← New search

2015 Kia Sorento

Owner reports · Recalls · Investigations

More warning signs than most Sorento years

Owner complaints for the 2015 Kia Sorento are substantially higher than the model-year median of 242.

About this comparison →

When problems were reported

Mileage at the reported incident

341 reports with mileage · 409 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Engine. Review the 360 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Structure. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Exterior Lighting. Review the 91 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

20 crash reports14 fire reports13 injury reports

Service Brakes complaints

21 reports
Clear category filter
Mileage unknown · Jul 11, 2026
Electrical SystemService BrakesVehicle Speed Control

I parked my car and it was sitting for about an hour I came back to the car and heard a humming noise found that weird but I had to drive home about 10 mins later I parked car, sound was still going even while car was off. So I thought to let it sit for another while. Came back to car sound was still on I started car and the abs…

Read full complaint

I parked my car and it was sitting for about an hour I came back to the car and heard a humming noise found that weird but I had to drive home about 10 mins later I parked car, sound was still going even while car was off. So I thought to let it sit for another while. Came back to car sound was still on I started car and the abs, traction, & brake light came on and not even 2 mins later my car starts smoking. So immediately I shut it off and have to leave my car parked in another city because I didn’t want to risk driving it home. Fast forward to next day. I got to my car and notice the speedometer had went out. i called Kia because I read about the HECU ABS recall. the service rep assured me my car would be covered so I pay a tow to get it towed to Kia dealer where they then tell me the recall had been repaired in a year that I didn’t even own the car and they refuse to look at it or fix without a fee. With this problem being a fire hazard and a manufacturing problem I should not have to come out of pocket for Kia mistake. I will be escalating this to corporate level.

NHTSA ODI #11749754

Mileage unknown · Jun 15, 2026
EngineService BrakesStructureFire

2015 Kia Sorento fire on the 7th I was drive lost brakes and steering and as soon as I stop to get out to check the whole truck went up in flames

NHTSA ODI #11744083

Mileage unknown · Apr 21, 2025
EngineFuel/propulsion SystemService BrakesFire

The entire car failed as it caught fire. I wasn't able to break or put the car into park and it rolled to a stop while smoke was coming through the vents. Because of this, my passenger and I exited the vehicle and crossed the expressway while a highway patroller was directing traffic away from the car. Within 2 minutes the car w…

Read full complaint

The entire car failed as it caught fire. I wasn't able to break or put the car into park and it rolled to a stop while smoke was coming through the vents. Because of this, my passenger and I exited the vehicle and crossed the expressway while a highway patroller was directing traffic away from the car. Within 2 minutes the car was engulfed in flames. The car is not available for inspection as it was towed away and disposed of. The safety of myself and the passenger were at risk because the entire car broke out in flames and soon exploded. If we stayed in the car for any longer than we did, we would have died. UNKOWN. I do not believe that the vehicle has been inspected. The warning lights all turned on at exactly the same time, about 3-5 seconds before the car completely stopped.

NHTSA ODI #11655958

147,000 miles · May 7, 2024
Service BrakesFire

The contact owned a 2015 Kia Sorento. The contact stated that the vehicle was driven to a store, and when the vehicle was turned off, the contact saw smoke and fire coming from the hood. The contact went into the store to get a fire extinguisher and bystanders used their fire extinguishers and attempted to extinguish the fire. T…

Read full complaint

The contact owned a 2015 Kia Sorento. The contact stated that the vehicle was driven to a store, and when the vehicle was turned off, the contact saw smoke and fire coming from the hood. The contact went into the store to get a fire extinguisher and bystanders used their fire extinguishers and attempted to extinguish the fire. The Fire department extinguished the fire. There were no occupants in the vehicle. No injuries were sustained. The contact stated that all vehicles were moved away from the fire, however, one vehicle was not moved. The contact stated that the vehicle was not on fire and it was unknown if there was damage to the vehicle. There were no occupants in that vehicle. There was a fire department report filed. There was a police report filed. The vehicle was destroyed. The vehicle was towed to the contact's residence. The contact discovered the NHTSA Campaign Number: 21V331000 (Service Brakes, Hydraulic), however, the contact was not notified that their VIN was included. The manufacturer was made aware of the failure. The failure mileage was approximately 147,000.

