IllustrationRIGHT FRONT PASSENGER OPENED PASSENGER-SIDE DOOR WITH INTERIOR DOOR HANDLE. DOOR HANDLE/METALLIC COATING SEPARATED AT SEAM AND CUT/PINCHED OCCUPANT'S RIGHT RING FINGER. HANDLE SEAM NOW SEPARATED/SHARP. VEHICLE WAS STATIONARY IN DRIVEWAY.
2008 Kia Spectra
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2008 Kia Spectra do not stand out strongly from the model-year median of 96.
About this comparison →How this year compares
Owner complaints by model year
Compare all Spectra years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
200–25K
1225–50K
1550–75K
1775–100K
24100–150K
5150K+
93 reports with mileage · 28 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports3 fire reports16 injury reports
What owners actually said
121 reportsTAKATA RECALL WAS RUNNING THE PAPER ROUTE FOR THE TELEGRAPH AND A DEER RAN OUT IN FRONT OF MY VEHICLE INSURANCE SAID LOSS CAUSE BUT AIR BAGS NEVER WENT OFF AND SOME HOW ENDED UP IN SALVAGE...
I TEST DROVE THE VEHICLE AND IT DROVE FINE. AFTER I SIGNED PAPERS TO BUY THE VEHICLE, I DROVE IT HOME. ON THE WAY HOME I WAS DOING THE SPEED LIMIT WHICH IS 65MPH BUT I ALWAYS STAY A LITTLE UNDER THAT SPEED LIMIT. I GOT TO ABOUT 65 AND BOOM IT WAS LIKE THE TRANSMISSION HAD COME THROUGH THE FLOOR AND IT FELT AS IF I WAS GOING TO B…
Read full complaint
I TEST DROVE THE VEHICLE AND IT DROVE FINE. AFTER I SIGNED PAPERS TO BUY THE VEHICLE, I DROVE IT HOME. ON THE WAY HOME I WAS DOING THE SPEED LIMIT WHICH IS 65MPH BUT I ALWAYS STAY A LITTLE UNDER THAT SPEED LIMIT. I GOT TO ABOUT 65 AND BOOM IT WAS LIKE THE TRANSMISSION HAD COME THROUGH THE FLOOR AND IT FELT AS IF I WAS GOING TO BE EJECTED FROM THE CAR! THAT SCARED ME TO DEATH!!! AFTER THAT IT STARTED DRAGGING SO I HAD TO EXIT THE HIGHWAY AND DRIVE THE CITY STREETS WITH MY EMERGENCY FLASHERS ON BECAUSE I COULD DO NO MORE THAN 35-40 MPH. I GOT THE CAR NOV 2016 AND THIS HAPPENS EVERYTIME I DRIVE IT. ITS DOING THE SAME THING JUST SITTING IN A DRIVE THROUGH. IT KICKS BACK SO HARD IT HURTS MY NECK. IT FEELS LIKE SOMEONE HITS ME FROM THE BACK EVERYTIME. I WOULD REALLY Y LIKE TO KNOW WHERE I CAN HAVE THIS REPAIR TAKEN CARE OF BECAUSE THIS IS VERY DANGEROUS. I HAVE READ A LOT OF REVIEWS ONLINE AND A LOT OF PEOPLE HAVE THE SAME ISSUE. IT'S BEEN DOING IT SINCE DAY ONE AND I NEED IT FIXED BECAUSE IT HURTS REALLY BAD. I DIDN'T DO THIS TO THE VEHICLE. IT HAPPENS NO MATTER WHAT SPEED YOU'RE DOING AND THEN ACTS LIKE IT'S STUCK IN HIGH GEAR AND TAKES OFF SLOWLY AFTER IT JERKS.
