NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
94 reportsClear category filter47,000 miles · Dec 10, 2019
Electrical SystemEngineFuel/propulsion System
ON OCTOBER 10 2019 MY WIFE WAS DRIVING THE KIDS TO SCHOOL IN OUR 2017 KIA SORENTO AND BEFORE SHE COULD GET OUT OF THE NEIGHBORHOOD THE CAR STARTED TO JERK UNCONTROLLABLY AND LOST ALL ACCELERATION BEFORE IT CUT OFF. SHE THEN TRIED TO RESTART THE CAR SEVERAL TIME BUT WAS UNSUCCESSFULLY IT IT STARTING BACK UP BEFORE IT STALLED OUT…
Read full complaint
ON OCTOBER 10 2019 MY WIFE WAS DRIVING THE KIDS TO SCHOOL IN OUR 2017 KIA SORENTO AND BEFORE SHE COULD GET OUT OF THE NEIGHBORHOOD THE CAR STARTED TO JERK UNCONTROLLABLY AND LOST ALL ACCELERATION BEFORE IT CUT OFF. SHE THEN TRIED TO RESTART THE CAR SEVERAL TIME BUT WAS UNSUCCESSFULLY IT IT STARTING BACK UP BEFORE IT STALLED OUT. AFTER THE CAR WAS LEFT ALONE FOR A WHILE I WENT OUT TO THE CAR AND IT STARTED BACK UP AND SEEMED LIKE IT DROVE FINE. WE DID NOT TAKE IT TO THE DEALERSHIP THAT TIME. AFTER THAT MY WIFE SAID THAT SHE FELT THE VEHICLE WAS NOT DRIVING LIKE IT SHOULD. SHE SAID THAT YOU BASICALLY HAD TO FLOOR IT FOR IT TO GET UP TO CRUISING SPEED. APPROXIMATELY 6 WEEKS LATER MY WIFE STARTED TO HAVE MORE PROBLEMS WITH THE VEHICLE. SHE STATED THAT THE ACCELERATION PROBLEM WAS VERY NOTICEABLE AND WAS SCARIED THAT IT WAS GOING TO STALL OUT AGAIN BEFORE SHE COULD GET HOME THAT DAY. SHE WAS ABLE TO GET HOME SAFE THAT TIME. LATER ON THAT DAY SHE HAD TO GO BACK OUT AND SHE SAID THAT IT STARTED UP FINE AND DROVE FINE UNTIL WITH OUT WARNING IT JUST SHUT OFF WHILE SHE WAS DRIVING IN THE MIDDLE OF BUSINESS INTERSECTION. THE CAR STARTED UP JUST FINE ONCE IT SHUT OFF AND MY WIFE DROVE IT TO A NEARBY PARKING LOT WHERE IT SAT UNTIL IT WAS TOWED TO THE DEALERSHIP. THE DEALERSHIP HAS HAD THE VEHICLE ABOUT 3 WEEKS NOW AND ARE UNABLE REPLICATE THE PROBLEM. THE DEALERSHIP SAID THAT THEY HAVE DONE EVERYTHING POSSIBLE TO SEE IF THERE WAS A PROBLEM WITH THE CAR. SINCE THEY CANNOT REPLICATE THE PROBLEM AND THERE IS NO CODES THEN THEY THINK THAT THE VEHICLE IS FINE. SIN E THE CAR CUT OFF ON MY WIFE TWICE IN SIX WEEKS SHE IS SCARED TO DRIVE THE CAR IN FEAR THAT IT WILL SHUT OFF ON HER AGAIN. THIS IS A MAJOR SAFETY CONCERN THAT NEEDS TO BE ADDRESSED BY KIA. I AM NOT THE ONLY ONE COMPLAINING ABOUT THIS PROBLEM WITH THIS CAR THIS COULD HAVE VERY EASILY RESULTED IN A MAJOR ACCIDENT
NHTSA ODI #11288268
35,000 miles · Nov 4, 2019
Electrical System
MY 2017 KIA SORENTO HEADLIGHTS WHEN OPERATING IN AUTO MODE WILL UNEXPECTEDLY AND WITHOUT WARNING TURN OFF. I HAVE TO TURN THE SWITCH MANUALLY TO MAKE THEM COME BACK ON. THIS CREATES AN EXTREME SAFETY HAZARD. IT HAS HAPPENED BOTH ON THE HIGHWAY / INTERSTATE AS WELL AS BACK ROADS. THIS NEEDS TO BE ADDRESSED BY KIA ASAP.
