Lamborghini is recalling certain model year 2004-2006 Gallardo Coupe and Spyder vehicles. In certain driving conditions, the high pressure steering pipes near the the steering assistance hydraulic system pump might leak.
Consequence & remedy
Consequence: Leaking fluid, in the presence of an ignition source, could result in a fire.
Remedy: Lamborghini will notify owners, and dealers will update the power steering system free of charge. The safety recall began on September 26, 2012. Owners may contact Lamborghini at 1-866-681-6276.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE08007 · Alleged Engine Compartment Fires
Opened Jan 29, 2008 · Closed Jun 4, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline; Fuel System, Gasoline; Fuel System, Other
THIS PRELIMINARY EVALUATION WAS OPENED TO INVESTIGATE THREE REPORTS OF ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.TWO OF THE REPORTS ALLEGED THAT A FIRE OCCURRED WHILE REFUELING.THE THIRDALLEGES A FIRE OCCURRED WHILE THE CONSUMER WAS DRIVING. INFORMATION PROVIDED BY LAMBORGHINI IN RESPONSE TO ODI'SINFORMATION REQUEST LETTER IDENTIFIED FOUR ADDITIONAL ENGINE COMPARTMENT FIRES INVOLVING THE SUBJECT VEHICLES.FOUR OF THE 7 TOTAL FIRE INCIDENTS REPORTED TO EITHER ODI OR LAMBORGHINI WERE ALLEGED TO BE CAUSED BY RUPTURES OF VARIOUS E-GEAR (HYDRAULIC TRANSMISSION CONTROL SYSTEM) HYDRAULIC FLUID LINES SPRAYING HYDRAULIC FLUID ON HOT EXHAUST COMPONENTS.EACH OF THESE INCIDENTS INVOLVED DIFFERENT E-GEAR HYDRAULIC LINES OR FITTINGS (THERE ARE FIVE HYDRAULIC LINES IN THE E-GEAR SYSTEM) AND A REVIEW OF INCIDENT VEHICLE SERVICE HISTORIES INDICATES THAT PRIOR REPAIRS MAY HAVE BEEN FACTORS IN ALL FOUR OF THESE FIRES. ODI'S ANALYSIS OF THE TWO INCIDENTS OF FIRE THAT OCCURRED WHILE REFUELING DID NOT IDENTIFY ANY VEHICLE FACTORS CONTRIBUTING TO THE FIRES.BASED ON THE INFORMATION PROVIDED AND CONSUMER DESCRIPTIONS OF THE INCIDENTS, ODI CANNOT CONCLUDE THAT THE FIRES ORIGINATED WITHIN THE VEHICLES AND NOT ON THE GROUND IN THE VICINITY OF THE VEHICLES.LAMBORGHINI'S ASSESSMENT OF THE SEVENTH FIRE IS THAT THE DRIVER'S SIDE FUEL RETURN LINE WAS IMPROPERLY RECONNECTED AFTER A FUEL SENDING UNIT REPLACEMENT.SERVICE HISTORY INFORMATION SHOWS THAT THE FIRE OCCURRED 3 DAYS AND 100 MILES AFTER THE SENDING UNIT REPLACEMENT.NO SAFETY RELATED DEFECT TREND HAS BEEN IDENTIFIED IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (5)
Engine And Engine Cooling:engine:gasoline
