSIONS,ONCE IN AN ACTIVE INTERSECTION WITH BARELY MISSING BEING STRUCK BY ANOTHER VEHICLE. THE 2ND TIME OCURRED ABOUT 4 MINUTES BEFORE THE PREVIOUS INSTANCE. ADDITIONALLY,THE VEHICLE AS A WHOLE SHOULDN'T BE ON THE HIGHWAY. TO MY KNOWLEDGE THIS VEHICLE HAS NEVER BEEN IN AN AC…
Read full complaint
THE 2003 LANDROVER FREELANDER STALLED ON 2 SEPERATE OCASSIONS,ONCE IN AN ACTIVE INTERSECTION WITH BARELY MISSING BEING STRUCK BY ANOTHER VEHICLE. THE 2ND TIME OCURRED ABOUT 4 MINUTES BEFORE THE PREVIOUS INSTANCE. ADDITIONALLY,THE VEHICLE AS A WHOLE SHOULDN'T BE ON THE HIGHWAY. TO MY KNOWLEDGE THIS VEHICLE HAS NEVER BEEN IN AN ACCIDENT AND IT'S UNCERTAIN IF IT MAY BE REFURBISHED FROM A AREA WHERE DAMAGE WAS SUCH THAT SOME WORK AND RELOCATION PRESENTED IT FOR SALE ELSEWHERE. THE VEHICLE PURCHASED AT A LITTLE OVER 73,000 MILES HAS BEEN IN THE SHOP 14 TIMES IN 27 MONTHS TOTALLING WELL OVER $10,000 IN REPAIRS. I PAID $12,288 FOR THE VEHICLE. INTAKE MANIIFOLD GASKETS,CYLINDER HEAD GASKETS, HEAD BOLTS,CAM BOLTS, THE FAMED "COOLANT LEAK" THAT HAS COOLANT LEAKING INTO THE ENGINE CAUSING IT TO CEASE UP. THAT'S THE ONLY THING THAT HASN'T HAPPENED MECHANICALLY WITH THIS VEHICLE. I RIDE AROUND, WHEN IT'S NOT IN THE SHOP,WITH COOLANT IN THE BACK IN CASE ITS STARTS TO STEAM AGAIN. LOCK ASSEMBLYS (2X), TORQUE CONVERTER MOTOR,THEMOSTAT AND SEVERAL OTHER ISSUES THAT MAKE IT NON-HIGHWAY WORTHY. THIS IS JUST MINE, AT THE EMUNDS.COM AUTOMOTIVE FORUM AMONG THE MANY OTHERS I VISITED THERE ARE HUNDREDS OF OTHERS WITH THE SAME PROBLEMS AND ARE LEFT WITH EITHER, BROKEN DOWN SITTING IN THE DRIVEWAY, IN THE DRIVEWAY AFTER ITS LAST REPAIR SO MILES ARE KEPT LOW FOR RESALE OR FORCED TO PROCURE ANOTHER VEHICLE OR MODE OF TRANSPORTATION, OR FORCED TO CONTINUE DRIVING IT AS ITS THEIR ONLY SOURCE OF TRANSPORTATION AND LOW RESOURCES WHILE STILL PAYING A LOAN ON IT AND AN EXTENDED WARRANTY COMPANY THAT YOU HOPE DOESN'T DANCE AROUND THE RESPONSIBILITY OF PAYING FOR REPAIRS THAT ARE OBVIOUS COVERED ITEMS IN THE WARRANTY. FINALLY, IF IT WEREN'T BAD ENOUGH TO BE STUCK WITH THIS VEHICLE AND NOT KNOW IF IT WILL REMAIN OPERABLE FOR THE LENGTH OF THE LOAN,CURRENTLY 48 MONTHS, I CAN'T EVEN RELY ON THE VEHICLE TO SAFELY TRANSPORT MY WIFE AND DAUGTHER. LANDROVER MECHANICS CAN'T KEEP THESE VEHICLES ON THE ROAD. *TR
NHTSA ODI #10284242
82,000 miles · Sep 13, 2009
Engine And Engine Cooling
ENGINE NEEDED TO BE REPLACED. MECHANIC SAID THAT THE COOLANT WAS GOING INTO ENGINE AND MIXING WITH THE OIL CAUSING OIL PRESSURE TO DROP. ALSO PISTONS WERE CRACKED BECAUSE ENGINE WAS RUNNING TO HOT (POSSIBLE CAUSE). I HAVE NUMEROUS PROBLEMS WITH THIS CAR WINDOWS, LEFT PASSENGER DOOR JAMS UP, THERMOSTAT NEEDED TO BE REPLACED, FUE…
Read full complaint
ENGINE NEEDED TO BE REPLACED. MECHANIC SAID THAT THE COOLANT WAS GOING INTO ENGINE AND MIXING WITH THE OIL CAUSING OIL PRESSURE TO DROP. ALSO PISTONS WERE CRACKED BECAUSE ENGINE WAS RUNNING TO HOT (POSSIBLE CAUSE). I HAVE NUMEROUS PROBLEMS WITH THIS CAR WINDOWS, LEFT PASSENGER DOOR JAMS UP, THERMOSTAT NEEDED TO BE REPLACED, FUEL PUMP NEEDED TO BE REPLACED AFTER CAR STALLED WHILE I WAS DRIVING, BRAKE LIGHTS WERE MALFUNCTIONING DEALERSHIP SAID I HAD REPLACED WRONG BULB ON ONE BRAKE LIGHT AND THAT CAUSED MALFUNCTION. I FOUND OUT AFTER SHELLING OUT 400 DOLLARS THAT THERE WAS A RECALL ON BRAKES. I HAVE ALSO HAD TO REPLACE BATTERY THE BATTERY TWICE IN THE FIVE YEARS I HAVE OWNED THIS CAR. ALL WINDOW MOTORS HAD TO BE WORKED ON FRONT RIGHT TWICE. *TR