NHTSA ODI #11278093
46,000 miles · Jul 23, 2019
Electrical SystemExterior Lighting
HEAD LIGHTS TURN OFF WHILE DRIVING DOWN THE ROAD
NHTSA ODI #11234040
67,000 miles · Jun 26, 2019
Electrical SystemEngineFuel/propulsion System
ENGINE IS SEVERELY SLUGGED AND THERE WAS NO WARNING EVER. FOUND OUT AFTER AN OIL CHANGED AT 67K AT JIFFY LUBE WHEN I TOOK IT TO THE OURISMAN KIA DEALER IN CHANTILLY, VA. THERE IS NO WARNING THAT ANY OF THIS SITUATION WAS STARTING TO HAPPEN EVEN AFTER A PREVIOUS OIL CHANGE AT KIA DEALER AT 58K MILES. THE DEALERSHIP DENIED MY C…
Read full complaint
ENGINE IS SEVERELY SLUGGED AND THERE WAS NO WARNING EVER. FOUND OUT AFTER AN OIL CHANGED AT 67K AT JIFFY LUBE WHEN I TOOK IT TO THE OURISMAN KIA DEALER IN CHANTILLY, VA. THERE IS NO WARNING THAT ANY OF THIS SITUATION WAS STARTING TO HAPPEN EVEN AFTER A PREVIOUS OIL CHANGE AT KIA DEALER AT 58K MILES. THE DEALERSHIP DENIED MY CLAIM WITH THE 100K MILE WARRANTY BECAUSE I DON'T HAVE PROOF THAT I DID ALL 9 OIL CHANGES. THEY PROCEEDED TO TELL ME THAT I NEED A NEW ENGINE BUT THAT THEY ARE ON BACKORDER NATIONWIDE AND WHO KNOWS WHAT DATE TBD THAT WILL BECOME AVAILABLE. THE REPAIR SHOP I TOOK IT TO PIEDOMONT IN HAYMARKET, VA SAYS THEY THINK IT IS SOMETHING LIKE A YEAR BEFORE IT MIGHT BE AVAILABLE. SO IN THE MEAN TIME NO LOANER WAS EVER OFFERED TO ME AND NO I HAVE A UNUSABLE VEHICLE THAT I HAVE SUBMITTED A CLAIM FOR WITH GEICO. I DO NOT HAVE FUNDING FOR A NEW ENGINE AND THE FACT THAT THE KIA MOTOR COMPANY HAS NO ENGINE TO EVEN SUPPLY TO ME IS COMPLETELY UNACCEPTABLE PRACTICE FOR A BUSINESS. ALSO 1 YEAR AGO MY BATTERY JUST DIED ACCORDING TO THE KIA DEALER DUE TO A PARASITIC DRAIN. THAT SEEMS SUSPICIOUS TO ME SINCE THE VEHICLE WAS ONLY A YEAR OLD AND HAD TO BE REPLACED WITH ONE I BOUGHT AT WALMART. ALSO, THE FUSE FOR THE DRIVER SEAT CONTINUOUSLY BLOWS.
NHTSA ODI #11222678
25,000 miles · Mar 13, 2019
Electrical SystemSteeringVehicle Speed Control
AS I AM DRIVING OVER 40 MPH, THE VEHICLE WILL LOSE ALL POWER AND CAUTION LIGHTS ILLUMINATE ON THE DASH, RADIO TURNS OFF, POWER STEERING GOES OUT, CAR DECREASES SPEED. THE CAR IMMEDIATELY TURNS BACK ON, BUT THERE IS NO ACCELERATION TO THE VEHICLE. THIS HAS HAPPENED 3 TIMES IN THE LAST 5 DAYS AND IT HAPPED 3 TIMES TODAY MARCH 12,…
Read full complaint
AS I AM DRIVING OVER 40 MPH, THE VEHICLE WILL LOSE ALL POWER AND CAUTION LIGHTS ILLUMINATE ON THE DASH, RADIO TURNS OFF, POWER STEERING GOES OUT, CAR DECREASES SPEED. THE CAR IMMEDIATELY TURNS BACK ON, BUT THERE IS NO ACCELERATION TO THE VEHICLE. THIS HAS HAPPENED 3 TIMES IN THE LAST 5 DAYS AND IT HAPPED 3 TIMES TODAY MARCH 12, 2019. ALL INCIDENTS WERE ON CITY STREETS, WHILE GOING STRAIGHT AT SPEEDS 40 MPH OR MORE. THE LAST TIME, WAS WHILE I WAS MAKING A RIGHT TURN GETTING ON THE FREEWAY. AFTER EACH OCCURRENCE, I WOULD SAFELY PULL OFF THE ROAD, TURN THE VEHICLE OFF, WAIT A COUPLE SECONDS AND TURN THE CAR BACK ON. THE CAR WOULD RESUME BACK TO NORMAL. I HAVE NOTICED THAT AFTER THE FIRST TIME THIS HAPPENED, WHEN I DO THE FIRST ATTEMPT TO TURN THE CAR ON, IT DOES NOT TURN OVER.
