NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
693 reportsClear category filterMileage unknown · Nov 26, 2021
EngineVehicle Speed Control
My children and I were on the freeway, and when I pushed the accelerator, nothing happened. No rpm increase, no engine change…nothing. I have had my car looked at and diagnosed, and nothing alerts to being wrong. The screen said Engine Control System, the engine light came on, and I had to pull all the way over across 4 lanes of…
Read full complaint
My children and I were on the freeway, and when I pushed the accelerator, nothing happened. No rpm increase, no engine change…nothing. I have had my car looked at and diagnosed, and nothing alerts to being wrong. The screen said Engine Control System, the engine light came on, and I had to pull all the way over across 4 lanes of traffic on the freeway, without being able to accelerate. I pulled over, put the car in park, and waited about 10 minutes. I turned the car back on and everything was fine. I do not understand. This is a safety hazard!
NHTSA ODI #11441769
Mileage unknown · Nov 26, 2021
Engine
My vehicle without any warning whatsoever, completely shut down while driving in interstate traffic. This was a very dangerous thing to happen while driving on a busy interstate. I was able to get to the side of the road but the vehicle would not start. I had my vehicle towed to my mechanics shop where he determined that the m…
Read full complaint
My vehicle without any warning whatsoever, completely shut down while driving in interstate traffic. This was a very dangerous thing to happen while driving on a busy interstate. I was able to get to the side of the road but the vehicle would not start. I had my vehicle towed to my mechanics shop where he determined that the motor had failed due to cylinder/piston damage. I was denied coverage by KIA so my only choice was to pay my mechanic to replace the motor with a remanufactured motor at a cost of $9000.
NHTSA ODI #11441704
Mileage unknown · Nov 17, 2021
Engine
I just bought my car in March of this year. It started overheating so I brought it to the mechanic where I was quoted $9,000 for a new motor. I still owe $17,000 on it. Was completely disrespected at the dealership by the service department. So now I’m stuck with a car that doesn’t drive and a huge loan I have to pay out. I was …
Read full complaint
I just bought my car in March of this year. It started overheating so I brought it to the mechanic where I was quoted $9,000 for a new motor. I still owe $17,000 on it. Was completely disrespected at the dealership by the service department. So now I’m stuck with a car that doesn’t drive and a huge loan I have to pay out. I was told that the oil level in my car was extremely low. I just recently had it changed and wasn’t due for over a month for another. No light sensor or anything went off.
NHTSA ODI #11440861
Mileage unknown · Nov 12, 2021
Engine
I was driving 85 MPH on the interstate and my engine lights started flashing (no engine light or oil light prior to this) and started slowing down. I got to the shoulder of the interstate and my car was making a terrible knocking noise. I have owned this car for 3 months. There is a little over 87K on my car. I had the car towed…
Read full complaint
I was driving 85 MPH on the interstate and my engine lights started flashing (no engine light or oil light prior to this) and started slowing down. I got to the shoulder of the interstate and my car was making a terrible knocking noise. I have owned this car for 3 months. There is a little over 87K on my car. I had the car towed to the nearest Kia dealership where I was told my engine was totaled. After paying 140.00 for a diagnostics report and being without a car for a whole month (keep in mind this is just for the report). I was quoted a total of 6,800 for them to fix my car. After further research I have found other people with the same issues with the engine. My engine is a 3.3L V6. In the previous lawsuit for Kia it only covers 2.4L engines where my engine is having the SAME issues. I should not have to pay for a new engine when this is a big issue with other consumers with the same car and engine type. Now im stuck paying on a car I CANT DRIVE until the 6800 is paid. I owe to much on my car for me to pay it off in full. This put me as well as everyone else on the interstate at risk and would have also put my children at risk if they were in the car. I am beyond irritated. As well as a given a whistleblower just coming out to state that these engines are not safe and kia and hyundai's neglect in keep their consumers safe. SOMETHING HAS TO BE DONE!
