2020 Kia Sorento

While driving my 2020 Kia Sorento on the freeway at highway speed, the panoramic sunroof suddenly shattered without warning. There was a very loud explosive sound that startled and frightened me while I was driving. I was not aware of anything striking the sunroof immediately before it shattered, and there were no warning lights, messages, noises, cracks, or other indications that the glass was about to fail. Because I was traveling at freeway speed when this occurred, the sudden explosion/shattering of the glass was extremely distracting and created a serious safety concern. I was frightened by the unexpected loud noise and could have lost control of the vehicle. Broken glass from a panoramic sunroof also presents a risk to the occupants of the vehicle and to other motorists. The component that failed was the panoramic sunroof glass. To my knowledge, the failure has not yet been reproduced or confirmed by a Kia dealer or independent repair facility, and the vehicle has not yet been inspected by Kia for the cause of the failure. I am reporting this incident because the sunroof appeared to shatter suddenly during normal highway driving without any prior warning, and I am concerned that this may represent a safety defect.

The contact owns a 2020 Kia Sorento. The contact stated that the front passenger’s side air bag warning light remained illuminated while an occupant was seated in the front passenger’s seat. The dealer was notified of the failure and informed the contact that there were no recalls or warranty associated with the vehicle failure. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 9,000.

My 2020 Kia Sorento stalled and shut off while driving and eventually stopped working completely, requiring it to be towed to a Kia dealership. The dealership first replaced the starter and then the high-pressure fuel pump, but the vehicle still would not operate. After further diagnosis, I was informed that the timing chain had failed/broken and the engine needed to be replaced, with a new engine quoted at approximately $12,000. I am concerned that this type of sudden engine failure and shutdown could create a serious safety hazard, especially if it occurs while driving in traffic or at highway speeds. I am requesting that NHTSA document and review this incident for similar failures involving 2020 Kia Sorento vehicles.

The contact called on behalf of his daughter who owns 2020 Kia Sorento. The contact stated that the vehicle was taken to a dealer for a routine oil change when the contact was informed that there was an unknown issue with the vehicle however, the vehicle was not diagnosed or repaired. The vehicle was taken to a different dealer where it was diagnosed that the transmission fluid was leaking and the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

Driving on highway at 65, traction control light, airbag light, parking light, bcw warning, all came in at the same time. I was able to pull off to the side and re start engine to clear the lights. As soon as I got up to 40 lights one by one flickered on until up to highway speed and then all flickered and dash dings. Two independent shops ran diagnostics and noted that only battery was dead. Replaced battery and the lights came back immediately.

The contact owns a 2020 Kia Sorento. The contact stated that while driving 30 MPH with her daughter and parents in the vehicle, an abnormal squeaking sound was heard emanating from the steering wheel. No warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the steering column needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but the repair was delayed because the manufacturer required information from the dealer, while the dealer claimed to be waiting for a response from the manufacturer. The failure mileage was 19,000.

The vehicle suffered a sudden, severe engine malfunction/misfire while in operation, presenting a serious safety hazard on the road. Following the incident, the vehicle was taken to an authorized dealership service center (Repair Order #XXX), where technicians verbally confirmed that the engine requires a complete replacement due to internal mechanical failure. The catastrophic mechanical failure of the engine directly caused consequential damage to the emissions system, entirely clogging the catalytic converter with unburned fuel/debris. Despite the clear link to the known, systemic defects inherent to the Theta II engine line—which is subject to active federal consent orders, safety recalls, and lifetime warranty extensions—both the dealership and Kia Corporate are refusing to honor the 8-year/80,000-mile Federal Emissions Defect Warranty. The manufacturer is attempting to use the catastrophic failure of their own defective, recalled engine line to evade their legal environmental and safety warranty obligations, leaving the consumer stranded without alternative transportation. This represents a systemic effort by the manufacturer to deflect liability for documented powertrain safety failures onto individual consumers. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2020 Kia Sorento consuming 1.5 or more quarts of oil every 1,000 miles. Completing oil consumption testing with Kia dealer, which requires I take the car back to the dealer every 1k miles, times, so they can verify the oil levels. Last check, when issue was discovered, vehicle was down to only 1qt of oil after driving only 2k miles from previous oil change. Note: the lambda engine was initially included in the latest Kia class action settlement but was dismissed per the plaintiff’s attorney in that case. However there are numerous reports from a large number of 2020 Kia Sorento owners now with the same issue and running into complete roadblocks in terms of recourse as for most the issue does not begin until they exceed the powertrain warranty. Especially if they’re secondary owners and not the original owner.