I JUST PURCHASED A 1997 KIA SPORTAGE WITH 38,000 MILES ON IT. IN THE TWO WEEKS SINCE PURCHASE I HAVE ALREADY HAD IT IN THE SHOP FOR REPAIR TWICE. WITH SUCH LOW MILES ON THE VEHICLE I THOUGHT IT WAS A GOOD AND SAFE PURCHASE BUT NOW I AM AFRAID I HAVE MADE A MISTAKE. THE DAY AFTER PURCHASE THE DRIVER SIDE WINDOW SWITCH BROKE AN…
Read full complaint
I JUST PURCHASED A 1997 KIA SPORTAGE WITH 38,000 MILES ON IT. IN THE TWO WEEKS SINCE PURCHASE I HAVE ALREADY HAD IT IN THE SHOP FOR REPAIR TWICE. WITH SUCH LOW MILES ON THE VEHICLE I THOUGHT IT WAS A GOOD AND SAFE PURCHASE BUT NOW I AM AFRAID I HAVE MADE A MISTAKE. THE DAY AFTER PURCHASE THE DRIVER SIDE WINDOW SWITCH BROKE AND I COULD NOT ROLL MY WINDOW UP. I TOOK IT IN THE SHOP TO HAVE A NEW ONE PUT IN. ON FRIDAY, OCTOBER 1 THE REAR DRIVE SHAFT GEAR BOX BROKE AS I WAS GOING DOWN THE ROAD WITH TWO OF MY CHILDREN IN THE CAR. LUCKILY I WAS DRIVING SLOW AND COULD STOP RIGHT AWAY. IF I WAS DRIVING DOWN THE HIGHWAY AT A FAST SPEED AND COULD NOT GET OVER IMMEDIATELY THE REAR TIRES COULD HAVE SEISED UP CAUSING SERIOUS INJURY OR DEATH TO ME AND MY CHILDREN. SOMEONE SHOULD LOOK INTO THIS PROBLEM AND FIX IT RIGHT AWAY BEFORE PEOPLE LOOSE THEIR LIVES OVER A POORLY MANUFACTURED SUV.*AK
NHTSA ODI #10093516
Mileage unknown · Jun 20, 2002
StructureSuspension
VEHICLE STARTED SHIMMYING VIOLENTLY WHILE GOING 60MPH. VEHICLE MADE A GRINDING NOISE IN FRONT END AND GRDUALLY COASTED TO A STOP. VEHICLE WAS TOWED TO A GARAGE, AND T FRAME FELL TO THE GROUND. DEALER WAS NOT CONTACTED. PLEASE PROVIDE MOE INFORMATION.*AK
NHTSA ODI #8012304
Mileage unknown · May 24, 2000
Power TrainSuspensionUnknown Or Other
ENGINE CHECK LIGHT COMES ON, AND THE VEHICLE MAKES A VIBRATING/HUMMING NOISE. ALSO, VEHICLE DOES NOT SHIFT INTO GEAR PROPERLY. DEALER HAS SEEN VEHICLE, AND CAN'T FIND THE CAUSE OF THE PROBLEM.*AK
NHTSA ODI #862426
Mileage unknown · Mar 17, 2000
Air BagsSuspension
WHILE DRIVING ON COUNTY ROAD AN ANIMAL RAN OUT IN FRONT OF VEHICLE, IT SWERVED TO AVOID HITTING THE ANIMAL. ROAD WAS WET. WENT INTO A DITCH, AND NEITHER AIRBAG DEPLOYED. *AK
NHTSA ODI #858753
Mileage unknown · Feb 13, 2000
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
BRAKES- EXCESSIVE BRAKING DISTANCE WHEN BRAKES APPLIED; ENGINE COOLANT SYSTEM- VEHICLE OVER HEADED CAUSED VENTS ON DASHBOARD TO POP; ELECTRICAL SYSTEM UNDER HOOD- CONTINUOUS "CHECK ENGINE LIGHT" EXPENSIVE REPAIR BILLS; ENGINE- SHAKES LIKE AN EARTHQUAKE, STALLS WHILE DRIVING, SCARED WILL CAUSE ACCIDENT/DEATH
NHTSA ODI #718699
Mileage unknown · Feb 19, 1999
Engine And Engine CoolingPower TrainSuspension
THIS VEHICLE IS GARBAGE - BOTH FRONT WINDOW MOTORS-REPLACED. TRANSMISSION REPLACED, AND IS NOW ACTING UP AGAIN. REAR-END REPLACED, ACTING UP, ENGINE SQUEALS, DEALER CAN'T HEAR IT, BURNING ANTI-FREEZE SMELL UPON WARMUP, TEMP GAUGE GOES CRAZY, IN 4WD VEHICLE DOES NOT WANT TO TURN, ONLY WANTS TO GO STRAIGHT, MAKINGS HARD "CLUNKING…
Read full complaint
