IllustrationTRAVELING POSTED SPEED LIMIT , CAR BEGAN TO SKID. MADE A SLIGHT TURN OF STEERING WHEEL CAR BEGAN TO ROLLOVER TWO OR THREE TIMES. *TR
2002 Kia Sportage
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Kia Sportage do not stand out strongly from the model-year median of 122.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sportage years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
290–25K
2825–50K
3950–75K
2075–100K
27100–150K
9150K+
152 reports with mileage · 82 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 69 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
15 crash reports6 fire reports7 injury reports
Steering complaints
9 reportsTL*THE CONTACT OWNS A 2002 KIA SPORTAGE. THE CONTACT STATED THAT WHENEVER HE DROVE, THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE THERMOSTAT WAS REPLACED. THE FAILURE CONTINUED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE RADIATOR WAS REPLACED. HOWE…
Read full complaint
TL*THE CONTACT OWNS A 2002 KIA SPORTAGE. THE CONTACT STATED THAT WHENEVER HE DROVE, THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE THERMOSTAT WAS REPLACED. THE FAILURE CONTINUED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE RADIATOR WAS REPLACED. HOWEVER, THE FAILURE CONTINUED. ALSO, WHILE TRAVELING APPROXIMATELY 35 MPH, THE CONTACT NOTICED THAT THE POWER STEERING MALFUNCTIONED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAN BELT WAS REPLACED. THE FAILURE MILEAGE WAS APPROXIMATELY 68,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 78,000.
WHILE DRIVING ON A STRAIGHT STRETCH OF HIGHWAY MY DAUGHTER FELT HER CAR JERK TO THE RIGHT. SHE ATTEMPTED TO TURN INTO THE JERK AND WAS NOT ABLE TO CONTROL ANYTHING ON THE CAR. IT BEGAN TO ROCK DESPITE HER EFFORTS AND THEN IMMEDIATELY ROLLED OVER MULTIPLE TIMES. THE FRONT END OF HER KIA SPORTAGE SUSTAINED CONSIDERABLE DAMAGE, …
Read full complaint
WHILE DRIVING ON A STRAIGHT STRETCH OF HIGHWAY MY DAUGHTER FELT HER CAR JERK TO THE RIGHT. SHE ATTEMPTED TO TURN INTO THE JERK AND WAS NOT ABLE TO CONTROL ANYTHING ON THE CAR. IT BEGAN TO ROCK DESPITE HER EFFORTS AND THEN IMMEDIATELY ROLLED OVER MULTIPLE TIMES. THE FRONT END OF HER KIA SPORTAGE SUSTAINED CONSIDERABLE DAMAGE, THE AIRBAGS DID NOT DEPLOY AND SHE SUFFERED ALMOST COMPLETE LOSS OF USE OF HER LEFT ARM. SHE IS STILL UNDERGOING TREATMENT AND THERAPY FOR THE INJURY AND ALSO WILL PROBABLY HAVE TO HAVE FURTHER SURGERY. THERE WERE WITNESSES BEHIND HER THAT REPORTED THAT THE CAR WAS GOING STRAIGHT, DID NOT RUN OFF THE ROAD JUST BEGAN TO FLIP. SHE DID NOT LOSE CONSCIENCE, DID NOT LOOK AWAY FROM THE ROAD. ALSO THE DRIVING CONDITIONS WERE NORMAL AND SHE WAS GOING 5 MILES UNDER THE SPEED LIMIT. WE REQUESTED THAT THE INSURANCE COMPANY INVESTIGATE BUT THEY STATED THEY DO NOT DO INVESTIGATIONS. WE REALLY BELIEVE THAT THERE WAS A STEERING MALFUNCTION AS WELL AS FAILURE ON THE AIRBAGS. *JB
2002 KIA SPORTAGE.*MR (NAR) FIRST OIL CHANGE, FILTER REPLACEMENT, LUBE, RATTLING NOISE UNDER STEERING WHEEL, SLUGGISH TRANSMISSION SHIFTING AND EXCESSIVE BRAKE RESIDUE ON RIGHT FRONT WHEEL. *CB
THE GEARS SHIFTED IMPROPERLY AND THERE WAS A RATTLING NOISE COMING FROM UNDER THE VEHICLE. CONSUMER WAS INFORMED THE TRANSMISSION NEEDED TO BE REPLACED, ALSO THE DEALER NOTICED THE STEERING GEAR BOX WAS LEAKING. *JB
CONSUMER STATED WHILE DRIVING THE VEHICLE SPENT OUT OF CONTROL, SHE ALSO STATED THAT THE STEERING WHEEL WAS SHAKING REALLY BAD. TS
THE STEERING BOX IN MY 2002 KIA SPORTAGE SUDDENLY BECOME INOPERABLE AND WOULD NOT PERMIT THE CAR TO BE STEERED TO THE RIGHT. IT HAPPENED WHILE I WAS DRIVING AND I NEARLY HAD AN ACCIDENT BEFORE I COULD GET IT STOPPED.
