NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
15 reportsClear category filter155,000 miles · Jun 18, 2024
Service Brakes, HydraulicFire
The contact owns a 2015 Kia Sorento. The contact stated that his vehicle had burst in flames while parked in his drive way. The contact called the fire department, however he was able to extinguish the flames using hand held extinguishers. The contact stated that the damage was contained to the front end of the vehicle, the engi…
Read full complaint
The contact owns a 2015 Kia Sorento. The contact stated that his vehicle had burst in flames while parked in his drive way. The contact called the fire department, however he was able to extinguish the flames using hand held extinguishers. The contact stated that the damage was contained to the front end of the vehicle, the engine compartment, the fire wall and the passenger front side. The fire department issued a report. The contact had not taken the vehicle to a local dealer. The vehicle was not diagnosed and was not repaired. The contact stated that the vehicle was towed to an impound lot. The manufacturer was not informed of the failure. The contact had searched online and related the fire to NHTSA Campaign Number: 21V331000 (Service Brakes, Hydraulic) which was associated to his VIN. The failure mileage was approximately 155,000.
NHTSA ODI #11595002
68,000 miles · Mar 27, 2024
Power TrainService Brakes, Hydraulic
The contact owns a 2015 Kia Sorento. The contact stated that while driving at an undisclosed speed, there was an abnormal knocking sound emanating from the engine compartment. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. After inve…
Read full complaint
The contact owns a 2015 Kia Sorento. The contact stated that while driving at an undisclosed speed, there was an abnormal knocking sound emanating from the engine compartment. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. After investigating the failure, the contact related the failure to the remedy for NHTSA Campaign Number: 21V331000 (Service Brakes, Hydraulic); the VIN was included, and the vehicle was repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 68,000.
NHTSA ODI #11579810
127,000 miles · Jul 6, 2023
Service Brakes, HydraulicVisibility
The contact owns a 2015 Kia Sorento. The contact stated while driving 30 MPH, the brakes and the steering wheel seized inadvertently, and the vehicle stalled. The contact was able to veer to the side of the road. The contact stated that she attempted to roll up the windows, but the vehicle failed to respond. The vehicle failed t…
Read full complaint
The contact owns a 2015 Kia Sorento. The contact stated while driving 30 MPH, the brakes and the steering wheel seized inadvertently, and the vehicle stalled. The contact was able to veer to the side of the road. The contact stated that she attempted to roll up the windows, but the vehicle failed to respond. The vehicle failed to restart after several attempts. The check engine warning light, ABS warning light, and other unknown warning lights were illuminated. The vehicle was towed to the residence, and then to a Triple A certified mechanic, where the battery and the alternator were replaced; however, the failure recurred. The dealer was notified of the failure and informed the contact that the failure was related to the electrical system; however, the vehicle was not diagnosed. Additionally, the contact stated that the sunroof failed to open or close unless the sunroof switch was depressed several times. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 21V331000 (Service Brakes, Hydraulic). The manufacturer was not notified of the failure. The failure mileage was approximately 127,000.
NHTSA ODI #11530648
93,000 miles · May 16, 2023
Service Brakes, Hydraulic
The contact owns a 2015 Kia Sorento. The contact stated while driving at an undisclosed speed, the vehicle lost motive power and stalled. The vehicle failed to restart after several attempts. The contact stated that several unknown warning lights were illuminated. The VIN was included in NHTSA Campaign Number: 21V331000 (Service…
Read full complaint
The contact owns a 2015 Kia Sorento. The contact stated while driving at an undisclosed speed, the vehicle lost motive power and stalled. The vehicle failed to restart after several attempts. The contact stated that several unknown warning lights were illuminated. The VIN was included in NHTSA Campaign Number: 21V331000 (Service Brakes, Hydraulic). The vehicle was towed to a local dealer, where it remained awaiting diagnostic test and repair. The manufacturer was made aware of the failure. The approximate failure mileage was 93,000.
NHTSA ODI #11522284
Mileage unknown · Jan 27, 2023
Service Brakes, Hydraulic
The contact owns a 2015 Kia Sorento. The contact received notification of NHTSA Campaign Number: 21V331000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware…
Read full complaint
The contact owns a 2015 Kia Sorento. The contact received notification of NHTSA Campaign Number: 21V331000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA ODI #11504065
125,000 miles · Sep 20, 2022
EngineService Brakes, Hydraulic
The contact owns a 2015 Kia Sorento. The contact stated that while driving at various speeds, the vehicle overheated with the temperature gauge indicating that the engine was hot. The contact also stated that smoke was coming from the vehicle. The vehicle was taken to a dealer and was diagnosed with engine failure; the vehicle w…
Read full complaint
The contact owns a 2015 Kia Sorento. The contact stated that while driving at various speeds, the vehicle overheated with the temperature gauge indicating that the engine was hot. The contact also stated that smoke was coming from the vehicle. The vehicle was taken to a dealer and was diagnosed with engine failure; the vehicle was no longer operable. The contact then received notification of NHTSA Campaign Number: 21V331000 (Service Brakes, Hydraulic) which she linked to the failure. The dealer and the manufacturer were notified of the issue and the contact was informed that the recall was not related to the engine failure. The vehicle was not repaired. The vehicle was towed back to the residence. The failure mileage was approximately 125,000.
