NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
70 reports90,000 miles · Dec 31, 2025
Engine And Engine Cooling
The contact owns a 2019 Kia Sportage. The contact stated that the vehicle was experiencing excessive oil consumption. The contact stated that the vehicle required 6 quarts of oil every 1,900 miles. The vehicle was recently taken to Valvoline, where an oil change was performed. The contact stated that while driving 60 MPH the fol…
Read full complaint
The contact owns a 2019 Kia Sportage. The contact stated that the vehicle was experiencing excessive oil consumption. The contact stated that the vehicle required 6 quarts of oil every 1,900 miles. The vehicle was recently taken to Valvoline, where an oil change was performed. The contact stated that while driving 60 MPH the following day, the vehicle started shuddering and misfiring, and the failure increased significantly while idling. The check engine warning light was illuminated. The contact stated that the failure persisted while driving at 60-65 MPH on the same day, and the engine stalled. The low oil pressure, the battery, and the check engine warning lights were illuminated. The contact was able to pull over to the side of the road. The contact was able to restart the vehicle and continued driving; however, the vehicle continuously shuddered and misfired. The vehicle was taken to Valvoline, where the contact was informed that the engine was misfiring. The contact stated that the vehicle stalled while driving after the service appointment. The vehicle was taken to the dealer, where the spark plugs and other unknown parts were replaced. The dealer then test-drove the vehicle; however the failure persisted. The dealer determined that the engine needed to be replaced. The vehicle was not repaired due to the cost. The contact related the failure to an unknown engine recall. The manufacturer was notified of the failure and informed the contact that the cost of the repair would not be covered unless the failure was related to the engine rod. The failure mileage was approximately 90,000.
NHTSA ODI #11707973
Mileage unknown · Nov 17, 2025
Fuel/propulsion SystemService BrakesSteering
The brake peddle keeps jamming and sticking . The steering wheel is now very lose and a lot of play . There is a steering wheel with exclamation point flashing on the dash . When the card turns off it makes electrical noises . It is consuming oil . A pint a week . It’s been towed twice in three weeks
NHTSA ODI #11699997
Mileage unknown · Nov 2, 2025
EngineFuel/propulsion SystemUnknown Or Other
My check engine light started blinking and the car was stalling out. I have now parked the car in my driveway. I bought the car October, 2024
NHTSA ODI #11697043
Mileage unknown · Oct 24, 2025
Engine
Severe oil consumption issue at 100k miles. Same issue seen on kia class action lawsuit for GDI engines. No leaks present, after 800 miles from oil change, no oil seen on dip stick.
NHTSA ODI #11695393
Mileage unknown · Oct 4, 2025
Engine
Engine went out at 150,000 miles.
NHTSA ODI #11691396
70,000 miles · Oct 2, 2025
Engine
The contact owns a 2019 Kia Sportage. The contact stated that while the vehicle was in for maintenance, the contact was informed that there was no oil in the engine. The contact stated that the oil warning light had only illuminated once. The vehicle was taken to the dealer, where the first oil consumption test was performed. Th…
Read full complaint
The contact owns a 2019 Kia Sportage. The contact stated that while the vehicle was in for maintenance, the contact was informed that there was no oil in the engine. The contact stated that the oil warning light had only illuminated once. The vehicle was taken to the dealer, where the first oil consumption test was performed. The dealer added oil to the vehicle. The contact checked the oil level every two weeks and noticed that the engine was consuming an excessive amount of engine oil. The contact was adding several quarts of oil every two weeks. The vehicle had several oil consumption tests performed by the dealer. The contact was informed that less than a quart of oil was lost. However, while the vehicle was at the dealer, all the oil had leaked out of the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure but did not offer any assistance. However, a claim was filed. The failure mileage was approximately 70,000.
NHTSA ODI #11690970
Mileage unknown · Sep 29, 2025
StructureUnknown Or Other
CLEAR COAT PAINT IS PEELING. ON TOP OF HATCHBACK. I DON'T KNOW WHEN IT STARTED, I JUST NOTICED IT TODAY 9-29-25. iT IS AVAILABLE FOR INSPECTION UPON REQUEST. NO WARNING MESSAGE PRIOR TO THE PROBLEM. I WENT TO DEALER AND THEY SAID THE PAINT WARRANTY EXPIRED IN 1922 AND THERE ARE NO RECALLS AND NOT EXTENDED WARRANTIES FOR THIS…
Read full complaint
CLEAR COAT PAINT IS PEELING. ON TOP OF HATCHBACK. I DON'T KNOW WHEN IT STARTED, I JUST NOTICED IT TODAY 9-29-25. iT IS AVAILABLE FOR INSPECTION UPON REQUEST. NO WARNING MESSAGE PRIOR TO THE PROBLEM. I WENT TO DEALER AND THEY SAID THE PAINT WARRANTY EXPIRED IN 1922 AND THERE ARE NO RECALLS AND NOT EXTENDED WARRANTIES FOR THIS AND KIA HAS NO RESPONSIBILITY THAT'S WHY THEY ONLY GIVE A 3 YEAR, 36,000 MILE WARRANTY ON PAINT.
NHTSA ODI #11690286
Mileage unknown · Sep 13, 2025
EngineUnknown Or Other
My oil consumption is approximately 1.5 quarts every 200 miles. I get my oil changed every month and every other week I need to top off. When my oil, is low there is no indication on the dash. I have to preform inspections on my car on a daily basis. Now, my car will randomly not start. I replaced the battery and changed the s…
Read full complaint
My oil consumption is approximately 1.5 quarts every 200 miles. I get my oil changed every month and every other week I need to top off. When my oil, is low there is no indication on the dash. I have to preform inspections on my car on a daily basis. Now, my car will randomly not start. I replaced the battery and changed the spark plugs.
NHTSA ODI #11687052
65,000 miles · Sep 10, 2025
Exterior Lighting
The contact owns a 2019 Kia Sportage. The contact stated that the high beam headlights failed to illuminate as designed. The contact researched and learned of an undisclosed Technical Service Bulletin concerning the failure with the halogen bulbs on the 2020 Kia Telluride. The vehicle was taken to the dealer but was not diagnose…
Read full complaint
The contact owns a 2019 Kia Sportage. The contact stated that the high beam headlights failed to illuminate as designed. The contact researched and learned of an undisclosed Technical Service Bulletin concerning the failure with the halogen bulbs on the 2020 Kia Telluride. The vehicle was taken to the dealer but was not diagnosed. The dealer confirmed that the VIN was not under recall or covered under warranty. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was 65,000.
NHTSA ODI #11686416
95,000 miles · Aug 28, 2025
Engine And Engine Cooling
The contact owns a 2019 Kia Sportage. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated, and the vehicle went to LIMP Mode. The vehicle was towed to the dealer, who performed an oil change and updated the Knock Sensor Detection System(KSDS). The contact stated that later, w…
Read full complaint
The contact owns a 2019 Kia Sportage. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated, and the vehicle went to LIMP Mode. The vehicle was towed to the dealer, who performed an oil change and updated the Knock Sensor Detection System(KSDS). The contact stated that later, while driving, the engine oil warning light illuminated. The contact checked the engine oil and discovered that the oil level was extremely low. The dealer was made aware of the failure and informed the contact that the pistons were faulty, and the engine needed to be replaced; however, the mileage had exceeded the warranty coverage. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 95,000.
NHTSA ODI #11683614
NHTSA investigations
2AQ23002 · Hyundai And Kia Abs Module Fires
Opened Nov 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration