Engine. Review the 386 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 160 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 153 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

23 crash reports46 fire reports16 injury reports

Service Brakes complaints

44 reports

Clear category filter

Mileage unknown · Aug 28, 2026

Electrical SystemEngineService Brakes

Read full complaint

I am filing an official safety complaint against the manufacturer for refusing to perform federally mandated safety recall repairs on my vehicle. My vehicle is impacted by critical safety recalls involving high-severity fire risks, specifically the Hydraulic Electronic Control Unit (HECU) electrical short circuit risk. Corporate Customer Care and my local authorized dealership have officially refused to schedule or perform these safety recall repairs. The representatives explicitly stated that my vehicle is denied service because I purchased it used from a third-party private owner, and because I do not possess complete historical maintenance records. The manufacturer is conflating civil class-action lawsuit requirements with federally mandated safety recalls. Under the National Traffic and Motor Vehicle Safety Act, a manufacturer cannot legally condition or deny an active, free safety recall repair based on a vehicle's third-party purchase history or maintenance records. Due to poorly trained employees at both the dealership and customer care offices, I have faced constant misinformation that has wasted an immense amount of my time. Because this non-compliance has caused a severe safety hazard to drag on for an extended period, I am also requesting that a loaner vehicle be provided immediately until this vehicle is made safe to drive. The manufacturer has logged these denials and communications under an active corporate file, which I can provide directly to investigators upon request. I request that the NHTSA investigate this non-compliance and instruct the manufacturer to immediately authorize the local service center to perform all open fire safety recall remedies without cost or penalty.

NHTSA ODI #11760502

Mileage unknown · Jul 23, 2026

Electrical SystemService BrakesUnknown Or Other

Read full complaint

This is a follow up of NHTSA case# 1840444. Complaint Description: Vehicle exhibited active CAN-bus communication timeout code DTC C1642 targeting the Hydraulic Electronic Control Unit (HECU). Following the official technical safety guidelines established under NHTSA Campaign 20V519000 (Kia SC197), an isolated parasitic current draw test was performed between the engine junction box positive power post and the ABS2 circuit terminal. Testing across three independent iterations utilizing a digital multimeter confirmed a continuous localized parasitic draw of 218.6 uA. This dramatically exceeds the manufacturer's maximum safety engineering threshold of 70.0 uA by over 312%. This quantified excessive amperage draw conclusively isolates an internal circuit board short-circuit condition caused by a failure of the internal HECU brake fluid seals. The vehicle presents an immediate network communication failure, brake malfunction, and thermal/fire risk. Kia Corporate must be compelled to immediately authorize an expedited, zero-cost component replacement under the active safety recall mandate.

NHTSA ODI #11752517

Mileage unknown · Jul 11, 2026

Electrical SystemService Brakes

Read full complaint

This is a follow up submission to NHTSA case #XXX. Organization Under Complaint: Hutchinson Kia, [XXX] Complaint Summary: The dealership is utilizing unfair and deceptive financial gating practices to avoid its legal obligations under a federal safety recall. The dealership refuses to look at or evaluate a vehicle subject to an urgent fire-risk HECU safety recall unless the consumer first authorizes a $189.00 diagnostic fee. The dealership refuses to give a firm, legally binding commitment that this fee will be waived for a confirmed recall component. Instead, they require the consumer to assume all financial risk upfront, stating the fee will only "likely" be waived based on their own internal, unverified findings. This creates a high-pressure trap where the consumer is forced to sign away financial rights to access a free, federally mandated safety remedy. The dealership is weaponizing a acute shortage of independent import and specialized repair facilities in the Macon, GA market. They are aware consumers have almost no local alternative venues to get an independent, affordable cross-check scan, and are using this regional monopoly to coerce consumers into signing open-ended diagnostic authorizations. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI #11749751