NHTSA ODI #11440262
Mileage unknown · Nov 10, 2021
EngineFuel/propulsion System
I just purchased my Kia Sorento in March of 2021. It doesn’t notify you when oil is LOW or OUT. Even with proper oil changes. Also the engine randomly started to overheat regardless that it’s barley got 107 miles on it. Of course there’s several recalls for this particular vehicle for the same issues but not for mine specificall…
Read full complaint
I just purchased my Kia Sorento in March of 2021. It doesn’t notify you when oil is LOW or OUT. Even with proper oil changes. Also the engine randomly started to overheat regardless that it’s barley got 107 miles on it. Of course there’s several recalls for this particular vehicle for the same issues but not for mine specifically. Insurance won’t cover wear and tear so now my cars in the shop for who knows how long with an extremely high bill expected.
NHTSA ODI #11439970
103,000 miles · Nov 9, 2021
Engine
The contact owns a 2016 Kia Sorento. The contact stated that the check engine warning light was illuminated. The vehicle was taken to an independent mechanic where the contact was notified about a knocking in the engine. The contact was informed that the engine needed to be replaced. The local dealer was not contacted. The vehic…
Read full complaint
The contact owns a 2016 Kia Sorento. The contact stated that the check engine warning light was illuminated. The vehicle was taken to an independent mechanic where the contact was notified about a knocking in the engine. The contact was informed that the engine needed to be replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 103,000.
NHTSA ODI #11439850
Mileage unknown · Nov 8, 2021
Electrical SystemEngine
Engine failed while driving. No warning lights. Have to purchase a new used engine. Fan blower resister: only blows at high or not at all. Has been fixed once and is now an issue again.
NHTSA ODI #11439804
Mileage unknown · Nov 7, 2021
Engine
Car failed while driving and now has a rod know and low oil
NHTSA ODI #11439608
128,459 miles · Nov 5, 2021
Engine
The contact owns a 2016 Kia Sorento. The contact stated that while driving at an undisclosed speed, the check engine warning light was illuminated. The vehicle was taken to the dealer and an independent mechanic on separate occasions. The dealer and an independent mechanic diagnosed the vehicle with engine failure. The vehicle w…
Read full complaint
The contact owns a 2016 Kia Sorento. The contact stated that while driving at an undisclosed speed, the check engine warning light was illuminated. The vehicle was taken to the dealer and an independent mechanic on separate occasions. The dealer and an independent mechanic diagnosed the vehicle with engine failure. The vehicle was repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 128,459.
NHTSA ODI #11439504
Mileage unknown · Oct 24, 2021
Engine
On Saturday 10/23/2021, I picked up my car at Kia Ron Bouchard Lancaster MA. They explained to me that warranty coverage is only extended if the problem was presented in PI1802. That wasn't my problem. I contacted another Dan O'Brien Kia dealership in Norwood MA, and found that one of the problems that might have caused my car …
Read full complaint
On Saturday 10/23/2021, I picked up my car at Kia Ron Bouchard Lancaster MA. They explained to me that warranty coverage is only extended if the problem was presented in PI1802. That wasn't my problem. I contacted another Dan O'Brien Kia dealership in Norwood MA, and found that one of the problems that might have caused my car to malfunction was a safe recall that was not made and therefore I lost my warranty. But I went to Kia several times and they always said they didn't have the parts to recall. In the document it says that my car would have the rod bearing warranty if it were failing. Asking another dealership he explained to me if when I presented the oil consumption problem on 07/23/2021 the part could already have problems. What are the symptoms of a bad rod bearing: Low Oil Pressure - Many times when a bearing is beginning to fail (or has failed), you will noticed signs of decreased oil pressure. This is usually more evident upon first starting the vehicle. In many cases, a bad rod bearing will lead to a "check engine oil" light being displayed on the dash. (Problems that were happening in my car when I was at Kia on 07/23/2021). Another explanation that the dealership gave me is that my car was showing excessive oil consumption and burning of oil and a problem that may have been caused by the defect of the part of the safe recall (E-CVVT COVER AND MOTOR PLUG REPLACEMENT) that was not made, which as a result occurred the Misfire and the cylinder lost compression. E-CVVT Cover defect could cause Late valve timing will keep the intake valve closed too long after the intake stroke has started, and will increase the vacuum in the cylinder. The high vacuum will have a tendency to suck oil up past the piston and rings into the upper part of the cylinder where it will be burned.
