IllustrationThe vehicle suddenly stalls while in traffic without notice. It has to be put in on park, turned completely off, and then restarted. People behind my car almost rear end my vehicle causing a collision. Highly unsafe. This has happened numerous times usually after being stopped at a traffic light or stop sign.
2016 Kia Soul
Owner reports · Recalls · Investigations
More warning signs than most Soul years
Owner complaints for the 2016 Kia Soul are substantially higher than the model-year median of 225.
About this comparison →How this year compares
Owner complaints by model year
Compare all Soul years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
320–25K
3825–50K
7750–75K
9375–100K
108100–150K
14150K+
362 reports with mileage · 448 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 555 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 105 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 83 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
28 crash reports35 fire reports17 injury reports
Engine complaints
555 reportsEngine is consuming large amounts of oil. One quart every 500 miles and getting worse.
My 2016 soul burst into flames following a loud explosion in the engine compartment. The vehicle is a total loss; but, the fire department extinguished the fire before the flames reached the fuel tank. What component or system failed or malfunctioned, and is it available for inspection upon request? Engine and No How was your …
Read full complaint
My 2016 soul burst into flames following a loud explosion in the engine compartment. The vehicle is a total loss; but, the fire department extinguished the fire before the flames reached the fuel tank. What component or system failed or malfunctioned, and is it available for inspection upon request? Engine and No How was your safety or the safety of others put at risk? Could have easily been killed had I not recognised the symptoms immediately and had the time to react. Has the problem been reproduced or confirmed by a dealer or independent service center? Irrellavent. The vehicle caught fire. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No. There is nothing left to inspect. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Only seconds before.
Excessive oil consumption-1 quart of oil every 400-600miles. This had been verified by a certified mechanic. The excessive oil consumption has destroyed the catalytic converter, code 420. The check engine light has been on since 95k miles. Spark plugs had to be replaced sooner than normal because they were covered w oil. …
Read full complaint
Excessive oil consumption-1 quart of oil every 400-600miles. This had been verified by a certified mechanic. The excessive oil consumption has destroyed the catalytic converter, code 420. The check engine light has been on since 95k miles. Spark plugs had to be replaced sooner than normal because they were covered w oil. Tail pipe has oil encrusted on the inside. While starting from a complete stop after 15 minutes of driving the car lost power and would not go over 45mph. Going up hill dropped to 15 mph. This has been replicated by a mechanic.
Vehicle is experiencing oil &/or carbon-like debree exiting out of the exhaust system. There are no warning indicators of any kind displaying. The car has regularly been taken to the dealership for service and maintenance problems. Motor has documented record of oil consumption due to testing at dealership. This is currently…
Read full complaint
Vehicle is experiencing oil &/or carbon-like debree exiting out of the exhaust system. There are no warning indicators of any kind displaying. The car has regularly been taken to the dealership for service and maintenance problems. Motor has documented record of oil consumption due to testing at dealership. This is currently the second catalytic converter to be replaced. I have all receipts for work performed.
The contact owns a 2016 Kia Soul. The contact stated while driving 75 MPH, there was a knocking sound coming from the vehicle. There was no warning light illuminated. The contact checked the oil level and became aware that the vehicle was low on oil. The contact added oil, but the failure persisted. The vehicle was not diagnosed…
Read full complaint
The contact owns a 2016 Kia Soul. The contact stated while driving 75 MPH, there was a knocking sound coming from the vehicle. There was no warning light illuminated. The contact checked the oil level and became aware that the vehicle was low on oil. The contact added oil, but the failure persisted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was 151,748.
Catalytic converters needed to be replaced
Bought 2016 Kia Soul one year ago (May 2022) with 79k miles. Feb 2023 engine light came on. Took it to Kia service center & they reset it and told us to come back if light came back on. It did along with oil change light (June 2023, 92k miles). We were told it had no oil, it was consuming oil, sludge in motor and there was nothi…
Read full complaint
Bought 2016 Kia Soul one year ago (May 2022) with 79k miles. Feb 2023 engine light came on. Took it to Kia service center & they reset it and told us to come back if light came back on. It did along with oil change light (June 2023, 92k miles). We were told it had no oil, it was consuming oil, sludge in motor and there was nothing they could do. Service mgr told us to check oil level regularly, top it off as needed and get regular oil changes and if/when it failed, then they would replace engine under new lawsuit settlement (extended warranty to 15yr/150k). We consulted another mechanic and he said it is faulty piston rings that caused oil consumption, that caused low oil and that ultimately caused possible sludge. Why aren't they fixing the problem instead of waiting until the engine fails? Probably because they were waiting to see if your engine fails after 15yr/150k mile warranty expires. New lawsuit in the works regarding oil consumption because it's happening to a lot of KIAs.