THIS PRELIMINARY EVALUATION WAS OPENED TO INVESTIGATE THREE REPORTS OF ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.TWO OF THE REPORTS ALLEGED THAT A FIRE OCCURRED WHILE REFUELING.THE THIRDALLEGES A FIRE OCCURRED WHILE THE CONSUMER WAS DRIVING. INFORMATION PROVIDED BY LAMBORGHINI IN RESPONSE TO ODI'SINFORMATION REQUEST LETTER IDENTIFIED FOUR ADDITIONAL ENGINE COMPARTMENT FIRES INVOLVING THE SUBJECT VEHICLES.FOUR OF THE 7 TOTAL FIRE INCIDENTS REPORTED TO EITHER ODI OR LAMBORGHINI WERE ALLEGED TO BE CAUSED BY RUPTURES OF VARIOUS E-GEAR (HYDRAULIC TRANSMISSION CONTROL SYSTEM) HYDRAULIC FLUID LINES SPRAYING HYDRAULIC FLUID ON HOT EXHAUST COMPONENTS.EACH OF THESE INCIDENTS INVOLVED DIFFERENT E-GEAR HYDRAULIC LINES OR FITTINGS (THERE ARE FIVE HYDRAULIC LINES IN THE E-GEAR SYSTEM) AND A REVIEW OF INCIDENT VEHICLE SERVICE HISTORIES INDICATES THAT PRIOR REPAIRS MAY HAVE BEEN FACTORS IN ALL FOUR OF THESE FIRES. ODI'S ANALYSIS OF THE TWO INCIDENTS OF FIRE THAT OCCURRED WHILE REFUELING DID NOT IDENTIFY ANY VEHICLE FACTORS CONTRIBUTING TO THE FIRES.BASED ON THE INFORMATION PROVIDED AND CONSUMER DESCRIPTIONS OF THE INCIDENTS, ODI CANNOT CONCLUDE THAT THE FIRES ORIGINATED WITHIN THE VEHICLES AND NOT ON THE GROUND IN THE VICINITY OF THE VEHICLES.LAMBORGHINI'S ASSESSMENT OF THE SEVENTH FIRE IS THAT THE DRIVER'S SIDE FUEL RETURN LINE WAS IMPROPERLY RECONNECTED AFTER A FUEL SENDING UNIT REPLACEMENT.SERVICE HISTORY INFORMATION SHOWS THAT THE FIRE OCCURRED 3 DAYS AND 100 MILES AFTER THE SENDING UNIT REPLACEMENT.NO SAFETY RELATED DEFECT TREND HAS BEEN IDENTIFIED IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Engine And Engine Cooling:engine
THIS PRELIMINARY EVALUATION WAS OPENED TO INVESTIGATE THREE REPORTS OF ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.TWO OF THE REPORTS ALLEGED THAT A FIRE OCCURRED WHILE REFUELING.THE THIRDALLEGES A FIRE OCCURRED WHILE THE CONSUMER WAS DRIVING. INFORMATION PROVIDED BY LAMBORGHINI IN RESPONSE TO ODI'SINFORMATION REQUEST LETTER IDENTIFIED FOUR ADDITIONAL ENGINE COMPARTMENT FIRES INVOLVING THE SUBJECT VEHICLES.FOUR OF THE 7 TOTAL FIRE INCIDENTS REPORTED TO EITHER ODI OR LAMBORGHINI WERE ALLEGED TO BE CAUSED BY RUPTURES OF VARIOUS E-GEAR (HYDRAULIC TRANSMISSION CONTROL SYSTEM) HYDRAULIC FLUID LINES SPRAYING HYDRAULIC FLUID ON HOT EXHAUST COMPONENTS.EACH OF THESE INCIDENTS INVOLVED DIFFERENT E-GEAR HYDRAULIC LINES OR FITTINGS (THERE ARE FIVE HYDRAULIC LINES IN THE E-GEAR SYSTEM) AND A REVIEW OF INCIDENT VEHICLE SERVICE HISTORIES INDICATES THAT PRIOR REPAIRS MAY HAVE BEEN FACTORS IN ALL FOUR OF THESE FIRES. ODI'S ANALYSIS OF THE TWO INCIDENTS OF FIRE THAT OCCURRED WHILE REFUELING DID NOT IDENTIFY ANY VEHICLE FACTORS CONTRIBUTING TO THE FIRES.BASED ON THE INFORMATION PROVIDED AND CONSUMER DESCRIPTIONS OF THE INCIDENTS, ODI CANNOT CONCLUDE THAT THE FIRES ORIGINATED WITHIN THE VEHICLES AND NOT ON THE GROUND IN THE VICINITY OF THE VEHICLES.LAMBORGHINI'S ASSESSMENT OF THE SEVENTH FIRE IS THAT THE DRIVER'S SIDE FUEL RETURN LINE WAS IMPROPERLY RECONNECTED AFTER A FUEL SENDING UNIT REPLACEMENT.SERVICE HISTORY INFORMATION SHOWS THAT THE FIRE OCCURRED 3 DAYS AND 100 MILES AFTER THE SENDING UNIT REPLACEMENT.NO SAFETY RELATED DEFECT TREND HAS BEEN IDENTIFIED IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Engine And Engine Cooling