NHTSA ODI #11587406

Mileage unknown · Jan 24, 2024
Service Brakes

rear brake lights stay on while car is running. Go off when car shut off

NHTSA ODI #11567563

Mileage unknown · Jan 14, 2024
Electrical SystemEngineService Brakes

Check engine light started coming on at about 39,000. miles took to local mechanic who preformed lots of repairs and called Kia for information concerning engine issue. Received notice of recall from Kia on the HECU -instructing me to park truck away from home due to fire. Check engine light back on again at 41,000 miles, took t…

Read full complaint

Check engine light started coming on at about 39,000. miles took to local mechanic who preformed lots of repairs and called Kia for information concerning engine issue. Received notice of recall from Kia on the HECU -instructing me to park truck away from home due to fire. Check engine light back on again at 41,000 miles, took to dealership where they replaced the HECU and fuel pump and fuel lines. Picked up truck and noticed when braking the truck shook all over and seem to almost stall when taking off. Check engine was back on and the alert of the system telling me I had an engine failure. Took truck back next day, again repairs of the PVB valve was done. Someone drove the truck of 180 miles on a check engine light and unplugged the battery. Got truck back and within 10 minutes the check engine light was back on and the system telling me engine failure and truck was unsafe to drive. Truck now at another Kia dealership, after many conversation with Kia the representative instructed me to tell the dealership where the truck was that the truck had a recall (supposedly) fixed. Called the dealership now tells me there is no fix for the HECU issue and they can not tell me the truck is safe to drive. I have not had the truck for now 4 months and Kia doesn't know how to fix it. I have filed 4 cases against Kia, they have not offered me a rental car or loaner and they do not have any expected date for me to get the truck back. I have files but it won't let me upload them for the receipts/ information from Kia

NHTSA ODI #11565432

Mileage unknown · Mar 15, 2023
Service Brakes

brake caliper failed and destroyed brakes, rotors and caused vehicle to shake when brakes applied

NHTSA ODI #11511910

Mileage unknown · Feb 9, 2022
Fuel/propulsion SystemService Brakes

There is a recall for part of my vehicle that says a fire could start. Need it fixed

NHTSA ODI #11451102

Mileage unknown · Sep 28, 2021
EngineService Brakes

vehicles lost due to certain engine fires. In some instances, the Settlement also provides a cash rebate if you lost faith in the vehicle after experiencing engine troubles related to the defect and you purchased another Kia vehicle within a specified timeframe. ▪ To qualify you must have bought or leased a “Class Vehicle,” whic…

Read full complaint

vehicles lost due to certain engine fires. In some instances, the Settlement also provides a cash rebate if you lost faith in the vehicle after experiencing engine troubles related to the defect and you purchased another Kia vehicle within a specified timeframe. ▪ To qualify you must have bought or leased a “Class Vehicle,” which are 2011–2018 and certain 2019 Kia Optima, 2012–2018 and certain 2019 Kia Sorento, and 2011–2018 and certain 2019 Kia Sportage vehicles equipped with or replaced with a genuine Theta II 2.0 liter or 2.4 liter gasoline direct injection engine within OEM specifications. For 2019 model year vehicles, the Class shall include those vehicles that were manufactured before the Knock Sensor Detection System technology was incorporated into their production.

