IllustrationPASSENGER AIRBAG INDICATOR FAILED TO TURN ON WHEN ADULT PASSENGER SAT IN SEAT. AIRBAG LIGHT APPEARED AND WAS BROUGHT TO DEALERSHIP. WAS INFORMED ISSUE WAS A DEFECTIVE OCS MAT ON PASSENGER SIDE. *TR
2007 Kia Spectra
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2007 Kia Spectra do not stand out strongly from the model-year median of 96.
About this comparison →How this year compares
Owner complaints by model year
Compare all Spectra years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
270–25K
2125–50K
2550–75K
2275–100K
22100–150K
5150K+
122 reports with mileage · 30 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
22 crash reports6 fire reports15 injury reports
Air Bags complaints
56 reportsAIRBAGS; FRONTAL; SENSOR/CONTROL MODULE: PASSENGER AIRBAG SEAT SENSOR MALFUNCTION. THE CENTER CONSOLE PASSENGER SEAT AIRBAG (YELLOW OCCUPANCY) ON/OFF LIGHT WOULD ILLUMINATE INTERMENT WHEN PASSENGER SAT IN PASSENGER SEAT REGARDLESS OF SPEED OR MOTION, I.E., SHORTLY AFTER ENGINE STARTUP THROUGH SHUTDOWN (SHOULD HAVE BEEN NO LIGH…
Read full complaint
AIRBAGS; FRONTAL; SENSOR/CONTROL MODULE: PASSENGER AIRBAG SEAT SENSOR MALFUNCTION. THE CENTER CONSOLE PASSENGER SEAT AIRBAG (YELLOW OCCUPANCY) ON/OFF LIGHT WOULD ILLUMINATE INTERMENT WHEN PASSENGER SAT IN PASSENGER SEAT REGARDLESS OF SPEED OR MOTION, I.E., SHORTLY AFTER ENGINE STARTUP THROUGH SHUTDOWN (SHOULD HAVE BEEN NO LIGHT ILLUMINATED WITH PASSENGER IN SEAT). THE PROBLEM STARTED MID JULY 2012 AND CONTINUED INTERMITTENTLY OVER THE NEXT 6 MONTHS UNTIL THE RED AIRBAG INOPERATIVE LIGHT (IN THE SPEEDOMETER CLUSTER) CAME ON AND REMAINED ILLUMINATED IN LATE DEC 2012. APROX WEIGHT OF THREE PASSENGERS WHO FREQUENTED THE PASSENGER SEAT OVER THE 6 MONTH PERIOD) WERE 135, 150 AND 215 LBS RESPECTIVELY. PASSENGER (SEAT) AIRBAG SENSOR MALFUNCTION WAS CONFIRMED (DIAGNOSED AND ISOLATED) BY HOLMES AUTOMOTIVE OF FORT WALTON BEACH FL, ON 24 DEC 2012. BELIEVE IDENTICAL PROBLEM AS NHTSA CAMPAIGN ID NBR 12V244000. *TR
TL* THE CONTACT OWNS A 2007 KIA SPECTRA. THE CONTACT STATED THAT THE DRIVER WAS TRAVELING AT UNKNOWN SPEEDS AND CRASHED INTO ANOTHER VEHICLE. UPON IMPACT, THE AIR BAGS FAILED TO DEPLOY AND THE SEAT BELT FAILED TO PREVENT THE DRIVER FROM STRIKING THE STEERING WHEEL. THE CONTACT'S VEHICLE WAS PUSHED UNDER THE SECOND VEHICLE INVOLV…
Read full complaint
TL* THE CONTACT OWNS A 2007 KIA SPECTRA. THE CONTACT STATED THAT THE DRIVER WAS TRAVELING AT UNKNOWN SPEEDS AND CRASHED INTO ANOTHER VEHICLE. UPON IMPACT, THE AIR BAGS FAILED TO DEPLOY AND THE SEAT BELT FAILED TO PREVENT THE DRIVER FROM STRIKING THE STEERING WHEEL. THE CONTACT'S VEHICLE WAS PUSHED UNDER THE SECOND VEHICLE INVOLVED IN THE CRASH. THE DRIVER SUSTAINED INJURIES TO THE EYE, FIFTH VERTEBRAE AND A COLLAPSED LUNG. THE POLICE WERE CONTACTED AND A REPORT WAS FILED. THE DRIVER WAS TRANSPORTED TO THE HOSPITAL VIA AMBULANCE AND REMAINED HOSPITALIZED FOR APPROXIMATELY 20 DAYS BEFORE PASSING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO LATER DIAGNOSED THE VEHICLE. THE RESULTS DETERMINED THAT THE AIR BAG SENSOR WAS NOT IMPACTED DUE TO THE POSITIONING OF THE VEHICLE IN THE CRASH. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS UNAVAILABLE.
