NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
56 reportsClear category filter104,000 miles · Jan 9, 2007
Engine And Engine CoolingPower Train
TL* - THE CONTACT OWNS A 1997 KIA SPORTAGE. THE VEHICLE WAS OVERHEATING. THE CONTACT SAID THAT THE USED CAR DEALER REPLACED THE RADIATOR AND THE MAIN HOSE. THE VEHICLE CONTINUED TO OVERHEAT, AND WHEN DIAGNOSED ,THE CONTACT WAS TOLD THE OVERHEATING WAS DUE TO THE CLUTCH OVERHEATING AND THE FAN STICKING. THE CONTACT DIDN'T THINK…
Read full complaint
TL* - THE CONTACT OWNS A 1997 KIA SPORTAGE. THE VEHICLE WAS OVERHEATING. THE CONTACT SAID THAT THE USED CAR DEALER REPLACED THE RADIATOR AND THE MAIN HOSE. THE VEHICLE CONTINUED TO OVERHEAT, AND WHEN DIAGNOSED ,THE CONTACT WAS TOLD THE OVERHEATING WAS DUE TO THE CLUTCH OVERHEATING AND THE FAN STICKING. THE CONTACT DIDN'T THINK THAT TRANSMISSION OIL WAS CIRCULATING THROUGHOUT THE VEHICLE PROPERLY. THERE WERE NO WARNING INDICATOR LIGHTS. THE VEHICLE CURRENTLY WILL NOT START. THE DEALER WAS NO LONGER IN BUSINESS. *AK
NHTSA ODI #10178267
85,000 miles · Dec 12, 2005
Engine And Engine Cooling
KIA REFUSES TO INCLUDE MY 1997 SPORTAGE EX 4WD IN RECALL FOR 1997 KIA SPORTAGES EX 4WD. RECALL 1CMP005 TO REPLACE THE ENGINE CONTROL MODULE (ECM) HAS NEVER BEEN PERFORMED. ALSO NOT SURE THAT RECALL 2CMP014 ON WIRING HAS BEEN PERFORMED. MY MAIN CONCERN AND THE REFUSAL FROM KIA IS ON THE ECM. *JB
NHTSA ODI #10144954
Mileage unknown · Dec 30, 2004
Engine And Engine Cooling
NHTSA CAMPAIGN 99V325000; KIA ISSUED AN ENGINE STALLING RECALL. THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. HOWEVER, THE ENGINE STALLED, AND CHECK ENGINE LIGHT REMAINED ON. *AK
NHTSA ODI #10105570
119,000 miles · Jan 15, 2004
Engine And Engine CoolingEquipmentFuel System, Gasoline
THIS CAR IS ABSOLUTELY UNSAFE TO DRIVE; AT ANY MOMENT IT MAY STALL DUE TO THE FAULTY ELECTRICAL SYSTEM. I HAVE HAD THIS CAR IN FOR SERVICE NUMEROUS TIMES AND I HAVE NEVER GOTTEN THE PROBLEM RESOLVED. I HAVE SIMPLY HAD ENOUGH AND WOULD LIKE SOME HELP.
NHTSA ODI #10069561
Mileage unknown · Jul 1, 2003
Engine And Engine Cooling
CONSUMER STATES THAT WHILE DRIVING AND WITH NO WARNING THE VEHICLE WOULD STALL OUT. DEALER NOTIFIED. *AK
NHTSA ODI #10026298
Mileage unknown · May 1, 2002
Engine And Engine CoolingPower Train
CONSUMER STATES WHEN HITTING BUMP SOMETHING IS LOOSE. DEALER FOULD BROKEN PROPELLER SHAFT. *TT
NHTSA ODI #565564
Mileage unknown · Apr 22, 2002
Electrical SystemEngine And Engine CoolingFire
VEHICLE STALLED AT 35 MPH. CONSUMER SMELLED SMOKE, THEN SAW FLAMES COMING FROM UNDER THE HOOD. VEHICLE WAS TOTALLED. *AK
NHTSA ODI #8008169
Mileage unknown · Mar 7, 2002
Engine And Engine CoolingExterior LightingPower Train
ON 4/23/01 I TOOK MY CAR TO WESTCOTT KIA MOTORS, I HAD A CONCERN REGUARDING MY TRANSMISSION, THEY INSPECTED AND SAID THEYFOUND SWITCH STOP LAMP WASNT WORKING AT WHICH TIME THEY REPLACED IT , IT WAS UNDER WARRANTY, THEY ALSO REPLACED AN EGR VALVE THAT WAS UNDER WARRANTY, STILL TO NO AVAIL OF HAVING MY TRANSMISSION CONCERNES RESOL…
Read full complaint
ON 4/23/01 I TOOK MY CAR TO WESTCOTT KIA MOTORS, I HAD A CONCERN REGUARDING MY TRANSMISSION, THEY INSPECTED AND SAID THEYFOUND SWITCH STOP LAMP WASNT WORKING AT WHICH TIME THEY REPLACED IT , IT WAS UNDER WARRANTY, THEY ALSO REPLACED AN EGR VALVE THAT WAS UNDER WARRANTY, STILL TO NO AVAIL OF HAVING MY TRANSMISSION CONCERNES RESOLVED WITH THIS DEALER (AFTER ALL THESE REPAIRS , MY CAR STILL HAD THE SAME PROBLEM I BROUGHT IT IN FOR) I FILED A COMPLAINT WITH KIA CONSUMER AFFAIRS. I WAITED A COUPLE OF MONTHS AND DECIDED TO TRY MY LUCK AT ANOTHER DEALER IN THE AREA SO I WENT TO EL CAJON KIA ON 11/19/01 AN ALLOWED THEM TO WORK ON MY CAR AT WHICH TIME THEY ORDERED A TRANSFER CASE TO BE INSTALLED ON 12/05/01, THEY REPLACED THE TRANSFER CASE AND IT BROKE