NHTSA ODI #10283811
Mileage unknown · Sep 10, 2009
Engine And Engine CoolingService Brakes, Hydraulic
WELL I HAVE HAD SEVERAL PROBLEMS WITH THE LANDROVER. ITS A HORRIBLE CAR, I HAVE ALREADY REPLACED THE ENGINE TWICE, ALONG WITH A FAULTY BRAKE LIGHT THAT WAS LATER RECALLED. THIS SUMMER, MY CAR BEGAN TO SMOKE AND OVERHEAT I IMMEDIATELY TOOK IT TO THE SHOP I WAS TOLD THERE HAD BEEN A CRACK AND THE COOLANT WAS LEAKI…
Read full complaint
WELL I HAVE HAD SEVERAL PROBLEMS WITH THE LANDROVER. ITS A HORRIBLE CAR, I HAVE ALREADY REPLACED THE ENGINE TWICE, ALONG WITH A FAULTY BRAKE LIGHT THAT WAS LATER RECALLED. THIS SUMMER, MY CAR BEGAN TO SMOKE AND OVERHEAT I IMMEDIATELY TOOK IT TO THE SHOP I WAS TOLD THERE HAD BEEN A CRACK AND THE COOLANT WAS LEAKING INTO MY ENGINE. THEY FIXED THE VEHICLE, A WEEK LATER THE CRACK CAME BACK BUT THIS TIME MY SIXTEEN YEAR OLD DAUGHTER WAS DRIVING AND IT BEGAN TO SMOKE LEAVING HER STRANDED ON THE FREEWAY. I AGAIN TOOK IT TO THE SHOP AND IT WAS FIXED THEY REPLACED THE PIPE AND FIXED THE CRACK. 2 DAYS LATER THE SAME THING HAPPENED SHE WAS AGAIN STRANDED ON THE FREEWAY, AND IT WAS TAKEN BACK TO THE SHOP. WE WERE TOLD BY OUR MECHANIC THAT I NOW NEEDED TO REPLACE MY ENGINE FOR THE THIRD TIME AND IT WAS A COMPLETE LEMON. I CALLED LANDROVER AND THEY WERE VERY RUDE, AND SAID THEY COULD DO NOTHING. I BEGAN TO READ REVIEWS ABOUT THE VEHICLE AND THIS APPARENTLY HAS HAPPENED TO ABOUT 85 % OF THE VEHICLES. PLEASE RECALL THIS CAR SO PEOPLE KNOW THE DANGERS OF THIS VEHICLE , AND ME AND THE REST OF THE LANDROVER OWNERS CAN GET JUSTICE! *TR
NHTSA ODI #10283589
70,000 miles · Sep 4, 2009
Engine And Engine Cooling
CAR LOST POWER ON HIGHWAY AFTER DRIVING 10 MILES AT SPEED OF 65-70 MPH, EXITING THE HIGHWAY. TEMPERATURE GAUGE SHOWED HIGH TEMPERATURE ONLY WHEN DECREASING SPEED. COOLANT WAS SMELLED IN THE ENGINE COMPARTMENT. CAR WAS TOWED TO REPAIR SHOP. REPAIR SHOP DID NOT HAVE PROPER EQUIPMENT. LAND ROVER OF ST.LOUIS WAS CALLED. REPAIR …
Read full complaint
CAR LOST POWER ON HIGHWAY AFTER DRIVING 10 MILES AT SPEED OF 65-70 MPH, EXITING THE HIGHWAY. TEMPERATURE GAUGE SHOWED HIGH TEMPERATURE ONLY WHEN DECREASING SPEED. COOLANT WAS SMELLED IN THE ENGINE COMPARTMENT. CAR WAS TOWED TO REPAIR SHOP. REPAIR SHOP DID NOT HAVE PROPER EQUIPMENT. LAND ROVER OF ST.LOUIS WAS CALLED. REPAIR DEPT. TOLD ME THAT THE REPAIR WOULD TOTAL MORE THAN THE VEHICLE WAS WORTH, THE ENGINE HAD KNOWN PROBLEMS FOR THAT MODEL YEAR. NOTHING HAS BEEN DONE, DUE TO LACK OF FUNDS AND THE ADVICE OF THE REPAIR SHOP. *TR
NHTSA ODI #10282841
53,000 miles · Aug 30, 2009
Engine And Engine Cooling
