NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
97 reportsClear category filterMileage unknown · Dec 17, 2018
Steering
SHORTLY AFTER BUYING THE KIA IT DEVELOPED A PROBLEM WHERE THE STEERING WHEEL WOULD STICK WHEN ATTEMPTING TO TURN LEFT OR RIGHT. IT TAKES A LITTLE EXTRA EFFORT TO MOVE THE WHEEL PAST THESE STICKING POINTS MOSTLY AT 12 O'CLOCK POSITION AND IT GRADUALLY BECOMES MORE DIFFICULT THE FASTER THE CAR TRAVELS. AT HIGHWAY SPEEDS THIS IS QU…
Read full complaint
SHORTLY AFTER BUYING THE KIA IT DEVELOPED A PROBLEM WHERE THE STEERING WHEEL WOULD STICK WHEN ATTEMPTING TO TURN LEFT OR RIGHT. IT TAKES A LITTLE EXTRA EFFORT TO MOVE THE WHEEL PAST THESE STICKING POINTS MOSTLY AT 12 O'CLOCK POSITION AND IT GRADUALLY BECOMES MORE DIFFICULT THE FASTER THE CAR TRAVELS. AT HIGHWAY SPEEDS THIS IS QUITE TROUBLESOME AND DANGEROUS AS THE PROBLEM IS AMPLIFIED. WHILE TRAVELING IN TRAFFIC AT HIGHER SPEEDS,WINDY CONDITIONS,SEARCHING YOUR MIRROR TO CHANGE LANES,ETC., IF THE CAR WANDERS SOMETIMES IT CAUSES ME TO OVER CORRECT WHICH IN TURN CAUSES ANOTHER OVER CORRECTION TO RETURN TO THE LANE . I HAVE HAD THESE PROBLEMS ON THE HIGHWAY AND CANNOT FIND A WAY TO ADJUST. THIS SEEMS TO BE AN INTERMITTENT PROBLEM BUT IF IT HAPPENS IT STAYS FOR THE DURATION OF THE DRIVE, IT MAY OR MAY NOT BE THERE NEXT TIME. A RECENT INCIDENT HAS CAUSED ME TO NOTIFY KIA AND NHTSA. THERE WAS NO ACCIDENT NO ONE WAS HURT BUT OVER CORRECTING CAUSED AN INCIDENT THAT SHOOK UP MY WIFE AND I AS I COULD HAVE EASILY LOST CONTROL ON THAT HIGHWAY, IN TRAFFIC AT THAT SPEED AT NIGHT. WE ENDED UP TAKING BACK ROADS. I HAVE BEEN TO THE DEALER WHERE I BOUGHT THE CAR BUT THEY FOUND NOTHING. A TECHNICIAN TOLD ME TODAY THAT I PROBABLY NEED TO GET USED TO THE ELECTRIC POWER STEERING. AFTER A YEAR NOW? HE APPARENTLY KNEW SOMETHING AND HAS ANSWERED SIMILAR QUESTIONS AS I BELIEVE THAT NOT ALL KIA'S HAVE ELECTRIC POWER STEERING. IT AMY ALSO BE WEATHER RELATED SINCE IT SEEMED TO RETURN AS THE WEATHER HAS GOTTEN COLDER. I HAVE SEARCHED ON LINE AND HAVE FOUND OTHERS WITH SIMILAR PROBLEMS WITH HYUNDAI AS WELL. I'M LEAVING THE CAR WITH A KIA DEALER 12/26.