WHILE I WAS ON THE FREEWAY 12/07/01 AT WHICH TIME I HAD THE VEHICLE TOWED TO THEIR SHOP, THEY REPAIRED THE TRANSFER CASE AGAIN AND STILL THE CLUNKING NOISE I HAD BROUGHT IT IN FOR WAS STILL THERE IN MY CAR, I DROVE MY CAR FOR A FEW MORE DAYS UNTILL IT STARTED TO HESITATE ON ME AND THE ENGINE LIGHT CAME ON, I HAD MY CAR TOWED BACK TO EL CAJON KIA AND THE TECHNICIAN TOOK A TEST DRIVE WITH ME AND STATED WHILE WE WERE DRIVING MY CAR THAT KIA ONLY PAYS THEM FOR 2 HOURS OF SERVICE TO VEHICLES, AND THAT IT WAS NORMAL PLAY THAT I WAS HEARING IN MY VEHICLE, AFTER ALL THE DAYS IN THE SHOP AND ALL THE REPAIRS DONE, MY CAR WAS NO BETTER THAN WHEN I TOOK IT IN FOR IT TO BE REPAIRED, I FEEL LIKE THEY DID MORE DAMAGE THAN GOOD TO MY VEHICLE, AND I ALSO FEEL THAT THERE IS A MAJOR PROBLEM WITH MY TRANSMISSION THAT THE DEALER FAILED TO REPAIR, I JUST TOOK MY CAR TO RANCHO KIA (WHERE I BOUGHT IT FROM AND HAD REPAIR PROBLEMS WITH REGUARDING MY TIRE LATCH) AND THEY HAD TO REPAIR WIRING TO MAF SENSOR AND REPLACED MY EGR VALVE AND ALSO MY PURGE SOLENOID WAS BROKEN AND THEY SAID THE CLUNKING NOISE IS MY FRONT HUB BEARINGS ARE LOOSE.
NHTSA ODI #759076
Mileage unknown · Jan 16, 2002
Engine And Engine Cooling
KIA HAS ISSUED A VOLUNTARY RECALL OF ITS 1998 SPORTAGE SPORT UTILITY VEHICLES TO REPLACE THE MANIFOLD CATALYTIC CONVERTER. THIS SAME PROBLEM HAS ALSO HAPPENED TO MY 1997 SPORTAGE. A FRIEND OF MINE HAS THE SAME MODEL AND YEAR AS MY SPORTAGE AND THE PROBLEM HAS HAPPENED TO HER VEHICLE ALSO. I THINK THIS RECALL NEEDS TO BE EXTENDE…
Read full complaint
KIA HAS ISSUED A VOLUNTARY RECALL OF ITS 1998 SPORTAGE SPORT UTILITY VEHICLES TO REPLACE THE MANIFOLD CATALYTIC CONVERTER. THIS SAME PROBLEM HAS ALSO HAPPENED TO MY 1997 SPORTAGE. A FRIEND OF MINE HAS THE SAME MODEL AND YEAR AS MY SPORTAGE AND THE PROBLEM HAS HAPPENED TO HER VEHICLE ALSO. I THINK THIS RECALL NEEDS TO BE EXTENDED TO THE 1997 SPORTAGES ALSO. THE CAR WILL NOT PASS EMMISIONS INSPECTIONS AND I DONT THINK I SHOULD HAVE TO PAY FOR A PROBLEM THAT WAS CAUSED BY THE MANUFACTURER.*AK
NHTSA ODI #756920
Mileage unknown · Oct 16, 2001
Engine And Engine Cooling
RECALL 99V325000 REPAIRS HAD BEEN DONE ON VEHICLE, BUT REMEDY DID NOT WORK. CONSUMER WAS STILL HAVING SAME STALLING PROBLEMS AS MENTIONED IN RECALL. *AK
NHTSA ODI #897805
NHTSA investigations
4EA06007 · Fuel Tank Leakage
Opened May 9, 2006 · Closed Nov 30, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (3)
Fuel System, Gasoline
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage:tank Assembly
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
RQ02013 · Engine Stalling POST-RECALL
Opened Oct 18, 2002 · Closed Sep 2, 2003
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Additional source detail variants (3)
Electrical System:wiring:front Underhood
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Electrical System:wiring
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Engine And Engine Cooling
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
PE02051 · Safety Belt Buckle Malfunction
Opened Jun 17, 2002 · Closed Sep 20, 2002
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
BY LETTER DATED AUGUST 25, 2002, KIA ADVISED NHTSA THAT THE SUBJECT VEHICLES WILL BE RECALLED.SPECIFIC CORRECTIVE ACTION TO BE TAKEN BY KIA HAS NOT BEEN REPORTED TO NHTSA AT THIS TIME.THE SAFETY RECALL PROGRAM HAS BEEN ASSIGNED CAMPAIGN NO. 02V-216.
SQ99021 · Check Engine Light Stays On
Opened Jun 30, 1999 · Closed Feb 2, 2000
Status: closed (inferred from source dates) · Electrical System
A monthly Technical Times published by Kia and distributed to dealer technicians identifying a wiring harness problem that could cause connectors C123 and C124 to pull apart slightly during engine load changes.This could lead to erratic or tempory loss
Illustration