NHTSA ODI #11186630
30,000 miles · Feb 20, 2019
Electrical System
WHEN VEHICLE IS IN MOTION THE HEADLIGHTS WILL RANDOMLY TURN OFF WHEN ON THE AUTO SETTING. THIS HAS HAPPEN MULTIPLE TIMES SINCE WE PURCHASED THIS VEHICLE AND IS A SERIOUS ACCIDENT WAITING TO HAPPEN. I HAVE VIEWED MULTIPLE REPORTS OF THIS ISSUE ONLINE FROM OTHER OWNERS. THIS HAS HAPPEN ON THE HIGHWAY AND CITY STREETS WHERE THE ROA…
Read full complaint
WHEN VEHICLE IS IN MOTION THE HEADLIGHTS WILL RANDOMLY TURN OFF WHEN ON THE AUTO SETTING. THIS HAS HAPPEN MULTIPLE TIMES SINCE WE PURCHASED THIS VEHICLE AND IS A SERIOUS ACCIDENT WAITING TO HAPPEN. I HAVE VIEWED MULTIPLE REPORTS OF THIS ISSUE ONLINE FROM OTHER OWNERS. THIS HAS HAPPEN ON THE HIGHWAY AND CITY STREETS WHERE THE ROADS HAVE NO LIGHTING.
NHTSA ODI #11181452
500 miles · Dec 18, 2018
Electrical System
THE CAR WILL BE OFF AND LOCKED AND ALL THE LIGHTS WILL PERIODICALLY COME ON. THIS HAS HAPPENED ABOUT 15TIMES IN THE 2YRS WE HAVE OWNED IT. THE DEALERSHIP HAS BEEN INFORMED. WE WERE TOLD THE KIA'S ON THE LOT DO THE SAME THING AND THEY DON'T KNOW WHY????
NHTSA ODI #11162142
68,100 miles · Oct 11, 2018
Electrical System
TL* THE CONTACT OWNS A 2017 KIA SORENTO WITH A TRAILER IN TOW. THE CONTACT STATED THAT THE BRAKE LIGHT ON THE TRAILER REMAINED ILLUMINATED WHILE DRIVING. THE VEHICLE WAS TAKEN TO KIA FORT WALTON BEACH (LOCATED AT 343 MIRACLE STRIP PARKWAY, FORT WALTON BEACH, FL 32548, (850) 275-2206), BUT WAS NOT DIAGNOSED OR REPAIRED. THE DEALE…
Read full complaint
TL* THE CONTACT OWNS A 2017 KIA SORENTO WITH A TRAILER IN TOW. THE CONTACT STATED THAT THE BRAKE LIGHT ON THE TRAILER REMAINED ILLUMINATED WHILE DRIVING. THE VEHICLE WAS TAKEN TO KIA FORT WALTON BEACH (LOCATED AT 343 MIRACLE STRIP PARKWAY, FORT WALTON BEACH, FL 32548, (850) 275-2206), BUT WAS NOT DIAGNOSED OR REPAIRED. THE DEALER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V862000 (TRAILER HITCHES, ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED CASE NUMBER: 12835928. THE APPROXIMATE FAILURE MILEAGE WAS 68,100.
NHTSA ODI #11139745
33,000 miles · Sep 27, 2018
Electrical System
WHILE DRIVING AT NIGHT WITH LIGHTS IN THE "AUTOMATIC" POSITION, THE HEADLIGHTS WILL RANDOMLY SWITCH TO PARKING LIGHTS AS INDICATED ON THE DASHBOARD DISPLAY AND BASED ON WHAT I CAN SEE OUT THE WINDSHIELD. AFTER 5 TO 10 SECONDS THE LIGHTS WILL TURN BACK ON AS INDICATED BY THE DASHBOARD DISPLAY AND WHAT I CAN SEE. THE PROBLEM IS …
Read full complaint
WHILE DRIVING AT NIGHT WITH LIGHTS IN THE "AUTOMATIC" POSITION, THE HEADLIGHTS WILL RANDOMLY SWITCH TO PARKING LIGHTS AS INDICATED ON THE DASHBOARD DISPLAY AND BASED ON WHAT I CAN SEE OUT THE WINDSHIELD. AFTER 5 TO 10 SECONDS THE LIGHTS WILL TURN BACK ON AS INDICATED BY THE DASHBOARD DISPLAY AND WHAT I CAN SEE. THE PROBLEM IS MOST COMMON AT HIGHWAY SPEEDS BUT HAS OCCURRED ON CITY STREETS AS WELL. IT USUALLY OCCURS WITHIN THE FIRST 10 MINUTES OF DRIVING. IF THE HEADLIGHT CONTROL SWITCH IS TURNED MANUALLY TO THE "ON" POSITION, THE LIGHTS WILL FUNCTION CORRECTLY.