NHTSA ODI #11162078
30,000 miles · Dec 13, 2018
Steering
COMPLAINED ABOUT STEERING WHEEL STICKING FOR THE LAST YEAR. DRIVING ON THE FREEWAY AT 70 MPH YESTERDAY MOVED INTO THE LEFT LANE TO PASS ANOTHER VEHICLE. I'M NOW IN THE LEFT LANE ABOUT TO PASS THE OTHER VEHICLE AND I NEEDED TO MAKE A LANE CORRECTION TO THE RIGHT HOWEVER THE STEERING WHEEL WAS STUCK AND I HAD TO PULL HARD ON THE …
Read full complaint
COMPLAINED ABOUT STEERING WHEEL STICKING FOR THE LAST YEAR. DRIVING ON THE FREEWAY AT 70 MPH YESTERDAY MOVED INTO THE LEFT LANE TO PASS ANOTHER VEHICLE. I'M NOW IN THE LEFT LANE ABOUT TO PASS THE OTHER VEHICLE AND I NEEDED TO MAKE A LANE CORRECTION TO THE RIGHT HOWEVER THE STEERING WHEEL WAS STUCK AND I HAD TO PULL HARD ON THE STEERING WHEEL AND THE STEERING WHEEL BROKE LOOSE AND MY VEHICLE VEERED TO THE RIGHT AND CAME WITHIN INCHES OF STRIKING THE VEHICLE I WAS PASSING. SAFETY ISSUE
NHTSA ODI #11161244
5,000 miles · Dec 11, 2018
Steering
AT SPEEDS RANGING FROM 25MPH TO 70MPH I MUST CONTINUALLY ADJUST THE STEERING WHEEL TO DRIVE STRAIGHT. THE CAR WILL DRIFT TO EITHER THE LEFT OR RIGHT AND FEELS "STICKY" TO TRY TO BRING BACK TO STRAIGHT. STEERING BECOMES UNSTUCK AND THERE IS AN OVER-CORRECTION AND MUST BE REPEATED IN THE OPPOSITE DIRECTION. IT FEELS LIKE WEAVING G…
Read full complaint
AT SPEEDS RANGING FROM 25MPH TO 70MPH I MUST CONTINUALLY ADJUST THE STEERING WHEEL TO DRIVE STRAIGHT. THE CAR WILL DRIFT TO EITHER THE LEFT OR RIGHT AND FEELS "STICKY" TO TRY TO BRING BACK TO STRAIGHT. STEERING BECOMES UNSTUCK AND THERE IS AN OVER-CORRECTION AND MUST BE REPEATED IN THE OPPOSITE DIRECTION. IT FEELS LIKE WEAVING GOING DOWN THE ROAD.SNOW OR ICY CONDITIONS EXAGGERATE THE OVER-CORRECTION.THERE IS 14,000 MILES ON VEHICLE BUT HAS BEEN PRESENT SINCE HAVING 5000 MILES. LEASED VEHICLE NEW JULY 2017. SPOKE TO DEALERSHIP SERVICE DEPARTMENT. NO RECALLS OR BULLETINS FOR THIS TYPE OF PROBLEM.VERY CONCERNED STEERING WILL LOCK UP IN A CURVE.
NHTSA ODI #11160766
12,000 miles · Dec 10, 2018
Steering
2017 SORENTO LX FWD AUTO - STEERING STICKS WHILE DRIVING ON THE HIGHWAY, WHEN YOU APPLY MORE PRESSURE TO THE STEERING WHEEL IT THEN RELEASES CAUSING DRIVER TO OVER CORRECT. THE ISSUE IS THEN REPEATED OVER AND OVER MAKING IT DIFFICULT TO DRIVE STRAIGHT.