CAR TOOK ME OFF THE SIDE OF THE ROAD AND STRAIGHT INTO A TREE DEAD CENTER ROUGHLY GOING 35 MILES AN HOUR. AIR BAGS DID NOT DEPLOY!!!! HIT MY HEAD ON STEERING WHEEL. AND NOW TRYING TO FIGURE OUT IF IT WAS THE DEALERSHIP SELLING DEFECTIVE CARS OR IF ITS KIA DEFECT. NOT UNDERSTANDING THIS WHOLE AIRBAG DOES NOT DEPLOY THING BECAUSE …
Read full complaint
CAR TOOK ME OFF THE SIDE OF THE ROAD AND STRAIGHT INTO A TREE DEAD CENTER ROUGHLY GOING 35 MILES AN HOUR. AIR BAGS DID NOT DEPLOY!!!! HIT MY HEAD ON STEERING WHEEL. AND NOW TRYING TO FIGURE OUT IF IT WAS THE DEALERSHIP SELLING DEFECTIVE CARS OR IF ITS KIA DEFECT. NOT UNDERSTANDING THIS WHOLE AIRBAG DOES NOT DEPLOY THING BECAUSE THE SAFETY GRAPH EXPLAINS 0-8 MPH AIRBAGS WILL NEVER GO OFF 8-14 MPH AIRBAGS ARE POSSIBLE BUT NOT LIKELY 14-ABOVE AIRBAGS SHOULD DEPLOY ALWAYS. *TR
RIGHT FRONT SEAT AIR BAG SENSOR, DEALER STATES NONE OF THE AIR BAGS WILL DEPLOY IN A COLLISION BECAUSE OF THIS SENSOR. *TR
EXPERIENCING SAME PROBLEM AS BELOW, BELIEVE THAT SENSORS ARE IDENTICAL PARTS, REQUEST ASSISTANCE TO INCLUDE ALL KIA MODELS PRODUCED DURING THIS TIME PERIOD THAT ARE EXPERIENCING SAME PROBLEM. PROBLEM VERIFIED BY COLONIAL KIA, COLONIAL HEIGHTS, VA AS SEAT SENSOR ON 6 JUL 12. NHTSA HAS ISSUED THE FOLLOWING SAFETY RECALL: MA…
Read full complaint
EXPERIENCING SAME PROBLEM AS BELOW, BELIEVE THAT SENSORS ARE IDENTICAL PARTS, REQUEST ASSISTANCE TO INCLUDE ALL KIA MODELS PRODUCED DURING THIS TIME PERIOD THAT ARE EXPERIENCING SAME PROBLEM. PROBLEM VERIFIED BY COLONIAL KIA, COLONIAL HEIGHTS, VA AS SEAT SENSOR ON 6 JUL 12. NHTSA HAS ISSUED THE FOLLOWING SAFETY RECALL: MAKE: KIA MODEL: RIO MODEL YEAR: 2007 MANUFACTURER: KIA MOTORS CORPORATION MFR'S REPORT DATE: MAY 29, 2012 NHTSA CAMPAIGN ID NUMBER: 12V244000 NHTSA ACTION NUMBER: N/A COMPONENT: AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE. *TR
TL* THE CONTACT OWNS A 2007 KIA SPECTRA 5. THE CONTACT STATED THAT THE PASSENGER SIDE AIR BAG SENSOR WARNING LAMP ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. UPDATED 07/10/12*LJ WHEN THE CONSUMER CONTACTED THE DEALER ABOUT THE AIR B…
Read full complaint
TL* THE CONTACT OWNS A 2007 KIA SPECTRA 5. THE CONTACT STATED THAT THE PASSENGER SIDE AIR BAG SENSOR WARNING LAMP ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. UPDATED 07/10/12*LJ WHEN THE CONSUMER CONTACTED THE DEALER ABOUT THE AIR BAG LIGHT ILLUMINATING WHEN THE SEAT WAS OCCUPIED, THE DEALER ADVISED HER TO SIT MORE CENTERED IN THE SEAT. UPDATED 07/11/12
2007 KIA SPECTRA. CONSUMER STATES AIRBAGS DID NOT DEPLOY DURING COLLISION *TGW THE CONSUMER STATED HE WAS DRIVING 15 MPH AND WAS REAR ENDED BY ANOTHER VEHICLE, WHO WAS TRAVELING AT 70 MPH. THE CONSUMER STATED HIS VEHICLE WAS EQUIPPED WITH FRONT AND SIDE AIR BAGS AND NONE OF THEM DEPLOYED.*JB
THE PASSENGER AIRBAG LIGHT GOES ON INTERMITTENTLY. THE DEALER HAS ATTEMPTED TO FIX THE PROBLEM 5 TIMES SO FAR. THEY CLAIM THEY ARE UNABLE TO DUPLICATE THE PROBLEM AND THERE ARE NO CODES STORED IN THE COMPUTER. THEREFORE, THE VEHICLE IS FINE. THE VEHICLE IS NOT SAFE FOR MY WIFE TO BE A PASSENGER. THEY HAVE OFFERED TO LOOK AT…
