NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
56 reportsClear category filterMileage unknown · Feb 19, 1999
Engine And Engine CoolingPower TrainSuspension
THIS VEHICLE IS GARBAGE - BOTH FRONT WINDOW MOTORS-REPLACED. TRANSMISSION REPLACED, AND IS NOW ACTING UP AGAIN. REAR-END REPLACED, ACTING UP, ENGINE SQUEALS, DEALER CAN'T HEAR IT, BURNING ANTI-FREEZE SMELL UPON WARMUP, TEMP GAUGE GOES CRAZY, IN 4WD VEHICLE DOES NOT WANT TO TURN, ONLY WANTS TO GO STRAIGHT, MAKINGS HARD "CLUNKING…
Read full complaint
THIS VEHICLE IS GARBAGE - BOTH FRONT WINDOW MOTORS-REPLACED. TRANSMISSION REPLACED, AND IS NOW ACTING UP AGAIN. REAR-END REPLACED, ACTING UP, ENGINE SQUEALS, DEALER CAN'T HEAR IT, BURNING ANTI-FREEZE SMELL UPON WARMUP, TEMP GAUGE GOES CRAZY, IN 4WD VEHICLE DOES NOT WANT TO TURN, ONLY WANTS TO GO STRAIGHT, MAKINGS HARD "CLUNKING" NOISE IF YOU ATTEMPT TO TURN. THE YUGO WAS A BETTER VEHICLE! *AK
NHTSA ODI #703509
Mileage unknown · Jan 25, 1999
Air BagsEngine And Engine CoolingStructure
ENGINE CHECK LIGHT IS ON, THE CAR IS STALLING, THE AIR BAG LIGHTS ARE ON. I AM AFRAID THAT THEY WILL DEPLOY AT ANY GIVEN TIME. ALMOST KILLED MYSELF AND MY DAUGHTER ON THE QUEENBORO BRIDGE, I WAS GOING 40 AND ALL OF A SUDDEN THE CAR ACCELERATED ON IT'S OWN, I APPLIED THE BRAKES, BUT THEY HAD TURNED HARD, I HAD NO BRAKES, PUT E…
Read full complaint
ENGINE CHECK LIGHT IS ON, THE CAR IS STALLING, THE AIR BAG LIGHTS ARE ON. I AM AFRAID THAT THEY WILL DEPLOY AT ANY GIVEN TIME. ALMOST KILLED MYSELF AND MY DAUGHTER ON THE QUEENBORO BRIDGE, I WAS GOING 40 AND ALL OF A SUDDEN THE CAR ACCELERATED ON IT'S OWN, I APPLIED THE BRAKES, BUT THEY HAD TURNED HARD, I HAD NO BRAKES, PUT EMERGENCY BRAKES, BUT NOTHING, WHEN IT WAS NEARING AN ACCIDENT BECAUSE I HAD TO STOP I THREW THE CAR IN NEUTRAL WHICH SLOWED IT DOWN ENOUGH FOR ME TO SAFELY PUT IT IN PARK IN THE MIDDLE OF A BRIDGE. THE CARS ENGINE ROARED WHEN I PUT IN PARK I COULDN'T MOVE OR FEAR OF KILLING MYSELF. THE LOCKS ON THE CAR KEEP OPENING AND CLOSING BY THEMSELF. IT NEEDS 2 QUARTS OF ENGINE OIL EVERY MONTH. I AM TOTALLY DISSATISFIED WITH THIS CAR. *AK
NHTSA ODI #702537
Mileage unknown · Oct 30, 1998
Engine And Engine Cooling
CONSUMER EXPERIENCING ONGOING PROBLEM WITH VEHICLE STALLING WIITHOUT WARNING. VEHICLE BEEN INSPECTED BY DEALER ON TWO OCCASIONS AND WAS UNABLE TO CORRECT OR DUPLICATE THE PROBLEM. *AK
NHTSA ODI #829839
Mileage unknown · Oct 28, 1998
Engine And Engine Cooling
CONSUMER EXPERIENCING PROBLEM WITH VEHICLE INTERMITTENTLY STALLING WHILE DRIVING. AND WHENEVER VEHICLE REACHES SPEED OF 15 -50 MPH. VEHICLE HAVE BEEN INSPECTED BY DEALER, INFORMED CONSUMER THAT THE PROBLEM COULD NOT BE DUPLICATED. *AK
NHTSA ODI #829616
Mileage unknown · Oct 1, 1998
Engine And Engine CoolingEquipmentVisibility
WHILE DRIVING AT ANY SPEED THE VEHICLE GIVES NO PRIOR WARNING. THE ENGINE CHECK LIGHT COMING ON. CONTACTED DEALER , CAN'T FIND THE PROBLEM. VEHICLE HAS BEEN IN THE SHOP THREE TIMES. *AK CHECK ENGINE LIGHT COMES ON AND ENGINE STALLES AT TIMES WHILE DRIVING DUE TO EGR VALVE FAILURE. HOOD RELEASE HANDLE WAS BROKE. RIGHT FRONT HU…