Mileage unknown · Jun 19, 2025

EnginePower TrainService Brakes

Read full complaint

I have had nothing but issues with my Kia since I purchased it May 30th, 2023. It's continually stalling, completely looses power, sometimes won't operate at all. My Kia is very unsafe and completely unreliable. I had to have it towed to the dealership before my first payment was even due. My Kia has has to be taken to the dealership a total of 5 times and still nothing has been resolved, other than oil change, diagnostic testing, spark plugs replacement, "fuel system service", HECU fuse installed. As of today's date (June 19th, 2025) I still owe close to $12,000 on it. This is utterly ridiculous and needs to be resolved asap. It has been continual issues from May 30th, 2023 through current date (June 19th, 2025). In 15 months I have only been able to drive it 4,876 miles. That's how unreliable it is. I need help getting these issues resolved asap.

NHTSA ODI #11667990

Mileage unknown · Mar 14, 2025

Service BrakesSteering

All of it. Car randomly shuts off and lose power steering. No. Dealership has inspected. ALL the lights in the dash light up, screen says battery discharge warning, car shuts off and lose power steering while driving down the road.

NHTSA ODI #11648264

Mileage unknown · Jun 27, 2024

Air BagsElectrical SystemService Brakes

Every light is on in the dash compartment. Power steering goes in and out. Brake lights not working even after being replaced. Car stuck in park unable to put into reverse. ABS/ Airbag light showing- ABS Sensor replaced and still not working Recall in 2022. Kia repaired vehicle and now that same issues are occurring Kia refus…

Read full complaint

NHTSA ODI #11597299

Mileage unknown · Nov 5, 2023

EngineForward Collision AvoidanceService BrakesCrashInjury

Read full complaint

Replaced engine 1/31/23 had open recall per 21v331was not repaired even though they wasn’t suppose to return vehicle according to recall. They said It would be safe to drive.Said they had no remedy to fix they would call me. Few days car stalls alternator was hanging had to replace. They didn’t replace properly. With in a month cars brakes were acting weird took in for diagnostic back brakes no remedy. Call Kia still no parts for recall. Sept 11,23 was pulling off expressway during 5 o'clock traffic my brakes locked up I had no control. Towed to Kia they wanted 75. to look at it then 2700. to fix the brakes. And stated I had no brake fluid. Which was just checked. They said recall did not cover the repairs Neither the engine recall nor the brake, hecu, abs, stability control recall. I contacted Kia they told me they would get back to me. As of Oct.31,23 they had not done any repairs or response from Kia. So I traded my car back to Kia so I would have a vehicle for school and work. I’ve tried to get reimbursement from Kia. For rental car etc. And keep getting the run around. I have towing, rental, and repairs that they are refusing to reimburse me. I drove the recalled vehicle for 9 months and could have been killed myself, my daughter, as well as others. Kia could care less! I traded vehicle 10/31 the recall was cleared on my 2014 Sorento on 11/4 according to Nhtsa.gov 3 days they clear it so they could sell it. I m really disgusted with Kia. I’m out thousands of dollars for their neglect. They couldn’t repair the recall for longer than 9 months for me . But as soon as I trade it to them it’s repaired or they are lying just so they can sell it. Just like when they sold it to me with 2 open recalls without telling me it had them. What do I need to do? Suggestions? I do have more receipts and documents

NHTSA ODI #11553665

Mileage unknown · Sep 18, 2023

Exterior LightingPower TrainService Brakes

Read full complaint

On 06/23/2023 i went to team Nissan located at 70 Keller st . took it in while purchasing new tires from tire warehouse told me about repairs that needed done that was still under warranty with team Nissan. when i took it to team Nissan they refused my warranty by telling me my car issuer was not any issue that they repaired back in July of 2022 for the amount of over 2thousand dollars. team Nissan lied to me let me leave their shop knowing the dangers just because they did not want to grant my warranty which where brakes outta tie Rodes and rear light INOP charged me 45 for en inspection to deny my warranty. I still can't drive my car because team Nissan wanted me to repay for pairs that was still covered under their own warranty my vehicle only has 120 thousand miles i was still in my year frame and way less than the miles. i prefer to bring in my documents if not i must downmload at another time cant take pic ith desktop