2003 LANDROVER FREELANDER WITH 35000 WHEN PROBLEMS STARTED. CHECK ENGINE LIGHT CAME ON SOON AFTER PURCHASE. CAR WOULDN'T HOLD COOLANT AND CONSTANTLY OVERHEATED. WE DROVE IT AS LITTLE AS POSSIBLE. ENGINE BLEW ON HIGHWAY. CERTIFIED MECHANIC SAID IT WAS BECAUSE OF THE HEAD GASKET AND THAT ENGINE NEEDED REPLACED FOR APPROX $6500. *T…
Read full complaint
2003 LANDROVER FREELANDER WITH 35000 WHEN PROBLEMS STARTED. CHECK ENGINE LIGHT CAME ON SOON AFTER PURCHASE. CAR WOULDN'T HOLD COOLANT AND CONSTANTLY OVERHEATED. WE DROVE IT AS LITTLE AS POSSIBLE. ENGINE BLEW ON HIGHWAY. CERTIFIED MECHANIC SAID IT WAS BECAUSE OF THE HEAD GASKET AND THAT ENGINE NEEDED REPLACED FOR APPROX $6500. *TR
NHTSA ODI #10282343
Official recalls
5Feb 9, 2007
ON CERTAIN SPORT UTILITY VEHICLES, THE BRAKE LIGHTS MAY REMAIN ILLUMINATED EVEN WHEN THE BRAKE PEDAL IS NOT DEPRESSED. HILL DESCENT CONTROL (HDC), TRACTION CONTROL (TC) AND CRUISE CONTROL WARNING LIGHTS MAY ALSO BE ILLUMINATED.
Consequence & remedy
Consequence: FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSPECT THE BRAKE LAMP OPERATION AND WHERE REQUIRED, ADJUST AND/OR REPLACE THE BRAKE LIGHT SWITCHES WITH NEW SWITCHES OF THE SAME DESIGN UNTIL A NEWLY DESIGNED BRAKE LAMP SWITCH IS AVAILABLE IN MAY 2007. OWNERS WILL THEN BE RE-NOTIFIED TO BRING THEIR VEHICLES IN FOR THE NEW BRAKE LIGHT SWITCH. AN INTERIM LETTER FOR THE INITIAL INSPECTION WAS MAILED ON MARCH 26, 2007. THE SECOND LETTER FOR REPLACEMENT OF THE SWITCHES WAS MAILED BEGINNING JULY 30, 2007. OWNERS MAY CONTACT LAND ROVER AT 1-80-637-6837.
Jun 28, 2005
ON CERTAIN FIVE DOOR SPORT UTILITY VEHICLES, IT IS POSSIBLE TO OPERATE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR WHEN THE CHILD SAFETY LEVER IS IN THE "ON" POSITION.
Consequence & remedy
Consequence: THE OCCUPANT MAY OPEN THE DOOR INADVERTENTLY WHILE THE VEHICLE IS IN MOTION AND FALL OUT INTO THE TRAFFIC, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSPECT AND REPLACE THE LATCH ASSEMBLY. THE RECALL BEGAN ON SEPTEMBER 8, 2005. OWNERS SHOULD CONTACT LAND ROVER AT 1-800-637-6837.
Oct 7, 2004
ON CERTAIN SPORT UTILITY VEHICLES, AN INCORRECT WELD NUT WAS INSTALLED. LACK OF THIS BOLT COULD EVENTUALLY CAUSE THE SUBFRAME TO CRACK OR BECOME DEFORMED.
Consequence & remedy
Consequence: A CRACKED OR DEFORMED SUBFRAME COULD POTENTIALLY LEAD TO INSTABILITY OF THE VEHICLE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE VEHICLE TO SEE IF THE SUBFRAME FIXING IS CORRECTLY FITTED AND CLAMPED UP. IF NECESSARY, THE SUBFRAME WILL BE REPLACED WITH A NEW ONE THAT HAS CORRECT WELD NUTS. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE. OWNERS SHOULD CONTACT LAND ROVER AT 1-800-637-6837.
Jul 12, 2004
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT MARGINALLY ABOVE THE PERMITTED 1000 HEAD IMPACT CRITERIA. AT THE LEFT AND RIGHT HAND A-PILLAR TRIM AREA.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL REPLACE THE A-PILLAR TRIM WITH A REVISED COMPONENT THAT ENABLES THE VEHICLE TO FULLY MEET THE REQUIREMENTS OF FMVSS 201. THE RECALL BEGAN ON DECEMBER 6, 2005. OWNERS SHOULD CONTACT LAND ROVER AT 1-800-637-6837.
May 5, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE CHILD DOOR LOCK ON THE LEFT HAND REAR DOOR CAN BECOME DISENGAGED.