NHTSA ODI #11437931
Official recalls
8Sep 19, 2022
Kia America, Inc. (Kia) is recalling certain 2016-2022 Sorento, 2021-2022 Sorento Hybrid (HEV), 2022-2023 Sorento Plug-In Hybrid (PHEV), and 2017-2022 Sportage vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
Consequence & remedy
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will inspect the vehicle, and, as necessary, replace the fuse and/or tow hitch harness module, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC249.
Aug 10, 2022
Kia America, Inc. (Kia) is recalling certain 2016 Sedona and Sorento vehicles. The vehicles may have been manufactured with faulty automatic transmission shift lever assembly components, preventing the shift lever from locking, which can allow the vehicle to rollaway.
Consequence & remedy
Consequence: A vehicle rollaway increases the risk of a crash and injury.
Remedy: Dealers will inspect and replace the automatic transmission shift lever assembly components, as necessary, free of charge. Owner notification letters were mailed October 7, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC246.
Dec 19, 2018
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Additional source detail variants (2)
Engine
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Nov 30, 2016
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Additional source detail variants (2)
Trailer Hitches
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Electrical System
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Oct 24, 2016
Kia Motors America (Kia) is recalling certain model year 2016 Kia Sorento vehicles manufactured March 3, 2016 to March 21, 2016. The driver's seatback frame may have been produced with inadequate weld joints and, as a result, the seatback may not function as designed in the event of a rear-end collision.
Consequence & remedy
Consequence: In the event of a crash, the driver seatback frame could break and fail to restrain a seat occupant, increasing the risk of injury.
Remedy: Kia will notify owners, and dealers will inspect the welds and replace the driver seatback frame, as necessary, free of charge. The recall began on December 9, 2016. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC140.
Jun 29, 2016
Kia Motors America (Kia) is recalling certain model year 2016 Sorento vehicles. A component of the rear suspension may not be properly welded.
Consequence & remedy
Consequence: The improper weld may break, affecting the rear suspension alignment, thereby increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will inspect the welds at the rear suspension cross-member, replacing the rear cross-member assembly, as necessary, free of charge. The recall began July 27, 2016. Owners may contact Kia Customer Service Department at 1-800-333-4542. Kia's number for this recall is SC137.
Jul 14, 2015
Kia Motors America (Kia) is recalling certain model year 2016 Kia Sorento vehicles manufactured October 23, 2014, to December 10, 2014. The affected vehicles have a front passenger seat belt whose buckle latch assembly may prevent the front passenger from fastening the seat belt.
Consequence & remedy
Consequence: If the front passenger seat belt cannot be latched, an occupant sitting in the front passenger seat has an increased risk of injury in the event of a crash.
Remedy: Kia will notify owners, and dealers will replace the front passenger seat belt buckle cover, free of charge. The recall began on August 18, 2015. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC123.
Feb 13, 2015
Kia Motors America (Kia) is recalling certain model year 2016 Sorento vehicles manufactured October 27, 2014, to January 29, 2015. Due to an improperly soldered component in the accelerator pedal assembly, the driver may not be able to accelerate the vehicle.
Consequence & remedy
Consequence: If the vehicle is unable to be accelerated, there is an increased risk of a crash.