NHTSA ODI #11157233
2,000 miles · Dec 9, 2018
Steering
STEERING DRIFTS AND VERY DIFFICULT TO CORRECT HAPPENS IN CITY DRIVING AND HIGHWAY. CONSTANTLY HAVE TO CORRECT STEERING
NHTSA ODI #11157110
11,432 miles · Mar 19, 2018
Steering
A FEW MONTHS AFTER PURCHASING THE 2017 KIA SORENTO WE BEGAN NOTICING STEERING ISSUES. IT DOESN'T HAPPEN ALL THE TIME BUT APPEARS TO HAPPEN AFTER THE CAR WARMS UP. YOU MUST CONSTANTLY ADJUST THE STEERING TO DRIVE STRAIGHT. THE CAR WILL DRIFT TO THE LEFT AND WHEN YOU TRY TO CORRECT, THE CAR FIGHTS YOU. ALL OF THE SUDDEN, THE S…
Read full complaint
A FEW MONTHS AFTER PURCHASING THE 2017 KIA SORENTO WE BEGAN NOTICING STEERING ISSUES. IT DOESN'T HAPPEN ALL THE TIME BUT APPEARS TO HAPPEN AFTER THE CAR WARMS UP. YOU MUST CONSTANTLY ADJUST THE STEERING TO DRIVE STRAIGHT. THE CAR WILL DRIFT TO THE LEFT AND WHEN YOU TRY TO CORRECT, THE CAR FIGHTS YOU. ALL OF THE SUDDEN, THE STEERING RELEASES AND THEN THE CAR DRIFTS RIGHT AND THE STEERING FIGHTS YOU TRYING TO ADJUST LEFT. IT MAKES IT VERY DIFFICULT TO KEEP THE VEHICLE DRIVING STRAIGHT EVEN ON STRAIGHT, FLAT ROADS. I STATED BELOW THAT IT HAPPENED ON MARCH 6, 2017. THAT WAS THE FIRST DATE THE CAR WAS TAKEN TO THE DEALER FOR SERVICE BUT THE ISSUE HAS BEEN ONGOING SINCE BEFORE THAT DATE.
NHTSA ODI #11080299
Mileage unknown · Feb 1, 2018
Steering
WHILE DRIVING THE CAR ON ANY ROAD (CITY OR HIGHWAY) IT WANTS TO DRIFT TO THE SIDE AND WHEN YOU GO TO CORRECT THE STEERING IT FEELS STICKY, FOR LACK OF BETTER WORDS, AND THERE IS A DELAY IN THE RESPONSE. SO I END UP OVER CORRECTING, AND I'M ALL OVER THE ROAD. THIS CAR IS SO UNSAFE AS IT IS RIGHT NOW. I'VE TAKEN MY CAR INTO THE DE…
Read full complaint
WHILE DRIVING THE CAR ON ANY ROAD (CITY OR HIGHWAY) IT WANTS TO DRIFT TO THE SIDE AND WHEN YOU GO TO CORRECT THE STEERING IT FEELS STICKY, FOR LACK OF BETTER WORDS, AND THERE IS A DELAY IN THE RESPONSE. SO I END UP OVER CORRECTING, AND I'M ALL OVER THE ROAD. THIS CAR IS SO UNSAFE AS IT IS RIGHT NOW. I'VE TAKEN MY CAR INTO THE DEALERSHIP TWICE, CALLED CONSUMER ADVISORS FOR KIA, HAS A TECH GO FOR A TEST DRIVE, AND SPOKE TO THE SERVICE MANAGER. WHILE THEY CAN VERIFY THERE'S AN ISSUE, THEY CAN'T DO ANYTHING TO FIX IT.
NHTSA ODI #11066534
Official recalls
4Sep 19, 2022
Kia America, Inc. (Kia) is recalling certain 2016-2022 Sorento, 2021-2022 Sorento Hybrid (HEV), 2022-2023 Sorento Plug-In Hybrid (PHEV), and 2017-2022 Sportage vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
Consequence & remedy
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will inspect the vehicle, and, as necessary, replace the fuse and/or tow hitch harness module, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC249.
Dec 19, 2018
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Additional source detail variants (2)
Engine
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Sep 21, 2017
Kia Motors America (Kia) is recalling certain 2017 Sorento vehicles equipped with 3.3L engines. The engine crankshaft may have been improperly heat treated and may fail.
Consequence & remedy
Consequence: If the crankshaft fails, the engine will stall, increasing the risk of a crash. A failed crankshaft also increases the risk of a fire.
Remedy: Kia will notify owners, and dealers will inspect the crankshaft, and, as necessary, replace the engine sub assembly, free of charge. The recall began November 6, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC153.
