CONSUMER STATES THAT SINCE BUYING THE VEHICLE IN JANUARY OF 2003 ROTORS HAVE BEEN REPLACED TWICE IN THAT TIME. THE FAULTY ROTORS CAUSED VIBRATION WHILE BRAKING. THE ROTORS WERE REPLACED ONCE AT 5699 MILES AND AGAIN AT 8694 MILES. WHEN THE ENGINE WAS STARTED ALL THE DOORS LOCKED, BUT WHEN IT WAS DAMP OUTSIDE THE LOCKS WORKED I…
Read full complaint
CONSUMER STATES THAT SINCE BUYING THE VEHICLE IN JANUARY OF 2003 ROTORS HAVE BEEN REPLACED TWICE IN THAT TIME. THE FAULTY ROTORS CAUSED VIBRATION WHILE BRAKING. THE ROTORS WERE REPLACED ONCE AT 5699 MILES AND AGAIN AT 8694 MILES. WHEN THE ENGINE WAS STARTED ALL THE DOORS LOCKED, BUT WHEN IT WAS DAMP OUTSIDE THE LOCKS WORKED INTERMITTENTLY. THE DRIVER'S SIDE WIPER WASHER WAS NOT WORKING AS WELL AS THE PASSENGER SIDE. THE DEALER READJUSTED IT. THERE WAS A RATTLING IN THE DASH ON THE DRIVERS SIDE BELOW THE AIR VENT. *AK *PH *NLM
NHTSA ODI #10032179
Mileage unknown · Mar 13, 2002
Electrical SystemSteeringStructure
DOOR STAYS AJAR. MECHANIC TOLD CONSUMER THAT DOOR IS NOT OFF LINE, YET DOOR DOES NOT CLOSE PROPERLY.*AK NOW HORN HAS FAILED, SECURITY ALARM SYSTEM ACTS ERRATICLY, THE RIGHT SIDE HOOD IF OFFLINE AND IS BENT CAUSING THE HOOD TO INTRUDE OUTWARD TOWARDS THE FRONT FENDER, AND THE DRIVER SIDE BACK WINDOW WILL NOT MOVE UP OR DOWN. *T…
Read full complaint
DOOR STAYS AJAR. MECHANIC TOLD CONSUMER THAT DOOR IS NOT OFF LINE, YET DOOR DOES NOT CLOSE PROPERLY.*AK NOW HORN HAS FAILED, SECURITY ALARM SYSTEM ACTS ERRATICLY, THE RIGHT SIDE HOOD IF OFFLINE AND IS BENT CAUSING THE HOOD TO INTRUDE OUTWARD TOWARDS THE FRONT FENDER, AND THE DRIVER SIDE BACK WINDOW WILL NOT MOVE UP OR DOWN. *TT
NHTSA ODI #8005631
Mileage unknown · Mar 13, 2002
Structure
DRIVER'S SIDE DOOR STAYS AJAR. TOOK VEHICLE TO DEALER, AND WAS TOLD THAT DOOR WAS NOT OFF LINE, YET DOOR WILL NOT CLOSE PROPERLY.*AK
ON CERTAIN VEHICLES, THE HEAT GENERATED BY THE ENGINE CAUSES REPEATED BENDING DEFORMATION OF THE POLYPROPYLENE COOLING FAN INCLUDING ITS RETAINING RING, WHICH STRESSES THE POLYPROPYLENE THEREBY INITIATING CRACKING OF THE BLADES. THE CENTRIFUGAL FORCES GENERATED BY THE ROTATION OF THE BLADES CAN CAUSE THE CRACKS TO PROPAGATE UNTIL COMPLETE SEPARATION OCCURS.