NHTSA ODI #11545088

Mileage unknown · Sep 16, 2023

Forward Collision AvoidanceService Brakes

Read full complaint

1. Kia sold me the car with open recalls. And did not disclose this. 2. I’m still paying on it and they had to replace the motor on 01/31/23 recall. 3. They again sent the car home with an open recall sc212 because they didn’t have the part to remedy the recall. (Brakes) 4. My brakes went out luckily in the parking lot. 5. Called Kia Customer Service they gave me the run around hung up on me left me on hold 27 minutes first. But I finally spoke to a supervisor and they agreed to have it towed to Mike Shaw Kia were I had purchased the car and who had done all maintenance and recall work. 6. Mile Shaw called me and now wants 75.00 to even look at my car. I have a11 yr old daughter and myself I have to take to school and work. This is a major recall I refuse to jeopardize my child’s life in this vehicle but I cannot afford to pay them anything plus the car payment insurance. And now I’m walking on top of all this.

NHTSA ODI #11544902

Mileage unknown · Aug 18, 2023

EngineSeat BeltsService Brakes

We bought the car 6 months ago from a dealership and since then the breaks are bad the engine makes this strange noise it always smells like oil is burning. The seat belts don't stay latch and I hr suspension is all over the place.

NHTSA ODI #11539474

Official recalls

23V652000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Sep 25, 2023

Kia America, Inc. (Kia) is recalling certain 2010-2019 Borrego, 2014-2016 Cadenza, 2010-2013 Forte, Forte Koup, Sportage, 2015-2018 K900, 2011-2015 Optima, 2011-2013 Optima Hybrid, Soul, 2012-2017 Rio, 2011-2014 Sorento, and 2010-2011 Rondo vehicles. The Hydraulic Electronic Control Unit (HECU) may experience an electrical short, which can result in an engine compartment fire while parked or driving.

Consequence & remedy

Consequence: An engine compartment fire while parked or driving can increase the risk of injury.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the HECU fuse, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed November 14, 2023. Owner notification letters were mailed March 29, 2024 through June 18, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC284.

21V331000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

May 10, 2021

Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles previously recalled under recall 20V-519. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.

Consequence & remedy

Consequence: An electrical short in the HECU increases the risk of a fire while parked or driving.

Remedy: Owners are advised to park outside and away from other vehicles and structures until the recall repair is completed. Dealers will install a new multi-fuse, and inspect the HECU for leaks, replacing the HECU if necessary, free of charge. Owner notification letters were mailed on July 2, 2021. This recall supersedes previous NHTSA recall number 20V-519. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC212.

20V519000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Aug 27, 2020

Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.

Consequence & remedy

Consequence: If the HECU short circuits, there is an increased risk of an engine compartment fire.

Remedy: Kia will notify owners, and dealers will inspect the HECU for leaking brake fluid and replace the HECU if necessary, free of charge. Owners are advised to park outside and away from other vehicles and structures until the recall repair is completed. The recall began October 20, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC197.

18V907000 · Engine; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Dec 19, 2018

Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.

Consequence & remedy

Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.

Additional source detail variants (2)

Engine

Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.

Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.

17V224000 · Engine And Engine Cooling:engine

Mar 31, 2017

Kia Motor Company (Kia) is recalling certain 2011-2014 Optima, 2012-2014 Sorento and 2011-2013 Sportage vehicles. Machining errors during the engine manufacturing process may cause premature bearing wear within the engine.

Consequence & remedy

Consequence: Bearing wear may result in the engine seizing, increasing the risk of a crash.

Remedy: Kia will notify owners, and dealers will inspect the engine assembly, and replace the engine if necessary, free of charge. The recall began June 20, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC147.

