NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
25 reportsClear category filterMileage unknown · Mar 14, 2001
Engine And Engine CoolingPower TrainSeat Belts
SINCE PURCHASE OF VEHICLE I HAVE HAD PROBLEMS WITH CEL COMING ON AND STAYING ON, I HAVE HAD PROBLEMS WITH CLUTCH, THE BELTS, AND RECENTLY THE EMISSION SYSTEMS, EACH TIME I GO IN THE PEOPLE AT THE DEALER SHIP ACT LIKE I AM DOING THESE THINGS ON PURPOSE AND THIS LAST TIME THEY TOLD ME THAT MY WARRANTY HAD EXPIRED. AND THAT IT WOUL…
Read full complaint
SINCE PURCHASE OF VEHICLE I HAVE HAD PROBLEMS WITH CEL COMING ON AND STAYING ON, I HAVE HAD PROBLEMS WITH CLUTCH, THE BELTS, AND RECENTLY THE EMISSION SYSTEMS, EACH TIME I GO IN THE PEOPLE AT THE DEALER SHIP ACT LIKE I AM DOING THESE THINGS ON PURPOSE AND THIS LAST TIME THEY TOLD ME THAT MY WARRANTY HAD EXPIRED. AND THAT IT WOULD COST 1,000 DOLLARS TO FIX. I WAS OUT RAGED.
NHTSA ODI #742416
Mileage unknown · Feb 23, 2001
Power TrainFire
WHILE TRAVELING 55MPH REAR AXEL BROKE AND RIGHT REAR TIRE CAME OFF, AND WHEEL AREA CAUGHT ON FIRE. TOOK TO DEALER AND HAS BEEN REPAIRED. *AK
NHTSA ODI #881209
Mileage unknown · Dec 12, 2000
Engine And Engine CoolingPower Train
THIS VEHICLE HAS BEEN A PROBLEM FROM THE DAY THAT I PURCHASED IT, ENGINE FAILED AND IT WAS IN SHOP FOR TWO MONTHS, TRANSMISSION FAILED, THE REAR END FAILED, THE FUEL ECONOMY SWITCH FAILED, THEN THE TRANSMISSION FAILED AGAIN, AND THE TRANSMISSION HAS FAILED THREE TIMES SINCE JULY, 2000. I HAVE HAD TWO NEAR ACCIDENTS ON THE INT…
Read full complaint
THIS VEHICLE HAS BEEN A PROBLEM FROM THE DAY THAT I PURCHASED IT, ENGINE FAILED AND IT WAS IN SHOP FOR TWO MONTHS, TRANSMISSION FAILED, THE REAR END FAILED, THE FUEL ECONOMY SWITCH FAILED, THEN THE TRANSMISSION FAILED AGAIN, AND THE TRANSMISSION HAS FAILED THREE TIMES SINCE JULY, 2000. I HAVE HAD TWO NEAR ACCIDENTS ON THE INTERSTATE DUE TO THESE MECHANICAL FAILURES. I HAVE TRIED FOR OVER TWO YEARS TO CONTACT A KIA REPRESENATIVE BUT THEY WILL NOT RESPOND TO MY COMPLAINTS . THE DEALER IS NO HELP, THEY ONLY GIVE YOU THE DELAY GAME. I HAVE A VEHICLE THAT IS NO GOOD, IT IS UNSAFE TO DRIVE AND A DANGER TO PUT ON THE ROAD. IT CONTINUALLY HAS PROBLEMS AND I AM HAVING TO MAKE PAYMENTS ON IT.PLEASE HELP
NHTSA ODI #737695
Mileage unknown · May 24, 2000
Power TrainSuspensionUnknown Or Other
ENGINE CHECK LIGHT COMES ON, AND THE VEHICLE MAKES A VIBRATING/HUMMING NOISE. ALSO, VEHICLE DOES NOT SHIFT INTO GEAR PROPERLY. DEALER HAS SEEN VEHICLE, AND CAN'T FIND THE CAUSE OF THE PROBLEM.*AK
NHTSA ODI #862426
Mileage unknown · Dec 2, 1999
Air BagsEngine And Engine CoolingPower Train
TRANSMISSION SHIFT SLIPS OUT OF PARK, AIR BAG LIGHT STAYS ON, COOLENT LEAK AT ENGINE LOWER LEFT , LOWER FRONT PULLEY BEARING DAMAGED ENGINE
NHTSA ODI #715551
Mileage unknown · Nov 24, 1999
Power Train
WHEN BACKING OUT SOMETIMES & WHEN PUSHING ON THE GAS, CAR WILL NOT MOVE. CAR WILL JUST EJECT BACK UNEXPECTEDLY. *AK
NHTSA ODI #851039
Mileage unknown · Nov 9, 1999
Power TrainFire
RIGHT AFTER PUTTING VEHICLE IN PARK THERE WAS A FIRE IN THE ENGINE COMPARTMENT. VEHICLE WILL BE TOWED TO THE DEALERSHIP. THE VEHICLE HAS CAUGHT ON FIRE 4 OTHER TIMES IN THE ENGINE COMPARTMENT WHILE DRIVING. ALL 4 TIMES THE TRANSMISSION FLUID WAS DRAINED AT THE DEALERSHIP. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK
NHTSA ODI #852717
Mileage unknown · Aug 23, 1999
Engine And Engine CoolingPower TrainVehicle Speed Control