Consequence & remedy
Consequence: SEPARATION OF THE FAN BLADE(S) CAN CREATE A RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE ENGINE COOLING FAN WITH A FAN MADE OF IMPROVED MATERIAL. THE RECALL BEGAN ON JUNE 11, 2007. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA07001 · Fan Blade Cracking/separation
Opened Jan 22, 2007 · Closed Apr 16, 2007
Status: closed (inferred from source dates) · Engine And Engine Cooling:cooling System:fan
KIA MOTORS AMERICA, INC. (KIA) HAS IDENTIFIED A DEFECT IN THE PLASTIC ENGINE COOLING FAN IN THE SUBJECT VEHICLES AND WILL CONDUCT A SAFETY RECALL.KIA'S DEFECT REPORT STATES, ...HEAT GENERATED BY THE ENGINE CAUSES REPEATED BENDING DEFORMATION OF THE POLYPROPYLENE COOLING FAN...INITIATING CRACKS IN THE FAN.THE CENTRIFUGAL FORCES GENERATED BY THE ROTATION OF THE BLADES CAN CAUSE THE CRACKS TO PROPAGATE UNTIL COMPLETE SEPARATION OCCURS...KIA ESTIMATES APPROXIMATELY 35,090 VEHICLES WILL BE SUBJECT TO THE RECALL, AS SOME OF THE 46,887 VEHICLES PRODUCED HAVE ALREADY HAD THE FAN REPLACED UNDER WARRANTY.KIA DEALERS WILL REPLACE THE ORIGINAL VERSION OF THE FAN WITH A FAN MADE OF IMPROVED MATERIAL.THIS INVESTIGATION WAS OPENED ON SEPTEMBER 21, 2006 AS PE06-042 AND UPGRADED TO ENGINEERING ANALYSIS EA07-001 ON JANUARY 22, 2007.PLEASE SEE NHTSA RECALL 07V161 FOR MORE DETAILED INFORMATION
PE06042 · Fan Blade Cracking/separation
Opened Sep 21, 2006 · Closed Jan 22, 2007
Status: closed (inferred from source dates) · Engine And Engine Cooling:cooling System:fan
THE INVESTIGATION OF ENGINE COOLING FANS IN THE SUBJECT VEHICLES WAS OPENED ON SEPTEMBER 21, 2006 AS PE06-042.THE BASIS FOR OPENING WAS 10 CONSUMER REPORTS ALLEGING FAN BLADE CRACKING AND BLADE SEPARATION.SIX OF THE REPORTS INDICATED THE SEPARATED FAN BLADES CAUSED DAMAGE TO OTHER ENGINE COMPARTMENT COMPONENTS.KIA HAS PROVIDED ADDITIONAL CONSUMER REPORTS AND INFORMATION IN ITS RESPONSE TO PE06-042.THE INVESTIGATION HAS BEEN UPGRADED TO ENGINEERING ANALYSIS (EA07-001) TO CONTINUE TO ASSESS THE CONSEQUENCE OF FAN BLADE SEPARATION IN THE SUBJECT VEHICLES.
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (3)
Fuel System, Gasoline
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage:tank Assembly
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
RQ03007 · Seat Belt Buckle False Latch/malfunction
Opened Oct 14, 2003 · Closed Feb 27, 2004
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
INFORMATION RECEIVED AND ANALYZED DURING THIS RQ DISCLOSED THAT MY 1999 AND 2000 KIA SEPHIA AND SPORTAGE VEHICLES WERE EQUIPPED WITH MODIFIED VERSIONS OF THE SAME SAFETY BELT LATCH ASSEMBLY AS THOSE RECALLED IN CAMPAIGN NO. 02V-216.THESE LATCH ASSEMBLIES WERE IDENTIFIED AS TYPE A97. ODI ANALYSES INDICATE A CONTINUING TREND OF CONSUMER COMPLAINTS FOLLOWING A SERIES OF DESIGN MODIFICATIONS MADE BY KIA TO IMPROVE THE A97 LATCH ASSEMBLY.MY 2001 AND 2002 SUBJECT VEHICLES WERE EQUIPPED WITH DIFFERENT DESIGN LATCH ASSEMBLIES (TYPE DB-6 OR AUTOLIV) AND EXHIBIT A MUCH LOWER COMPLAINT COUNT.THIS RQ HAS BEEN UPGRADED TO AN EA IN ORDER TO FURTHER INVESTIGATE THIS MATTER FOR THE SUBJECT VEHICLES EQUIPPED WITH TYPE A97 LATCH ASSEMBLIES.
Illustration