13V356000 · Power Train:axle Assembly:axle Shaft

Aug 13, 2013

Kia Motors Corp. is recalling certain model year 2014 front wheel drive Sorento vehicles manufactured January 7, 2013, through March 12, 2013; and equipped with 2.4 liter engines. Due to a manufacturing issue, the right front axle shaft may fracture.

Consequence & remedy

Consequence: A fractured front axle may result in a loss of power to the wheels. Additionally, if the vehicle is parked without the parking brake applied, it may roll away. Either condition increases the risk of a crash.

Remedy: Kia will notify owners, and dealers will replace the front axle shaft assembly, free of charge. The recall began on September 9, 2013. Owners may contact Kia at 1-800-333-4542 . Kia's recall number is SC099.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

AQ23002 · Hyundai And Kia Abs Module Fires

Opened Nov 17, 2023 · No close date supplied

Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.

DP22003 · Loss Of Motive Power

Opened Sep 12, 2022 · Closed Dec 12, 2023

Status: closed (inferred from source dates) · Engine

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

EA21003 · Engine Fires

Opened Dec 22, 2021 · Closed Feb 5, 2024

Status: closed (inferred from source dates) · Engine

On March 29, 2019, the Office of Defects Investigation (ODI) opened two Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) to broadly investigate incidents of non-crash fires (regardless of origin or operational status of the vehicle) on various model year Hyundai and Kia vehicles. During the PE investigations, Hyundai and Kia issued several recalls to address vehicle fires, including those due to engine failures involving various engine types. The remedies for the engine failure recalls typically involve engine inspection (to detect existing damage), and if necessary, engine replacement. Additionally, both manufacturers have been installing an engine control software modification known as Knock Sensor Detection Software (KSDS) which is intended to detect impending engine failure, alert the driver, and limit engine power (to lessen likelihood of engine failure).KSDS is being installed under recalls and non-safety field actions, and both companies have extended limited engine warranties (see recall files). On December 22, 2021, ODI upgraded PE19-003 and PE19-004 to this Engineering Analysis (EA21-003, covering both Hyundai and Kia) to evaluate the scope of the prior recalls related to engine failures/fires and the efficacy of the recall remedies for the recalls, as well as the long-term viability of related programs and non-safety field actions being conducted by Hyundai and Kia. The former issue involved approximately 550,000 MY 2013 Hyundai Elantra, MY 2011 Kia Sorento, and MY 2012-2015 Kia Rio. The latter issue involved approximately 2.5 million recalled vehicles, which have been identified as displaying potential remedy concerns: Hyundai recalls 15V-568, 17V-226, 20V-746, and 21V-727; and Kia recalls 17V-224, 19V-120, 20V-750, and 21V-844. Regarding the recall scope issue, among all of the scope vehicles identified at EA opening, ODI found only the MY 2011 Kia Sorento vehicles equipped with both the Theta II 2.4L 4-cylinder Multi-Point Injection (MPI) and the Lambda II 3.5L 6-cylinder MPI engines experienced relatively high rates of reported fires. In December 2023, Kia issued recall 23V-877 that will cover about 80,000 MY 2011 Kia Sorento vehicles equipped with the Theta II 2.4L MPI engines. The remedy will involve an inspection, and if necessary, a replacement of the engine, as well as the installation of KSDS. It should be noted that in 2021 these vehicles were included in a KSDS product improvement campaign with warranty extension. For the MY 2011 Sorento vehicles equipped with the Lambda II 3.5L engines, ODI believes that future engine failures/fires involving these vehicles will likely be due to a lax in adhering to the proper or scheduled engine maintenance (regular engine oil changes), rather than a design or manufacturing engine issue. Regarding the issue of the efficacy of the recall remedies, ODI found the majority of the recalled Hyundai and Kia vehicles, by model, experienced lower reported fire rates after the remedies were applied. Furthermore, ODI found that for most vehicles that did not receive the recall remedies, by model, experienced relatively high fire rates. To address this problem, Hyundai informed ODI in December 2023, that it will renotify all of its owners covered by the Hyundai recalls of engine failures/fires every 8 months for the next 3 years. In December 2023, Kia stated that it will renotify the majority of its owners every 8 months for the next 3 years.Several previously recalled Kia models are excluded from the renotification due to their lower reported rates of engine fires. Overall, the renotification actions will help to increase the recall completion rates, thus reduce the frequency of engine fires in the future. In view of the recall action being taken by Kia and renotification actions being taken by both Kia and Hyundai, ODI is closing this Engineering Analysis. Also, both companies have been released from the 2020-iniated Consent Orders (Kia since November 2022 and Hyundai since November 2023). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DP21003 · Throttle Control System Vulnerabilities