Nov 30, 2016
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Additional source detail variants (2)
Trailer Hitches
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Electrical System
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE23019 · Loss Of Motive Power
Opened Nov 13, 2023 · Closed Jul 23, 2024
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:oil/lubrication:seals/gaskets
On November 13, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23-019) to investigate allegations of loss of motive power relating to head gasket and/or head bolt failure in Model Year (MY) 2016-2017 Kia Sorento vehicles equipped with the 3.3 L Lambda II engine. When the investigation was opened, ODI had received 13 Vehicle Owner Questionnaires (VOQs) related to reports of loss of motive power. In an information request letter dated November 30, 2023, ODI requested technical information and failure data relating to the alleged defect in the subject MY 2016-2017 Kia Sorento as well as several peer vehicle populations which share the 3.3 L engine. In its February 26, 2024, response to ODI’s information request, Kia provided 2022 customer complaints (including techline and field reports) and 1738 warranty claims representing 2411 unique vehicles within the subject vehicle population. Of the customer complaints provided by Kia, they identified only 53 unique allegations of a loss of motive power resulting from the alleged defect. Kia determined that the remaining reports were minor vehicle drivability or engine performance issues. ODI reviewed the information provided by Kia, along with additional VOQs submitted to NHTSA following the opening of the investigation. When eliminating duplicative reports across the data sources, the total number of allegations of loss of motive power relating to the alleged defect in the subject vehicles is 77, representing an incident report rate of 59 per 100,000 vehicles. The MY 2016 Kia Sorento exhibited both the highest overall complaint rate and loss of motive power report rate across all subject and peer vehicle populations, representing an incident report rate of 102 per 100,000 vehicles. Across all data sources, there are no allegations of crashes or fires relating to the alleged defect. The one injury incident reflected in the failure summary table above is related to a consumer who was reportedly burned (minor burn requiring medical attention) while attempting to remove the coolant reservoir cap following a loss of motive power event. In their response to ODI, Kia described that if the threads of a head bolt hole in the subject engine becomes damaged, the clamping force between the cylinder head and engine block can decrease in the area of the affected head bolt. Kia’s assessment of the alleged defect is that when the failure occurs, drivers are provided with numerous warning signs prior to a potential loss of motive power event. According to Kia, potential warning signs associated with this failure include coolant leak/consumption or noticeable coolant odor, engine oil leak/consumption, engine temperature gauge rising to “H” (hot), check engine light illuminating, engine cooling fan remaining on following the engine being shut off, HVAC system not functioning properly, unusual engine noise, difficulty starting the vehicle, and smoke/condensation emitting from the engine compartment or exhaust. Through both its review of the information provided by Kia and outreach to consumers, ODI confirmed that there is reasonable detectability present in the vast majority of occurrences of the alleged defect. To mitigate the alleged defect, Kia increased the engagement depth of the head bolt threads for all subject engines, beginning in May 2017. ODI’s analysis of the failure data demonstrates that this corrective action correlates with a much lower incident report rate for engines produced following the change (8 per 100,000 vehicles for the MY 2018-2020 Kia Sorento). In December 2023, Kia launched extended warranty campaign WTY035 covering failures associated with the alleged defect in the subject vehicle population through 15 years or 180,000 miles, whichever comes first. Through its investigation, ODI identified the following peer vehicle populations, which were produced prior to the corrective action and exhibit failure rates comparable to the subject vehicles: MY 2014-2015 Kia Sorento, MY 2015-2016 Kia Sedona, and MY 2014-2017 Kia Cadenza equipped with the 3.3 L engine. Through discussions with ODI during the investigation, Kia decided to launch extended warranty campaign WTY039 in May 2024, which covers these peer vehicle populations through 15 years or 180,000 miles, whichever comes first. Based on analysis of the failure data indicating a low incident report rate of loss of motive power for the alleged defect, and in consideration of the warning signs which frequently occur from head gasket and/or head bolt failure in the subject engines, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:oil/lubrication:seals/gaskets
