NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
399 reportsMileage unknown · Aug 25, 2026
Unknown Or Other
I have a 2017 Kia Sportage with a recurring door latch problem. Several years ago, the driver’s door developed a problem where it would not open properly from the outside. Kia repaired the driver’s door latch under warranty extension WTY020. The passenger door has now developed the exact same problem. It will not open from the…
Read full complaint
I have a 2017 Kia Sportage with a recurring door latch problem. Several years ago, the driver’s door developed a problem where it would not open properly from the outside. Kia repaired the driver’s door latch under warranty extension WTY020. The passenger door has now developed the exact same problem. It will not open from the outside, although it can still be opened from inside. A Kia dealership diagnosed the problem as a failed door latch. Kia’s WTY020 warranty extension was created for this known latch problem and provided 10 years/unlimited mileage coverage based on the vehicle’s original in-service date. Kia says my coverage expired approximately one month before this passenger-side latch failed. I requested goodwill assistance from Kia because this is the same known defect that was previously repaired on my vehicle. Kia denied the request, reconsidered it after I challenged the decision, and ultimately denied it again as a final decision. Kia also refused partial assistance. I paid $224 for the diagnostic. The dealership’s repair estimate is $761.17, including the diagnostic fee. I am reporting this because the same latch defect has now occurred on both sides of my vehicle. A passenger door that cannot be opened from the outside may present a safety concern. I am asking NHTSA to document this complaint and consider whether this recurring door-latch problem warrants further investigation.
NHTSA ODI #11759462
Mileage unknown · Aug 2, 2026
EngineFire
Engine caught fire , insurance denied the claim . Kia has a class action lawsuit Theta 2 . It was towed into the dealership for approximately 3 mts . During the diagnostic they discovered a crack in the number 3 cylinder wall . They rejected the claim due to what they said was a leaky valve cover gasket even though it had been r…
Read full complaint
Engine caught fire , insurance denied the claim . Kia has a class action lawsuit Theta 2 . It was towed into the dealership for approximately 3 mts . During the diagnostic they discovered a crack in the number 3 cylinder wall . They rejected the claim due to what they said was a leaky valve cover gasket even though it had been replaced within the last year . The car has 66,000 miles and has been well maintained. There’s copious examples of similar of engine failures and Kia gives the same reason for not fixing the problem.
NHTSA ODI #11754337
Mileage unknown · Jul 22, 2026
Engine
Engine burns excess oil, I am forced to add oil every other day as it consumes an excessive amount. When I spoke with the Kia Dealership they told me I have an unlimited warranty on the engine but it need to blow before they will replace it. I’m spending a fortune on oil.
NHTSA ODI #11752117
Mileage unknown · Jul 17, 2026
Engine
The engine consumes a massive amount of oil to where I have to check my oil constantly and refill as often as weekly. This can pose a risk to myself and others due to the engine failing while I am driving. I am sure other issues can come from an engine running out of soil that I’m not aware of.
NHTSA ODI #11751196
Mileage unknown · Jul 17, 2026
Engine
My car went into limp mode on the high way due to a faulty knock sensor. my car decelerated rapidly, which could have put me and others around me at risk. I had to repair this problem on my own even though other cars similar to my make and model have had the same issue.
NHTSA ODI #11751195
Mileage unknown · Jul 8, 2026
Air BagsEngineVehicle Speed Control
One day as I was turning at a green light the car completely stopped on me. I had to turn it off and then restart it and it worked fine. About a week later I had to drive to my cousin's house 45 minutes away and the car would not go, it acted like it was stalling and It didn't want to go over 2000RPMs and it was really sluggish …
Read full complaint
One day as I was turning at a green light the car completely stopped on me. I had to turn it off and then restart it and it worked fine. About a week later I had to drive to my cousin's house 45 minutes away and the car would not go, it acted like it was stalling and It didn't want to go over 2000RPMs and it was really sluggish like it didn't want to shift into the next gear. I finally got on the highway and it would not go past 60 miles an hour and then also if you try to drive it, it will slow down like its shutting off on you. I've had a new battery replaced, 4 new tires a windshield, and wipers replaced. I took the car to AutoZone and also to another guy and both of them used their computers and said that it's the engine and they called it rod knocking. I called customer service and they said yes their is a recall and that they would replace the engine. I tried to call kia in mesquite Texas because that is the closest one to me and I left a voicemail they did not call me back I am carless I'm a single disabled mother I need a working car.