NHTSA ODI #11132008
Mileage unknown · Jun 23, 2018
Electrical System
TAKATA RECALL THE REAR PASSENGER DOOR SHOWS AS "OPEN" ON THE DASH SCREEN EVEN WHEN THE VEHICLE IS OFF. THE DOOR IS CLOSED AND SHOWS AS OPEN WHEN DRIVING ELIMINATING IMPERATIVE ON-SCREEN NOTIFICATIONS.
NHTSA ODI #11103569
Official recalls
4Sep 19, 2022
Kia America, Inc. (Kia) is recalling certain 2016-2022 Sorento, 2021-2022 Sorento Hybrid (HEV), 2022-2023 Sorento Plug-In Hybrid (PHEV), and 2017-2022 Sportage vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
Consequence & remedy
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will inspect the vehicle, and, as necessary, replace the fuse and/or tow hitch harness module, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC249.
Dec 19, 2018
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Additional source detail variants (2)
Engine
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Sep 21, 2017
Kia Motors America (Kia) is recalling certain 2017 Sorento vehicles equipped with 3.3L engines. The engine crankshaft may have been improperly heat treated and may fail.
Consequence & remedy
Consequence: If the crankshaft fails, the engine will stall, increasing the risk of a crash. A failed crankshaft also increases the risk of a fire.
Remedy: Kia will notify owners, and dealers will inspect the crankshaft, and, as necessary, replace the engine sub assembly, free of charge. The recall began November 6, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC153.
Nov 30, 2016
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Additional source detail variants (2)
Trailer Hitches
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Electrical System
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE23019 · Loss Of Motive Power
Opened Nov 13, 2023 · Closed Jul 23, 2024
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:oil/lubrication:seals/gaskets
On November 13, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23-019) to investigate allegations of loss of motive power relating to head gasket and/or head bolt failure in Model Year (MY) 2016-2017 Kia Sorento vehicles equipped with the 3.3 L Lambda II engine. When the investigation was opened, ODI had received 13 Vehicle Owner Questionnaires (VOQs) related to reports of loss of motive power. In an information request letter dated November 30, 2023, ODI requested technical information and failure data relating to the alleged defect in the subject MY 2016-2017 Kia Sorento as well as several peer vehicle populations which share the 3.3 L engine. In its February 26, 2024, response to ODI’s information request, Kia provided 2022 customer complaints (including techline and field reports) and 1738 warranty claims representing 2411 unique vehicles within the subject vehicle population. Of the customer complaints provided by Kia, they identified only 53 unique allegations of a loss of motive power resulting from the alleged defect. Kia determined that the remaining reports were minor vehicle drivability or engine performance issues. ODI reviewed the information provided by Kia, along with additional VOQs submitted to NHTSA following the opening of the investigation. When eliminating duplicative reports across the data sources, the total number of allegations of loss of motive power relating to the alleged defect in the subject vehicles is 77, representing an incident report rate of 59 per 100,000 vehicles. The MY 2016 Kia Sorento exhibited both the highest overall complaint rate and loss of motive power report rate across all subject and peer vehicle populations, representing an incident report rate of 102 per 100,000 vehicles. Across all data sources, there are no allegations of crashes or fires relating to the alleged defect. The one injury incident reflected in the failure summary table above is related to a consumer who was reportedly burned (minor burn requiring medical attention) while attempting to remove the coolant reservoir cap following a loss of motive power event. In their response to ODI, Kia described that if the threads of a head bolt hole in the subject engine becomes damaged, the clamping force between the cylinder head and engine block can decrease in the area of the affected head bolt. Kia’s assessment of the alleged defect is that when the failure occurs, drivers are provided with numerous warning signs prior to a potential loss of motive power event. According to Kia, potential warning signs associated with this failure include coolant leak/consumption or noticeable coolant odor, engine oil leak/consumption, engine temperature gauge rising to “H” (hot), check engine light illuminating, engine cooling fan remaining on following the engine being shut off, HVAC system not functioning properly, unusual engine noise, difficulty starting the vehicle, and smoke/condensation emitting from the engine compartment or exhaust. Through both its review of the information provided by Kia and outreach to consumers, ODI confirmed that there is reasonable detectability present in the vast majority of occurrences of the alleged defect. To mitigate the alleged defect, Kia increased the engagement depth of the head bolt threads for all subject engines, beginning in May 2017. ODI’s analysis of the failure data demonstrates that this corrective action correlates with a much lower incident