Consequence & remedy
Consequence: THIS COULD LEAD TO A CHILD BEING ABLE TO OPEN A REAR DOOR WHILE THE VEHICLE IS IN MOTION, INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL REPLACE THE LEFT HAND REAR LATCH. THE RECALL BEGAN DECEMBER 4, 2004. OWNERS SHOULD CONTACT LAND ROVER AT 1-800-637-6837.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA07018 · Fuel Pump Failure - Stall
Opened Dec 7, 2007 · Closed Dec 22, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
SUBJECT COMPONENT FAILURES FOUND THAT CAN OCCUR AT ANY SPEED AND GENERALLY RESULT IN A NO RESTART CONDITION.THESE ARE GENERALLY CONSIDERED TO BE FACTORS THAT INCREASE THE POTENTIAL SEVERITY OF STALLING INCIDENTS.HOWEVER, THESE INCIDENTS HAVE OCCURRED AT RELATIVELY LOW RATES IN THE SUBJECT VEHICLE POPULATION WHEN COMPARED WITH PRIOR INVESTIGATIONS INVOLVING SIMILAR CATEGORIES OF ENGINE STALL CONSEQUENCES.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR MORE INFORMATION ABOUT THIS INVESTIGATION.
PE07036 · Fuel Pump Failure
Opened Jul 17, 2007 · Closed Dec 10, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE07-036 ON JULY 17, 2007, BASED ON THREE CONSUMER COMPLAINTS ALLEGING INCIDENTS OF SUDDEN ENGINE STALL WHILE DRIVING DUE TO FUEL PUMP FAILURE IN MODEL YEAR (MY) 2003 LAND ROVER FREELANDER VEHICLES.IN EACH INCIDENT THE VEHICLE COULD NOT BE RESTARTED AND HAD TO BE TOWED FOR REPAIRS. IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, FORD PROVIDED OWNER COMPLAINT INFORMATION, FIELD REPORTS AND WARRANTY CLAIM DATA FOR APPROXIMATELY 9,985 SUBJECT VEHICLES SOLD IN THE UNITED STATES.THE BASE WARRANTY FOR THE SUBJECT VEHICLES IS 48 MONTHS OR 50,000 MILES, WHICHEVER OCCURS FIRST.FORD CATEGORIZED THE DATA BY ENGINE STALLS THAT OCCURRED WHILE DRIVING, ENGINE STALLS WITH AN UNKNOWN DRIVING CONDITION, NO START CONDITIONS AND OTHER DRIVEABILITY CONDITIONS. ODI'S ANALYSIS SHOWED THAT THE SUBJECT VEHICLES HAVE EXPERIENCED A 6.7% FUEL PUMP WARRANTY CLAIM RATE FOR ALL CONDITIONS AFTER APPROXIMATELY 4 TO 5 YEARS OF SERVICE, INCLUDING 1.4% CATEGORIZED AS A STALL WHILE DRIVING EVENT AND 2.1% CATEGORIZED AS A STALL WITH AN UNKNOWN DRIVING CONDITION.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-018) TO FURTHER ASSESS THE FREQUENCY AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Additional source detail variants (2)
Fuel System, Gasoline:delivery:fuel Pump
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE07-036 ON JULY 17, 2007, BASED ON THREE CONSUMER COMPLAINTS ALLEGING INCIDENTS OF SUDDEN ENGINE STALL WHILE DRIVING DUE TO FUEL PUMP FAILURE IN MODEL YEAR (MY) 2003 LAND ROVER FREELANDER VEHICLES.IN EACH INCIDENT THE VEHICLE COULD NOT BE RESTARTED AND HAD TO BE TOWED FOR REPAIRS. IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, FORD PROVIDED OWNER COMPLAINT INFORMATION, FIELD REPORTS AND WARRANTY CLAIM DATA FOR APPROXIMATELY 9,985 SUBJECT VEHICLES SOLD IN THE UNITED STATES.THE BASE WARRANTY FOR THE SUBJECT VEHICLES IS 48 MONTHS OR 50,000 MILES, WHICHEVER OCCURS FIRST.FORD CATEGORIZED THE DATA BY ENGINE STALLS THAT OCCURRED WHILE DRIVING, ENGINE STALLS WITH AN UNKNOWN DRIVING CONDITION, NO START CONDITIONS AND OTHER DRIVEABILITY CONDITIONS. ODI'S ANALYSIS SHOWED THAT THE SUBJECT VEHICLES HAVE EXPERIENCED A 6.7% FUEL PUMP WARRANTY CLAIM RATE FOR ALL CONDITIONS AFTER APPROXIMATELY 4 TO 5 YEARS OF SERVICE, INCLUDING 1.4% CATEGORIZED AS A STALL WHILE DRIVING EVENT AND 2.1% CATEGORIZED AS A STALL WITH AN UNKNOWN DRIVING CONDITION.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-018) TO FURTHER ASSESS THE FREQUENCY AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Fuel System, Gasoline:delivery