NHTSA ODI #11434756

Mileage unknown · Jul 26, 2021
EngineService BrakesSteeringCrashInjury

Motor shuts down completely disabling the car electronically. I lose my brakes and my steering. In February 2020, I almost died driving the vehicle the car engine seized while driving and was replaced by KIA. I never received an itemized bill from Dealership they stole the rental from my private driveway to and stole $5,000 and…

Read full complaint

Motor shuts down completely disabling the car electronically. I lose my brakes and my steering. In February 2020, I almost died driving the vehicle the car engine seized while driving and was replaced by KIA. I never received an itemized bill from Dealership they stole the rental from my private driveway to and stole $5,000 and my belongings from the vehicle. One June 29.2021 I almost died again driving the car. The New Engine shuts down and I lose breaks and steering and hit an animal trying to get off the road for safety since I no longer have breaks to my vehicle. The animal ripped off my undercarriage and dented my radiator. The car was smoking and the engine would start and when driven 50 feet keep shutting down and locking no breaks no power no steering becoming a hazard to myself and others. I have had no resolve with any dealership I have been to 4 different Kia dealerships and The Hyundai Certified Pre Owned Used Car Sales Dealer I purchased the car from. Instead of helping me and not placing my life and other lives in danger. I was threatened, antagonized, slandered, Defamed, and Had the police called to remove me because I refused to commit a crime and set my car on fire like the Dealership told me to do. I need help.

NHTSA ODI #11426547

Official recalls

3

21V331000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

May 10, 2021

Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles previously recalled under recall 20V-519. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.

Consequence & remedy

Consequence: An electrical short in the HECU increases the risk of a fire while parked or driving.

Remedy: Owners are advised to park outside and away from other vehicles and structures until the recall repair is completed. Dealers will install a new multi-fuse, and inspect the HECU for leaks, replacing the HECU if necessary, free of charge. Owner notification letters were mailed on July 2, 2021. This recall supersedes previous NHTSA recall number 20V-519. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC212.

20V519000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Aug 27, 2020

Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.

Consequence & remedy

Consequence: If the HECU short circuits, there is an increased risk of an engine compartment fire.

Remedy: Kia will notify owners, and dealers will inspect the HECU for leaking brake fluid and replace the HECU if necessary, free of charge. Owners are advised to park outside and away from other vehicles and structures until the recall repair is completed. The recall began October 20, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC197.

18V907000 · Engine; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Dec 19, 2018

Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.

Consequence & remedy

Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.

Additional source detail variants (2)

Engine

Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.

Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.

Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.

Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

AQ23002 · Hyundai And Kia Abs Module Fires

Opened Nov 17, 2023 · No close date supplied

Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.

DP22003 · Loss Of Motive Power

Opened Sep 12, 2022 · Closed Dec 12, 2023

Status: closed (inferred from source dates) · Engine

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing.  There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DP21002 · Engine Oil Pressure Switch Leak

Opened Nov 12, 2021 · Closed Jun 26, 2023

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:oil/lubrication:pressure/temperature Sensor

In a letter dated September 30, 2021, Mr. Gerald James (the petitioner) requested that NHTSA conduct an investigation of the Model Year (MY) 2015-2017 Kia Sorento equipped with 3.3L V6 ?Lambda? engines for ?severe oil leaks? from the oil pressure switch (OPS) that could ?lead to engine failure? with little warning to the driver. Mr. James based this request on his own experience and data found in NHTSA?s Vehicle Owner Questionnaire (VOQ) database. NHTSA reviewed the material cited by the petitioner, information submitted by Kia, NHTSA?s testing, and other pertinent information in NHTSA databases.On November 12, 2021, ODI opened Defect Petition DP21-002 to evaluate the petitioner?s request. ODI performed an analysis that included evaluation of the petitioner?s vehicle, searches of ODI complaints from vehicle owners, non-dealer field reports, manufacturers? supplemental information relating to design of the component, and component testing performed by ODI.On December 16, 2021, ODI and Kia North America performed a joint inspection on the petitioner?s vehicle. ODI and Kia agreed the OPS was leaking oil and observed oil in the crevices atop the engine block. The vehicle received a new replacement OPS and was delivered back to the petitioner. The original part that was removed from the subject vehicle was retained by ODI for further analysis.As of December 30, 2022, for the MY 2015-2017 Kia Sorento population of 161,519 vehicles with 3.3L engine, NHTSA reviewed internal data and has identified no consumer complaints or field reports in its database, with unique Vehicle Identification Numbers (VIN), citing engine failure or stalling related to the petition?s allegation of defective OPS. When combined with the supplemental warranty and technical analysis from the manufacturer, field report and customer complaint data in response to the Information Request letter sent, NHTSA identified no unique VINs alleging engine failure or stalls caused by OPS leaking on the subject vehicles named in the petition.On April 4, 2022, the Vehicle Research and Test Center (VRTC) performed testing of the petitioner?s component (OPS) based on testing protocol consistent with Kia?s specifications for the subject vehicle. The testing involved the petitioner?s original OPS in a controlled system to replicate the subject vehicle?s oil pressure, flow, and temperature. VRTC determined that a vehicle would have to miss more than a dozen oil change intervals to reach low engine oil capacity. Testing also revealed the OPS would operate, as manufacturer intended, illuminating the vehicle?s MIL to alert the driver of lower oil pressure.In April of 2022, Kia North America issued a warranty extension that extended the coverage of the Oil Pressure Switch from 5 years/60,000 miles to 15 years/150,000 miles on MY 2014-2018 Sorento, MY 2014-2016 Cadenza, and MY 2015-2018 Sedona vehicles, all equipped with the 3.3L Lambda engine. The extended warranty coverage includes diagnosis, repair, and applies to customers experiencing engine oil leaking from the engine or if the engine oil pressure warning light stays illuminated after the engine is turned on.After a thorough review of the material submitted by the petitioner, information already in NHTSA's possession, testing performed by VRTC, technical information provided by Kia, the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that an engine failure due to the alleged defect is likely and does not warrant a formal investigation. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be publi

