2018 Kia Stinger

The bright lights on both headlights stopped working instantly.. the design is flawed as it operates on a shutter using one bulb.. the malfunction is cause by premature failure of the gears in the shutter. The dealerships are aware of this problem as the shutter is also used in their Telluride vehicles as well… it causes safety issues when driving at night. Kia also knows the problem also the gear in the headlight can’t be replaced and Kia forces to replace whole headlight assembly which is $1200 per light.. on many Stinger forums a lot of people are saying the same problems with their headlights. This is a major safety hazard!

Oil Pressure Switch is bad. Kia had a recall begin July 3, 2029 that the part was faulty and did extend to eligible vehicles to 15 years or 150,000 miles. This part is known problem in the make and model of the Kia Stinger and I now have this issue with my 2018 Stinger GT2 with 115,000 miles. Many complaint on forums related to this but it seems that Kia has selected specific vehicles only. Oil light comes on when care is stopped at an idle. Then goes off and does happen when car is cold.

The contact owns a 2018 Kia Stinger. The contact stated while driving at an undisclosed speed, the vehicle was shuddering and lost motor power. The contact previously replaced the spark plugs, and the engine out of pocket. In addition, excessive white smoke was coming from the exhaust pipes. The vehicle was towed to a local dealer where it was diagnosed with a misfire in cylinder #3. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken to another local dealer, Hersons Kia (15531 Frederick Rd, Rockville, MD 20855) where the Oxygen sensor was replaced. The contact stated excessive white smoke was coming from the exhaust pipes. The vehicle was taken to an independent mechanic where the engine, spark plugs, and turbocharger were replaced. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 122,000.

Casey Kia located in Newport News Virginia continues to delay the replacement of my fuel pump. I was told it was replaced but 2 weeks later I was having the same issue to the point where my car was decelerating on the interstate. After I took it back in for them to repair it I was told they would look into it. I received a call saying the fuel pump was never replaced and the only thing that had been done originally was a software update, so basically I was lied to and put in a very dangerous situation because a fire could've been caused while driving. They also said they were waiting for approval for the recall before they repaired it. Had I known it wasn't repair I wouldn't have driven the car. I was supposed to pick my car up on 07/26 but I was told they ordered the wrong part and it would be available to them on 07/29.

1.What component or system failed or malfunctioned, and is it available for inspection upon request? •The malfunctioning components are the car seats. Specifically, both the driver and passenger seats do not go back up after reclining. Yes, these seats are available for inspection upon request. 2.How was your safety or the safety of others put at risk? •The safety of the driver and passengers was compromised because the driver seat could not be adjusted back to a safe and upright position, which is crucial for maintaining proper control of the vehicle. This poses a significant risk of accidents. 3.Has the problem been reproduced or confirmed by a dealer or independent service center? •The problem has not yet been reproduced or confirmed by a dealer or an independent service center. 4.Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? •The vehicle or the malfunctioning seats have not been inspected by the manufacturer, police, insurance representatives, or others at this time. 5.Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? •There were no warning lamps, messages, or other symptoms prior to the failure. The issue is the car seats they don’t go up after reclining . It started with passenger seat. One day I reclined while on 20 min ride . It didn’t go back up . Stayed reclined. Then a couple weeks later while cleaning the car I reclined the driver seat to clean the dust from the top of the seat and the seat did not go back up after recline. After my own research I found out that many people online who own the same vehicle encountered the same issue I have attacked screenshots of the other people encountering same issue. It can be found on the Stingerforum online and on Reddit

*Notice* There has been NO ACCIDENT but it could potentially be a fatal one. When performing the auto start up process the car's RPM increases rapidly, the engine makes a sputtering sound as if the car will crank or that there is a misfire and shuts down. This results in the check engine light coming on the instrument panel and error code P0172: Replace High Pressure Fuel Pump.

The contact owns a 2018 Kia Stinger. The contact stated while driving at an undisclosed speed, the contact noticed a very strong oil burning odor. The contact pulled over, raised the hood, and observed smoke coming from under the hood of the vehicle. The contact stated that the oil was recently changed by the dealer. No warning light was illuminated. The vehicle was taken back to the dealer, and a diagnostic test was performed, and the contact was informed the turbo oil feed line had failed. The vehicle was not repaired due to the cost. The contact referenced NHTSA Campaign Number: 24V169000 (Engine and Engine Cooling) as a possible solution however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was approximately 139,000.

On 11/13/2020 my car had 26,942 miles. I experienced my first issue with my vehicle where it lost power while driving on the freeway. My vehicle was in the shop for 17 days where they replaced the fuel pump directly affected my turbo. On 10/19/2023 my vehicle had 68,366 miles on it while driving to work when I went to accelerate from a stop sign there was no power and I literally had to drift to the side of the road. My vehicle was in the shop for seven days and it was the same issue. A few weeks after my vehicle was repaired, I received the recall notice, however at this time there was no resolution it was nearly a recall campaign. On 12/29/2023 my vehicle had 70,290 miles (not even 2000 miles since my vehicle had returned from the shop) as I was leaving work, my car begin sputtering like it was going to lose power. I made it home safely however, upon trying to start my vehicle the next morning there was a warning and a message saying not to drive my vehicle. My vehicle has been in the service center since December 30, 2023 with no resolution.

The contact owns a 2018 Kia Stinger. The contact received notification of NHTSA Campaign Number: 23V634000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated while driving 75 MPH and depressing the accelerator pedal, the vehicle lost motive power inadvertently. There was no warning light illuminated. The contact was able to veer to the side of the road. The contact stated that the vehicle was stuck in second gear. The contact was able to drive to the dealer at slow speed. The dealer diagnosed that the fuel pump assembly part number: 35320-2CTB1 and bolts needed to be replaced. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 65,000. VIN tool confirms parts not available.