STEERING HAS EXCESSIVE PLAY. KIA REPRESENTATIVES STATE " ALL SPORTAGES ARE LIKE THAT AND THEY WILL NOT FIX."*AK
DOOR STAYS AJAR. MECHANIC TOLD CONSUMER THAT DOOR IS NOT OFF LINE, YET DOOR DOES NOT CLOSE PROPERLY.*AK NOW HORN HAS FAILED, SECURITY ALARM SYSTEM ACTS ERRATICLY, THE RIGHT SIDE HOOD IF OFFLINE AND IS BENT CAUSING THE HOOD TO INTRUDE OUTWARD TOWARDS THE FRONT FENDER, AND THE DRIVER SIDE BACK WINDOW WILL NOT MOVE UP OR DOWN. *T…
Read full complaint
DOOR STAYS AJAR. MECHANIC TOLD CONSUMER THAT DOOR IS NOT OFF LINE, YET DOOR DOES NOT CLOSE PROPERLY.*AK NOW HORN HAS FAILED, SECURITY ALARM SYSTEM ACTS ERRATICLY, THE RIGHT SIDE HOOD IF OFFLINE AND IS BENT CAUSING THE HOOD TO INTRUDE OUTWARD TOWARDS THE FRONT FENDER, AND THE DRIVER SIDE BACK WINDOW WILL NOT MOVE UP OR DOWN. *TT
Official recalls
107V161000 · Engine And Engine Cooling:cooling System:fan
Apr 16, 2007
ON CERTAIN VEHICLES, THE HEAT GENERATED BY THE ENGINE CAUSES REPEATED BENDING DEFORMATION OF THE POLYPROPYLENE COOLING FAN INCLUDING ITS RETAINING RING, WHICH STRESSES THE POLYPROPYLENE THEREBY INITIATING CRACKING OF THE BLADES. THE CENTRIFUGAL FORCES GENERATED BY THE ROTATION OF THE BLADES CAN CAUSE THE CRACKS TO PROPAGATE UNTIL COMPLETE SEPARATION OCCURS.
