2019 Kia Soul

My 2019 Kia Soul has been professionally diagnosed with DTC B162000, “Internal Fault – Replace SRSCM,” involving the Supplemental Restraint System/Airbag Control Module. My repair shop documented this diagnosis on August 24, 2026. Kia Safety Recall SC226 / NHTSA Recall 22V-031 addresses an Airbag Control Unit defect in certain 2017-2019 Kia Souls and specifically addresses vehicles exhibiting DTC B1620. However, I have been informed that my VIN is not included in the recall and the recall repair is therefore unavailable for my vehicle. I am concerned that my vehicle may have the same safety defect despite being excluded from the recall population. The airbag system is safety-critical, and I am requesting that NHTSA investigate whether the affected population should include additional 2019 Kia Soul vehicles.

The contact owns a 2019 Kia Soul. The contact stated that while driving at an undisclosed speed, there was a burning odor and smoke coming from the exhaust pipe. Additionally, the engine was consuming an excessive amount of engine oil. The contact pulled over and checked the engine oil level, and the dipstick indicated that the engine oil level was extremely low. The contact stated that engine oil was added to the engine. The vehicle was taken to the dealer, where it failed the oil consumption test; however, the manufacturer declined to replace the engine and informed the contact that the vehicle was not covered under warranty. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 59,000.

I purchased a 2019 Kia Soul in June 2022. Since purchasing the vehicle, it has been stolen three separate times. During at least one theft, the steering column was damaged to bypass the ignition, and responding officers indicated the theft method was consistent with the widely reported Kia theft method. I had possession of my keys during the incidents. The repeated thefts created a significant safety risk, financial loss, and left me without reliable transportation. I am concerned the vehicle’s theft-deterrent system did not provide reasonable protection against unauthorized operation. Police reports were filed for each theft, and the incidents have been reported to Kia. I am submitting this complaint so NHTSA can evaluate whether this vehicle’s anti-theft system presents a safety-related defect or warrants further investigation.

I was driving through a busy intersection when the vehicle stopped accelerating causing risk to myself and other drivers. I was able to get the vehicle through the intersection and pulled over. I turned the vehicle off and it would not restart. I had the vehicle towed to my local independent service center where a diagnostic was performed. It was found to be engine failure due to the connecting rod to the pistons. It resulted in a loud rod knock and white smoke from the engine. There were no warning lights or sounds or quality of driving prior to the failure until the vehicle suddenly stopped accelerating. Vehicle was regularly maintained. Kia is currently in a lawsuit due to engine failure but does not include my VIN even though it experienced the same exact cause of engine failure as many of their other vehicles. The vehicle has not been inspected by the manufacturer, police, or insurance representives.

Engine and engine components caught fire while driving. This put my husbands life at risk and could have caused harm to other drivers if he was driving on a busier road. Car fire could have completely engulfed the car and caused harm or even death. Fire department was called to assist with extinguishing the fire and to ensure that further danger did not persist.

On [XXX], while my vehicle was at the dealership for a federally mandated engine replacement recall (Campaign PI2107Y/Z), the service department attempted to obstruct the completion of the safety repair. The dealership informed me that unless I paid a 264.40 fee for maintenance and fluids, they were required by the manufacturer to drain the old, contaminated coolant from my failed engine and reuse it in the brand-new replacement engine. This threat of intentional contamination poses a severe safety risk, as reusing old fluid from a failed engine can lead to premature engine failure or overheating, potentially creating another hazardous situation on the road. I contacted the manufacturer corporate office (Case [XXX]), and they confirmed that no such requirement to reuse old coolant exists and that the dealership had not even attempted to file a claim for fluids. The dealership misrepresented manufacturer policy to monetize a free safety recall and threatened to sabotage the integrity of the new engine to force a sale. This issue was confirmed to be a dealership-level fabrication by the manufacturer’s corporate customer service line. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Engine has 86k miles and has been well maintained. Recently it started to consume oil rapidly as per last oil change report. We took it to dealership after oil change mechanic suggested needing to have problems looked at per Kias recent service bulletins on high oil consumption issues. I requested the car be evaluated for the oil issue and the dealership service tech confirmed "engine damage DUE TO high oil consumption" but would not perform oil consumption test. The particular vin is not included in current recalls or bulletins but has the same engine as other model years that are in the recall/bulletins for engine oil consumption. Dealership suggests engine replacement but the car is out of warranty because it changed owners before 100k miles. I have opened a case with kia and, to date, they continue to deny the engine replacement due to car being out of warranty. This oil consumption issue is a MAJOR SAFETY RISK and ALL KIAS HAVING THIS ENGINE ISSUE should be offered replacement by Kia, assuming regular maintenance is proven. Other Kias with this same engine are being replaced at Kias expense but Kia is trying to save money by only approving certain year models, leaving thousands of Kia owners left at having to replace engines at the owners expense (over $9000 dollars) when the car itself is no longer worth barely half of that cost. The NHTSA needs to step in to protect the consumers and issue a bulletin for any Kia model having this type of oil consumption issue before more people die or suffer major breakdowns and wrecks from car fires or engine lock ups.