Read full complaint
WHILE DRIVING AT ANY SPEED THE VEHICLE GIVES NO PRIOR WARNING. THE ENGINE CHECK LIGHT COMING ON. CONTACTED DEALER , CAN'T FIND THE PROBLEM. VEHICLE HAS BEEN IN THE SHOP THREE TIMES. *AK CHECK ENGINE LIGHT COMES ON AND ENGINE STALLES AT TIMES WHILE DRIVING DUE TO EGR VALVE FAILURE. HOOD RELEASE HANDLE WAS BROKE. RIGHT FRONT HUBCAP FELL OFF. RADIO BEZEL WAS BROKE. *YH
NHTSA ODI #828455
Mileage unknown · Aug 29, 1998
Engine And Engine Cooling
WATER PUMP FAILED CAUSING NOISE.
NHTSA ODI #539446
Mileage unknown · Aug 13, 1998
Engine And Engine Cooling
WHILE DRIVING VEHICLE INTERMITTENTLY SHUT DOWN WITHOUT CAUSE. VEHICLE BEEN IN/OUT OF DEALER SHOP MORE THEN NINE OCCASIONS, AND CONDITION CANNOT BE RESOLVED. DEALER/MANUFACTURER NOTIFIED. *AK
NHTSA ODI #826658
Mileage unknown · Aug 11, 1998
Engine And Engine Cooling
WHILE DRIVING VEHICLE ABOUT ANY MPH AND WHEN MAKING A TURN OR JUST DRIVING, THE ENGINE STALLED WITHOUT A WARNING. *AK
NHTSA ODI #826565
Mileage unknown · Jul 30, 1998
Engine And Engine CoolingFuel System, GasolineStructure
AUTO LEAKING FLUID NEAR ENGINE. IN ADDITION, INTERMITTENT STALLING/ELECTRICAL DOOR AND WINDOW SWITCH FAILED, AND ENGINE CHECK LIGHT COMES ON/OFF. *AK
NHTSA ODI #826107
Mileage unknown · Jul 1, 1998
Engine And Engine Cooling
WHEN TRAVELING AT ANY SPEED THE VEHICLE WILL CUT OFF WITHOUT PRIOR WARNING . CONSUMER HAS CONTACTED THE DEALER, DEALER UNABLE TO DETERMINE THE PROBLEM. *AK
NHTSA ODI #824921
NHTSA investigations
4EA06007 · Fuel Tank Leakage
Opened May 9, 2006 · Closed Nov 30, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (3)
Fuel System, Gasoline
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage:tank Assembly
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
RQ02013 · Engine Stalling POST-RECALL
Opened Oct 18, 2002 · Closed Sep 2, 2003
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Additional source detail variants (3)
Electrical System:wiring:front Underhood
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Electrical System:wiring
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Engine And Engine Cooling
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
PE02051 · Safety Belt Buckle Malfunction
Opened Jun 17, 2002 · Closed Sep 20, 2002
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
BY LETTER DATED AUGUST 25, 2002, KIA ADVISED NHTSA THAT THE SUBJECT VEHICLES WILL BE RECALLED.SPECIFIC CORRECTIVE ACTION TO BE TAKEN BY KIA HAS NOT BEEN REPORTED TO NHTSA AT THIS TIME.THE SAFETY RECALL PROGRAM HAS BEEN ASSIGNED CAMPAIGN NO. 02V-216.
SQ99021 · Check Engine Light Stays On
Opened Jun 30, 1999 · Closed Feb 2, 2000
Status: closed (inferred from source dates) · Electrical System
A monthly Technical Times published by Kia and distributed to dealer technicians identifying a wiring harness problem that could cause connectors C123 and C124 to pull apart slightly during engine load changes.This could lead to erratic or tempory loss
Illustration