MY CAR HAS APPROX 145000 MILES. DRIVES GREAT EXCEPT FOR IN THE LAST FEW MONTHS IT HAS A TRANSMISSION PROBLEM. I GOOGLED THE PROBLEM AND NUMEROUS PEOPLE HAVE THE EXACT SAME PROBLEM. AFTER DRIVING THE CAR AFTER SITTING ALL NIGHT FOR ABOUT AN HOUR YOU CAN BE DRIVING 5 MPH OR 60 MPH THE CAR WILL JERK HARD...FROM THE TRANSMISSION. I…
Read full complaint
MY CAR HAS APPROX 145000 MILES. DRIVES GREAT EXCEPT FOR IN THE LAST FEW MONTHS IT HAS A TRANSMISSION PROBLEM. I GOOGLED THE PROBLEM AND NUMEROUS PEOPLE HAVE THE EXACT SAME PROBLEM. AFTER DRIVING THE CAR AFTER SITTING ALL NIGHT FOR ABOUT AN HOUR YOU CAN BE DRIVING 5 MPH OR 60 MPH THE CAR WILL JERK HARD...FROM THE TRANSMISSION. I HAVE HAD THE CAR INSPECTED AND FIXED NUMEROUS TIMES. MECHANIC'S SAY THE TRANSMISSION IS IN GOOD CONDITION. THEY HAVE FIXED NUMEROUS ITEMS ON 3 DIFFERENT TIMES WITH THE TRANSMISSION; FLUSHED, WELDED, ETC . MECHANIC SAID THAT AFTER GOOGLING PROBLEM THAT MAY BE A COMPUTER DOWNLOAD THAT IS NEEDED. AS STATED ABOVE NUMEROUS PEOPLE HAVE SAME PROBLEM WITH 2007 THRU 2011 KIA
TL* THE CONTACT OWNED A 2008 KIA SPECTRA. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT APPLIED THE BRAKES WHILE APPROACHING A RED LIGHT. THE ENGINE SHUT DOWN, AND THE STEERING AND BRAKES FAILED. THE VEHICLE CROSSED THE INTERSECTION AND CRASHED INTO THE REAR DRIVER SIDE OF ANOTHER VEHICLE. THE BRAKE AND STEERING LIGHTS INDICAT…
Read full complaint
TL* THE CONTACT OWNED A 2008 KIA SPECTRA. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT APPLIED THE BRAKES WHILE APPROACHING A RED LIGHT. THE ENGINE SHUT DOWN, AND THE STEERING AND BRAKES FAILED. THE VEHICLE CROSSED THE INTERSECTION AND CRASHED INTO THE REAR DRIVER SIDE OF ANOTHER VEHICLE. THE BRAKE AND STEERING LIGHTS INDICATORS REMAINED ILLUMINATED. THE VEHICLE WAS DESTROYED AND TOWED. THE AIR BAGS FAILED TO DEPLOY. TWO INJURIES WERE SUSTAINED, WHICH REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.
ON 9/19/2016 I WAS DRIVING ON THE 91 FREEWAY ABOUT 40 MILES FROM HOME, MY CAR MADE A LOUD NOISE AND SHUT OFF, I WAS IN THE LEFT (FAST LANE) AND LOST ALL POWER, I PUT ON THE HAZARD LIGHTS AND HONKED THE HORN AS I STEERED THE CAR TOWARD THE RIGHT SIDE OF THE FREEWAY CROSSING SEVERAL LANES, LUCKILY I MADE IT WITHOUT HAVING AN ACCID…
Read full complaint
ON 9/19/2016 I WAS DRIVING ON THE 91 FREEWAY ABOUT 40 MILES FROM HOME, MY CAR MADE A LOUD NOISE AND SHUT OFF, I WAS IN THE LEFT (FAST LANE) AND LOST ALL POWER, I PUT ON THE HAZARD LIGHTS AND HONKED THE HORN AS I STEERED THE CAR TOWARD THE RIGHT SIDE OF THE FREEWAY CROSSING SEVERAL LANES, LUCKILY I MADE IT WITHOUT HAVING AN ACCIDENT, I CALLED FOR THE NEAREST TOW COMPANY TO COME AND TOW MY CAR HOME. WHEN I GOT HOME I OPENED THE HOOD AND SEEN THE CRANKSHAFT CAME THROUGH THE PLASTIC...
