Engine And Engine CoolingExterior LightingPower Train
ON 4/23/01 I TOOK MY CAR TO WESTCOTT KIA MOTORS, I HAD A CONCERN REGUARDING MY TRANSMISSION, THEY INSPECTED AND SAID THEYFOUND SWITCH STOP LAMP WASNT WORKING AT WHICH TIME THEY REPLACED IT , IT WAS UNDER WARRANTY, THEY ALSO REPLACED AN EGR VALVE THAT WAS UNDER WARRANTY, STILL TO NO AVAIL OF HAVING MY TRANSMISSION CONCERNES RESOL…
Read full complaint
ON 4/23/01 I TOOK MY CAR TO WESTCOTT KIA MOTORS, I HAD A CONCERN REGUARDING MY TRANSMISSION, THEY INSPECTED AND SAID THEYFOUND SWITCH STOP LAMP WASNT WORKING AT WHICH TIME THEY REPLACED IT , IT WAS UNDER WARRANTY, THEY ALSO REPLACED AN EGR VALVE THAT WAS UNDER WARRANTY, STILL TO NO AVAIL OF HAVING MY TRANSMISSION CONCERNES RESOLVED WITH THIS DEALER (AFTER ALL THESE REPAIRS , MY CAR STILL HAD THE SAME PROBLEM I BROUGHT IT IN FOR) I FILED A COMPLAINT WITH KIA CONSUMER AFFAIRS. I WAITED A COUPLE OF MONTHS AND DECIDED TO TRY MY LUCK AT ANOTHER DEALER IN THE AREA SO I WENT TO EL CAJON KIA ON 11/19/01 AN ALLOWED THEM TO WORK ON MY CAR AT WHICH TIME THEY ORDERED A TRANSFER CASE TO BE INSTALLED ON 12/05/01, THEY REPLACED THE TRANSFER CASE AND IT BROKE WHILE I WAS ON THE FREEWAY 12/07/01 AT WHICH TIME I HAD THE VEHICLE TOWED TO THEIR SHOP, THEY REPAIRED THE TRANSFER CASE AGAIN AND STILL THE CLUNKING NOISE I HAD BROUGHT IT IN FOR WAS STILL THERE IN MY CAR, I DROVE MY CAR FOR A FEW MORE DAYS UNTILL IT STARTED TO HESITATE ON ME AND THE ENGINE LIGHT CAME ON, I HAD MY CAR TOWED BACK TO EL CAJON KIA AND THE TECHNICIAN TOOK A TEST DRIVE WITH ME AND STATED WHILE WE WERE DRIVING MY CAR THAT KIA ONLY PAYS THEM FOR 2 HOURS OF SERVICE TO VEHICLES, AND THAT IT WAS NORMAL PLAY THAT I WAS HEARING IN MY VEHICLE, AFTER ALL THE DAYS IN THE SHOP AND ALL THE REPAIRS DONE, MY CAR WAS NO BETTER THAN WHEN I TOOK IT IN FOR IT TO BE REPAIRED, I FEEL LIKE THEY DID MORE DAMAGE THAN GOOD TO MY VEHICLE, AND I ALSO FEEL THAT THERE IS A MAJOR PROBLEM WITH MY TRANSMISSION THAT THE DEALER FAILED TO REPAIR, I JUST TOOK MY CAR TO RANCHO KIA (WHERE I BOUGHT IT FROM AND HAD REPAIR PROBLEMS WITH REGUARDING MY TIRE LATCH) AND THEY HAD TO REPAIR WIRING TO MAF SENSOR AND REPLACED MY EGR VALVE AND ALSO MY PURGE SOLENOID WAS BROKEN AND THEY SAID THE CLUNKING NOISE IS MY FRONT HUB BEARINGS ARE LOOSE.
NHTSA ODI #759076
Mileage unknown · May 20, 1999
Exterior LightingInterior Lighting
BRAKE LIGHT STAYS ON. WHENEVER TURNING ON INTERIOR LIGHTS, BRAKE LIGHT ILLUMINATES AND STAYS ON. DEALER SAIS VEHICLE IS NOT UNDER WARRANTY. *AK
NHTSA ODI #838206
Mileage unknown · Jul 22, 1998
Exterior Lighting
CONSUMER COMPLAINED OF NOT HAVING ANY HAZARD LIGHTS, AND WAS UNABLE TO GET THE DEALER TO REPAIR THEM. DEALER INFORMED CONSUMER THAT THEY ARE WAITING ON THE PARTS. *AK
ON CERTAIN PASSENGER VEHICLES, THE SAFETY BELT BUCKLE MAY "FALSE LATCH" AND EXPOSE THE DRIVER TO UNRESTRAINED MOVEMENT DURING A CRASH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: OWNER NOTIFICATION BEGAN DECEMBER 20, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE WIRES CONNECTED TO THE C123 AND C124 CONNECTORS CAN BE PUT UNDER TENSION BY MOVEMENT OF THE ENGINE, THUS PULLING THE WIRES AND CONNECTORS, LOOSENING THEM AND RESULTING IN A LOSS OF CIRCUIT CONTINUITY.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE ENGINE STALLING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SPRING CLIPS TO LOCK THE CONNECTORS TOGETHER. IN ADDITION, THE DEALERS WILL BE INSTRUCTED TO SOLDER A SPLICE IN THE WIRE HARNESS.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MICROSWITCH ON THE REAR HATCH LOCK CYLINDER CAN MALFUNCTION CAUSING THE POWER DOOR LOCKS TO UNLOCK INADVERTENTLY.
Consequence & remedy
Consequence: SHOULD THIS OCCUR, SECURITY FROM UNWANTED INTRUSION INTO THE VEHICLE IS LOST.
Remedy: DEALERS WILL MODIFY THE REAR HATCH DOOR UNLOCK CIRCUIT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (3)
Fuel System, Gasoline
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage:tank Assembly
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
RQ02013 · Engine Stalling POST-RECALL
Opened Oct 18, 2002 · Closed Sep 2, 2003
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Additional source detail variants (3)
Electrical System:wiring:front Underhood
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Electrical System:wiring
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Engine And Engine Cooling
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
PE02051 · Safety Belt Buckle Malfunction
Opened Jun 17, 2002 · Closed Sep 20, 2002
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
BY LETTER DATED AUGUST 25, 2002, KIA ADVISED NHTSA THAT THE SUBJECT VEHICLES WILL BE RECALLED.SPECIFIC CORRECTIVE ACTION TO BE TAKEN BY KIA HAS NOT BEEN REPORTED TO NHTSA AT THIS TIME.THE SAFETY RECALL PROGRAM HAS BEEN ASSIGNED CAMPAIGN NO. 02V-216.
SQ99021 · Check Engine Light Stays On
Opened Jun 30, 1999 · Closed Feb 2, 2000
Status: closed (inferred from source dates) · Electrical System
A monthly Technical Times published by Kia and distributed to dealer technicians identifying a wiring harness problem that could cause connectors C123 and C124 to pull apart slightly during engine load changes.This could lead to erratic or tempory loss
Illustration