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE07-036 ON JULY 17, 2007, BASED ON THREE CONSUMER COMPLAINTS ALLEGING INCIDENTS OF SUDDEN ENGINE STALL WHILE DRIVING DUE TO FUEL PUMP FAILURE IN MODEL YEAR (MY) 2003 LAND ROVER FREELANDER VEHICLES.IN EACH INCIDENT THE VEHICLE COULD NOT BE RESTARTED AND HAD TO BE TOWED FOR REPAIRS. IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, FORD PROVIDED OWNER COMPLAINT INFORMATION, FIELD REPORTS AND WARRANTY CLAIM DATA FOR APPROXIMATELY 9,985 SUBJECT VEHICLES SOLD IN THE UNITED STATES.THE BASE WARRANTY FOR THE SUBJECT VEHICLES IS 48 MONTHS OR 50,000 MILES, WHICHEVER OCCURS FIRST.FORD CATEGORIZED THE DATA BY ENGINE STALLS THAT OCCURRED WHILE DRIVING, ENGINE STALLS WITH AN UNKNOWN DRIVING CONDITION, NO START CONDITIONS AND OTHER DRIVEABILITY CONDITIONS. ODI'S ANALYSIS SHOWED THAT THE SUBJECT VEHICLES HAVE EXPERIENCED A 6.7% FUEL PUMP WARRANTY CLAIM RATE FOR ALL CONDITIONS AFTER APPROXIMATELY 4 TO 5 YEARS OF SERVICE, INCLUDING 1.4% CATEGORIZED AS A STALL WHILE DRIVING EVENT AND 2.1% CATEGORIZED AS A STALL WITH AN UNKNOWN DRIVING CONDITION.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-018) TO FURTHER ASSESS THE FREQUENCY AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
EA05016 · Brake Light Switch Failure
Opened Oct 14, 2005 · Closed Feb 22, 2007
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
ON JUNE 16, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE05-034) TO INVESTIGATE ALLEGED STOP LAMP (BRAKE) SWITCH FAILURES IN CERTAIN MODEL YEAR (MY) 2004 LAND ROVER DISCOVERY SERIES II VEHICLES.ON OCTOBER 14, 2005, THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS AND THE SCOPE EXPANDED TO INCLUDE CERTAIN MY 2002 THROUGH 2005 FREELANDER VEHICLES THAT USE A SUBSTANTIALLY SIMILAR SELF-ADJUSTING STOP LAMP SWITCH FURNISHED BY THE SAME SUPPLIER, METHODE ELECTRONICS MALTA, LTD. (METHODE).IN SEPTEMBER 2003, METHODE MOVED THE PRODUCTION OF AN INTERNAL SWITCH COMPONENT, KNOWN AS THE SLIDER MECHANISM, FROM A VALIDATED PLASTIC INJECTION-MOLDING TOOL (?CAVITY 1?) TO ANOTHER TOOL (?CAVITY 2?) THAT HAD NOT BEEN USED BEFORE TO PRODUCE PARTS FOR LAND ROVER.SLIDERS FROM CAVITY 2 MAY BE CHARACTERIZED BY POOR FILL, LACK OF DEFINITION IN THE SLIDER TEETH AND DIMENSIONAL INSTABILITY.CONSEQUENTLY, THE SLIDER MAY BE UNABLE TO RESTRAIN IMPROPER MOVEMENT OF THE PLUNGER DURING NORMAL BRAKE PEDAL OPERATION.THIS MAY CAUSE THE SWITCH TO FALL OUT OF ADJUSTMENT, THUS SIGNIFICANTLY REDUCING THE EFFORT REQUIRED TO ENERGIZE THE SWITCH AND ILLUMINATE THE STOP LAMPS.?CAVITY 2? SWITCHES WERE INSTALLED IN APPROXIMATELY 8,763 DISCOVERY SUBJECT VEHICLES BUILT FROM DECEMBER 2003 THROUGH MAY 2004 AND APPROXIMATELY 3,915 FREELANDER SUBJECT VEHICLES BUILT FROM OCTOBER 2003 