Additional source detail variants (2)

Engine And Engine Cooling:engine:oil/lubrication:pressure/temperature Sensor

In a letter dated September 30, 2021, Mr. Gerald James (the petitioner) requested that NHTSA conduct an investigation of the Model Year (MY) 2015-2017 Kia Sorento equipped with 3.3L V6 ?Lambda? engines for ?severe oil leaks? from the oil pressure switch (OPS) that could ?lead to engine failure? with little warning to the driver. Mr. James based this request on his own experience and data found in NHTSA?s Vehicle Owner Questionnaire (VOQ) database. NHTSA reviewed the material cited by the petitioner, information submitted by Kia, NHTSA?s testing, and other pertinent information in NHTSA databases.On November 12, 2021, ODI opened Defect Petition DP21-002 to evaluate the petitioner?s request. ODI performed an analysis that included evaluation of the petitioner?s vehicle, searches of ODI complaints from vehicle owners, non-dealer field reports, manufacturers? supplemental information relating to design of the component, and component testing performed by ODI.On December 16, 2021, ODI and Kia North America performed a joint inspection on the petitioner?s vehicle. ODI and Kia agreed the OPS was leaking oil and observed oil in the crevices atop the engine block. The vehicle received a new replacement OPS and was delivered back to the petitioner. The original part that was removed from the subject vehicle was retained by ODI for further analysis.As of December 30, 2022, for the MY 2015-2017 Kia Sorento population of 161,519 vehicles with 3.3L engine, NHTSA reviewed internal data and has identified no consumer complaints or field reports in its database, with unique Vehicle Identification Numbers (VIN), citing engine failure or stalling related to the petition?s allegation of defective OPS. When combined with the supplemental warranty and technical analysis from the manufacturer, field report and customer complaint data in response to the Information Request letter sent, NHTSA identified no unique VINs alleging engine failure or stalls caused by OPS leaking on the subject vehicles named in the petition.On April 4, 2022, the Vehicle Research and Test Center (VRTC) performed testing of the petitioner?s component (OPS) based on testing protocol consistent with Kia?s specifications for the subject vehicle. The testing involved the petitioner?s original OPS in a controlled system to replicate the subject vehicle?s oil pressure, flow, and temperature. VRTC determined that a vehicle would have to miss more than a dozen oil change intervals to reach low engine oil capacity. Testing also revealed the OPS would operate, as manufacturer intended, illuminating the vehicle?s MIL to alert the driver of lower oil pressure.In April of 2022, Kia North America issued a warranty extension that extended the coverage of the Oil Pressure Switch from 5 years/60,000 miles to 15 years/150,000 miles on MY 2014-2018 Sorento, MY 2014-2016 Cadenza, and MY 2015-2018 Sedona vehicles, all equipped with the 3.3L Lambda engine. The extended warranty coverage includes diagnosis, repair, and applies to customers experiencing engine oil leaking from the engine or if the engine oil pressure warning light stays illuminated after the engine is turned on.After a thorough review of the material submitted by the petitioner, information already in NHTSA's possession, testing performed by VRTC, technical information provided by Kia, the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that an engine failure due to the alleged defect is likely and does not warrant a formal investigation. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be publi