Remedy: Kia will notify owners, and dealers will replace the accelerator assembly, free of charge. The recall began on February 19, 2015. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC115.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE23019 · Loss Of Motive Power
Opened Nov 13, 2023 · Closed Jul 23, 2024
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:oil/lubrication:seals/gaskets
On November 13, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23-019) to investigate allegations of loss of motive power relating to head gasket and/or head bolt failure in Model Year (MY) 2016-2017 Kia Sorento vehicles equipped with the 3.3 L Lambda II engine. When the investigation was opened, ODI had received 13 Vehicle Owner Questionnaires (VOQs) related to reports of loss of motive power. In an information request letter dated November 30, 2023, ODI requested technical information and failure data relating to the alleged defect in the subject MY 2016-2017 Kia Sorento as well as several peer vehicle populations which share the 3.3 L engine. In its February 26, 2024, response to ODI’s information request, Kia provided 2022 customer complaints (including techline and field reports) and 1738 warranty claims representing 2411 unique vehicles within the subject vehicle population. Of the customer complaints provided by Kia, they identified only 53 unique allegations of a loss of motive power resulting from the alleged defect. Kia determined that the remaining reports were minor vehicle drivability or engine performance issues. ODI reviewed the information provided by Kia, along with additional VOQs submitted to NHTSA following the opening of the investigation. When eliminating duplicative reports across the data sources, the total number of allegations of loss of motive power relating to the alleged defect in the subject vehicles is 77, representing an incident report rate of 59 per 100,000 vehicles. The MY 2016 Kia Sorento exhibited both the highest overall complaint rate and loss of motive power report rate across all subject and peer vehicle populations, representing an incident report rate of 102 per 100,000 vehicles. Across all data sources, there are no allegations of crashes or fires relating to the alleged defect. The one injury incident reflected in the failure summary table above is related to a consumer who was reportedly burned (minor burn requiring medical attention) while attempting to remove the coolant reservoir cap following a loss of motive power event. In their response to ODI, Kia described that if the threads of a head bolt hole in the subject engine becomes damaged, the clamping force between the cylinder head and engine block can decrease in the area of the affected head bolt. Kia’s assessment of the alleged defect is that when the failure occurs, drivers are provided with numerous warning signs prior to a potential loss of motive power event. According to Kia, potential warning signs associated with this failure include coolant leak/consumption or noticeable coolant odor, engine oil leak/consumption, engine temperature gauge rising to “H” (hot), check engine light illuminating, engine cooling fan remaining on following the engine being shut off, HVAC system not functioning properly, unusual engine noise, difficulty starting the vehicle, and smoke/condensation emitting from the engine compartment or exhaust. Through both its review of the information provided by Kia and outreach to consumers, ODI confirmed that there is reasonable detectability present in the vast majority of occurrences of the alleged defect. To mitigate the alleged defect, Kia increased the engagement depth of the head bolt threads for all subject engines, beginning in May 2017. ODI’s analysis of the failure data demonstrates that this corrective action correlates with a much lower incident report rate for engines produced following the change (8 per 100,000 vehicles for the MY 2018-2020 Kia Sorento). In December 2023, Kia launched extended warranty campaign WTY035 covering failures associated with the alleged defect in the subject vehicle population through 15 years or 180,000 miles, whichever comes first. Through its investigation, ODI identified the following peer vehicle populations, which were produced prior to the corrective action and exhibit failure rates comparable to the subject vehicles: MY 2014-2015 Kia Sorento, MY 2015-2016 Kia Sedona, and MY 2014-2017 Kia Cadenza equipped with the 3.3 L engine. Through discussions with ODI during the investigation, Kia decided to launch extended warranty campaign WTY039 in May 2024, which covers these peer vehicle populations through 15 years or 180,000 miles, whichever comes first. Based on analysis of the failure data indicating a low incident report rate of loss of motive power for the alleged defect, and in consideration of the warning signs which frequently occur from head gasket and/or head bolt failure in the subject engines, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:oil/lubrication:seals/gaskets