THROUGH MAY 2004.ADDITIONALLY, STOP LAMP SWITCHES IN CERTAIN MY 2002 THROUGH 2005 FREELANDER SUBJECT VEHICLES MAY SLIP OUT OF ADJUSTMENT AS A RESULT OF SWITCH DAMAGE DUE TO AN INCORRECT SETTING PROCEDURE DURING VEHICLE MANUFACTURE OR AS A RESULT OF SWITCH MOUNTING BRACKET FLEX.ANALYSIS OF ALL AVAILABLE DATA INDICATES THE PREDOMINANT FAILURE MODE IS CONSTANT STOP LAMP ILLUMINATION.OTHER REPORTED CONSEQUENCES OF STOP LAMP SWITCH MALADJUSTMENT INCLUDE INOPERATIVE AUTOMATIC TRANSMISSION GEAR SELECTOR/BRAKE PEDAL SHIFT INTERLOCK, INOPERATIVE SPEED (CRUISE) CONTROL, AND TELLTALE ILLUMINATION AS DESCRIBED IN TECHNICAL SERVICE BULLETIN (TSB) NO. LT206-001 DATED OCTOBER 28, 2004 ISSUED BY THE MANUFACTURER TO LAND ROVER DEALERS IN THE UNITED KINGDOM (UK).TO DATE, ODI IS AWARE OF 77 NON-DUPLICATIVE COMPLAINTS THAT ALLEGE STOP LAMP SWITCH FAILURE ON THE SUBJECT VEHICLES (10 COMPLAINTS ON MY 2004 DISCOVERY, 45 ON MY 2002 FREELANDER, 19 ON MY 2003 FREELANDER, AND 3 ON MY 2004 FREELANDER VEHICLES).ADDITIONALLY, 4,595 DISCOVERY AND 13,370 FREELANDER SUBJECT VEHICLES HAVE EXPERIENCED ONE OR MORE WARRANTY CLAIMS TO REPLACE THE STOP LAMP SWITCH.OF THE 5,170 WARRANTY CLAIMS PAID TO REPLACE STOP LAMP SWITCHES ON DISCOVERY SUBJECT VEHICLES, APPROXIMATELY 31% OCCURRED BEFORE THE VEHICLE WAS SOLD NEW AND APPROXIMATELY 88% OCCURRED WITHIN THE FIRST 12 MONTHS OF VEHICLE SERVICE.THE WARRANTY TREND ON DISCOVERY SUBJECT VEHICLES IS IN DECLINE WITH 3,545 CLAIMS PAID IN CALENDAR YEAR (CY) 2004, 1,303 CLAIMS PAID IN CY 2005, AND 322 CLAIMS PAID IN CY 2006 THROUGH SEPTEMBER 28, 2006 (WHICH IS WHEN ODI LAST RECEIVED UPDATED WARRANTY CLAIMS DATA FROM LAND ROVER), AND IT APPEARS THAT THE ALLEGED DEFECT ON DISCOVER SUBJECT VEHICLES HAS BEEN REMEDIED THROUGH WARRANTY REPAIRS.HOWEVER, ODI ANALYSIS OF THE MANUFACTURER?S WARRANTY AND COMPLAINT RECORDS INDICATES THE FAILURE TREND ON CERTAIN FREELANDER SUBJECT VEHICLES IS ONGOING.BY LETTER DATED FEBRUARY 2, 2007, LAND ROVER HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 07V-041) TO REPLACE DEFECTIVE STOP LAMP SWITCHES IN APPROXIMATELY 33,247 MY 2002 THROUGH 2005 FREELANDER VEHICLES BUILT AT THE SOLIHULL, UK ASSEMBLY PLANT FROM SEPTEMBER 5, 2001 THROUGH MAY 19, 2005. ALTHOUGH ODI HAS CONCERN
Additional source detail variants (2)
Exterior Lighting:brake Lights
ON JUNE 16, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE05-034) TO INVESTIGATE ALLEGED STOP LAMP (BRAKE) SWITCH FAILURES IN CERTAIN MODEL YEAR (MY) 2004 LAND ROVER DISCOVERY SERIES II VEHICLES.ON OCTOBER 14, 2005, THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS AND THE SCOPE EXPANDED TO INCLUDE CERTAIN MY 2002 THROUGH 2005 FREELANDER VEHICLES THAT USE A SUBSTANTIALLY SIMILAR SELF-ADJUSTING STOP LAMP SWITCH FURNISHED BY THE SAME SUPPLIER, METHODE ELECTRONICS MALTA, LTD. (METHODE).IN SEPTEMBER 2003, METHODE MOVED THE PRODUCTION OF AN INTERNAL SWITCH COMPONENT, KNOWN AS THE SLIDER MECHANISM, FROM A VALIDATED PLASTIC INJECTION-MOLDING TOOL (?CAVITY 1?) TO ANOTHER TOOL (?CAVITY 2?) THAT HAD NOT BEEN USED BEFORE TO PRODUCE PARTS FOR LAND ROVER.SLIDERS FROM CAVITY 2 MAY BE CHARACTERIZED BY POOR FILL, LACK OF DEFINITION IN THE SLIDER TEETH AND DIMENSIONAL