Engine

In a letter dated September 30, 2021, Mr. Gerald James (the petitioner) requested that NHTSA conduct an investigation of the Model Year (MY) 2015-2017 Kia Sorento equipped with 3.3L V6 ?Lambda? engines for ?severe oil leaks? from the oil pressure switch (OPS) that could ?lead to engine failure? with little warning to the driver. Mr. James based this request on his own experience and data found in NHTSA?s Vehicle Owner Questionnaire (VOQ) database. NHTSA reviewed the material cited by the petitioner, information submitted by Kia, NHTSA?s testing, and other pertinent information in NHTSA databases.On November 12, 2021, ODI opened Defect Petition DP21-002 to evaluate the petitioner?s request. ODI performed an analysis that included evaluation of the petitioner?s vehicle, searches of ODI complaints from vehicle owners, non-dealer field reports, manufacturers? supplemental information relating to design of the component, and component testing performed by ODI.On December 16, 2021, ODI and Kia North America performed a joint inspection on the petitioner?s vehicle. ODI and Kia agreed the OPS was leaking oil and observed oil in the crevices atop the engine block. The vehicle received a new replacement OPS and was delivered back to the petitioner. The original part that was removed from the subject vehicle was retained by ODI for further analysis.As of December 30, 2022, for the MY 2015-2017 Kia Sorento population of 161,519 vehicles with 3.3L engine, NHTSA reviewed internal data and has identified no consumer complaints or field reports in its database, with unique Vehicle Identification Numbers (VIN), citing engine failure or stalling related to the petition?s allegation of defective OPS. When combined with the supplemental warranty and technical analysis from the manufacturer, field report and customer complaint data in response to the Information Request letter sent, NHTSA identified no unique VINs alleging engine failure or stalls caused by OPS leaking on the subject vehicles named in the petition.On April 4, 2022, the Vehicle Research and Test Center (VRTC) performed testing of the petitioner?s component (OPS) based on testing protocol consistent with Kia?s specifications for the subject vehicle. The testing involved the petitioner?s original OPS in a controlled system to replicate the subject vehicle?s oil pressure, flow, and temperature. VRTC determined that a vehicle would have to miss more than a dozen oil change intervals to reach low engine oil capacity. Testing also revealed the OPS would operate, as manufacturer intended, illuminating the vehicle?s MIL to alert the driver of lower oil pressure.In April of 2022, Kia North America issued a warranty extension that extended the coverage of the Oil Pressure Switch from 5 years/60,000 miles to 15 years/150,000 miles on MY 2014-2018 Sorento, MY 2014-2016 Cadenza, and MY 2015-2018 Sedona vehicles, all equipped with the 3.3L Lambda engine. The extended warranty coverage includes diagnosis, repair, and applies to customers experiencing engine oil leaking from the engine or if the engine oil pressure warning light stays illuminated after the engine is turned on.After a thorough review of the material submitted by the petitioner, information already in NHTSA's possession, testing performed by VRTC, technical information provided by Kia, the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that an engine failure due to the alleged defect is likely and does not warrant a formal investigation. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be publi

DP21003 · Throttle Control System Vulnerabilities

Opened Nov 12, 2021 · Closed Jun 20, 2023

Status: closed (inferred from source dates) · Vehicle Speed Control:throttle

The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.

Go deeper into Kia Sorento problems