NHTSA ODI #11485398
70,000 miles · May 27, 2022
EngineService Brakes, Hydraulic
The contact owns a 2015 Kia Sorento. The contact stated while driving 65 MPH, the vehicle overheated and the wheels were shaking. The vehicle also experienced brake failure. The check engine warning light was illuminated. The vehicle was taken to the local dealer and diagnosed with engine failure. The engine was replaced. The ma…
Read full complaint
The contact owns a 2015 Kia Sorento. The contact stated while driving 65 MPH, the vehicle overheated and the wheels were shaking. The vehicle also experienced brake failure. The check engine warning light was illuminated. The vehicle was taken to the local dealer and diagnosed with engine failure. The engine was replaced. The manufacturer was notified of the failure. The contact related the failure to NHTSA Campaign Number: 21V331000 (Service Brakes, Hydraulics). The approximate failure mileage was 70,000.
NHTSA ODI #11466442
Mileage unknown · May 27, 2022
Service Brakes, Hydraulic
The abs brake system malfunctioning. The vehicle component was inspected by the manufacture. Because light came on. They first said it was the brakes; so, we had the brakes repaired in February. In April the ABS light came back on again. This time the emergency brake light came on too. The KIA manufacturer said since our car …
Read full complaint
The abs brake system malfunctioning. The vehicle component was inspected by the manufacture. Because light came on. They first said it was the brakes; so, we had the brakes repaired in February. In April the ABS light came back on again. This time the emergency brake light came on too. The KIA manufacturer said since our car was not listed with the other ABS recall, repairs of the system is on us. The cost for repair is $1,000 plus to fix the ABS system and EBS light issue. Although we explained about this being a known safety issue, the manufacturer refused to address and stated repair cost was on us.
NHTSA ODI #11466333
99,702 miles · Mar 9, 2022
EngineService Brakes, Hydraulic
The contact owns a 2015 Kia Sorento. The contact received notification of NHTSA Campaign Number: 21V331000 (Service Brakes, Hydraulic). The contact stated that while driving at an undisclosed speed, the ABS and oil warning lights illuminated. The vehicle then lost motive power. Upon inspection, the contact noticed there was no o…
Read full complaint
The contact owns a 2015 Kia Sorento. The contact received notification of NHTSA Campaign Number: 21V331000 (Service Brakes, Hydraulic). The contact stated that while driving at an undisclosed speed, the ABS and oil warning lights illuminated. The vehicle then lost motive power. Upon inspection, the contact noticed there was no oil in the oil reservoir. The vehicle was taken to an independent mechanic and diagnosed with camshaft position sensor failure. The mechanic replaced camshaft position sensor; however, the failure recurred with a rattling sound coming from the vehicle. The vehicle was then towed to the dealer and diagnosed with engine damage and connecting rod failure. The dealer performed a Product Improvement Campaign: PI1802 (Knock Sensor Detection System - ECU Logic Improvement) software update. The contact was informed that the engine needed to be replaced. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure and directed the contact to take the vehicle to a dealer. The manufacturer declined the engine replacement since the contact did not have the product improvement campaign software update prior to the failure. The failure mileage was 99,702.