VEHICLE WOULD JERK. ENGINE CHECK LIGHT KEPT COMING ON. VEHCLE WOULD OVERHEAT & FAIL TO START. ALSO, VEHICLE HAD REVVED WHILE AT STOP LIGHT DUE TO FAST IDLE . THE PORTED PASSAGE HOLE WAS TOO SMALL. IT NEEDED TO BE WIDER ACCORDING TO MECHANIC. DRIVESHAFT BROKE TWICE IN LAST 6 MONTHS. *AK
NHTSA ODI #845632
Mileage unknown · Jul 21, 1999
Engine And Engine CoolingLatches/locks/linkagesPower Train
AFTER PURCHASING THIS VEHICLE NEW WE ARE VERY UPSET AT THE LACK OF CONCERN AND ASSISSTANCE FROM THE NUMEROUS GOVERNMENT AGENCIES I HAVE CONTACTED, COMPLETED FORMS AND MAILED THEM, I HAVE YET TO BE CONTACTED. BOTH MY 4 YEAR OLD SON & I ALMOST LOST OUR LIVES WHEN MY ENGINE STALLED ON AN INTERSTATE SPEED LIMIT 70 CARS TURNING EVERY…
Read full complaint
AFTER PURCHASING THIS VEHICLE NEW WE ARE VERY UPSET AT THE LACK OF CONCERN AND ASSISSTANCE FROM THE NUMEROUS GOVERNMENT AGENCIES I HAVE CONTACTED, COMPLETED FORMS AND MAILED THEM, I HAVE YET TO BE CONTACTED. BOTH MY 4 YEAR OLD SON & I ALMOST LOST OUR LIVES WHEN MY ENGINE STALLED ON AN INTERSTATE SPEED LIMIT 70 CARS TURNING EVERYWAY TO AVOID US, I REALLY FELT THERE WAS NO HOPE WHEN I SAW AN 18 WHEELER APPROACHING, I TURNED TO MOVE MY SON FROM THE REAR SEAT TO THE FRONT SO I COULD AT LEAST HOLD HIM, THE DRIVER SAW ME AND WHEN HE MANAGED TO STOP HIS RIG WAS JACKKNIFED AND 1 SIDE HIT THE BLOCK BARRIER. I HAVE DOCUMENTS TO PROVE THE ENGINE PROBLEMS IN 97 KIA'S CAN'T BE REPAIRED.WILL LIVES BE LOST BEFORE KIA IS HELD RESPONSIBLE? PLEASE HELP
NHTSA ODI #708920
Mileage unknown · Apr 18, 1999
Power TrainService Brakes, HydraulicCrash
DRIVING BETWEEN 40-45 MPH DRIVESHAFT FELL OUT, DAMAGING ENTIRE UNDERSIDE OF VEHICLE GOUGING FUEL TANK IN SEVERAL PLACES. REAR END FELL LOCKING UP BRAKES AND THROWING VEHICLE INTO UNCONTROLLABLE BOUNCING FOR OVER QUARTER MILE. DRIVESHAFT FLEW INFRONT OF OTHER VEHICLES WINDSHIELD. WIFE(9 MO. PREG.) & SON IN CAR WITH ME. *AK
NHTSA ODI #705742
NHTSA investigations
4EA06007 · Fuel Tank Leakage
Opened May 9, 2006 · Closed Nov 30, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (3)
Fuel System, Gasoline
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage:tank Assembly
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
RQ02013 · Engine Stalling POST-RECALL
Opened Oct 18, 2002 · Closed Sep 2, 2003
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Additional source detail variants (3)
Electrical System:wiring:front Underhood
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Electrical System:wiring
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Engine And Engine Cooling
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
PE02051 · Safety Belt Buckle Malfunction
Opened Jun 17, 2002 · Closed Sep 20, 2002
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
BY LETTER DATED AUGUST 25, 2002, KIA ADVISED NHTSA THAT THE SUBJECT VEHICLES WILL BE RECALLED.SPECIFIC CORRECTIVE ACTION TO BE TAKEN BY KIA HAS NOT BEEN REPORTED TO NHTSA AT THIS TIME.THE SAFETY RECALL PROGRAM HAS BEEN ASSIGNED CAMPAIGN NO. 02V-216.
SQ99021 · Check Engine Light Stays On
Opened Jun 30, 1999 · Closed Feb 2, 2000
Status: closed (inferred from source dates) · Electrical System
A monthly Technical Times published by Kia and distributed to dealer technicians identifying a wiring harness problem that could cause connectors C123 and C124 to pull apart slightly during engine load changes.This could lead to erratic or tempory loss
Illustration