On November 13, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23-019) to investigate allegations of loss of motive power relating to head gasket and/or head bolt failure in Model Year (MY) 2016-2017 Kia Sorento vehicles equipped with the 3.3 L Lambda II engine. When the investigation was opened, ODI had received 13 Vehicle Owner Questionnaires (VOQs) related to reports of loss of motive power. In an information request letter dated November 30, 2023, ODI requested technical information and failure data relating to the alleged defect in the subject MY 2016-2017 Kia Sorento as well as several peer vehicle populations which share the 3.3 L engine. In its February 26, 2024, response to ODI’s information request, Kia provided 2022 customer complaints (including techline and field reports) and 1738 warranty claims representing 2411 unique vehicles within the subject vehicle population. Of the customer complaints provided by Kia, they identified only 53 unique allegations of a loss of motive power resulting from the alleged defect. Kia determined that the remaining reports were minor vehicle drivability or engine performance issues. ODI reviewed the information provided by Kia, along with additional VOQs submitted to NHTSA following the opening of the investigation. When eliminating duplicative reports across the data sources, the total number of allegations of loss of motive power relating to the alleged defect in the subject vehicles is 77, representing an incident report rate of 59 per 100,000 vehicles. The MY 2016 Kia Sorento exhibited both the highest overall complaint rate and loss of motive power report rate across all subject and peer vehicle populations, representing an incident report rate of 102 per 100,000 vehicles. Across all data sources, there are no allegations of crashes or fires relating to the alleged defect. The one injury incident reflected in the failure summary table above is related to a consumer who was reportedly burned (minor burn requiring medical attention) while attempting to remove the coolant reservoir cap following a loss of motive power event. In their response to ODI, Kia described that if the threads of a head bolt hole in the subject engine becomes damaged, the clamping force between the cylinder head and engine block can decrease in the area of the affected head bolt. Kia’s assessment of the alleged defect is that when the failure occurs, drivers are provided with numerous warning signs prior to a potential loss of motive power event. According to Kia, potential warning signs associated with this failure include coolant leak/consumption or noticeable coolant odor, engine oil leak/consumption, engine temperature gauge rising to “H” (hot), check engine light illuminating, engine cooling fan remaining on following the engine being shut off, HVAC system not functioning properly, unusual engine noise, difficulty starting the vehicle, and smoke/condensation emitting from the engine compartment or exhaust. Through both its review of the information provided by Kia and outreach to consumers, ODI confirmed that there is reasonable detectability present in the vast majority of occurrences of the alleged defect. To mitigate the alleged defect, Kia increased the engagement depth of the head bolt threads for all subject engines, beginning in May 2017. ODI’s analysis of the failure data demonstrates that this corrective action correlates with a much lower incident report rate for engines produced following the change (8 per 100,000 vehicles for the MY 2018-2020 Kia Sorento). In December 2023, Kia launched extended warranty campaign WTY035 covering failures associated with the alleged defect in the subject vehicle population through 15 years or 180,000 miles, whichever comes first. Through its investigation, ODI identified the following peer vehicle populations, which were produced prior to the corrective action and exhibit failure rates comparable to the subject vehicles: MY 2014-2015 Kia Sorento, MY 2015-2016 Kia Sedona, and MY 2014-2017 Kia Cadenza equipped with the 3.3 L engine. Through discussions with ODI during the investigation, Kia decided to launch extended warranty campaign WTY039 in May 2024, which covers these peer vehicle populations through 15 years or 180,000 miles, whichever comes first. Based on analysis of the failure data indicating a low incident report rate of loss of motive power for the alleged defect, and in consideration of the warning signs which frequently occur from head gasket and/or head bolt failure in the subject engines, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On November 13, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23-019) to investigate allegations of loss of motive power relating to head gasket and/or head bolt failure in Model Year (MY) 2016-2017 Kia Sorento vehicles equipped with the 3.3 L Lambda II engine. When the investigation was opened, ODI had received 13 Vehicle Owner Questionnaires (VOQs) related to reports of loss of motive power. In an information request letter dated November 