NHTSA ODI #11455933
Mileage unknown · Aug 30, 2021
Service Brakes, Hydraulic
The contact owns a 2015 Kia Sorento. The contact received notification of NHTSA campaign number 21V331000 (Service Brakes, Hydraulic) however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not available. The contact stated that the manufacturer had exceed…
Read full complaint
The contact owns a 2015 Kia Sorento. The contact received notification of NHTSA campaign number 21V331000 (Service Brakes, Hydraulic) however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA ODI #11431100
NHTSA investigations
4AQ23002 · Hyundai And Kia Abs Module Fires
Opened Nov 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP21002 · Engine Oil Pressure Switch Leak
Opened Nov 12, 2021 · Closed Jun 26, 2023
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:oil/lubrication:pressure/temperature Sensor
In a letter dated September 30, 2021, Mr. Gerald James (the petitioner) requested that NHTSA conduct an investigation of the Model Year (MY) 2015-2017 Kia Sorento equipped with 3.3L V6 ?Lambda? engines for ?severe oil leaks? from the oil pressure switch (OPS) that could ?lead to engine failure? with little warning to the driver. Mr. James based this request on his own experience and data found in NHTSA?s Vehicle Owner Questionnaire (VOQ) database. NHTSA reviewed the material cited by the petitioner, information submitted by Kia, NHTSA?s testing, and other pertinent information in NHTSA databases.On November 12, 2021, ODI opened Defect Petition DP21-002 to evaluate the petitioner?s request. ODI performed an analysis that included evaluation of the petitioner?s vehicle, searches of ODI complaints from vehicle owners, non-dealer field reports, manufacturers? supplemental information relating to design of the component, and component testing performed by ODI.On December 16, 2021, ODI and Kia North America performed a joint inspection on the petitioner?s vehicle. ODI and Kia agreed the OPS was leaking oil and observed oil in the crevices atop the engine block. The vehicle received a new replacement OPS and was delivered back to the petitioner. The original part that was removed from the subject vehicle was retained by ODI for further analysis.As of December 30, 2022, for the MY 2015-2017 Kia Sorento population of 161,519 vehicles with 3.3L engine, NHTSA reviewed internal data and has identified no consumer complaints or field reports in its database, with unique Vehicle Identification Numbers (VIN), citing engine failure or stalling related to the petition?s allegation of defective OPS. When combined with the supplemental warranty and technical analysis from the manufacturer, field report and customer complaint data in response to the Information Request letter sent, NHTSA identified no unique VINs alleging engine failure or stalls caused by OPS leaking on the subject vehicles named in the petition.On April 4, 2022, the Vehicle Research and Test Center (VRTC) performed testing of the petitioner?s component (OPS) based on testing protocol consistent with Kia?s specifications for the subject vehicle. The testing involved the petitioner?s original OPS in a controlled system to replicate the subject vehicle?s oil pressure, flow, and temperature. VRTC determined that a vehicle would have to miss more than a dozen oil change intervals to reach low engine oil capacity. Testing also revealed the OPS would operate, as manufacturer intended, illuminating the vehicle?s MIL to alert the driver of lower oil pressure.In April of 2022, Kia North America issued a warranty extension that extended the coverage of the Oil Pressure Switch from 5 years/60,000 miles to 15 years/150,000 miles on MY 2014-2018 Sorento, MY 2014-2016 Cadenza, and MY 2015-2018 Sedona vehicles, all equipped with the 3.3L Lambda engine. The extended warranty coverage includes diagnosis, repair, and applies to customers experiencing engine oil leaking from the engine or if the engine oil pressure warning light stays illuminated after the engine is turned on.After a thorough review of the material submitted by the petitioner, information already in NHTSA's possession, testing performed by VRTC, technical information provided by Kia, the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that an engine failure due to the alleged defect is likely and does not warrant a formal investigation. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be publi
Additional source detail variants (2)
Engine And Engine Cooling:engine:oil/lubrication:pressure/temperature Sensor
In a letter dated September 30, 2021, Mr. Gerald James (the petitioner) requested that NHTSA conduct an investigation of the Model Year (MY) 2015-2017 Kia Sorento equipped with 3.3L V6 ?Lambda? engines for ?severe oil leaks? from the oil pressure switch (OPS) that could ?lead to engine failure? with little warning to the driver. Mr. James based this request on his own experience and data found in NHTSA?s Vehicle Owner Questionnaire (VOQ) database. NHTSA reviewed the material cited by the petitioner, information submitted by Kia, NHTSA?s testing, and other pertinent information in NHTSA databases.On November 12, 2021, ODI opened Defect Petition DP21-002 to evaluate the petitioner?s request. ODI performed an analysis that included evaluation of the petitioner?s vehicle, searches of ODI complaints from vehicle owners, non-dealer field reports, manufacturers? supplemental information relating to design of the component, and component testing performed by ODI.On December 16, 2021, ODI and Kia North America performed a joint inspection on the petitioner?s vehicle. ODI and Kia agreed the OPS was leaking oil and observed oil in the crevices atop the engine block. The vehicle received a new replacement OPS and was delivered back to the petitioner. The original part that was removed from the subject vehicle