Opened Nov 12, 2021 · Closed Jun 20, 2023

Status: closed (inferred from source dates) · Vehicle Speed Control:throttle

The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.

PE19004 · Non-crash Vehicle Fires

Opened Mar 29, 2019 · Closed Dec 22, 2021

Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery; Electrical SYSTEM:12V/24V/48V Battery:cables; Electrical System:alternator/generator/regulator; Electrical System:ignition; Electrical System:ignition:module; Electrical System:ignition:switch; Electrical System:starter Assembly; Electrical System:starter Assembly:relay; Electrical System:starter Assembly:solenoid; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:interior/under Dash; Engine; Engine And Engine Cooling; Engine And Engine Cooling:cooling System; Engine And Engine Cooling:cooling System:fan; Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings; Engine And Engine Cooling:cooling System:radiator Assembly; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline; Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys; Engine And Engine Cooling:engine:gasoline:turbo/supercharger; Engine And Engine Cooling:engine:other Fuel Types:turbo/supercharger; Engine And Engine Cooling:exhaust System; Engine And Engine Cooling:exhaust System:emission Control ; Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor; Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv); Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve); Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe; Exterior Lighting; Exterior Lighting:back Up Lights; Exterior Lighting:back Up Lights:switch; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Exterior Lighting:fog Lights; Exterior Lighting:fog Lights:switch; Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit; Exterior Lighting:headlights; Exterior Lighting:headlights:concealment Devices; Exterior Lighting:headlights:high/low Beam Dimmer Switch; Exterior Lighting:headlights:switch; Exterior Lighting:tail Lights; Exterior Lighting:tail Lights:switch; Exterior Lighting:turn Signal:flasher Unit; Exterior Lighting:turn Signal:switch; Unknown Or Other

During this Preliminary Evaluation (PE), the Office of Defects Investigation (ODI) assessed the scope, frequency and potential safety-related consequences of non-crash vehicle fires caused by both engine failures and failures of other vehicle systems/components in model year (MY) 2011-2014 Kia Optima, MY 2011-2014 Kia Sorento and MY 2010-2015 Kia Soul vehicles equipped with Theta II, Gamma, Nu and Lambda II engines (approximately 1.7 million vehicles). ODI also reviewed field and other data on other Kia vehicles (approximately 3.6 million additional vehicles) equipped with the same engines used in the above-mentioned vehicles.As a result of this PE, Kia has issued NHTSA Recalls 20V-750 and 21V-844 to address potential engine failures and fires in certain Kia vehicles equipped with various engine types.Additional information on these and other related recall actions is available in the downloadable version of this resume available at NHTSA.gov.In addition, ODI has upgraded this PE to an Engineering Analysis (EA) 21-003 which will focus on potential recall scope concerns and recall remedy concerns related to the engine failure-related recalls mentioned above and conducted previously.See the EA21-003 Opening Resume available at NHTSA.gov for more information.Also available in the downloadable version of this resume is a list of the reference numbers for the 444 ODI reports, or Vehicle Owner Questionnaires (VOQs), cited above which ODI received through mid-November 2021.Note that the Manufacturer reports cited above are customer complaints received through March 2019.

