2023 Kia Telluride

On XXX, at approximately 7:40 a.m., my 2023 Kia Telluride, VIN [XXX], experienced a sudden mechanical failure while traveling approximately 65+ mph southbound on [XXX]. The vehicle suddenly locked up, causing the driver to lose control, skid, and swerve toward the side of the freeway. The rear wheels appeared to be locked. Fortunately, no collision occurred and no one was injured. The vehicle was towed for inspection. A technician at Colton Tire advised that the axle appeared to be bent. The vehicle was then transported by flatbed to Allstar Kia in [XXX] for diagnosis. The Kia dealership initially suggested the vehicle must have been involved in an accident because of a minor exterior scrape on the driver's-side rear passenger door. The vehicle has not been involved in an accident or collision. The scrape occurred while slowly maneuvering into a home garage at approximately 1–2 mph and did not involve impact to the wheel, axle, suspension, drivetrain, or differential. The dealership later advised that the technician believed an alleged “accident” caused the differential to slowly leak over time, ultimately causing the axle to bend “pretty badly.” I dispute this conclusion and have requested the complete diagnostic findings and physical evidence in writing. I am reporting this incident because the vehicle suddenly experienced a serious mechanical failure and loss-of-control event at freeway speed. I am also requesting investigation of whether the intermediate shaft, right-front driveshaft, axle, differential, or related drivetrain components could have been affected by NHTSA Safety Recall 24V-214 / Kia Safety Recall SC303, or another mechanical defect. I understand the recall has not been established as the cause of this specific incident. I am asking that the actual cause of the sudden vehicle lockup be investigated because the failure occurred at approximately 65+ mph and could have resulted in a serious crash. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2023 Kia Telluride. The contact received notification of NHTSA Campaign Number: 26V430000 (Seats); however, the part to do the recall repair was not yet available. The dealer was contacted and confirmed that parts were not yet available for the recall repair. The contact was concerned that the recall posed a fire risk, rendering the vehicle unsafe to drive or park. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and denied rental vehicle assistance. The contact had not experienced a failure.

This is an update to my original NHTSA complaint (ID 11755209) regarding an intermittent no-start/no-crank defect on my 2023 Kia Telluride (VIN [XXX]). Since my original filing, the identical defect has recurred twice more, on XXX — once at approximately 1:01–1:30 PM EST and again at approximately 5:03–5:17 PM EST, the same day. In both incidents, the dashboard and infotainment system powered up normally, but the vehicle would not crank, consistent with all prior occurrences dating back to XXX. This brings the total documented occurrences to six between XXX and August 8, 2026, including two in a single day. In both August 8 incidents, my wife was stranded and had to be picked up because the vehicle would not start. This follows a dealer-confirmed and dealer-executed starter replacement (Kia of Cleveland, RO dated XXX, part #36100-3L160) that was performed after the dealer duplicated the fault on the vehicle and on a bench test — and a 4th recurrence on XXX, just 10 days after that repair. I have video evidence of all four August incidents (XXX, and the two on XXX showing the instrument cluster and infotainment fully powered with a no-crank condition. I am providing this update because the frequency of occurrences is escalating — two failures in a single day — despite a repair that was physically confirmed by the dealer's own testing. This strongly suggests the actual root cause (potentially an immobilizer/smart-key system fault, IBU communication failure, or intermittent wiring/ground fault) has not been correctly identified, and the defect continues to pose an unreasonable stranding risk to occupants. I am concurrently pursuing a vehicle replacement request with Kia America under Customer Care Case #26211382. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2023 Kia Telluride (VIN [XXX]) has an intermittent no-start/no-crank defect that has occurred on four separate occasions between [XXX] and [XXX] (mileage range 49,850–51,180). In each occurrence, the dashboard and infotainment system power on normally, but the engine will not crank when the start button is pressed, with both key fobs. The fault clears itself with no consistent trigger, making it undetectable by standard diagnostic scans after the fact. The vehicle was taken to Kia of Cleveland (2492 South Lee Highway, Cleveland, TN 37311) three times. On the first two visits (6/18/26 and 7/1/26) the dealer could not duplicate the fault and returned the vehicle unrepaired. On the third visit (7/17/26–7/27/26), the dealer successfully duplicated the no-start condition both on the vehicle and on a bench test after removing the starter, and replaced the starter under warranty (part #36100-3L160). Despite this confirmed and completed repair, the identical no-start condition recurred on [XXX], only 10 days and approximately 250 miles later. This is a safety issue: on [XXX], my wife was attempting to leave for work with our twin 5-year-old daughters in the vehicle when it failed to start. This is the type of defect that could strand occupants in unsafe locations or conditions (heat, cold, traffic, isolated areas) with no warning and no reliable workaround. I have video evidence of the [XXX] incident showing the vehicle's instrument cluster and infotainment fully powered with a no-crank condition, timestamped and showing the odometer reading. I am filing this complaint because the defect has now defeated a dealer-confirmed and dealer-executed repair, suggesting a root cause (such as an immobilizer/smart-key system fault, IBU communication failure, or intermittent wiring/ground fault) that has not yet been correctly identified. I am concurrently requesting a vehicle replacement from Kia America under Case #[XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

A P0741 warning light comes on and off leading driver to believe the problem is intermittent when in fact it is a torque converter failed. The intermittent nature of the warning light could lead drivers to believe the problem is not a safety issue, particularly on a SUV with only 105,000 miles. However, when a converter fails it is definitely a safety issue.

Driver Assistance Warning (DAW) warning bells and dash sign "Driver Needs a Break" with Coffee Pot showing goes off constantly. Even with safest driving possible, on purpose safest driving, the warning and sounds goes off every few miles and few minutes. KIA dealer has kept car for 2 weeks and say they can not duplicate and I drive it (Perfectly) and it goes off. this is a 2023 Kia telluride , previous year models and later models you could turn off or turn down sensitivity of this warning. KIA eliminated the owner the opportunity to disable or turn down this warning. It is a safety hazard because it is always going off, causing the driver to take his attention from the road to the dash every few minutes with the bells and coffee pot Take A Break Warning . KIA will not do anything about it.