report rate for engines produced following the change (8 per 100,000 vehicles for the MY 2018-2020 Kia Sorento). In December 2023, Kia launched extended warranty campaign WTY035 covering failures associated with the alleged defect in the subject vehicle population through 15 years or 180,000 miles, whichever comes first. Through its investigation, ODI identified the following peer vehicle populations, which were produced prior to the corrective action and exhibit failure rates comparable to the subject vehicles: MY 2014-2015 Kia Sorento, MY 2015-2016 Kia Sedona, and MY 2014-2017 Kia Cadenza equipped with the 3.3 L engine. Through discussions with ODI during the investigation, Kia decided to launch extended warranty campaign WTY039 in May 2024, which covers these peer vehicle populations through 15 years or 180,000 miles, whichever comes first. Based on analysis of the failure data indicating a low incident report rate of loss of motive power for the alleged defect, and in consideration of the warning signs which frequently occur from head gasket and/or head bolt failure in the subject engines, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:oil/lubrication:seals/gaskets
On November 13, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23-019) to investigate allegations of loss of motive power relating to head gasket and/or head bolt failure in Model Year (MY) 2016-2017 Kia Sorento vehicles equipped with the 3.3 L Lambda II engine. When the investigation was opened, ODI had received 13 Vehicle Owner Questionnaires (VOQs) related to reports of loss of motive power. In an information request letter dated November 30, 2023, ODI requested technical information and failure data relating to the alleged defect in the subject MY 2016-2017 Kia Sorento as well as several peer vehicle populations which share the 3.3 L engine. In its February 26, 2024, response to ODI’s information request, Kia provided 2022 customer complaints (including techline and field reports) and 1738 warranty claims representing 2411 unique vehicles within the subject vehicle population. Of the customer complaints provided by Kia, they identified only 53 unique allegations of a loss of motive power resulting from the alleged defect. Kia determined that the remaining reports were minor vehicle drivability or engine performance issues. ODI reviewed the information provided by Kia, along with additional VOQs submitted to NHTSA following the opening of the investigation. When eliminating duplicative reports across the data sources, the total number of allegations of loss of motive power relating to the alleged defect in the subject vehicles is 77, representing an incident report rate of 59 per 100,000 vehicles. The MY 2016 Kia Sorento exhibited both the highest overall complaint rate and loss of motive power report rate across all subject and peer vehicle populations, representing an incident report rate of 102 per 100,000 vehicles. Across all data sources, there are no allegations of crashes or fires relating to the alleged defect. The one injury incident reflected in the failure summary table above is related to a consumer who was reportedly burned (minor burn requiring medical attention) while attempting to remove the coolant reservoir cap following a loss of motive power event. In their response to ODI, Kia described that if the threads of a head bolt hole in the subject engine becomes damaged, the clamping force between the cylinder head and engine block can decrease in the area of the affected head bolt. Kia’s assessment of the alleged defect is that when the failure occurs, drivers are provided with numerous warning signs prior to a potential loss of motive power event. According to Kia, potential warning signs associated with this failure include coolant leak/consumption or noticeable coolant odor, engine oil leak/consumption, engine temperature gauge rising to “H” (hot), check engine light illuminating, engine cooling fan remaining on following the engine being shut off, HVAC system not functioning properly, unusual engine noise, difficulty starting the vehicle, and smoke/condensation emitting from the engine compartment or exhaust. Through both its review of the information provided by Kia and outreach to consumers, ODI confirmed that there is reasonable detectability present in the vast majority of occurrences of the alleged defect. To mitigate the alleged defect, Kia increased the engagement depth of the head bolt threads for all subject engines, beginning in May 2017. ODI’s analysis of the failure data demonstrates that this corrective action correlates with a much lower incident report rate for engines produced following the change (8 per 100,000 vehicles for the MY 2018-2020 Kia Sorento). In December 2023, Kia launched extended warranty campaign WTY035 covering failures associated with the alleged defect in the subject vehicle population through 15 years or 180,000 miles, whichever comes first. Through its investigation, ODI identified the following peer vehicle populations, which were produced prior to the corrective action and exhibit failure rates comparable to the subject vehicles: MY 2014-2015 Kia Sorento, MY 2015-2016 Kia Sedona, and MY 2014-2017 Kia Cadenza equipped with the 3.3 L engine. Through discussions with ODI during the investigation, Kia decided to launch