INSTABILITY.CONSEQUENTLY, THE SLIDER MAY BE UNABLE TO RESTRAIN IMPROPER MOVEMENT OF THE PLUNGER DURING NORMAL BRAKE PEDAL OPERATION.THIS MAY CAUSE THE SWITCH TO FALL OUT OF ADJUSTMENT, THUS SIGNIFICANTLY REDUCING THE EFFORT REQUIRED TO ENERGIZE THE SWITCH AND ILLUMINATE THE STOP LAMPS.?CAVITY 2? SWITCHES WERE INSTALLED IN APPROXIMATELY 8,763 DISCOVERY SUBJECT VEHICLES BUILT FROM DECEMBER 2003 THROUGH MAY 2004 AND APPROXIMATELY 3,915 FREELANDER SUBJECT VEHICLES BUILT FROM OCTOBER 2003 THROUGH MAY 2004.ADDITIONALLY, STOP LAMP SWITCHES IN CERTAIN MY 2002 THROUGH 2005 FREELANDER SUBJECT VEHICLES MAY SLIP OUT OF ADJUSTMENT AS A RESULT OF SWITCH DAMAGE DUE TO AN INCORRECT SETTING PROCEDURE DURING VEHICLE MANUFACTURE OR AS A RESULT OF SWITCH MOUNTING BRACKET FLEX.ANALYSIS OF ALL AVAILABLE DATA INDICATES THE PREDOMINANT FAILURE MODE IS CONSTANT STOP LAMP ILLUMINATION.OTHER REPORTED CONSEQUENCES OF STOP LAMP SWITCH MALADJUSTMENT INCLUDE INOPERATIVE AUTOMATIC TRANSMISSION GEAR SELECTOR/BRAKE PEDAL SHIFT INTERLOCK, INOPERATIVE SPEED (CRUISE) CONTROL, AND TELLTALE ILLUMINATION AS DESCRIBED IN TECHNICAL SERVICE BULLETIN (TSB) NO. LT206-001 DATED OCTOBER 28, 2004 ISSUED BY THE MANUFACTURER TO LAND ROVER DEALERS IN THE UNITED KINGDOM (UK).TO DATE, ODI IS AWARE OF 77 NON-DUPLICATIVE COMPLAINTS THAT ALLEGE STOP LAMP SWITCH FAILURE ON THE SUBJECT VEHICLES (10 COMPLAINTS ON MY 2004 DISCOVERY, 45 ON MY 2002 FREELANDER, 19 ON MY 2003 FREELANDER, AND 3 ON MY 2004 FREELANDER VEHICLES).ADDITIONALLY, 4,595 DISCOVERY AND 13,370 FREELANDER SUBJECT VEHICLES HAVE EXPERIENCED ONE OR MORE WARRANTY CLAIMS TO REPLACE THE STOP LAMP SWITCH.OF THE 5,170 WARRANTY CLAIMS PAID TO REPLACE STOP LAMP SWITCHES ON DISCOVERY SUBJECT VEHICLES, APPROXIMATELY 31% OCCURRED BEFORE THE VEHICLE WAS SOLD NEW AND APPROXIMATELY 88% OCCURRED WITHIN THE FIRST 12 MONTHS OF VEHICLE SERVICE.THE WARRANTY TREND ON DISCOVERY SUBJECT VEHICLES IS IN DECLINE WITH 3,545 CLAIMS PAID IN CALENDAR YEAR (CY) 2004, 1,303 CLAIMS PAID IN CY 2005, AND 322 CLAIMS PAID IN CY 2006 THROUGH SEPTEMBER 28, 2006 (WHICH IS WHEN ODI LAST RECEIVED UPDATED WARRANTY CLAIMS DATA FROM LAND ROVER), AND IT APPEARS THAT THE ALLEGED DEFECT ON DISCOVER SUBJECT VEHICLES HAS BEEN REMEDIED THROUGH WARRANTY REPAIRS.HOWEVER, ODI ANALYSIS OF THE MANUFACTURER?S WARRANTY AND COMPLAINT RECORDS INDICATES THE FAILURE TREND ON CERTAIN FREELANDER SUBJECT VEHICLES IS ONGOING.BY LETTER DATED FEBRUARY 2, 2007, LAND ROVER HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 07V-041) TO REPLACE DEFECTIVE STOP LAMP SWITCHES IN APPROXIMATELY 33,247 MY 2002 THROUGH 2005 FREELANDER VEHICLES BUILT AT THE SOLIHULL, UK ASSEMBLY PLANT FROM SEPTEMBER 5, 2001 THROUGH MAY 19, 2005. ALTHOUGH ODI HAS CONCERN
Exterior Lighting:brake Lights:switch