THIS PRELIMINARY EVALUATION WAS OPENED TO INVESTIGATE THREE REPORTS OF ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.TWO OF THE REPORTS ALLEGED THAT A FIRE OCCURRED WHILE REFUELING.THE THIRDALLEGES A FIRE OCCURRED WHILE THE CONSUMER WAS DRIVING. INFORMATION PROVIDED BY LAMBORGHINI IN RESPONSE TO ODI'SINFORMATION REQUEST LETTER IDENTIFIED FOUR ADDITIONAL ENGINE COMPARTMENT FIRES INVOLVING THE SUBJECT VEHICLES.FOUR OF THE 7 TOTAL FIRE INCIDENTS REPORTED TO EITHER ODI OR LAMBORGHINI WERE ALLEGED TO BE CAUSED BY RUPTURES OF VARIOUS E-GEAR (HYDRAULIC TRANSMISSION CONTROL SYSTEM) HYDRAULIC FLUID LINES SPRAYING HYDRAULIC FLUID ON HOT EXHAUST COMPONENTS.EACH OF THESE INCIDENTS INVOLVED DIFFERENT E-GEAR HYDRAULIC LINES OR FITTINGS (THERE ARE FIVE HYDRAULIC LINES IN THE E-GEAR SYSTEM) AND A REVIEW OF INCIDENT VEHICLE SERVICE HISTORIES INDICATES THAT PRIOR REPAIRS MAY HAVE BEEN FACTORS IN ALL FOUR OF THESE FIRES. ODI'S ANALYSIS OF THE TWO INCIDENTS OF FIRE THAT OCCURRED WHILE REFUELING DID NOT IDENTIFY ANY VEHICLE FACTORS CONTRIBUTING TO THE FIRES.BASED ON THE INFORMATION PROVIDED AND CONSUMER DESCRIPTIONS OF THE INCIDENTS, ODI CANNOT CONCLUDE THAT THE FIRES ORIGINATED WITHIN THE VEHICLES AND NOT ON THE GROUND IN THE VICINITY OF THE VEHICLES.LAMBORGHINI'S ASSESSMENT OF THE SEVENTH FIRE IS THAT THE DRIVER'S SIDE FUEL RETURN LINE WAS IMPROPERLY RECONNECTED AFTER A FUEL SENDING UNIT REPLACEMENT.SERVICE HISTORY INFORMATION SHOWS THAT THE FIRE OCCURRED 3 DAYS AND 100 MILES AFTER THE SENDING UNIT REPLACEMENT.NO SAFETY RELATED DEFECT TREND HAS BEEN IDENTIFIED IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Gasoline
THIS PRELIMINARY EVALUATION WAS OPENED TO INVESTIGATE THREE REPORTS OF ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.TWO OF THE REPORTS ALLEGED THAT A FIRE OCCURRED WHILE REFUELING.THE THIRDALLEGES A FIRE OCCURRED WHILE THE CONSUMER WAS DRIVING. INFORMATION PROVIDED BY LAMBORGHINI IN RESPONSE TO ODI'SINFORMATION REQUEST LETTER IDENTIFIED FOUR ADDITIONAL ENGINE COMPARTMENT FIRES INVOLVING THE SUBJECT VEHICLES.FOUR OF THE 7 TOTAL FIRE INCIDENTS REPORTED TO EITHER ODI OR LAMBORGHINI WERE ALLEGED TO BE CAUSED BY RUPTURES OF VARIOUS E-GEAR (HYDRAULIC TRANSMISSION CONTROL SYSTEM) HYDRAULIC FLUID LINES SPRAYING HYDRAULIC FLUID ON HOT EXHAUST COMPONENTS.EACH