extended warranty campaign WTY039 in May 2024, which covers these peer vehicle populations through 15 years or 180,000 miles, whichever comes first. Based on analysis of the failure data indicating a low incident report rate of loss of motive power for the alleged defect, and in consideration of the warning signs which frequently occur from head gasket and/or head bolt failure in the subject engines, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On November 13, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23-019) to investigate allegations of loss of motive power relating to head gasket and/or head bolt failure in Model Year (MY) 2016-2017 Kia Sorento vehicles equipped with the 3.3 L Lambda II engine. When the investigation was opened, ODI had received 13 Vehicle Owner Questionnaires (VOQs) related to reports of loss of motive power. In an information request letter dated November 30, 2023, ODI requested technical information and failure data relating to the alleged defect in the subject MY 2016-2017 Kia Sorento as well as several peer vehicle populations which share the 3.3 L engine. In its February 26, 2024, response to ODI’s information request, Kia provided 2022 customer complaints (including techline and field reports) and 1738 warranty claims representing 2411 unique vehicles within the subject vehicle population. Of the customer complaints provided by Kia, they identified only 53 unique allegations of a loss of motive power resulting from the alleged defect. Kia determined that the remaining reports were minor vehicle drivability or engine performance issues. ODI reviewed the information provided by Kia, along with additional VOQs submitted to NHTSA following the opening of the investigation. When eliminating duplicative reports across the data sources, the total number of allegations of loss of motive power relating to the alleged defect in the subject vehicles is 77, representing an incident report rate of 59 per 100,000 vehicles. The MY 2016 Kia Sorento exhibited both the highest overall complaint rate and loss of motive power report rate across all subject and peer vehicle populations, representing an incident report rate of 102 per 100,000 vehicles. Across all data sources, there are no allegations of crashes or fires relating to the alleged defect. The one injury incident reflected in the failure summary table above is related to a consumer who was reportedly burned (minor burn requiring medical attention) while attempting to remove the coolant reservoir cap following a loss of motive power event. In their response to ODI, Kia described that if the threads of a head bolt hole in the subject engine becomes damaged, the clamping force between the cylinder head and engine block can decrease in the area of the affected head bolt. Kia’s assessment of the alleged defect is that when the failure occurs, drivers are provided with numerous warning signs prior to a potential loss of motive power event. According to Kia, potential warning signs associated with this failure include coolant leak/consumption or noticeable coolant odor, engine oil leak/consumption, engine temperature gauge rising to “H” (hot), check engine light illuminating, engine cooling fan remaining on following the engine being shut off, HVAC system not functioning properly, unusual engine noise, difficulty starting the vehicle, and smoke/condensation emitting from the engine compartment or exhaust. Through both its review of the information provided by Kia and outreach to consumers, ODI confirmed that there is reasonable detectability present in the vast majority of occurrences of the alleged defect. To mitigate the alleged defect, Kia increased the engagement depth of the head bolt threads for all subject engines, beginning in May 2017. ODI’s analysis of the failure data demonstrates that this corrective action correlates with a much lower incident report rate for engines produced following the change (8 per 100,000 vehicles for the MY 2018-2020 Kia Sorento). In December 2023, Kia launched extended warranty campaign WTY035 covering failures associated with the alleged defect in the subject vehicle population through 15 years or 180,000 miles, whichever comes first. Through its investigation, ODI identified the following peer vehicle populations, which were produced prior to the corrective action and exhibit failure rates comparable to the subject vehicles: MY 2014-2015 Kia Sorento, MY 2015-2016 Kia Sedona, and MY 2014-2017 Kia Cadenza equipped with the 3.3 L engine. Through discussions with ODI during the investigation, Kia decided to launch extended warranty campaign WTY039 in May 2024, which covers these peer vehicle populations through 15 years or 180,000 miles, whichever comes first. Based on analysis of the failure data indicating a low incident report rate of loss of motive power for the alleged defect, and in consideration of the warning signs which frequently occur from head gasket and/or head bolt failure in the subject engines, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP21002 · Engine Oil Pressure Switch Leak
Opened Nov 12, 2021 · Closed Jun 26, 2023
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:oil/lubrication:pressure/temperature Sensor