On November 13, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23-019) to investigate allegations of loss of motive power relating to head gasket and/or head bolt failure in Model Year (MY) 2016-2017 Kia Sorento vehicles equipped with the 3.3 L Lambda II engine. When the investigation was opened, ODI had received 13 Vehicle Owner Questionnaires (VOQs) related to reports of loss of motive power. In an information request letter dated November 30, 2023, ODI requested technical information and failure data relating to the alleged defect in the subject MY 2016-2017 Kia Sorento as well as several peer vehicle populations which share the 3.3 L engine. In its February 26, 2024, response to ODI’s information request, Kia provided 2022 customer complaints (including techline and field reports) and 1738 warranty claims representing 2411 unique vehicles within the subject vehicle population. Of the customer complaints provided by Kia, they identified only 53 unique allegations of a loss of motive power resulting from the alleged defect. Kia determined that the remaining reports were minor vehicle drivability or engine performance issues. ODI reviewed the information provided by Kia, along with additional VOQs submitted to NHTSA following the opening of the investigation. When eliminating duplicative reports across the data sources, the total number of allegations of loss of motive power relating to the alleged defect in the subject vehicles is 77, representing an incident report rate of 59 per 100,000 vehicles. The MY 2016 Kia Sorento exhibited both the highest overall complaint rate and loss of motive power report rate across all subject and peer vehicle populations, representing an incident report rate of 102 per 100,000 vehicles. Across all data sources, there are no allegations of crashes or fires relating to the alleged defect. The one injury incident reflected in the failure summary table above is related to a consumer who was reportedly burned (minor burn requiring medical attention) while attempting to remove the coolant reservoir cap following a loss of motive power event. In their response to ODI, Kia described that if the threads of a head bolt hole in the subject engine becomes damaged, the clamping force between the cylinder head and engine block can decrease in the area of the affected head bolt. Kia’s assessment of the alleged defect is that when the failure occurs, drivers are provided with numerous warning signs prior to a potential loss of motive power event. According to Kia, potential warning signs associated with this failure include coolant leak/consumption or noticeable coolant odor, engine oil leak/consumption, engine temperature gauge rising to “H” (hot), check engine light illuminating, engine cooling fan remaining on following the engine being shut off, HVAC system not functioning properly, unusual engine noise, difficulty starting the vehicle, and smoke/condensation emitting from the engine compartment or exhaust. Through both its review of the information provided by Kia and outreach to consumers, ODI confirmed that there is reasonable detectability present in the vast majority of occurrences of the alleged defect. To mitigate the alleged defect, Kia increased the engagement depth of the head bolt threads for all subject engines, beginning in May 2017. ODI’s analysis of the failure data demonstrates that this corrective action correlates with a much lower incident report rate for engines produced following the change (8 per 100,000 vehicles for the MY 2018-2020 Kia Sorento). In December 2023, Kia launched extended warranty campaign WTY035 covering failures associated with the alleged defect in the subject vehicle population through 15 years or 180,000 miles, whichever comes first. Through its investigation, ODI identified the following peer vehicle populations, which were produced prior to the corrective action and exhibit failure rates comparable to the subject vehicles: MY 2014-2015 Kia Sorento, MY 2015-2016 Kia Sedona, and MY 2014-2017 Kia Cadenza equipped with the 3.3 L engine. Through discussions with ODI during the investigation, Kia decided to launch extended warranty campaign WTY039 in May 2024, which covers these peer vehicle populations through 15 years or 180,000 miles, whichever comes first. Based on analysis of the failure data indicating a low incident report rate of loss of motive power for the alleged defect, and in consideration of the warning signs which frequently occur from head gasket and/or head bolt failure in the subject engines, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On November 13, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23-019) to investigate allegations of loss of motive power relating to head gasket and/or head bolt failure in Model Year (MY) 2016-2017 Kia Sorento vehicles equipped with the 3.3 L Lambda II engine. When the investigation was opened, ODI had received 13 Vehicle Owner Questionnaires (VOQs) related to reports of loss of motive power. In an information request letter dated November 