Read full complaint
THE PASSENGER AIRBAG LIGHT GOES ON INTERMITTENTLY. THE DEALER HAS ATTEMPTED TO FIX THE PROBLEM 5 TIMES SO FAR. THEY CLAIM THEY ARE UNABLE TO DUPLICATE THE PROBLEM AND THERE ARE NO CODES STORED IN THE COMPUTER. THEREFORE, THE VEHICLE IS FINE. THE VEHICLE IS NOT SAFE FOR MY WIFE TO BE A PASSENGER. THEY HAVE OFFERED TO LOOK AT IT AGAIN AFTER WE HAD THE DISTRICT ATTORNEY'S OFFICE GET INVOLVED, BUT WE ARE 45 MILES AWAY FROM THE DEALER. THE LAST TIME THEY LOOKED AT IT THEY SAID IT WAS FINE. WE STILL HAVE AN UNSAFE VEHICLE. *TR
TL*THE CONTACT OWNS A 2007 KIA SPECTRA. THE CONTACT STATED THAT THE PATCH OF ICE ON THE ROAD CAUSED HER TO CRASH INTO THE GUARD RAIL WHILE DRIVING 65 MPH. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS COMPLETELY DESTROYED. SHE SUSTAINED INJURIES TO HER HEAD WHEN SHE HIT IT ON THE STEERING WHEEL AND BECAME UNCONSCIOUS. A POLIC…
Read full complaint
TL*THE CONTACT OWNS A 2007 KIA SPECTRA. THE CONTACT STATED THAT THE PATCH OF ICE ON THE ROAD CAUSED HER TO CRASH INTO THE GUARD RAIL WHILE DRIVING 65 MPH. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS COMPLETELY DESTROYED. SHE SUSTAINED INJURIES TO HER HEAD WHEN SHE HIT IT ON THE STEERING WHEEL AND BECAME UNCONSCIOUS. A POLICE REPORT IS AVAILABLE IF NEEDED. THE VEHICLE WAS TOWED TO THE DEALER. THE FAILURE MILEAGE WAS 40,000.
Official recalls
111V256000 · Fuel System, Other:storage:tank Assembly:mounting
Apr 25, 2011
KIA IS RECALLING CERTAIN MODEL YEAR 2004-2007 SPECTRA LD VEHICLES MANUFACTURED FROM NOVEMBER 7, 2003, THROUGH MARCH 6, 2007, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. THERE IS A POSSIBILITY THAT CORROSION OF THE FUEL TANK STRAPS WHICH HOLD THE TANK MAY OCCUR AS A RESULT OF PROLONGED EXPOSURE TO ROAD SALT. AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY SEPARATE ALLOWING THE FUEL TANK TO CONTACT THE GROUND AND POSSIBLY DISRUPT THE INTEGRITY OF THE TANK.
Consequence & remedy
Consequence: THE FUEL TANK CAN FALL FROM THE VEHICLE AND STRIKE THE GROUND WHICH COULD CAUSE A FUEL LEAK. LEAKING FUEL CAN CREATE A FIRE HAZARD.
Remedy: DEALERS WILL REPLACE THE FUEL TANK STRAPS AND ATTACHING HARDWARE WITH NEW ZINC COATED PARTS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 6, 2011. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE15031 · Occupant Classification System
Opened Sep 1, 2015 · Closed Feb 11, 2016
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Air Bags:sensor:occupant Classification
The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,
Additional source detail variants (4)
Air Bags:frontal
The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,
Air Bags:frontal:sensor/control MODULE-INACTIVE
The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,
Air Bags
The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,
Air Bags:sensor:occupant Classification
The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,