Additional source detail variants (392)

Electrical SYSTEM:12V/24V/48V Battery:cables

Electrical SYSTEM:12V/24V/48V Battery

Electrical System:alternator/generator/regulator

Electrical System:ignition

Electrical System:ignition:module

Electrical System:ignition:switch

Electrical System

Electrical System:starter Assembly

Electrical System:starter Assembly:relay

Electrical System:starter Assembly:solenoid

Electrical System:wiring:front Underhood

Electrical System:wiring:interior/under Dash

Electrical System:wiring

Engine And Engine Cooling:cooling System:fan

Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings

Engine And Engine Cooling:cooling System

Engine And Engine Cooling:cooling System:radiator Assembly

Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys

Engine And Engine Cooling:engine:gasoline

Engine And Engine Cooling:engine:gasoline:turbo/supercharger

Engine And Engine Cooling:engine

Engine And Engine Cooling:engine:other Fuel Types:turbo/supercharger

Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor

Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)

Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve)

Engine And Engine Cooling:exhaust System:emission Control

Engine And Engine Cooling:exhaust System

Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

Engine And Engine Cooling

Engine

Exterior Lighting:back Up Lights

Exterior Lighting:back Up Lights:switch

Exterior Lighting:brake Lights

Exterior Lighting:brake Lights:switch

Exterior Lighting:fog Lights

Exterior Lighting:fog Lights:switch

Exterior Lighting:hazard Flashing Warning Lights

Exterior Lighting:hazard Flashing Warning Lights:switch

Exterior Lighting:hazard Flashing Warning Lights:unit

Exterior Lighting:headlights:concealment Devices

Exterior Lighting:headlights:high/low Beam Dimmer Switch

Exterior Lighting:headlights

Exterior Lighting:headlights:switch

Exterior Lighting

Exterior Lighting:tail Lights

Exterior Lighting:tail Lights:switch

Exterior Lighting:turn Signal:flasher Unit

Exterior Lighting:turn Signal:switch

Unknown Or Other

DP18003 · Non-crash Vehicle Fires

Opened Aug 21, 2018 · Closed May 10, 2019

Status: closed (inferred from source dates) · Electrical System; Electrical System: Instrument Cluster/panel; Electrical SYSTEM:12V/24V/48V Battery; Electrical SYSTEM:12V/24V/48V Battery:cables; Electrical System:alternator/generator/regulator; Electrical System:ignition; Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module; Electrical System:ignition:module; Electrical System:ignition:switch; Electrical System:propulsion System:traction Battery; Electrical System:starter Assembly; Electrical System:starter Assembly:relay; Electrical System:starter Assembly:solenoid; Electrical System:wiring; Electrical System:wiring: Rear Compartment/trunk; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash; Engine; Engine And Engine Cooling; Engine And Engine Cooling:cooling System; Engine And Engine Cooling:cooling System:fan; Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings; Engine And Engine Cooling:cooling System:radiator Assembly; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline; Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys; Engine And Engine Cooling:engine:gasoline:turbo/supercharger; Engine And Engine Cooling:engine:other Fuel Types:turbo/supercharger; Engine And Engine Cooling:exhaust System; Engine And Engine Cooling:exhaust System:emission Control ; Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor; Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv); Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve); Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Exterior Lighting:fog Lights; Exterior Lighting:fog Lights:switch; Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit; Exterior Lighting:headlights; Exterior Lighting:headlights:concealment Devices; Exterior Lighting:headlights:high/low Beam Dimmer Switch; Exterior Lighting:headlights:switch; Exterior Lighting:tail Lights; Exterior Lighting:tail Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit; Exterior Lighting:turn Signal:switch; Unknown Or Other