The contact owns a 2016 Kia Soul. The contact stated while driving 30 MPH, the vehicle vibrated violently and lost motive power. The contact stated that while accelerating, the vehicle failed to exceed 10 MPH. The check engine warning light was illuminated. The vehicle was taken to the dealer however, the mechanic failed to dete…
Read full complaint
The contact owns a 2016 Kia Soul. The contact stated while driving 30 MPH, the vehicle vibrated violently and lost motive power. The contact stated that while accelerating, the vehicle failed to exceed 10 MPH. The check engine warning light was illuminated. The vehicle was taken to the dealer however, the mechanic failed to determine the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 73,000.
The contact owns a 2016 Kia Soul. The contact stated that while driving at various speeds, the vehicle suddenly shifted into LIMP Mode and decelerated to approximately 15 MPH. The vehicle was taken to the local mechanic who diagnosed that the oxygen sensor and catalytic convertor was faulty and needed to be replaced. The oxygen …
Read full complaint
The contact owns a 2016 Kia Soul. The contact stated that while driving at various speeds, the vehicle suddenly shifted into LIMP Mode and decelerated to approximately 15 MPH. The vehicle was taken to the local mechanic who diagnosed that the oxygen sensor and catalytic convertor was faulty and needed to be replaced. The oxygen sensor and catalytic convertor was replaced on three separate occasions however, the failure persisted. The local dealer and manufacturer were notified of the failure, but no assistance was provided. The failure mileage was 120,000. The VIN was unavailable.
Official recalls
219V120000 · Engine; Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor
Feb 22, 2019
Kia Motors America (Kia) is recalling certain 2012-2016 Kia Soul vehicles equipped with 1.6L Gasoline Direct Injection (GDI) engines. High exhaust gas temperatures may damage the catalytic converter, possibly resulting in abnormal engine combustion and damage to one or more of the engine's pistons and possible piston connecting rod failure.
Consequence & remedy
Consequence: Piston damage may result in an engine stall, increasing the risk of a crash. A broken connecting rod may puncture the engine block allowing engine oil to escape. The leaking oil may contact the exhaust, increasing the risk of a fire.
Remedy: Kia will notify owners, and dealers will upgrade the Catalytic Overheating Protection Engine Control Unit logic to prevent overheating of the catalytic converter. In addition, the catalytic converter will also be replaced if it has been damaged. Depending on the extent of any damage, the engine may also be replaced, free of charge. The recall began April 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC176.
Additional source detail variants (2)
Engine
Kia Motors America (Kia) is recalling certain 2012-2016 Kia Soul vehicles equipped with 1.6L Gasoline Direct Injection (GDI) engines. High exhaust gas temperatures may damage the catalytic converter, possibly resulting in abnormal engine combustion and damage to one or more of the engine's pistons and possible piston connecting rod failure.
Consequence: Piston damage may result in an engine stall, increasing the risk of a crash. A broken connecting rod may puncture the engine block allowing engine oil to escape. The leaking oil may contact the exhaust, increasing the risk of a fire.
Remedy: Kia will notify owners, and dealers will upgrade the Catalytic Overheating Protection Engine Control Unit logic to prevent overheating of the catalytic converter. In addition, the catalytic converter will also be replaced if it has been damaged. Depending on the extent of any damage, the engine may also be replaced, free of charge. The recall began April 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC176.
Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor
Kia Motors America (Kia) is recalling certain 2012-2016 Kia Soul vehicles equipped with 1.6L Gasoline Direct Injection (GDI) engines. High exhaust gas temperatures may damage the catalytic converter, possibly resulting in abnormal engine combustion and damage to one or more of the engine's pistons and possible piston connecting rod failure.
Consequence: Piston damage may result in an engine stall, increasing the risk of a crash. A broken connecting rod may puncture the engine block allowing engine oil to escape. The leaking oil may contact the exhaust, increasing the risk of a fire.