THIS VEHICLE IS GARBAGE - BOTH FRONT WINDOW MOTORS-REPLACED. TRANSMISSION REPLACED, AND IS NOW ACTING UP AGAIN. REAR-END REPLACED, ACTING UP, ENGINE SQUEALS, DEALER CAN'T HEAR IT, BURNING ANTI-FREEZE SMELL UPON WARMUP, TEMP GAUGE GOES CRAZY, IN 4WD VEHICLE DOES NOT WANT TO TURN, ONLY WANTS TO GO STRAIGHT, MAKINGS HARD "CLUNKING" NOISE IF YOU ATTEMPT TO TURN. THE YUGO WAS A BETTER VEHICLE! *AK
NHTSA ODI #703509
Mileage unknown · Nov 18, 1998
StructureSuspension
WHEN DRIVING CONSUMER NOTICED A KNOCKING SOUND COMING FROM THE FRONT END OF THE VEHICLE, CONSUMER IS ALSO HAVING PROBLEM WITH LEAKAGE INSIDE THE VEHICLE. CONSUMER HAS CONTACTED THE DEALER, DEALER HAS ATTEMPTED TO CORRECT THE PROBLEM, PROBLEM STILL OCCURS. *ML
ON CERTAIN PASSENGER VEHICLES, THE SAFETY BELT BUCKLE MAY "FALSE LATCH" AND EXPOSE THE DRIVER TO UNRESTRAINED MOVEMENT DURING A CRASH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: OWNER NOTIFICATION BEGAN DECEMBER 20, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE WIRES CONNECTED TO THE C123 AND C124 CONNECTORS CAN BE PUT UNDER TENSION BY MOVEMENT OF THE ENGINE, THUS PULLING THE WIRES AND CONNECTORS, LOOSENING THEM AND RESULTING IN A LOSS OF CIRCUIT CONTINUITY.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE ENGINE STALLING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SPRING CLIPS TO LOCK THE CONNECTORS TOGETHER. IN ADDITION, THE DEALERS WILL BE INSTRUCTED TO SOLDER A SPLICE IN THE WIRE HARNESS.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MICROSWITCH ON THE REAR HATCH LOCK CYLINDER CAN MALFUNCTION CAUSING THE POWER DOOR LOCKS TO UNLOCK INADVERTENTLY.
Consequence & remedy
Consequence: SHOULD THIS OCCUR, SECURITY FROM UNWANTED INTRUSION INTO THE VEHICLE IS LOST.
Remedy: DEALERS WILL MODIFY THE REAR HATCH DOOR UNLOCK CIRCUIT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (3)
Fuel System, Gasoline
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage:tank Assembly
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
RQ02013 · Engine Stalling POST-RECALL
Opened Oct 18, 2002 · Closed Sep 2, 2003
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Additional source detail variants (3)
Electrical System:wiring:front Underhood
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Electrical System:wiring
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Engine And Engine Cooling
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
PE02051 · Safety Belt Buckle Malfunction
Opened Jun 17, 2002 · Closed Sep 20, 2002
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
BY LETTER DATED AUGUST 25, 2002, KIA ADVISED NHTSA THAT THE SUBJECT VEHICLES WILL BE RECALLED.SPECIFIC CORRECTIVE ACTION TO BE TAKEN BY KIA HAS NOT BEEN REPORTED TO NHTSA AT THIS TIME.THE SAFETY RECALL PROGRAM HAS BEEN ASSIGNED CAMPAIGN NO. 02V-216.
SQ99021 · Check Engine Light Stays On
Opened Jun 30, 1999 · Closed Feb 2, 2000
Status: closed (inferred from source dates) · Electrical System
A monthly Technical Times published by Kia and distributed to dealer technicians identifying a wiring harness problem that could cause connectors C123 and C124 to pull apart slightly during engine load changes.This could lead to erratic or tempory loss
Illustration