In a letter dated June 11, 2018, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a safety defect investigation into non-collision related fires on model year (MY) 2011-2014 Kia Optima and Sorento, and Hyundai Sonata and Santa Fe vehicles. In a letter dated July 24, 2018, CAS requested that MY 2010-2015 Kia Soul vehicles be added to the petition. CAS stated that there is a higher number of complaints to NHTSA regarding non-crash fires on these vehicles compared to other similar vehicles. The Office of Defects Investigation (ODI) had already opened Recall Queries (RQ17-003 and RQ17-004) on all Kia and Hyundai vehicles equipped with Theta II engines for engine failures that may cause stalling and fires.The queries cover most of the petition subject Optima, Sorento, Sonata, and Santa Fe vehicles but not any of the subject Soul vehicles.On August 21, 2018, ODI opened a Defect Petition (DP18-003) to evaluate whether to grant or deny the CAS petition. ODI sent Information Request letters to Kia and Hyundai (September and October 2018) requesting information on all engine and non-engine related fires in the petition vehicles.ODI performed extensive analysis on the information obtained from Kia and Hyundai. During the DP18-003 analysis, Kia and Hyundai each initiated three additional safety recalls related to engine compartment fires on certain petitioned and non-petitioned vehicles (nearly 740,000 total vehicles: Recalls 18V-907, 18V-934, 19V-101, 19V-063, 19V-120, and 19V-204). Based on ODI?s review of the applicable materials, including responses to Information Requests sent to multiple manufacturers, Vehicle Owner Questionnaires (VOQ), and Early Warning Data, NHTSA decided to grant the petition.The CAS petition was granted on March 29, 2019. Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) have been opened to assess the scope, frequency, and potential safety-related consequences of alleged defects relating to non-collision vehicle fires in the 2011-2014 Kia Optima and Sorento, 2011-2014 Hyundai Sonata and Santa Fe, and 2010-2015 Kia Soul.Attached is a list of the reference numbers for the 404 VOQs cited above.

Additional source detail variants (208)

Electrical SYSTEM:12V/24V/48V Battery:cables

Electrical SYSTEM:12V/24V/48V Battery

Electrical System:alternator/generator/regulator

Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module

Electrical System:ignition

Electrical System:ignition:module

Electrical System:ignition:switch

Electrical System: Instrument Cluster/panel

Electrical System

Electrical System:propulsion System:traction Battery

Electrical System:starter Assembly

Electrical System:starter Assembly:relay

Electrical System:starter Assembly:solenoid

Electrical System:wiring:front Underhood

Electrical System:wiring:fuses And Circuit Breakers

Electrical System:wiring:interior/under Dash

Electrical System:wiring

Electrical System:wiring: Rear Compartment/trunk

Engine And Engine Cooling:cooling System:fan

Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings

Engine And Engine Cooling:cooling System

Engine And Engine Cooling:cooling System:radiator Assembly

Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys

Engine And Engine Cooling:engine:gasoline

Engine And Engine Cooling:engine:gasoline:turbo/supercharger

Engine And Engine Cooling:engine

Engine And Engine Cooling:engine:other Fuel Types:turbo/supercharger

Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor

Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)

Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve)