THE RIGHT-SIDE PASSENGER BRAKES LIGHTS ARE NOT WORKING. ALL BULBS ARE GOOD. MY CRUISE CONTROL HAS BEEN WORKING INTERMITTENTLY. AS I'M UNABLE TO VIEW MY BRAKE LIGHTS WHILE DRIVING, I'M GOING TO ASSUME THAT THESE TWO PROBLEMS ARE OCCURRING AT THE SAME TIME. I BELIEVE IT IS DUE TO A DEFECTIVE BRAKE SWITCH. I TESTED THE CRUISE CONT…
Read full complaint
THE RIGHT-SIDE PASSENGER BRAKES LIGHTS ARE NOT WORKING. ALL BULBS ARE GOOD. MY CRUISE CONTROL HAS BEEN WORKING INTERMITTENTLY. AS I'M UNABLE TO VIEW MY BRAKE LIGHTS WHILE DRIVING, I'M GOING TO ASSUME THAT THESE TWO PROBLEMS ARE OCCURRING AT THE SAME TIME. I BELIEVE IT IS DUE TO A DEFECTIVE BRAKE SWITCH. I TESTED THE CRUISE CONTROL BY TRYING TO ENGAGE IT WHILE DRIVING AT 40 MPH. IT DID NOT ENGAGE. WHEN CHECKING THE BRAKES WITH THE CAR PARKED IN THE DRIVEWAY - THEY WORKED INTERMITTENTLY. ALL WIRES ARE IN GOOD SHAPE AND FREE FROM CORROSION. I ALSO HAVE A PROBLEM WITH THE PASSENGER AIRBAG SENSOR AND REPORTED THIS TO YOUR ORGANIZATION. AT THE TIME I REPORTED IT THERE HAD NOT BEEN ENOUGH COMPLAINTS FOR THE SPECTRA, SPECIFICALLY, TO RECEIVE ANY HELP. THE PROBLEM DID EXIST IN HIGH NUMBERS IN OTHER KIA MODELS OF THE SAME YEAR -2008. RECENTLY, I RECEIVED NOTICE THAT THE AIR BAG SENSOR DEFECT HAS NOW BEEN RECOGNIZED AND I CAN HAVE THIS REPAIR MADE AT THE DEALERSHIP AT KIA'S EXPENSE. I THINK IT IS PRUDENT TO REPORT THIS APPARENT BRAKE SWITCH DEFECT AS I NOTICE RECALLS ON OTHER KIA MODELS OF THE SAME YEAR AS MINE - 2008 FOR BRAKE SWITCH DEFECT.
TL* THE CONTACT OWNS A 2008 KIA SPECTRA. WHILE DRIVING APPROXIMATELY 40 MPH, THE STEERING WHEEL LOCKED AND THE VEHICLE STALLED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS ABLE TO BE RESTARTED, BUT THE FAILURE RECURRED. THE VEHICLE WAS DRIVEN TO THE DEALER, BUT THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE W…
Read full complaint
TL* THE CONTACT OWNS A 2008 KIA SPECTRA. WHILE DRIVING APPROXIMATELY 40 MPH, THE STEERING WHEEL LOCKED AND THE VEHICLE STALLED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS ABLE TO BE RESTARTED, BUT THE FAILURE RECURRED. THE VEHICLE WAS DRIVEN TO THE DEALER, BUT THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 122,171....UPDATED 07/19/16 *BF UPDATED 06/15/18*JB
TL* THE CONTACT OWNS A 2008 KIA SPECTRA. WHILE THE VEHICLE WAS PARKED, THE AIR BAG WARNING LIGHT REMAINED ILLUMINATED. THE DEALER DIAGNOSED THAT THE OCS SENSOR MAT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED DUE TO PART UNAVAILABILITY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
WHILE DRIVING HWY AT 70 MILES, WHEN I INCREASE TO 75/80 THE CAR VIOLENTLY DOWNSHIFTS. I AM AFRAID TO DRIVE ON THE HIGHWAY NOW BECAUSE OF IT. I THOUGHT I RAN OVER SOMETHING BUT NO, IT DID IT AGAIN WITH MY 83 YEAR OLD MOTHER IN PASSENGER SEAT. WE WERE BOTH SHOOK UP OVER IT. NOW, I DO GO PAST 50 BECAUSE I DON'T FEEL SAFE AND IT'S …
Read full complaint
WHILE DRIVING HWY AT 70 MILES, WHEN I INCREASE TO 75/80 THE CAR VIOLENTLY DOWNSHIFTS. I AM AFRAID TO DRIVE ON THE HIGHWAY NOW BECAUSE OF IT. I THOUGHT I RAN OVER SOMETHING BUT NO, IT DID IT AGAIN WITH MY 83 YEAR OLD MOTHER IN PASSENGER SEAT. WE WERE BOTH SHOOK UP OVER IT. NOW, I DO GO PAST 50 BECAUSE I DON'T FEEL SAFE AND IT'S ONLY 8 YEARS OLD.
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE15031 · Occupant Classification System
Opened Sep 1, 2015 · Closed Feb 11, 2016
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Air Bags:sensor:occupant Classification
The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,
Additional source detail variants (4)
Air Bags:frontal
The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,
Air Bags:frontal:sensor/control MODULE-INACTIVE
The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,
Air Bags
The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,
Air Bags:sensor:occupant Classification
The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,