was retained by ODI for further analysis.As of December 30, 2022, for the MY 2015-2017 Kia Sorento population of 161,519 vehicles with 3.3L engine, NHTSA reviewed internal data and has identified no consumer complaints or field reports in its database, with unique Vehicle Identification Numbers (VIN), citing engine failure or stalling related to the petition?s allegation of defective OPS. When combined with the supplemental warranty and technical analysis from the manufacturer, field report and customer complaint data in response to the Information Request letter sent, NHTSA identified no unique VINs alleging engine failure or stalls caused by OPS leaking on the subject vehicles named in the petition.On April 4, 2022, the Vehicle Research and Test Center (VRTC) performed testing of the petitioner?s component (OPS) based on testing protocol consistent with Kia?s specifications for the subject vehicle. The testing involved the petitioner?s original OPS in a controlled system to replicate the subject vehicle?s oil pressure, flow, and temperature. VRTC determined that a vehicle would have to miss more than a dozen oil change intervals to reach low engine oil capacity. Testing also revealed the OPS would operate, as manufacturer intended, illuminating the vehicle?s MIL to alert the driver of lower oil pressure.In April of 2022, Kia North America issued a warranty extension that extended the coverage of the Oil Pressure Switch from 5 years/60,000 miles to 15 years/150,000 miles on MY 2014-2018 Sorento, MY 2014-2016 Cadenza, and MY 2015-2018 Sedona vehicles, all equipped with the 3.3L Lambda engine. The extended warranty coverage includes diagnosis, repair, and applies to customers experiencing engine oil leaking from the engine or if the engine oil pressure warning light stays illuminated after the engine is turned on.After a thorough review of the material submitted by the petitioner, information already in NHTSA's possession, testing performed by VRTC, technical information provided by Kia, the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that an engine failure due to the alleged defect is likely and does not warrant a formal investigation. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be publi
Engine
In a letter dated September 30, 2021, Mr. Gerald James (the petitioner) requested that NHTSA conduct an investigation of the Model Year (MY) 2015-2017 Kia Sorento equipped with 3.3L V6 ?Lambda? engines for ?severe oil leaks? from the oil pressure switch (OPS) that could ?lead to engine failure? with little warning to the driver. Mr. James based this request on his own experience and data found in NHTSA?s Vehicle Owner Questionnaire (VOQ) database. NHTSA reviewed the material cited by the petitioner, information submitted by Kia, NHTSA?s testing, and other pertinent information in NHTSA databases.On November 12, 2021, ODI opened Defect Petition DP21-002 to evaluate the petitioner?s request. ODI performed an analysis that included evaluation of the petitioner?s vehicle, searches of ODI complaints from vehicle owners, non-dealer field reports, manufacturers? supplemental information relating to design of the component, and component testing performed by ODI.On December 16, 2021, ODI and Kia North America performed a joint inspection on the petitioner?s vehicle. ODI and Kia agreed the OPS was leaking oil and observed oil in the crevices atop the engine block. The vehicle received a new replacement OPS and was delivered back to the petitioner. The original part that was removed from the subject vehicle was retained by ODI for further analysis.As of December 30, 2022, for the MY 2015-2017 Kia Sorento population of 161,519 vehicles with 3.3L engine, NHTSA reviewed internal data and has identified no consumer complaints or field reports in its database, with unique Vehicle Identification Numbers (VIN), citing engine failure or stalling related to the petition?s allegation of defective OPS. When combined with the supplemental warranty and technical analysis from the manufacturer, field report and customer complaint data in response to the Information Request letter sent, NHTSA identified no unique VINs alleging engine failure or stalls caused by OPS leaking on the subject vehicles named in the petition.On April 4, 2022, the Vehicle Research and Test Center (VRTC) performed testing of the petitioner?s component (OPS) based on testing protocol consistent with Kia?s specifications for the subject vehicle. The testing involved the petitioner?s original OPS in a controlled system to replicate the subject vehicle?s oil pressure, flow, and temperature. VRTC determined that a vehicle would have to miss more than a dozen oil change intervals to reach low engine oil capacity. Testing also revealed the OPS would operate, as manufacturer intended, illuminating the vehicle?s MIL to alert the driver of lower oil pressure.In April of 2022, Kia North America issued a warranty extension that extended the coverage of the Oil Pressure Switch from 5 years/60,000 miles to 15 years/150,000 miles on MY 2014-2018 Sorento, MY 2014-2016 Cadenza, and MY 2015-2018 Sedona vehicles, all equipped with the 3.3L Lambda engine. The extended warranty coverage includes diagnosis, repair, and applies to customers experiencing engine oil leaking from the engine or if the engine oil pressure warning light stays illuminated after the engine is turned on.After a thorough review of the material submitted by the petitioner, information already in NHTSA's possession, testing performed by VRTC, technical information provided by Kia, the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that an engine failure due to the alleged defect is likely and does not warrant a formal investigation. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be publi
DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
Illustration