Engine And Engine Cooling:exhaust System:emission Control

Engine And Engine Cooling:exhaust System

Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

Engine And Engine Cooling

Engine

Exterior Lighting:brake Lights

Exterior Lighting:brake Lights:switch

Exterior Lighting:fog Lights

Exterior Lighting:fog Lights:switch

Exterior Lighting:hazard Flashing Warning Lights

Exterior Lighting:hazard Flashing Warning Lights:switch

Exterior Lighting:hazard Flashing Warning Lights:unit

Exterior Lighting:headlights:concealment Devices

Exterior Lighting:headlights:high/low Beam Dimmer Switch

Exterior Lighting:headlights

Exterior Lighting:headlights:switch

Exterior Lighting:tail Lights

Exterior Lighting:tail Lights:switch

Exterior Lighting:turn Signal:flasher Unit

Exterior Lighting:turn Signal

Exterior Lighting:turn Signal:switch

Unknown Or Other

RQ17003 · Scope And Timeliness

Opened May 18, 2017 · Closed Dec 22, 2021

Status: closed (inferred from source dates) · Engine

NHTSA opened Recall Query (RQ) 17-003 to investigate the timeliness and scope of Kia?s Theta II GDI engine recall (Recall No. 17V-224), and Kia?s compliance with reporting requirements. On November 23, 2020, the Agency entered into a Consent Order with Kia to administratively resolve NHTSA?s assertions of violations of law in connection with RQ17-003. NHTSA?s assertions included that Kia may be liable for civil penalties on multiple grounds, including that Recall No. 17V-224 was untimely and Kia?s recall report contained certain inaccuracies.Under the Consent Order, Kia agreed to a total civil penalty of $70,000,000. The total civil penalty included a payment of $27,000,000 as a Non-Deferred Amount.Kia also agreed to a sum of $27,000,000 as an Abeyance Amount to be deferred and held in abeyance pending its satisfactory completion, as reasonably determined by NHTSA, of the requirements of the Consent Order.Kia also agreed to a $16,000,000 Performance Obligation Amount to be expended by Kia to fulfill specified Safety Data Analytics Infrastructure obligations. The Consent Order also includes other terms designed to enhance Kia?s safety practices, and requires Kia to retain a Third-Party Auditor who directly reports to NHTSA.Other than RQ17-003, the Consent Order is not intended to affect any other current or future investigation of NHTSA which may involve vehicles equipped with Theta II GDI engines. In particular, Engineering Analysis (EA) 21-003 (which is upgraded from Preliminary Evaluation (PE) 19-004) continues NHTSA?s evaluation of certain performance and design issues relating to the Theta II and other engines.Nothing in the Consent Order discharges Kia from any obligation to comply with the Safety Act or regulations thereunder, including the obligation to carry out recalls in accordance with the law, and to initiate a recall upon any future determination by Kia, or upon any finally adjudicated order from NHTSA, that vehicles equipped with Theta II GDI engines contain a defect related to motor vehicle safety or do not comply with an applicable FMVSS.This RQ is closed. Closure of this RQ has no bearing on the terms of the Consent Order, including Kia's ongoing performance obligations, and does not represent a determination by the agency as to Kia's performance under the Consent Order to date.

Additional source detail variants (2)

Engine

PE13025 · Front Axle Shaft Failure

Opened Jul 5, 2013 · Closed Sep 20, 2013

Status: closed (inferred from source dates) · Power Train; Power Train:axle Assembly:axle Shaft

In a letter dated August 9, 2013, Hyundai-Kia America Technical Center, Inc. (Hyundai-Kia) submitted two Defect Information Reports (DIR) to NHTSA identifying a safety defect related to fracture of the right front axle shaft in MY 2013 front wheel drive Hyundai Santa Fe Sport vehicles built from July 13, 2012 through March 12, 2013 and MY 2014 front wheel drive Kia Sorento vehicles built from January 7 through March 12, 2013 (Recall Nos. 13V-355 and 13V-356).According to Hyundai-Kia, the right front axle driveshaft may develop a crack in the area of the stub at the wheel end of the shaft due to problems with the stub supplier's forging process for axles installed in vehicles built prior to March 12, 2013.When moving from a stop, the crack can lead to a separation of the shaft, causing a loud noise and loss of motive power.In addition, should the driver fail to engage the parking brake on an inclined surface, the vehicle may roll.In either case, a crash could result.ODI's review of consumer complaints and data submitted by Hyundai-Kia, identified 21 complaints alleging right-front axle shaft failure and 60 warranty claims related to right front axle replacements.All of the vehicles identified in the complaints and warranty claims were manufactured during the vehicle builds periods identified in the DIR.The Preliminary Evaluation is closed.The ODI report cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10524563, 10524274, 10508727, and 10505768.

Additional source detail variants (2)

Power Train:axle Assembly:axle Shaft

Power Train

Go deeper into Kia Sorento problems

Kia Sorento transmission problems →Kia Sorento electrical problems →