30, 2023, ODI requested technical information and failure data relating to the alleged defect in the subject MY 2016-2017 Kia Sorento as well as several peer vehicle populations which share the 3.3 L engine. In its February 26, 2024, response to ODI’s information request, Kia provided 2022 customer complaints (including techline and field reports) and 1738 warranty claims representing 2411 unique vehicles within the subject vehicle population. Of the customer complaints provided by Kia, they identified only 53 unique allegations of a loss of motive power resulting from the alleged defect. Kia determined that the remaining reports were minor vehicle drivability or engine performance issues. ODI reviewed the information provided by Kia, along with additional VOQs submitted to NHTSA following the opening of the investigation. When eliminating duplicative reports across the data sources, the total number of allegations of loss of motive power relating to the alleged defect in the subject vehicles is 77, representing an incident report rate of 59 per 100,000 vehicles. The MY 2016 Kia Sorento exhibited both the highest overall complaint rate and loss of motive power report rate across all subject and peer vehicle populations, representing an incident report rate of 102 per 100,000 vehicles. Across all data sources, there are no allegations of crashes or fires relating to the alleged defect. The one injury incident reflected in the failure summary table above is related to a consumer who was reportedly burned (minor burn requiring medical attention) while attempting to remove the coolant reservoir cap following a loss of motive power event. In their response to ODI, Kia described that if the threads of a head bolt hole in the subject engine becomes damaged, the clamping force between the cylinder head and engine block can decrease in the area of the affected head bolt. Kia’s assessment of the alleged defect is that when the failure occurs, drivers are provided with numerous warning signs prior to a potential loss of motive power event. According to Kia, potential warning signs associated with this failure include coolant leak/consumption or noticeable coolant odor, engine oil leak/consumption, engine temperature gauge rising to “H” (hot), check engine light illuminating, engine cooling fan remaining on following the engine being shut off, HVAC system not functioning properly, unusual engine noise, difficulty starting the vehicle, and smoke/condensation emitting from the engine compartment or exhaust. Through both its review of the information provided by Kia and outreach to consumers, ODI confirmed that there is reasonable detectability present in the vast majority of occurrences of the alleged defect. To mitigate the alleged defect, Kia increased the engagement depth of the head bolt threads for all subject engines, beginning in May 2017. ODI’s analysis of the failure data demonstrates that this corrective action correlates with a much lower incident report rate for engines produced following the change (8 per 100,000 vehicles for the MY 2018-2020 Kia Sorento). In December 2023, Kia launched extended warranty campaign WTY035 covering failures associated with the alleged defect in the subject vehicle population through 15 years or 180,000 miles, whichever comes first. Through its investigation, ODI identified the following peer vehicle populations, which were produced prior to the corrective action and exhibit failure rates comparable to the subject vehicles: MY 2014-2015 Kia Sorento, MY 2015-2016 Kia Sedona, and MY 2014-2017 Kia Cadenza equipped with the 3.3 L engine. Through discussions with ODI during the investigation, Kia decided to launch extended warranty campaign WTY039 in May 2024, which covers these peer vehicle populations through 15 years or 180,000 miles, whichever comes first. Based on analysis of the failure data indicating a low incident report rate of loss of motive power for the alleged defect, and in consideration of the warning signs which frequently occur from head gasket and/or head bolt failure in the subject engines, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP21002 · Engine Oil Pressure Switch Leak
Opened Nov 12, 2021 · Closed Jun 26, 2023
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:oil/lubrication:pressure/temperature Sensor