30, 2023, ODI requested technical information and failure data relating to the alleged defect in the subject MY 2016-2017 Kia Sorento as well as several peer vehicle populations which share the 3.3 L engine. In its February 26, 2024, response to ODI’s information request, Kia provided 2022 customer complaints (including techline and field reports) and 1738 warranty claims representing 2411 unique vehicles within the subject vehicle population. Of the customer complaints provided by Kia, they identified only 53 unique allegations of a loss of motive power resulting from the alleged defect. Kia determined that the remaining reports were minor vehicle drivability or engine performance issues. ODI reviewed the information provided by Kia, along with additional VOQs submitted to NHTSA following the opening of the investigation. When eliminating duplicative reports across the data sources, the total number of allegations of loss of motive power relating to the alleged defect in the subject vehicles is 77, representing an incident report rate of 59 per 100,000 vehicles. The MY 2016 Kia Sorento exhibited both the highest overall complaint rate and loss of motive power report rate across all subject and peer vehicle populations, representing an incident report rate of 102 per 100,000 vehicles. Across all data sources, there are no allegations of crashes or fires relating to the alleged defect. The one injury incident reflected in the failure summary table above is related to a consumer who was reportedly burned (minor burn requiring medical attention) while attempting to remove the coolant reservoir cap following a loss of motive power event. In their response to ODI, Kia described that if the threads of a head bolt hole in the subject engine becomes damaged, the clamping force between the cylinder head and engine block can decrease in the area of the affected head bolt. Kia’s assessment of the alleged defect is that when the failure occurs, drivers are provided with numerous warning signs prior to a potential loss of motive power event. According to Kia, potential warning signs associated with this failure include coolant leak/consumption or noticeable coolant odor, engine oil leak/consumption, engine temperature gauge rising to “H” (hot), check engine light illuminating, engine cooling fan remaining on following the engine being shut off, HVAC system not functioning properly, unusual engine noise, difficulty starting the vehicle, and smoke/condensation emitting from the engine compartment or exhaust. Through both its review of the information provided by Kia and outreach to consumers, ODI confirmed that there is reasonable detectability present in the vast majority of occurrences of the alleged defect. To mitigate the alleged defect, Kia increased the engagement depth of the head bolt threads for all subject engines, beginning in May 2017. ODI’s analysis of the failure data demonstrates that this corrective action correlates with a much lower incident report rate for engines produced following the change (8 per 100,000 vehicles for the MY 2018-2020 Kia Sorento). In December 2023, Kia launched extended warranty campaign WTY035 covering failures associated with the alleged defect in the subject vehicle population through 15 years or 180,000 miles, whichever comes first. Through its investigation, ODI identified the following peer vehicle populations, which were produced prior to the corrective action and exhibit failure rates comparable to the subject vehicles: MY 2014-2015 Kia Sorento, MY 2015-2016 Kia Sedona, and MY 2014-2017 Kia Cadenza equipped with the 3.3 L engine. Through discussions with ODI during the investigation, Kia decided to launch extended warranty campaign WTY039 in May 2024, which covers these peer vehicle populations through 15 years or 180,000 miles, whichever comes first. Based on analysis of the failure data indicating a low incident report rate of loss of motive power for the alleged defect, and in consideration of the warning signs which frequently occur from head gasket and/or head bolt failure in the subject engines, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP21002 · Engine Oil Pressure Switch Leak
Opened Nov 12, 2021 · Closed Jun 26, 2023
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:oil/lubrication:pressure/temperature Sensor