ON JUNE 16, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE05-034) TO INVESTIGATE ALLEGED STOP LAMP (BRAKE) SWITCH FAILURES IN CERTAIN MODEL YEAR (MY) 2004 LAND ROVER DISCOVERY SERIES II VEHICLES.ON OCTOBER 14, 2005, THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS AND THE SCOPE EXPANDED TO INCLUDE CERTAIN MY 2002 THROUGH 2005 FREELANDER VEHICLES THAT USE A SUBSTANTIALLY SIMILAR SELF-ADJUSTING STOP LAMP SWITCH FURNISHED BY THE SAME SUPPLIER, METHODE ELECTRONICS MALTA, LTD. (METHODE).IN SEPTEMBER 2003, METHODE MOVED THE PRODUCTION OF AN INTERNAL SWITCH COMPONENT, KNOWN AS THE SLIDER MECHANISM, FROM A VALIDATED PLASTIC INJECTION-MOLDING TOOL (?CAVITY 1?) TO ANOTHER TOOL (?CAVITY 2?) THAT HAD NOT BEEN USED BEFORE TO PRODUCE PARTS FOR LAND ROVER.SLIDERS FROM CAVITY 2 MAY BE CHARACTERIZED BY POOR FILL, LACK OF DEFINITION IN THE SLIDER TEETH AND DIMENSIONAL INSTABILITY.CONSEQUENTLY, THE SLIDER MAY BE UNABLE TO RESTRAIN IMPROPER MOVEMENT OF THE PLUNGER DURING NORMAL BRAKE PEDAL OPERATION.THIS MAY CAUSE THE SWITCH TO FALL OUT OF ADJUSTMENT, THUS SIGNIFICANTLY REDUCING THE EFFORT REQUIRED TO ENERGIZE THE SWITCH AND ILLUMINATE THE STOP LAMPS.?CAVITY 2? SWITCHES WERE INSTALLED IN APPROXIMATELY 8,763 DISCOVERY SUBJECT VEHICLES BUILT FROM DECEMBER 2003 THROUGH MAY 2004 AND APPROXIMATELY 3,915 FREELANDER SUBJECT VEHICLES BUILT FROM OCTOBER 2003 THROUGH MAY 2004.ADDITIONALLY, STOP LAMP SWITCHES IN CERTAIN MY 2002 THROUGH 2005 FREELANDER SUBJECT VEHICLES MAY SLIP OUT OF ADJUSTMENT AS A RESULT OF SWITCH DAMAGE DUE TO AN INCORRECT SETTING PROCEDURE DURING VEHICLE MANUFACTURE OR AS A RESULT OF SWITCH MOUNTING BRACKET FLEX.ANALYSIS OF ALL AVAILABLE DATA INDICATES THE PREDOMINANT FAILURE MODE IS CONSTANT STOP LAMP ILLUMINATION.OTHER REPORTED CONSEQUENCES OF STOP LAMP SWITCH MALADJUSTMENT INCLUDE INOPERATIVE AUTOMATIC TRANSMISSION GEAR SELECTOR/BRAKE PEDAL SHIFT INTERLOCK, INOPERATIVE SPEED (CRUISE) CONTROL, AND TELLTALE ILLUMINATION AS DESCRIBED IN TECHNICAL SERVICE BULLETIN (TSB) NO. LT206-001 DATED OCTOBER 28, 2004 ISSUED BY THE MANUFACTURER TO LAND ROVER DEALERS IN THE UNITED KINGDOM (UK).TO DATE, ODI IS AWARE OF 77 NON-DUPLICATIVE COMPLAINTS THAT ALLEGE STOP LAMP SWITCH FAILURE ON THE SUBJECT VEHICLES (10 COMPLAINTS ON MY 2004 DISCOVERY, 45 ON MY 2002 FREELANDER, 19 ON MY 2003 FREELANDER, AND 3 ON MY 2004 FREELANDER VEHICLES).ADDITIONALLY, 4,595 DISCOVERY AND 13,370 FREELANDER SUBJECT VEHICLES HAVE EXPERIENCED ONE OR MORE WARRANTY CLAIMS TO REPLACE THE STOP LAMP SWITCH.OF THE 5,170 WARRANTY CLAIMS PAID TO REPLACE STOP LAMP SWITCHES ON DISCOVERY SUBJECT VEHICLES, APPROXIMATELY 31% OCCURRED BEFORE THE VEHICLE WAS SOLD NEW AND APPROXIMATELY 88% OCCURRED WITHIN THE FIRST 12 MONTHS OF VEHICLE SERVICE.THE WARRANTY TREND ON DISCOVERY SUBJECT VEHICLES IS IN DECLINE WITH 3,545 CLAIMS PAID IN CALENDAR YEAR (CY) 2004, 1,303 CLAIMS PAID IN CY 2005, AND 322 CLAIMS PAID IN CY 2006 THROUGH SEPTEMBER 28, 2006 (WHICH IS WHEN ODI LAST RECEIVED UPDATED WARRANTY CLAIMS DATA FROM LAND ROVER), AND IT APPEARS THAT THE ALLEGED DEFECT ON DISCOVER SUBJECT VEHICLES HAS BEEN REMEDIED THROUGH WARRANTY REPAIRS.HOWEVER, ODI ANALYSIS OF THE MANUFACTURER?S WARRANTY AND COMPLAINT RECORDS INDICATES THE FAILURE TREND ON CERTAIN FREELANDER SUBJECT VEHICLES IS ONGOING.BY LETTER DATED FEBRUARY 2, 2007, LAND ROVER HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 07V-041) TO REPLACE DEFECTIVE STOP LAMP SWITCHES IN APPROXIMATELY 33,247 MY 2002 THROUGH 2005 FREELANDER VEHICLES BUILT AT THE SOLIHULL, UK ASSEMBLY PLANT FROM SEPTEMBER 5, 2001 THROUGH MAY 19, 2005. ALTHOUGH ODI HAS CONCERN
Illustration