In a letter dated September 30, 2021, Mr. Gerald James (the petitioner) requested that NHTSA conduct an investigation of the Model Year (MY) 2015-2017 Kia Sorento equipped with 3.3L V6 ?Lambda? engines for ?severe oil leaks? from the oil pressure switch (OPS) that could ?lead to engine failure? with little warning to the driver. Mr. James based this request on his own experience and data found in NHTSA?s Vehicle Owner Questionnaire (VOQ) database. NHTSA reviewed the material cited by the petitioner, information submitted by Kia, NHTSA?s testing, and other pertinent information in NHTSA databases.On November 12, 2021, ODI opened Defect Petition DP21-002 to evaluate the petitioner?s request. ODI performed an analysis that included evaluation of the petitioner?s vehicle, searches of ODI complaints from vehicle owners, non-dealer field reports, manufacturers? supplemental information relating to design of the component, and component testing performed by ODI.On December 16, 2021, ODI and Kia North America performed a joint inspection on the petitioner?s vehicle. ODI and Kia agreed the OPS was leaking oil and observed oil in the crevices atop the engine block. The vehicle received a new replacement OPS and was delivered back to the petitioner. The original part that was removed from the subject vehicle was retained by ODI for further analysis.As of December 30, 2022, for the MY 2015-2017 Kia Sorento population of 161,519 vehicles with 3.3L engine, NHTSA reviewed internal data and has identified no consumer complaints or field reports in its database, with unique Vehicle Identification Numbers (VIN), citing engine failure or stalling related to the petition?s allegation of defective OPS. When combined with the supplemental warranty and technical analysis from the manufacturer, field report and customer complaint data in response to the Information Request letter sent, NHTSA identified no unique VINs alleging engine failure or stalls caused by OPS leaking on the subject vehicles named in the petition.On April 4, 2022, the Vehicle Research and Test Center (VRTC) performed testing of the petitioner?s component (OPS) based on testing protocol consistent with Kia?s specifications for the subject vehicle. The testing involved the petitioner?s original OPS in a controlled system to replicate the subject vehicle?s oil pressure, flow, and temperature. VRTC determined that a vehicle would have to miss more than a dozen oil change intervals to reach low engine oil capacity. Testing also revealed the OPS would operate, as manufacturer intended, illuminating the vehicle?s MIL to alert the driver of lower oil pressure.In April of 2022, Kia North America issued a warranty extension that extended the coverage of the Oil Pressure Switch from 5 years/60,000 miles to 15 years/150,000 miles on MY 2014-2018 Sorento, MY 2014-2016 Cadenza, and MY 2015-2018 Sedona vehicles, all equipped with the 3.3L Lambda engine. The extended warranty coverage includes diagnosis, repair, and applies to customers experiencing engine oil leaking from the engine or if the engine oil pressure warning light stays illuminated after the engine is turned on.After a thorough review of the material submitted by the petitioner, information already in NHTSA's possession, testing performed by VRTC, technical information provided by Kia, the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that an engine failure due to the alleged defect is likely and does not warrant a formal investigation. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be publi
Additional source detail variants (2)
Engine And Engine Cooling:engine:oil/lubrication:pressure/temperature Sensor
In a letter dated September 30, 2021, Mr. Gerald James (the petitioner) requested that NHTSA conduct an investigation of the Model Year (MY) 2015-2017 Kia Sorento equipped with 3.3L V6 ?Lambda? engines for ?severe oil leaks? from the oil pressure switch (OPS) that could ?lead to engine failure? with little warning to the driver. Mr. James based this request on his own experience and data found in NHTSA?s Vehicle Owner Questionnaire (VOQ) database. NHTSA reviewed the material cited by the petitioner, information submitted by Kia, NHTSA?s testing, and other pertinent information in NHTSA databases.On November 12, 2021, ODI opened Defect Petition DP21-002 to evaluate the petitioner?s request. ODI performed an analysis that included evaluation of the petitioner?s vehicle, searches of ODI complaints from vehicle owners, non-dealer field reports, manufacturers? supplemental information relating to design of the component, and component testing performed by ODI.On December 16, 2021, ODI and Kia North America performed a joint inspection on the petitioner?s vehicle. ODI and Kia agreed the OPS was leaking oil and observed oil in the crevices atop the engine block. The vehicle received a new replacement OPS and was delivered back to the petitioner. The original part that was removed from the subject vehicle was retained by ODI for further analysis.As of December 30, 2022, for the MY 2015-2017 Kia Sorento population of 161,519 vehicles with 3.3L engine, NHTSA reviewed internal data and has identified no consumer complaints or field reports in its database, with unique Vehicle Identification Numbers (VIN), citing engine failure or stalling related to the petition?s allegation of defective OPS. When combined with the supplemental warranty and technical analysis from the