In a letter dated September 30, 2021, Mr. Gerald James (the petitioner) requested that NHTSA conduct an investigation of the Model Year (MY) 2015-2017 Kia Sorento equipped with 3.3L V6 ?Lambda? engines for ?severe oil leaks? from the oil pressure switch (OPS) that could ?lead to engine failure? with little warning to the driver. Mr. James based this request on his own experience and data found in NHTSA?s Vehicle Owner Questionnaire (VOQ) database. NHTSA reviewed the material cited by the petitioner, information submitted by Kia, NHTSA?s testing, and other pertinent information in NHTSA databases.On November 12, 2021, ODI opened Defect Petition DP21-002 to evaluate the petitioner?s request. ODI performed an analysis that included evaluation of the petitioner?s vehicle, searches of ODI complaints from vehicle owners, non-dealer field reports, manufacturers? supplemental information relating to design of the component, and component testing performed by ODI.On December 16, 2021, ODI and Kia North America performed a joint inspection on the petitioner?s vehicle. ODI and Kia agreed the OPS was leaking oil and observed oil in the crevices atop the engine block. The vehicle received a new replacement OPS and was delivered back to the petitioner. The original part that was removed from the subject vehicle was retained by ODI for further analysis.As of December 30, 2022, for the MY 2015-2017 Kia Sorento population of 161,519 vehicles with 3.3L engine, NHTSA reviewed internal data and has identified no consumer complaints or field reports in its database, with unique Vehicle Identification Numbers (VIN), citing engine failure or stalling related to the petition?s allegation of defective OPS. When combined with the supplemental warranty and technical analysis from the manufacturer, field report and customer complaint data in response to the Information Request letter sent, NHTSA identified no unique VINs alleging engine failure or stalls caused by OPS leaking on the subject vehicles named in the petition.On April 4, 2022, the Vehicle Research and Test Center (VRTC) performed testing of the petitioner?s component (OPS) based on testing protocol consistent with Kia?s specifications for the subject vehicle. The testing involved the petitioner?s original OPS in a controlled system to replicate the subject vehicle?s oil pressure, flow, and temperature. VRTC determined that a vehicle would have to miss more than a dozen oil change intervals to reach low engine oil capacity. Testing also revealed the OPS would operate, as manufacturer intended, illuminating the vehicle?s MIL to alert the driver of lower oil pressure.In April of 2022, Kia North America issued a warranty extension that extended the coverage of the Oil Pressure Switch from 5 years/60,000 miles to 15 years/150,000 miles on MY 2014-2018 Sorento, MY 2014-2016 Cadenza, and MY 2015-2018 Sedona vehicles, all equipped with the 3.3L Lambda engine. The extended warranty coverage includes diagnosis, repair, and applies to customers experiencing engine oil leaking from the engine or if the engine oil pressure warning light stays illuminated after the engine is turned on.After a thorough review of the material submitted by the petitioner, information already in NHTSA's possession, testing performed by VRTC, technical information provided by Kia, the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that an engine failure due to the alleged defect is likely and does not warrant a formal investigation. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be publi
Additional source detail variants (2)
Engine And Engine Cooling:engine:oil/lubrication:pressure/temperature Sensor
In a letter dated September 30, 2021, Mr. Gerald James (the petitioner) requested that NHTSA conduct an investigation of the Model Year (MY) 2015-2017 Kia Sorento equipped with 3.3L V6 ?Lambda? engines for ?severe oil leaks? from the oil pressure switch (OPS) that could ?lead to engine failure? with little warning to the driver. Mr. James based this request on his own experience and data found in NHTSA?s Vehicle Owner Questionnaire (VOQ) database. NHTSA reviewed the material cited by the petitioner, information submitted by Kia, NHTSA?s testing, and other pertinent information in NHTSA databases.On November 12, 2021, ODI opened Defect Petition DP21-002 to evaluate the petitioner?s request. ODI performed an analysis that included evaluation of the petitioner?s vehicle, searches of ODI complaints from vehicle owners, non-dealer field reports, manufacturers? supplemental information relating to design of the component, and component testing performed by ODI.On December 16, 2021, ODI and Kia North America performed a joint inspection on the petitioner?s vehicle. ODI and Kia agreed the OPS was leaking oil and observed oil in the crevices atop the engine block. The vehicle received a new replacement OPS and was delivered back to the petitioner. The original part that was removed from the subject vehicle was retained by ODI for further analysis.As of December 30, 2022, for the MY 2015-2017 Kia Sorento population of 161,519 vehicles with 3.3L engine, NHTSA reviewed internal data and has identified no consumer complaints or field reports in its database, with unique Vehicle Identification Numbers (VIN), citing engine failure or stalling related to the petition?s allegation of defective OPS. When combined with the supplemental warranty and technical analysis from the manufacturer, field report and customer complaint data in response to the Information Request letter sent, NHTSA identified no unique VINs alleging engine failure or stalls caused by OPS leaking on the subject vehicles named in the petition.On April 4, 2022, the Vehicle Research and Test Center (VRTC) performed testing of the petitioner?s component (OPS) based on testing protocol consistent with Kia?s specifications for the subject vehicle. The testing involved the petitioner?s original OPS in a controlled system to replicate the subject vehicle?s oil pressure, flow, and temperature. VRTC determined that a vehicle would have to miss more than a dozen oil change intervals to reach low engine oil capacity. Testing also revealed the OPS would operate, as manufacturer intended, illuminating the vehicle?s MIL to alert the driver of lower oil pressure.In April of 2022, Kia North America issued a warranty extension that extended the coverage of the Oil Pressure Switch from 5 years/60,000 miles to 15 years/150,000 miles on MY 2014-2018 Sorento, MY 2014-2016 Cadenza, and MY 2015-2018 Sedona vehicles, all equipped with the 3.3L Lambda engine. The extended warranty coverage includes diagnosis, repair, and applies to customers experiencing engine oil leaking from the engine or if the engine oil pressure warning light stays illuminated after the engine is turned on.After a thorough review of the material submitted by the petitioner, information already in NHTSA's possession, testing performed by VRTC, technical information provided by Kia, the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that an engine failure due to the alleged defect is likely and does not warrant a formal investigation. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be publi
Engine
In a letter dated September 30, 2021, Mr. Gerald James (the petitioner) requested that NHTSA conduct an investigation of the Model Year (MY) 2015-2017 Kia Sorento equipped with 3.3L V6 ?Lambda? engines for ?severe oil leaks? from the oil pressure switch (OPS) that could ?lead to engine failure? with little warning to the driver. Mr. James based this request on his own experience and data found in NHTSA?s Vehicle Owner Questionnaire (VOQ) database. NHTSA reviewed the material cited by the petitioner, information submitted by Kia, NHTSA?s testing, and other pertinent information in NHTSA databases.On November 12, 2021, ODI opened Defect Petition DP21-002 to evaluate the petitioner?s request. ODI performed an analysis that included evaluation of the petitioner?s vehicle, searches of ODI complaints from vehicle owners, non-dealer field reports, manufacturers? supplemental information relating to design of the component, and component testing performed by ODI.On December 16, 2021, ODI and Kia North America performed a joint inspection on the petitioner?s vehicle. ODI and Kia agreed the OPS was leaking oil and observed oil in the crevices atop the engine block. The vehicle received a new replacement OPS and was delivered back to the petitioner. The original part that was removed from the subject vehicle was retained by ODI for further analysis.As of December 30, 2022, for the MY 2015-2017 Kia Sorento population of 161,519 vehicles with 3.3L engine, NHTSA reviewed internal data and has identified no consumer complaints or field reports in its database, with unique Vehicle Identification Numbers (VIN), citing engine failure or stalling related to the petition?s allegation of defective OPS. When combined with the supplemental warranty and technical analysis from the manufacturer, field report and customer complaint data in response to the Information Request letter sent, NHTSA identified no unique VINs alleging engine failure or stalls caused by OPS leaking on the subject vehicles named in the petition.On April 4, 2022, the Vehicle Research and Test Center (VRTC) performed testing of the petitioner?s component (OPS) based on testing protocol consistent with Kia?s specifications for the subject vehicle. The testing involved the petitioner?s original OPS in a controlled system to replicate the subject vehicle?s oil pressure, flow, and temperature. VRTC determined that a vehicle would have to miss more than a dozen oil change intervals to reach low engine oil capacity. Testing also revealed the OPS would operate, as manufacturer intended, illuminating the vehicle?s MIL to alert the driver of lower oil pressure.In April of 2022, Kia North America issued a warranty extension that extended the coverage of the Oil Pressure Switch from 5 years/60,000 miles to 15 years/150,000 miles on MY 2014-2018 Sorento, MY 2014-2016 Cadenza, and MY 2015-2018 Sedona vehicles, all equipped with the 3.3L Lambda engine. The extended warranty coverage includes diagnosis, repair, and applies to customers experiencing engine oil leaking from the engine or if the engine oil pressure warning light stays illuminated after the engine is turned on.After a thorough review of the material submitted by the petitioner, information already in NHTSA's possession, testing performed by VRTC, technical information provided by Kia, the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that an engine failure due to the alleged defect is likely and does not warrant a formal investigation. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be publi
Illustration