Remedy: Kia will notify owners, and dealers will upgrade the Catalytic Overheating Protection Engine Control Unit logic to prevent overheating of the catalytic converter. In addition, the catalytic converter will also be replaced if it has been damaged. Depending on the extent of any damage, the engine may also be replaced, free of charge. The recall began April 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC176.
17V608000 · Steering
Sep 29, 2017
Kia Motors America (Kia) is recalling certain 2014-2016 Soul and Soul EV vehicles. The pinion plug may allow the pinion gear to separate from the steering gear assembly.
Consequence & remedy
Consequence: If the pinion gear separates, steering will be lost, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will inspect and secure the pinion plug or replace the steering gear assembly, as necessary, free of charge. The recall began November 16, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC155. Note: This recall supersedes campaigns 14V-332 and 15V-736. Vehicles previously remedied under those numbers are being recalled again under this campaign.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA21003 · Engine Fires
Opened Dec 22, 2021 · Closed Feb 5, 2024
Status: closed (inferred from source dates) · Engine
On March 29, 2019, the Office of Defects Investigation (ODI) opened two Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) to broadly investigate incidents of non-crash fires (regardless of origin or operational status of the vehicle) on various model year Hyundai and Kia vehicles. During the PE investigations, Hyundai and Kia issued several recalls to address vehicle fires, including those due to engine failures involving various engine types. The remedies for the engine failure recalls typically involve engine inspection (to detect existing damage), and if necessary, engine replacement. Additionally, both manufacturers have been installing an engine control software modification known as Knock Sensor Detection Software (KSDS) which is intended to detect impending engine failure, alert the driver, and limit engine power (to lessen likelihood of engine failure).KSDS is being installed under recalls and non-safety field actions, and both companies have extended limited engine warranties (see recall files). On December 22, 2021, ODI upgraded PE19-003 and PE19-004 to this Engineering Analysis (EA21-003, covering both Hyundai and Kia) to evaluate the scope of the prior recalls related to engine failures/fires and the efficacy of the recall remedies for the recalls, as well as the long-term viability of related programs and non-safety field actions being conducted by Hyundai and Kia. The former issue involved approximately 550,000 MY 2013 Hyundai Elantra, MY 2011 Kia Sorento, and MY 2012-2015 Kia Rio. The latter issue involved approximately 2.5 million recalled vehicles, which have been identified as displaying potential remedy concerns: Hyundai recalls 15V-568, 17V-226, 20V-746, and 21V-727; and Kia recalls 17V-224, 19V-120, 20V-750, and 21V-844. Regarding the recall scope issue, among all of the scope vehicles identified at EA opening, ODI found only the MY 2011 Kia Sorento vehicles equipped with both the Theta II 2.4L 4-cylinder Multi-Point Injection (MPI) and the Lambda II 3.5L 6-cylinder MPI engines experienced relatively high rates of reported fires. In December 2023, Kia issued recall 23V-877 that will cover about 80,000 MY 2011 Kia Sorento vehicles equipped with the Theta II 2.4L MPI engines. The remedy will involve an inspection, and if necessary, a replacement of the engine, as well as the installation of KSDS. It should be noted that in 2021 these vehicles were included in a KSDS product improvement campaign with warranty extension. For the MY 2011 Sorento vehicles equipped with the Lambda II 3.5L engines, ODI believes that future engine failures/fires involving these vehicles will likely be due to a lax in adhering to the proper or scheduled engine maintenance (regular engine oil changes), rather than a design or manufacturing engine issue. Regarding the issue of the efficacy of the recall remedies, ODI found the majority of the recalled Hyundai and Kia vehicles, by model, experienced lower reported fire rates after the remedies were applied. Furthermore, ODI found that for most vehicles that did not receive the recall remedies, by model, experienced relatively high fire rates. To address this problem, Hyundai informed ODI in December 2023, that it will renotify all of its owners covered by the Hyundai recalls of engine failures/fires every 8 months for the next 3 years. In December 2023, Kia stated that it will renotify the majority of its owners every 8 months for the next 3 years.Several previously recalled Kia models are excluded from the renotification due to their lower reported rates of engine fires. Overall, the renotification actions will help to increase the recall completion rates, thus reduce the frequency of engine fires in the future. In view of the recall action being taken by Kia and renotification actions being taken by both Kia and Hyundai, ODI is closing this Engineering Analysis. Also, both companies have been released from the 2020-iniated Consent Orders (Kia since November 2022 and Hyundai since November 2023). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.