In a letter dated September 30, 2021, Mr. Gerald James (the petitioner) requested that NHTSA conduct an investigation of the Model Year (MY) 2015-2017 Kia Sorento equipped with 3.3L V6 ?Lambda? engines for ?severe oil leaks? from the oil pressure switch (OPS) that could ?lead to engine failure? with little warning to the driver. Mr. James based this request on his own experience and data found in NHTSA?s Vehicle Owner Questionnaire (VOQ) database. NHTSA reviewed the material cited by the petitioner, information submitted by Kia, NHTSA?s testing, and other pertinent information in NHTSA databases.On November 12, 2021, ODI opened Defect Petition DP21-002 to evaluate the petitioner?s request. ODI performed an analysis that included evaluation of the petitioner?s vehicle, searches of ODI complaints from vehicle owners, non-dealer field reports, manufacturers? supplemental information relating to design of the component, and component testing performed by ODI.On December 16, 2021, ODI and Kia North America performed a joint inspection on the petitioner?s vehicle. ODI and Kia agreed the OPS was leaking oil and observed oil in the crevices atop the engine block. The vehicle received a new replacement OPS and was delivered back to the petitioner. The original part that was removed from the subject vehicle was retained by ODI for further analysis.As of December 30, 2022, for the MY 2015-2017 Kia Sorento population of 161,519 vehicles with 3.3L engine, NHTSA reviewed internal data and has identified no consumer complaints or field reports in its database, with unique Vehicle Identification Numbers (VIN), citing engine failure or stalling related to the petition?s allegation of defective OPS. When combined with the supplemental warranty and technical analysis from the manufacturer, field report and customer complaint data in response to the Information Request letter sent, NHTSA identified no unique VINs alleging engine failure or stalls caused by OPS leaking on the subject vehicles named in the petition.On April 4, 2022, the Vehicle Research and Test Center (VRTC) performed testing of the petitioner?s component (OPS) based on testing protocol consistent with Kia?s specifications for the subject vehicle. The testing involved the petitioner?s original OPS in a controlled system to replicate the subject vehicle?s oil pressure, flow, and temperature. VRTC determined that a vehicle would have to miss more than a dozen oil change intervals to reach low engine oil capacity. Testing also revealed the OPS would operate, as manufacturer intended, illuminating the vehicle?s MIL to alert the driver of lower oil pressure.In April of 2022, Kia North America issued a warranty extension that extended the coverage of the Oil Pressure Switch from 5 years/60,000 miles to 15 years/150,000 miles on MY 2014-2018 Sorento, MY 2014-2016 Cadenza, and MY 2015-2018 Sedona vehicles, all equipped with the 3.3L Lambda engine. The extended warranty coverage includes diagnosis, repair, and applies to customers experiencing engine oil leaking from the engine or if the engine oil pressure warning light stays illuminated after the engine is turned on.After a thorough review of the material submitted by the petitioner, information already in NHTSA's possession, testing performed by VRTC, technical information provided by Kia, the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that an engine failure due to the alleged defect is likely and does not warrant a formal investigation. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be publi
Additional source detail variants (2)
Engine And Engine Cooling:engine:oil/lubrication:pressure/temperature Sensor
In a letter dated September 30, 2021, Mr. Gerald James (the petitioner) requested that NHTSA conduct an investigation of the Model Year (MY) 2015-2017 Kia Sorento equipped with 3.3L V6 ?Lambda? engines for ?severe oil leaks? from the oil pressure switch (OPS) that could ?lead to engine failure? with little warning to the driver. Mr. James based this request on his own experience and data found in NHTSA?s Vehicle Owner Questionnaire (VOQ) database. NHTSA reviewed the material cited by the petitioner, information submitted by Kia, NHTSA?s testing, and other pertinent information in NHTSA databases.On November 12, 2021, ODI opened Defect Petition DP21-002 to evaluate the petitioner?s request. ODI performed an analysis that included evaluation of the petitioner?s vehicle, searches of ODI complaints from vehicle owners, non-dealer field reports, manufacturers? supplemental information relating to design of the component, and component testing performed by ODI.On December 16, 2021, ODI and Kia North America performed a joint inspection on the petitioner?s vehicle. ODI and Kia agreed the OPS was leaking oil and observed oil in the crevices atop the engine block. The vehicle received a new replacement OPS and was delivered back to the petitioner. The original part that was removed from the subject vehicle was retained by ODI for further analysis.As of December 30, 2022, for the MY 2015-2017 Kia Sorento population of 161,519 vehicles with 3.3L engine, NHTSA reviewed internal data and has identified no consumer complaints or field reports in its database, with unique Vehicle Identification Numbers (VIN), citing engine failure or stalling related to the petition?s allegation of defective OPS. When combined with the supplemental warranty and technical analysis from the manufacturer, field report and customer complaint data in response to the Information Request letter sent, NHTSA identified no unique VINs alleging engine failure or stalls caused by OPS leaking on the subject vehicles named in the petition.On April 4, 2022, the Vehicle Research and Test Center (VRTC) performed testing of the petitioner?s component (OPS) based on testing protocol consistent with Kia?s specifications for the subject vehicle. The testing involved the petitioner?s original OPS in a controlled system to replicate the subject vehicle?s oil pressure, flow, and temperature. VRTC determined that a vehicle would have to miss more than a dozen oil change intervals to reach low engine oil capacity. Testing also revealed the OPS would operate, as manufacturer intended, illuminating the vehicle?s MIL to alert the driver of lower oil pressure.In April of 2022, Kia North America issued a warranty extension that extended the coverage of the Oil Pressure Switch from 5 years/60,000 miles to 15 years/150,000 miles on MY 2014-2018 Sorento, MY 2014-2016 Cadenza, and MY 2015-2018 Sedona vehicles, all equipped with the 3.3L Lambda engine. The extended warranty coverage includes diagnosis, repair, and applies to customers experiencing engine oil leaking from the engine or if the engine oil pressure warning light stays illuminated after the engine is turned on.After a thorough review of the material submitted by the petitioner, information already in NHTSA's possession, testing performed by VRTC, technical information provided by Kia, the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that an engine failure due to the alleged defect is likely and does not warrant a formal investigation. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be publi
Engine
In a letter dated September 30, 2021, Mr. Gerald James (the petitioner) requested that NHTSA conduct an investigation of the Model Year (MY) 2015-2017 Kia Sorento equipped with 3.3L V6 ?Lambda? engines for ?severe oil leaks? from the oil pressure switch (OPS) that could ?lead to engine failure? with little warning to the driver. Mr. James based this request on his own experience and data found in NHTSA?s Vehicle Owner Questionnaire (VOQ) database. NHTSA reviewed the material cited by the petitioner, information submitted by Kia, NHTSA?s testing, and other pertinent information in NHTSA databases.On November 12, 2021, ODI opened Defect Petition DP21-002 to evaluate the petitioner?s request. ODI performed an analysis that included evaluation of the petitioner?s vehicle, searches of ODI complaints from vehicle owners, non-dealer field reports, manufacturers? supplemental information relating to design of the component, and component testing performed by ODI.On December 16, 2021, ODI and Kia North America performed a joint inspection on the petitioner?s vehicle. ODI and Kia agreed the OPS was leaking oil and observed oil in the crevices atop the engine block. The vehicle received a new replacement OPS and was delivered back to the petitioner. The original part that was removed from the subject vehicle was retained by ODI for further analysis.As of December 30, 2022, for the MY 2015-2017 Kia Sorento population of 161,519 vehicles with 3.3L engine, NHTSA reviewed internal data and has identified no consumer complaints or field reports in its database, with unique Vehicle Identification Numbers (VIN), citing engine failure or stalling related to the petition?s allegation of defective OPS. When combined with the supplemental warranty and technical analysis from the manufacturer, field report and customer complaint data in response to the Information Request letter sent, NHTSA identified no unique VINs alleging engine failure or stalls caused by OPS leaking on the subject vehicles named in the petition.On April 4, 2022, the Vehicle Research and Test Center (VRTC) performed testing of the petitioner?s component (OPS) based on testing protocol consistent with Kia?s specifications for the subject vehicle. The testing involved the petitioner?s original OPS in a controlled system to replicate the subject vehicle?s oil pressure, flow, and temperature. VRTC determined that a vehicle would have to miss more than a dozen oil change intervals to reach low engine oil capacity. Testing also revealed the OPS would operate, as manufacturer intended, illuminating the vehicle?s MIL to alert the driver of lower oil pressure.In April of 2022, Kia North America issued a warranty extension that extended the coverage of the Oil Pressure Switch from 5 years/60,000 miles to 15 years/150,000 miles on MY 2014-2018 Sorento, MY 2014-2016 Cadenza, and MY 2015-2018 Sedona vehicles, all equipped with the 3.3L Lambda engine. The extended warranty coverage includes diagnosis, repair, and applies to customers experiencing engine oil leaking from the engine or if the engine oil pressure warning light stays illuminated after the engine is turned on.After a thorough review of the material submitted by the petitioner, information already in NHTSA's possession, testing performed by VRTC, technical information provided by Kia, the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that an engine failure due to the alleged defect is likely and does not warrant a formal investigation. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be publi
Illustration