NHTSA ODI #11749087
Mileage unknown · Jul 6, 2026
EngineFuel/propulsion System
After fueling, vehicle idled fine with no warning lights. Once pulling onto the highway and making highway speeds, the vehicle suddenly lost acceleration, and was stranded in the highway. We required the assistance of law enforcement to direct traffic. It was 10pm and the temperatures were 35 degree below zero with the windchill…
Read full complaint
After fueling, vehicle idled fine with no warning lights. Once pulling onto the highway and making highway speeds, the vehicle suddenly lost acceleration, and was stranded in the highway. We required the assistance of law enforcement to direct traffic. It was 10pm and the temperatures were 35 degree below zero with the windchill. The vehicle was towed to a Kia dealership, where they diagnosed loss of compression in the pistons. The dealership stated the engine had been burning/consuming oil and that the burnt valve caused the loss of compression and sudden breakdown. This vehicle uses the 2.4L Theta II GDI engine, which has a long history of engine failures, oil consumption complaints, stalling, and class-action litigation involving sudden engine failure and loss of power. Kia denied coverage by claiming only rod-bearing failures qualify for warranty extension, even though excessive oil consumption and compression loss appear closely related to the same broader engine defect pattern. Other owners have also reported 2017 Sportage excessive oil consumption leading to compression loss and engine failure. I believe this is a serious safety defect because the engine can fail suddenly while driving at highway speed, drivers may have little warning before loss of power, oil consumption may not trigger adequate warning before catastrophic failure. This creates crash risk, roadside hazard exposure, and potential fire risk.
NHTSA ODI #11748466
75,000 miles · Jun 24, 2026
FirerelatedTrailer HitchesFireInjury
The contact's mother owned a 2017 Kia Sportage. The contact stated that while her brother was driving at an undisclosed speed, the vehicle lost motive power. The contact's brother parked the vehicle, rolled down the window, and became aware that there was smoke coming from under the hood before the vehicle caught on fire. The co…
Read full complaint
The contact's mother owned a 2017 Kia Sportage. The contact stated that while her brother was driving at an undisclosed speed, the vehicle lost motive power. The contact's brother parked the vehicle, rolled down the window, and became aware that there was smoke coming from under the hood before the vehicle caught on fire. The contact's brother exited the vehicle and ran away from the vehicle. The contact's brother called the contact and the police about the fire. The Police, bomb squad, and firefighters arrived at the scene. The firefighters extinguished the fire. The Police, bomb squad, and fire department reports were filed. The contact's brother received medical treatment for a severe asthma attack. The vehicle was towed to a tow yard, but the insurance company had not yet declared the vehicle a total loss because the vehicle only had liability coverage. Upon investigation, the contact's brother discovered that the VIN was included in NHTSA Campaign Number: 22V703000 (Trailer Hitches); however, the contact's mother had not received a recall notification. The manufacturer was not made aware of the failure. The failure mileage was approximately 75,000.
NHTSA ODI #11746213
Mileage unknown · Jun 16, 2026
Engine
My 2017 Kia Sportage has experienced excessive oil consumption, cylinder #3 misfires, loss of power, and highway stalling events. The dealership initially documented engine damage and indicated findings consistent with internal engine failure, including concerns related to metal contamination and cylinder damage. These issues ap…
Read full complaint
My 2017 Kia Sportage has experienced excessive oil consumption, cylinder #3 misfires, loss of power, and highway stalling events. The dealership initially documented engine damage and indicated findings consistent with internal engine failure, including concerns related to metal contamination and cylinder damage. These issues appear consistent with numerous complaints from other Kia owners involving the same engine family. Kia has since backtracked on prior findings, and both Kia and the dealership have stopped responding to my requests for clarification and documentation. The cylinder damage and related engine failures appear to be symptoms of a larger engine defect that poses a safety risk due to sudden loss of power and stalling while driving. I request that NHTSA investigate these recurring engine failures and Kia’s handling of these claims.
NHTSA ODI #11744503
Mileage unknown · Jun 16, 2026
Electrical System
Window regulator failure - power window could not be rolled up. Had to be replaced.
NHTSA ODI #11744476
Official recalls
4Sep 19, 2022
Kia America, Inc. (Kia) is recalling certain 2016-2022 Sorento, 2021-2022 Sorento Hybrid (HEV), 2022-2023 Sorento Plug-In Hybrid (PHEV), and 2017-2022 Sportage vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
Consequence & remedy
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will inspect the vehicle, and, as necessary, replace the fuse and/or tow hitch harness module, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC249.
Mar 4, 2021
Kia Motors America (Kia) is recalling certain 2017-2021 Sportage and Cadenza vehicles. The electrical circuit in the Hydraulic Electronic Control Unit (HECU) may short-circuit, which can cause a fire in the engine compartment.
Consequence & remedy
Consequence: An engine compartment fire can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures as a precaution until the recall repair is complete. Kia will notify owners, and dealers will replace certain fuses in the electrical junction box. Vehicles equipped with an electronic parking brake (EPB) will also receive a HECU software update. Repairs will be performed free of charge. The recall began on April 30, 2021. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC206.
Dec 19, 2018
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Additional source detail variants (2)
Engine
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Nov 30, 2016
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Additional source detail variants (2)
Trailer Hitches
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Electrical System
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2AQ23002 · Hyundai And Kia Abs Module Fires
Opened Nov 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration