2024 Kia Telluride

The contact owns a 2024 Kia Telluride. The contact stated that while driving 45 MPH, a small rock struck the front windshield, creating a bullet-sized hole in the windshield. Additionally, while driving on the Interstate on two separate occasions, rocks struck the front windshield and caused chips in the windshield. The vehicle was taken to a glass center, where the windshield was replaced. The technician informed the contact that the glass was thin. The contact called the local dealer and was informed that the windshield was thin and there was no recall for the failure. The dealer informed the contact that the glass needed to be replaced and recalibrated. The contact called two other dealers in Texas and retrieved similar information. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 42.

On Thursday, June 5, 2025, I discovered a 2-inch crack at the bottom center of my windshield after my vehicle had been parked in my garage for three consecutive days without being driven. There was no known impact or external force that could have caused the crack. The vehicle remained stationary and protected from environmental elements during this time. On Tuesday, June 10, 2025, I drove the vehicle to a glass repair company at the request of the dealership. While en route, I observed the crack rapidly expand from 2 inches to over 12 inches in length, extending upward and curving toward the driver’s side view area. The glass company inspected the windshield and confirmed there was no evidence of impact damage (e.g., from a rock or debris). Safety Risk: The expanding crack compromised the structural integrity of the windshield and obstructed the driver’s field of vision, posing a potential safety hazard. A weakened windshield may also reduce the effectiveness of airbag deployment and roof support in the event of a collision. Inspection and Confirmation: The issue was evaluated by an independent glass repair company, which confirmed the absence of any impact damage. The dealership referred me to this inspection. The manufacturer has not yet inspected the vehicle directly. Availability for Inspection: Yes, the cracked windshield is still available for inspection upon request. Warning Signs or Symptoms Prior to Failure: There were no warning lamps, messages, or other symptoms prior to the appearance of the crack. The crack was first noticed after the vehicle had been parked and unused for several days.

3rd sear Buckle RH - 3rd row Rear bench right side rear passenger seatbelt anchor/buckle assembly (Right of 3RD Position) is damaged when rear seat is in down-folded position and soft length of seat buckle has slipped back under rear back rest. Receiving buckle is being crushed when seat is in folded position - KIA dealer argues misuse by customer - but fault is with manufacturer as rear buckle can slip below elastic tether because there is no stable anchor length between fixing bolt and tether point. Result is that seat buckle coupling becomes crushed when seat is in folded position. Part Replaced with K 89843 S9510WK

The contact owns a 2024 Kia Telluride. The contact stated while driving at undisclosed speeds, the check engine warning light illuminated. The vehicle was taken to the local dealer for a routine oil change prior to the failure. The vehicle was taken to another local dealer, Van Nuys Kia (6115 Van Nuys Blvd., Van Nuys, CA 91401); where it was diagnosed that the evaporator cooler and charcoal canister were leaking emissions. There was a small leak in the evaporator system. The vehicle was not repaired. The manufacturer was contacted and confirmed that there were no recalls or warranty coverage on the vehicle. The failure mileage was approximately 10,000.

During normal driving conditions, the windshield started cracking halfway up the drivers side horizontally. The crack begins from the edge under the trim and goes almost halfway across. The windshield does not appear to have been damaged in any way and no impacts from rocks. I saw the crack start from the outer edge and travel across the windshield as I was driving. The vehicle is kept in a garage. I contacted the dealer and they told me to contact Kia Customer Service which I am doing later today. This certainly appears to be a defect and is a safety hazard as the glass cracked without any direct cause. The vehicle is available for inspection.