Consequence & remedy
Consequence: SEPARATION OF THE FAN BLADE(S) CAN CREATE A RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE ENGINE COOLING FAN WITH A FAN MADE OF IMPROVED MATERIAL. THE RECALL BEGAN ON JUNE 11, 2007. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA07001 · Fan Blade Cracking/separation
Opened Jan 22, 2007 · Closed Apr 16, 2007
Status: closed (inferred from source dates) · Engine And Engine Cooling:cooling System:fan
KIA MOTORS AMERICA, INC. (KIA) HAS IDENTIFIED A DEFECT IN THE PLASTIC ENGINE COOLING FAN IN THE SUBJECT VEHICLES AND WILL CONDUCT A SAFETY RECALL.KIA'S DEFECT REPORT STATES, ...HEAT GENERATED BY THE ENGINE CAUSES REPEATED BENDING DEFORMATION OF THE POLYPROPYLENE COOLING FAN...INITIATING CRACKS IN THE FAN.THE CENTRIFUGAL FORCES GENERATED BY THE ROTATION OF THE BLADES CAN CAUSE THE CRACKS TO PROPAGATE UNTIL COMPLETE SEPARATION OCCURS...KIA ESTIMATES APPROXIMATELY 35,090 VEHICLES WILL BE SUBJECT TO THE RECALL, AS SOME OF THE 46,887 VEHICLES PRODUCED HAVE ALREADY HAD THE FAN REPLACED UNDER WARRANTY.KIA DEALERS WILL REPLACE THE ORIGINAL VERSION OF THE FAN WITH A FAN MADE OF IMPROVED MATERIAL.THIS INVESTIGATION WAS OPENED ON SEPTEMBER 21, 2006 AS PE06-042 AND UPGRADED TO ENGINEERING ANALYSIS EA07-001 ON JANUARY 22, 2007.PLEASE SEE NHTSA RECALL 07V161 FOR MORE DETAILED INFORMATION
PE06042 · Fan Blade Cracking/separation
Opened Sep 21, 2006 · Closed Jan 22, 2007
Status: closed (inferred from source dates) · Engine And Engine Cooling:cooling System:fan
THE INVESTIGATION OF ENGINE COOLING FANS IN THE SUBJECT VEHICLES WAS OPENED ON SEPTEMBER 21, 2006 AS PE06-042.THE BASIS FOR OPENING WAS 10 CONSUMER REPORTS ALLEGING FAN BLADE CRACKING AND BLADE SEPARATION.SIX OF THE REPORTS INDICATED THE SEPARATED FAN BLADES CAUSED DAMAGE TO OTHER ENGINE COMPARTMENT COMPONENTS.KIA HAS PROVIDED ADDITIONAL CONSUMER REPORTS AND INFORMATION IN ITS RESPONSE TO PE06-042.THE INVESTIGATION HAS BEEN UPGRADED TO ENGINEERING ANALYSIS (EA07-001) TO CONTINUE TO ASSESS THE CONSEQUENCE OF FAN BLADE SEPARATION IN THE SUBJECT VEHICLES.
EA06007 · Fuel Tank Leakage
Opened May 9, 2006 · Closed Nov 30, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (3)
Fuel System, Gasoline
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage:tank Assembly
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
RQ03007 · Seat Belt Buckle False Latch/malfunction
Opened Oct 14, 2003 · Closed Feb 27, 2004
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
INFORMATION RECEIVED AND ANALYZED DURING THIS RQ DISCLOSED THAT MY 1999 AND 2000 KIA SEPHIA AND SPORTAGE VEHICLES WERE EQUIPPED WITH MODIFIED VERSIONS OF THE SAME SAFETY BELT LATCH ASSEMBLY AS THOSE RECALLED IN CAMPAIGN NO. 02V-216.THESE LATCH ASSEMBLIES WERE IDENTIFIED AS TYPE A97. ODI ANALYSES INDICATE A CONTINUING TREND OF CONSUMER COMPLAINTS FOLLOWING A SERIES OF DESIGN MODIFICATIONS MADE BY KIA TO IMPROVE THE A97 LATCH ASSEMBLY.MY 2001 AND 2002 SUBJECT VEHICLES WERE EQUIPPED WITH DIFFERENT DESIGN LATCH ASSEMBLIES (TYPE DB-6 OR AUTOLIV) AND EXHIBIT A MUCH LOWER COMPLAINT COUNT.THIS RQ HAS BEEN UPGRADED TO AN EA IN ORDER TO FURTHER INVESTIGATE THIS MATTER FOR THE SUBJECT VEHICLES EQUIPPED WITH TYPE A97 LATCH ASSEMBLIES.