manufacturer, field report and customer complaint data in response to the Information Request letter sent, NHTSA identified no unique VINs alleging engine failure or stalls caused by OPS leaking on the subject vehicles named in the petition.On April 4, 2022, the Vehicle Research and Test Center (VRTC) performed testing of the petitioner?s component (OPS) based on testing protocol consistent with Kia?s specifications for the subject vehicle. The testing involved the petitioner?s original OPS in a controlled system to replicate the subject vehicle?s oil pressure, flow, and temperature. VRTC determined that a vehicle would have to miss more than a dozen oil change intervals to reach low engine oil capacity. Testing also revealed the OPS would operate, as manufacturer intended, illuminating the vehicle?s MIL to alert the driver of lower oil pressure.In April of 2022, Kia North America issued a warranty extension that extended the coverage of the Oil Pressure Switch from 5 years/60,000 miles to 15 years/150,000 miles on MY 2014-2018 Sorento, MY 2014-2016 Cadenza, and MY 2015-2018 Sedona vehicles, all equipped with the 3.3L Lambda engine. The extended warranty coverage includes diagnosis, repair, and applies to customers experiencing engine oil leaking from the engine or if the engine oil pressure warning light stays illuminated after the engine is turned on.After a thorough review of the material submitted by the petitioner, information already in NHTSA's possession, testing performed by VRTC, technical information provided by Kia, the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that an engine failure due to the alleged defect is likely and does not warrant a formal investigation. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be publi
Engine
In a letter dated September 30, 2021, Mr. Gerald James (the petitioner) requested that NHTSA conduct an investigation of the Model Year (MY) 2015-2017 Kia Sorento equipped with 3.3L V6 ?Lambda? engines for ?severe oil leaks? from the oil pressure switch (OPS) that could ?lead to engine failure? with little warning to the driver. Mr. James based this request on his own experience and data found in NHTSA?s Vehicle Owner Questionnaire (VOQ) database. NHTSA reviewed the material cited by the petitioner, information submitted by Kia, NHTSA?s testing, and other pertinent information in NHTSA databases.On November 12, 2021, ODI opened Defect Petition DP21-002 to evaluate the petitioner?s request. ODI performed an analysis that included evaluation of the petitioner?s vehicle, searches of ODI complaints from vehicle owners, non-dealer field reports, manufacturers? supplemental information relating to design of the component, and component testing performed by ODI.On December 16, 2021, ODI and Kia North America performed a joint inspection on the petitioner?s vehicle. ODI and Kia agreed the OPS was leaking oil and observed oil in the crevices atop the engine block. The vehicle received a new replacement OPS and was delivered back to the petitioner. The original part that was removed from the subject vehicle was retained by ODI for further analysis.As of December 30, 2022, for the MY 2015-2017 Kia Sorento population of 161,519 vehicles with 3.3L engine, NHTSA reviewed internal data and has identified no consumer complaints or field reports in its database, with unique Vehicle Identification Numbers (VIN), citing engine failure or stalling related to the petition?s allegation of defective OPS. When combined with the supplemental warranty and technical analysis from the manufacturer, field report and customer complaint data in response to the Information Request letter sent, NHTSA identified no unique VINs alleging engine failure or stalls caused by OPS leaking on the subject vehicles named in the petition.On April 4, 2022, the Vehicle Research and Test Center (VRTC) performed testing of the petitioner?s component (OPS) based on testing protocol consistent with Kia?s specifications for the subject vehicle. The testing involved the petitioner?s original OPS in a controlled system to replicate the subject vehicle?s oil pressure, flow, and temperature. VRTC determined that a vehicle would have to miss more than a dozen oil change intervals to reach low engine oil capacity. Testing also revealed the OPS would operate, as manufacturer intended, illuminating the vehicle?s MIL to alert the driver of lower oil pressure.In April of 2022, Kia North America issued a warranty extension that extended the coverage of the Oil Pressure Switch from 5 years/60,000 miles to 15 years/150,000 miles on MY 2014-2018 Sorento, MY 2014-2016 Cadenza, and MY 2015-2018 Sedona vehicles, all equipped with the 3.3L Lambda engine. The extended warranty coverage includes diagnosis, repair, and applies to customers experiencing engine oil leaking from the engine or if the engine oil pressure warning light stays illuminated after the engine is turned on.After a thorough review of the material submitted by the petitioner, information already in NHTSA's possession, testing performed by VRTC, technical information provided by Kia, the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that an engine failure due to the alleged defect is likely and does not warrant a formal investigation. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be publi
Illustration