OF THESE INCIDENTS INVOLVED DIFFERENT E-GEAR HYDRAULIC LINES OR FITTINGS (THERE ARE FIVE HYDRAULIC LINES IN THE E-GEAR SYSTEM) AND A REVIEW OF INCIDENT VEHICLE SERVICE HISTORIES INDICATES THAT PRIOR REPAIRS MAY HAVE BEEN FACTORS IN ALL FOUR OF THESE FIRES. ODI'S ANALYSIS OF THE TWO INCIDENTS OF FIRE THAT OCCURRED WHILE REFUELING DID NOT IDENTIFY ANY VEHICLE FACTORS CONTRIBUTING TO THE FIRES.BASED ON THE INFORMATION PROVIDED AND CONSUMER DESCRIPTIONS OF THE INCIDENTS, ODI CANNOT CONCLUDE THAT THE FIRES ORIGINATED WITHIN THE VEHICLES AND NOT ON THE GROUND IN THE VICINITY OF THE VEHICLES.LAMBORGHINI'S ASSESSMENT OF THE SEVENTH FIRE IS THAT THE DRIVER'S SIDE FUEL RETURN LINE WAS IMPROPERLY RECONNECTED AFTER A FUEL SENDING UNIT REPLACEMENT.SERVICE HISTORY INFORMATION SHOWS THAT THE FIRE OCCURRED 3 DAYS AND 100 MILES AFTER THE SENDING UNIT REPLACEMENT.NO SAFETY RELATED DEFECT TREND HAS BEEN IDENTIFIED IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other
THIS PRELIMINARY EVALUATION WAS OPENED TO INVESTIGATE THREE REPORTS OF ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.TWO OF THE REPORTS ALLEGED THAT A FIRE OCCURRED WHILE REFUELING.THE THIRDALLEGES A FIRE OCCURRED WHILE THE CONSUMER WAS DRIVING. INFORMATION PROVIDED BY LAMBORGHINI IN RESPONSE TO ODI'SINFORMATION REQUEST LETTER IDENTIFIED FOUR ADDITIONAL ENGINE COMPARTMENT FIRES INVOLVING THE SUBJECT VEHICLES.FOUR OF THE 7 TOTAL FIRE INCIDENTS REPORTED TO EITHER ODI OR LAMBORGHINI WERE ALLEGED TO BE CAUSED BY RUPTURES OF VARIOUS E-GEAR (HYDRAULIC TRANSMISSION CONTROL SYSTEM) HYDRAULIC FLUID LINES SPRAYING HYDRAULIC FLUID ON HOT EXHAUST COMPONENTS.EACH OF THESE INCIDENTS INVOLVED DIFFERENT E-GEAR HYDRAULIC LINES OR FITTINGS (THERE ARE FIVE HYDRAULIC LINES IN THE E-GEAR SYSTEM) AND A REVIEW OF INCIDENT VEHICLE SERVICE HISTORIES INDICATES THAT PRIOR REPAIRS MAY HAVE BEEN FACTORS IN ALL FOUR OF THESE FIRES. ODI'S ANALYSIS OF THE TWO INCIDENTS OF FIRE THAT OCCURRED WHILE REFUELING DID NOT IDENTIFY ANY VEHICLE FACTORS CONTRIBUTING TO THE FIRES.BASED ON THE INFORMATION PROVIDED AND CONSUMER DESCRIPTIONS OF THE INCIDENTS, ODI CANNOT CONCLUDE THAT THE FIRES ORIGINATED WITHIN THE VEHICLES AND NOT ON THE GROUND IN THE VICINITY OF THE VEHICLES.LAMBORGHINI'S ASSESSMENT OF THE SEVENTH FIRE IS THAT THE DRIVER'S SIDE FUEL RETURN LINE WAS IMPROPERLY RECONNECTED AFTER A FUEL SENDING UNIT REPLACEMENT.SERVICE HISTORY INFORMATION SHOWS THAT THE FIRE OCCURRED 3 DAYS AND 100 MILES AFTER THE SENDING UNIT REPLACEMENT.NO SAFETY RELATED DEFECT TREND HAS BEEN IDENTIFIED IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
2005 Lamborghini Gallardo Problems, Complaints & Recalls | Skip That Year
Illustration